2006 Polaris Ranger XP 700 EFI 4x4 Owners Manual - Page 107
2006 Polaris Ranger XP 700 EFI 4x4 Manual
Page 107 highlights
TROUBLESHOOTING Contact your Polaris dealer for service if you're unable to identify solutions using the following charts. Engine Doesn't Turn Over Possible Cause Low battery voltage Loose battery connections Loose solenoid connections Loose electronic control box connections Solution Recharge battery to 12.5 VDC Check all connections and tighten Check all connections and tighten Inspect, clean, reinstall connectors Engine Turns Over, Fails to Start Possible Cause Out of fuel Clogged fuel filter Water is present in fuel Old or non-recommended fuel Fouled or defective spark plug(s) No spark to spark plug Crankcase filled with water or fuel Clogged fuel filter Low battery voltage Mechanical failure Solution Refuel Inspect and clean or replace Drain the fuel system and refuel Replace with new fuel Inspect plug(s), replace if necessary Inspect plug(s), replace if necessary Immediately see your Polaris dealer Replace the filter Recharge battery to 12.5 VDC See your Polaris dealer Engine Pings or Knocks Possible Cause Poor quality or low octane fuel Incorrect ignition timing Incorrect spark plug gap or heat range Solution Replace with recommended fuel See your Polaris dealer Set gap to specs or replace plugs 104
-
1 -
2
-
3
-
4
-
5
-
6
-
7
-
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102 -
103 -
104 -
105 -
106 -
107 -
108 -
109 -
110 -
111 -
112 -
113
-
114
-
115
-
116
-
117
-
118
-
119
-
120
-
121
-
122
 |
 |
