2009 Yamaha Motorsports RS Venture Owners Manual
2009 Yamaha Motorsports RS Venture Manual
2009 Yamaha Motorsports RS Venture manual content summary:
- 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 1
OWNER'S MANUAL Read this manual carefully before operating this vehicle. RST90Y LIT-12628-02-72 8ET-28199-14 - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 2
ESU10041 Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold. - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 3
sporting and touring snowmobiles. It represents the high degree of craftsmanship and reliability that have made Yamaha a leader in these fields. This manual will give you an understanding of the operation, inspection, and basic maintenance of this snowmobile. If you have any questions concerning the - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 4
information ESU10151 Particularly important information is distinguished in this manual by the following notations. This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 5
Contents Location of the important labels ...1 Safety information ...3 Description ...5 Control functions ...7 Main switch ...7 Starter (choke) lever ...7 Throttle lever ...7 Engine overheating prevention system ...8 Throttle override system (T.O.R.S.) ...8 Speedometer unit ...9 High beam indicator - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 6
Contents Adjusting the headlight beam ...Fittings and fasteners ...Battery ...Replacing a fuse ...62 62 62 63 Troubleshooting ...66 Storage ...70 Specifications ...72 Consumer information...74 Identification number records ...74 YAMAHA MOTOR CORPORATION, U.S.A. SNOWMOBILE LIMITED WARRANTY...75 - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 7
Location of the important labels ESU10213 Read and understand all of the labels on your vehicle. They contain important information for safe and proper operation of your vehicle. Never remove any labels from your vehicle. If a label becomes difficult to read or comes off, a replacement label is - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 8
oil loss if crankcase breather hoses are not installed correctly. Inspect hoses and clamps for correct installation after battery service or air box removal. See Service Manual. 8 ATTENTION Des dommages graves risquent de survenir par suite de fuites d'huile résultant d'un mauvais branchement des - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 9
release the throttle and apply the brake gently-not suddenly. While using your snowmobile G Before you operate your snowmobile G G Read the Owner's Manual and all labels. Become familiar with all of the operating controls and their function. Consult a Yamaha dealer about any control or function - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 10
Safety information be unable to save yourself. Also, deadly levels of carbon monoxide can linger for hours or days in enclosed or poorly-ventilated areas. If you experience any symptoms of carbon monoxide poisoning, leave the area immediately, get fresh air, and SEEK MEDICAL TREATMENT. G Do not run - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 11
Description ESU10260 1. Storage compartment 2. Tool kit 3. Air filter 4. Battery 5. Coolant reservoir 6. Fuse box 7. Throttle stop screw 8. Main fuse 9. Oil filler cap 10. Passenger grip warmer switch 11. Solo touring storage area 12. Backrest 13. Rear carrier 14. Tail/brake lights 15. Slide rail - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 12
grip/thumb warmer level indicator 26. Odometer/tripmeter TIP G G The snowmobile you have purchased may differ slightly from those shown in the figures of this manual. Design and specifications are subjected to change without notice. 6 - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 13
Control functions ESU10282 Main switch The main switch controls the ignition and lighting systems. The various positions are described below. 1. Starter (choke) lever TIP Refer to the "Starting the engine" section on page 28 for proper operation. 1. Off 2. On 3. Start Off The ignition circuit is - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 14
Throttle position sensor 1. Throttle lever ESU10321 Running On Open Trouble Off Open T.O.R.S. will operate. Off Closed Engine Run Run has been corrected and that the engine can be operated without a problem before restarting the engine. Continuing to operate with a malfunction could cause - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 15
Control functions Trouble a tachometer (which shows engine speed) an odometer (which shows the total distance traveled) G a tripmeter (which shows the distance traveled since it was last set to - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 16
Control functions Odometer and tripmeter modes Pushing the select/reset button switches the display between the odometer mode "ODO" and the tripmeter mode "TRIP". To reset the tripmeter, push the select/reset button for at least one second while the tripmeter is displayed. TIP To switch the - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 17
Control functions Grip/thumb warmer level indicator When the grip warmer adjustment switch is pressed, the grip warmer indicator comes on and the display switches to the grip warmer level. When the thumb warmer adjustment switch is pressed, the thumb warmer indicator comes on and the display - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 18
of the snowmobile. The fuel level warning indicator, warning light, and all segments of the fuel meter warn the rider of the above problems by flashing continuously. If this occurs, have a Yamaha dealer inspect the snowmobile as soon as possible. 1. Oil level warning indicator " 2. Warning light - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 19
Control functions ESU10512 Coolant temperature warning indicator " " If the engine overheats, the coolant temperature warning indicator and the warning light come on. When this occurs, stop the engine immediately and allow the engine to cool down, and then check the coolant level in the coolant - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 20
Control functions To raise the temperature, press the respective switch to "HI". To lower the temperature, press the switch to "LO". (See page 10 for more information.) ESU10691 Auxiliary DC jack The auxiliary DC jack is located in the front panel and can be used for accessories. TIP 1. Headlight - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 21
end does not project out over the handlebar end. This will help prevent brake lever damage when the snowmobile is placed on its side for service. ESU10581 Parking brake lever When parking the snowmobile or starting the engine, apply the parking brake by moving the parking brake lever to the left - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 22
Control functions 1. Pull out. 2. Slide to "FWD" (forward). 3. Release. 1. Shroud latch 2. Shroud ECS00140 NOTICE Make sure that all cables and wires are in place when closing the shroud. ESU10751 Drive guard EWS00401 WARNING G 1. Pull out. 2. Slide to "REV" (reverse). 3. Release. ECS00072 G - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 23
Control functions 1. Drive guard ESU10760 V-belt holders Keep a spare V-belt for emergency use by placing it into the V-belt holders provided. 1. 2. 3. 4. Passenger grip warmer switch Off "HI" (high) "LO" (low) ESU10700 Footrests The footrests can be installed in two locations to suit - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 24
Control functions To adjust the backrest angle, turn the backrest adjusting knob until the backrest reaches the desired position. The rear storage area can be used only when the passenger seat is removed. 1. Backrest adjusting knob EWS00130 1. Rear storage area 2. Rear carrier WARNING Do not sit - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 25
Control functions 5. 6. Slide the rear carrier backward until it stops. Pull the carrier lock lever up to lock the rear carrier in place. Then, place the lever under the rear carrier and secure it with the holder. NOTICE: When using the rear storage area, do not load any cargo that is too large for - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 26
level WARNING Gasoline and gasoline vapors are extremely flammable. To avoid fires and explosions and to reduce the risk of injury when refueling, follow these instructions. 20 - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 27
Control functions G G G Make sure that snow or ice does not enter the fuel tank when refueling. Do not use alcohol deicers or water absorbing additives with oxygenated fuel. The fuel tank should be filled with straight gasoline as specified. ESU10871 Suspension 3. 4. Wipe up any spilled fuel - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 28
Control functions 1. 2. Loosen the locknut. To increase the spring preload and thereby harden the suspension, turn the adjusting nut in direction (a). To decrease the spring preload and thereby soften the suspension, turn the adjusting nut in direction (b). Center shock absorber 1 2 (a) (b) 1. - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 29
Control functions Tightening torque: Locknut: 42 Nm (4.2 m·kgf, 30 ft·lbf) Rear torsion springs EWS00750 ESU13092 Adjusting the 2-up adjusting blocks EWS00760 WARNING Make sure that the 2-up adjusting blocks are installed in the same position on both sides of the snowmobile, otherwise poor - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 30
Control functions 1. 2. 3. 4. 2-up position (rider and passenger) Solo rider position Special tool Lock pin 2. 3. 4. Pull the lock pin and turn the special tools to change the block position. Release the lock pin. Remove the special tools from the 2-up adjusting block. ESU11033 Adjusting the - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 31
Control functions 1. Red paint area 2. Adjustable range 3. Standard position 3. Tighten the locknut while holding the adjusting nut in place. Locknut tightening torque: 25 Nm (2.5 m·kgf, 18 ft·lbf) 25 - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 32
inspection and maintenance procedures and schedules described in the Owner's Manual. EWS00191 WARNING Failure to inspect or maintain the vehicle operate the vehicle if you find any problem. If a problem cannot be corrected by the procedures provided in this manual, have the vehicle inspected by a - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 33
Pre-operation checks ITEM Drive track Slide runners Steering Lights, signals and switches Throttle lever Throttle override system (T.O.R.S.) CHECKS • Check for deflection, wear and damage. • If necessary, have Yamaha dealer replace track. • Check for wear and damage. • If necessary, have Yamaha - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 34
Operation ESU11292 Starting the engine Read the Owner's Manual carefully to become familiar with all controls. If there is a control or function you do not understand, ask your Yamaha dealer. EWS00201 WARNING Failure to - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 35
oil must be changed and the oil filter cartridge replaced. If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer riding safely. Before operating the snowmobile, read this Owner's Manual completely and understand the operation of the controls. Pay - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 36
control of the throttle and brake, and master turning techniques in this area before trying more difficult terrain. Set the parking brake and follow the instructions on page 28 to start the engine. Once the engine has warmed up, you are ready to begin riding your snowmobile. As you approach a curve - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 37
WARNING Driving across the face of a slope ("sidehilling") can lead to overturn or loss of control if proper techniques are not used. Follow these instructions to reduce your risk of an accident. Do not try steeper or more difficult inclines until you have developed your skill on gentle slopes - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 38
Operation the seat and the foot of your uphill leg on the running board. This position will make it easier for you to shift your body weight as needed. Hard-packed snow It can be more difficult to negotiate on hardpacked snow as both the skis and drive track do not have as much traction as when the - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 39
Operation G G Always check the drive track for damage or maladjustment before operating the snowmobile. Do not operate the snowmobile if you find damage to the drive track. etc. If snow coverage is not sufficient, stay on trails to avoid impact damage to the drive track. Studded track In general - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 40
Operation G Reduce speed and avoid sharp turning when operating the snowmobile in reverse. To select the desired operating position, pull the shift lever out, slide it to "FWD" or to "REV" until it stops, and then release it. NOTICE: Do not shift from "FWD" to "REV" or from "REV" to "FWD" while the - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 41
Operation help protect against corrosion. Be sure to clean the snowmobile when you get to your destination to remove any corrosive salts. ESU11420 Transporting When transporting your snowmobile on a trailer or in a truck, observe the following recommendations to help protect it from damage: G Make - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 42
has moving parts that can catch on body parts or clothing, and electrical parts that can cause shocks or fires. G Running the engine while servicing can lead to eye injury, burns, fire, or carbon monoxide poisoning-possibly leading to death. See page 3 for more information about carbon monoxide - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 43
Periodic maintenance and adjustment INITIAL ITEM REMARKS 1 month or 800 km (500 mi) (40 hr) EVERY Seasonally or 4000 km (2500 mi) (200 hr) PAGE * * * * Crankcase breather system Fuel filter Fuel line Idle speed • Check breather hose for cracks or damage. • Replace if necessary. • Check condition. - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 44
Periodic maintenance and adjustment ESU11561 General maintenance and lubrication chart INITIAL ITEM REMARKS 1 month or 800 km (500 mi) (40 hr) EVERY Seasonally or 4000 km (2500 mi) (200 hr) PAGE Engine oil * Engine oil filter cartridge Cooling system • Change (warm engine before draining) • - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 45
Periodic maintenance and adjustment INITIAL ITEM REMARKS 1 month or 800 km (500 mi) (40 hr) EVERY Seasonally or 4000 km (2500 mi) (200 hr) PAGE * Steering system • Check toe-out. • Adjust if necessary. • Check bearing assemblies for looseness. • Lubricate with specified grease. • Lubricate with - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 46
track air leak or carburetion problem for that cylinder. Do not attempt to diagnose such problems yourself. Instead, take the snowmobile (0.75 in) TIP If you do not have a torque wrench available during a service operation requiring one, take your snowmobile to a Yamaha dealer to check the torque - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 47
Periodic maintenance and adjustment 1. Spark plug gap 2. Spark plug reach 1. Throttle stop screw Before installing any spark plug, measure the electrode gap with a wire thickness gauge and adjust to specification. Spark plug gap: 0.7-0.8 mm (0.028-0.031 in) When installing the spark plug, always - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 48
Periodic maintenance and adjustment ESU11862 Checking the throttle override system (T.O.R.S.) Check the T.O.R.S. for proper operation. EWS00352 WARNING When checking the T.O.R.S., take precautions to avoid snowmobile movement which could cause an accident: G Make sure that the throttle lever moves - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 49
is less air as altitude increases. Less air means less oxygen available for combustion. Your snowmobile can be adjusted to overcome most of the problems found in high-altitude riding. Carburetor adjustments are the most important. Less air at high altitude makes the air/fuel ratio too rich, which - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 50
Periodic maintenance and adjustment sult a Yamaha dealer. The dealer can tell you if there are any changes necessary for the altitude where you plan to ride. NOTICE: The drive chain gears and V-belt clutch should be adjusted when operating above a high altitude of 900 m (3000 ft). Consult a Yamaha - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 51
Periodic maintenance and adjustment 5. Remove the oil filler cap, wipe the dipstick clean, insert it back into the oil filler hole (without screwing it in), and then remove it again to check the oil level. 7. Insert the dipstick into the oil filler hole, and then tighten the oil filler cap. 8. - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 52
Periodic maintenance and adjustment 2 1 1. Oil level gauge coupler 2. Oil filler cap 1. Engine oil drain bolt (crankcase) 2. " " mark 7. Remove the oil filler cap, cylinder head cap, and drain bolt to drain the oil from the oil tank. TIP G G G A " " mark is stamped on the crankcase near the - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 53
Periodic maintenance and adjustment Tightening torque: Oil filter cartridge: 17 Nm (1.7 m·kgf, 12 ft·lbf) 13. Install the engine oil drain bolts, and then tighten them to the specified torques. Tightening torques: Engine oil drain bolt (crankcase): 10 Nm (1.0 m·kgf, 7.2 ft·lbf) Engine oil drain bolt - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 54
Periodic maintenance and adjustment When the engine has cooled, place a thick rag or towel over the coolant reservoir cap, and slowly rotate the cap counterclockwise to the detent. This procedure allows any residual pressure to escape. When the hissing sound has stopped, press down on the cap while - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 55
Periodic maintenance and adjustment 4. 5. Install the coolant reservoir cap. Check for any coolant leakage. TIP If you find any leaks, consult a Yamaha dealer. ESU12052 V-belt EWS00401 WARNING G G Coming in contact with the rotating Vbelt or clutch parts can cause severe injury or death. Never - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 56
Periodic maintenance and adjustment 2. Rotate the secondary sliding sheave clockwise and push it so that it separates from the secondary fixed sheave. 1. Secondary sliding sheave 2. Secondary fixed sheave 3. Pull the V-belt up over the secondary fixed sheave. 1. Edge of the secondary sheave - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 57
Periodic maintenance and adjustment 1. Edge of the secondary sheave assembly 2. V-belt position Standard V-belt position: From 1.5 mm (0.06 in) above the edge of the secondary sheave assembly to 0.5 mm (0.02 in) below the edge 6. If the V-belt position is incorrect, adjust it by removing or adding - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 58
Periodic maintenance and adjustment 9. Rotate the secondary sliding sheave clockwise and push it so that it separates from the secondary fixed sheave. 1. Dipstick 3. 1. Secondary sliding sheave 2. Secondary fixed sheave 10. Install the V-belt between the secondary sliding and fixed sheaves. - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 59
failure in the brake system. Do not operate the snowmobile if you find any problems in the brake system. You could lose braking ability, which could lead to prevent brake lever damage when the snowmobile is placed on its side for service. Test the brake at a low speed when starting out to make sure - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 60
Periodic maintenance and adjustment Brake pad wear limit: 7.5 mm (0.30 in) Checking the parking brake pads Check the parking brake pads for wear by measuring the thickness of the pads. If the parking brake pads reach the wear limit, ask a Yamaha dealer to replace them. 1. 2. 3. 4. 5. Parking - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 61
Periodic maintenance and adjustment Checking the brake fluid level EWS00460 G WARNING Be careful that water does not enter the master cylinder when refilling. Water will significantly lower the boiling point of the fluid and may result in vapor lock. If the brake fluid level goes down, consult a - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 62
Periodic maintenance and adjustment To align the skis 1. Turn the handlebar so the skis face straight ahead. 2. Check the following for ski alignment: G Skis are facing forward. G Ski toe-out (distance A - distance B) is within specification. If excessive free play is felt, consult a Yamaha dealer. - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 63
to allow the drive track to spin, a suitable stand must be used to support the rear of the snowmobile. Never allow anyone to hold the rear of the is damaged to the depth where fabric reinforcement material is visible or support rods are broken. Otherwise, track damage or fail- 1. Area where - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 64
Periodic maintenance and adjustment ure could result in loss of braking ability and snowmobile control, which could cause an accident. Checking the drive track EWS00490 WARNING Do not operate the snowmobile if you find damage to the drive track, or if it has been maladjusted. Drive track damage or - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 65
Periodic maintenance and adjustment 1. Rear axle nut 3. 4. Start the engine and rotate the drive track one or two turns. Stop the engine. Check the drive track alignment with the slide runners. If the alignment is incorrect, align the drive track by turning the left and right adjusting nuts. 1. - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 66
Periodic maintenance and adjustment 5. Adjust the drive track deflection to specification. NOTICE: The right and left adjusting nuts should be turned an equal amount. [ECS00592] Drive track deflection Left adjusting nut Right adjusting nut More than specified Turn in Turn in Less than specified Turn - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 67
Periodic maintenance and adjustment 1 2 1. Throttle cable end 1. Headlight coupler 2. Bulb holder cover 4. Unhook the bulb holder by pushing it in, then upward. 1. Lubrication point 1. Bulb holder 5. 6. 1. Lubrication point ESU12211 Remove the bulb. Install the new bulb, and then hook the - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 68
Periodic maintenance and adjustment 1. Do not touch the glass part of the bulb. 1. Phillips screwdriver Bulb type: Halogen bulb 7. 8. Install the bulb holder cover, and then connect the headlight coupler. Close the shroud. 3. 4. To lower the headlight beam, turn the Phillips screwdriver in - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 69
Periodic maintenance and adjustment EYES: Flush with water for 15 minutes and get prompt medical attention. Batteries produce explosive gases. Keep sparks, flame, cigarettes, etc. away. Ventilate when charging or using in an enclosed space. Always shield your eyes when working near batteries. KEEP - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 70
Periodic maintenance and adjustment 7. Lift up the air filter case, slide the crankcase breather hose clamp (air filter case side) down, disconnect the crankcase breather hose from the air filter case, and then remove the air filter case. 1. Joint clamp screw 5. Slide the oil tank breather hose - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 71
Periodic maintenance and adjustment 10. Connect the negative battery lead. 11. Install the air filter case by reversing the removal steps. NOTICE: Be sure to connect the breather hoses securely when installing the air filter case. [ECS00641] TIP When installing the air filter case, connect the - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 72
Troubleshooting ESU12374 Engine turns over but does not start 1. Fuel system No fuel supplied to combustion chamber • No fuel in tank: Supply fuel. ↓ • Clogged fuel line: - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 73
Troubleshooting G Be sure to pull the lead covers back over the terminals completely. If the terminals are exposed, they could come into contact with the frame - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 74
Troubleshooting 7. Pull the black (-) connecting lead cover to expose the terminal through the slit in the cover, and then connect the black (-) jumper cable to the - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 75
Troubleshooting G G Clogged fuel system: See "Engine turns over but does not start- Yamaha dealer to inspect. Oily or dirty V-belt or primary and secondary sheave assembly surfaces: Clean. Problem with the driveline: See "V-belt twists" above. G Worn or sticking secondary sheave assembly: Ask - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 76
Storage ESU12413 Long-term storage requires some preventive procedures to guard against deterioration. marks. If the windshield is scratched, use a quality plastic polishing compound after washing. Cleaning Thoroughly clean the snowmobile, inside and out, to remove the corrosive salts and acids - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 77
a plastic or vinyl cover-condensation could be trapped underneath which could increase the chances of rusting. Returning to service after storage When returning your snowmobile to service, install the V-belt and battery and adjust the drive track. Remove the spark plugs and clean or replace them - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 78
3-cylinder Displacement: 973.0 cm³ Bore × stroke: 79.0 × 66.2 mm (3.11 × 2.61 in) Idling speed: 1300-1500 r/min Engine oil: Recommended grade: API service SG type or higher, JASO standard MA Type: YAMALUBE 4 0W-30, SAE 0W-30 Carburetor: Manufacturer: KEIHIN Model × quantity: CVK40 × 3 Fuel: Type - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 79
Specifications Without oil filter cartridge replacement: 2.8 L (2.96 US qt, 2.46 Imp.qt) Total amount: 3.7 L (3.91 US qt, 3.26 Imp.qt) Brake: Type: Hydraulic disc type (ventilated disc) Operation: Handle lever, left-hand operated Throttle: Operation: Handle lever, right-hand operated Electrical - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 80
Consumer information ESU12480 Identification number records Record the frame serial number, engine serial number (Primary ID), and key identification number in the spaces provided for assistance when ordering spare parts from a Yamaha dealer. Also, record and keep the ID numbers in a separate place - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 81
and maintain the snowmobile as specified in the appropriate Owner's Manual. WARRANTY TRANSFER: To transfer any remaining warranty from the original . An inspection and registration fee will be charged for this service. EMISSION CONTROL SYSTEM WARRANTY Yamaha Motor Corporation, USA also warrants - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 82
of having the dealer do them? A. Yes, if you are a qualified snowmobile mechanic and follow the procedures specified in the Owner's and Service Manual. We do recommend, however, that items requiring special tools or equipment be done by a Yamaha snowmobile dealer. Q. Under what conditions is the - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 83
machine requires warranty service, you must take it to any authorized Yamaha snowmobile dealer within the continental United States. Be sure to bring your warranty identification card or other valid proof of the original date of purchase. If a question or problem arises regarding warranty, first - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 84
Consumer information ESU12510 YAMAHA EXTENDED SERVICE (Y.E.S.) 78 - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 85
Index 2-up adjusting blocks, adjusting ...23 A Air filter, checking...42 Auxiliary DC jack ...14 B Backrest ...17 Battery...62 Brake and parking brake ...53 Brake lever ...15 Break-in...29 C Carburetors ...43 Center shock absorber and rear torsion springs, adjusting spring preload ...22 Control rods - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 86
Index Tool kit...40 Transporting ...35 Troubleshooting ...66 V Valve clearance...44 V-belt...49 V-belt holders ...17 - 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 87
- 2009 Yamaha Motorsports RS Venture | Owners Manual - Page 88
YAMAHA MOTOR CO., LTD. PRINTED IN JAPAN 2008.04-0.3×1 CR PRINTED ON RECYCLED PAPER
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
 |
 |
OWNER’S MANUAL
RST90Y
8ET-28199-14
LIT-12628-02-72
Read this manual carefully
before operating this vehicle.