2004 Polaris Sportsman 700 Owners Manual - Page 120

2004 Polaris Sportsman 700 Manual

Page 120 highlights

TROUBLESHOOTING Contact your Polaris dealer for service if you're unable to identify solutions using the following charts. Engine Doesn't Turn Over Possible Cause Tripped circuit breaker Low battery voltage Loose battery connections Loose solenoid connections Solution Reset the breaker Recharge battery to 12.5 VDC Check all connections and tighten Check all connections and tighten Engine Turns Over, Fails to Start Possible Cause Out of fuel Clogged fuel valve or filter Water is present in fuel Fuel valve is turned off Old or non-recommended fuel Fouled or defective spark plug(s) No spark to spark plug Crankcase filled with water or fuel Overuse of choke Clogged fuel filter Low battery voltage Mechanical failure Solution Refuel Inspect and clean or replace Drain the fuel system and refuel Turn the fuel valve on Replace with new fuel Inspect plug(s), replace if necessary Inspect plug(s), verify stop switch is on Immediately see your Polaris dealer Inspect, clean and/or replace spark plugs Replace the filter Recharge battery to 12.5 VDC See your Polaris dealer Engine Pings or Knocks Possible Cause Poor quality or low octane fuel Incorrect ignition timing Incorrect spark plug gap or heat range Solution Replace with recommended fuel See your Polaris dealer Set gap to specs or replace plugs 117

  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
  • 93
  • 94
  • 95
  • 96
  • 97
  • 98
  • 99
  • 100
  • 101
  • 102
  • 103
  • 104
  • 105
  • 106
  • 107
  • 108
  • 109
  • 110
  • 111
  • 112
  • 113
  • 114
  • 115
  • 116
  • 117
  • 118
  • 119
  • 120
  • 121
  • 122
  • 123
  • 124
  • 125
  • 126
  • 127
  • 128
  • 129
  • 130
  • 131
  • 132
  • 133
  • 134
  • 135
  • 136
  • 137

117
TROUBLESHOOTING
ContactyourPolarisdealerforserviceifyou’reunabletoidentify
solutionsusingthefollowingcharts.
EngineDoesn’tTurnOver
PossibleCause
Solution
Trippedcircuitbreaker
Resetthebreaker
Lowbatteryvoltage
Rechargebatteryto12.5VDC
Loosebatteryconnections
Checkallconnectionsandtighten
Loosesolenoidconnections
Checkallconnectionsandtighten
EngineTurnsOver,FailstoStart
PossibleCause
Solution
Outoffuel
Refuel
Cloggedfuelvalveorfilter
Inspectandcleanorreplace
Waterispresentinfuel
Drainthefuelsystemandrefuel
Fuelvalveisturnedoff
Turnthefuelvalveon
Oldornon-recommendedfuel
Replacewithnewfuel
Fouledordefectivesparkplug(s)
Inspectplug(s),replaceifnecessary
Nosparktosparkplug
Inspectplug(s),verifystopswitchison
Crankcasefilledwithwaterorfuel
ImmediatelyseeyourPolarisdealer
Overuseofchoke
Inspect,cleanand/orreplacesparkplugs
Cloggedfuelfilter
Replacethefilter
Lowbatteryvoltage
Rechargebatteryto12.5VDC
Mechanicalfailure
SeeyourPolarisdealer
EnginePingsorKnocks
PossibleCause
Solution
Poorqualityorlowoctanefuel
Replacewithrecommendedfuel
Incorrectignitiontiming
SeeyourPolarisdealer
Incorrectsparkpluggaporheatrange
Setgaptospecsorreplaceplugs