2011 Yamaha Motorsports V Star 650 Custom Owners Manual
2011 Yamaha Motorsports V Star 650 Custom Manual
2011 Yamaha Motorsports V Star 650 Custom manual content summary:
- 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 1
Read this manual carefully before operating this vehicle. OWNER'S MANUAL XVS65A(C) LIT-11626-24-10 1BF-28199-11 - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 2
EAU10042 Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold. - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 3
Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. Yamaha continually seeks advancements in product design and quality. Therefore, while this manual contains the most current product information available at the time of - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 4
INFORMATION EAU10132 Particularly important information is distinguished in this manual by the following notations: This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 5
INFORMATION EAU10193 XVS65A(C) OWNER'S MANUAL ©2010 by Yamaha Motor Corporation, U.S.A. 1st edition, April 2010 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A. - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 6
TABLE OF CONTENTS LOCATION OF IMPORTANT LABELS ...1-1 SAFETY INFORMATION ...2-1 DESCRIPTION ...3-1 Left view ...3-1 Right view ...3-2 Controls and instruments...3-3 INSTRUMENT AND CONTROL FUNCTIONS ...4-1 Main switch/steering lock ...4-1 Indicator and warning lights ...4-2 Speedometer unit ...4-3 - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 7
tail/brake light bulb ...7-32 Supporting the motorcycle ...7-33 Front wheel ...7-34 Rear wheel ...7-35 Troubleshooting ...7-37 Troubleshooting chart ...7-38 MOTORCYCLE CARE AND STORAGE CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...10-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...10-9 - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 8
LOCATION OF IMPORTANT LABELS EAU10384 1 Read and understand all of the labels on your vehicle. They contain important information for safe and proper operation of your vehicle. Never remove any labels from your vehicle. If a label becomes difficult to read or comes off, a replacement label is - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 9
LOCATION OF IMPORTANT LABELS 1 4 1 2 5 A1 3 TIRE INFORMATION Cold tire normal pressure should be set as follows. • Up to 90 kg (198 lbs) load FRONT : 200 kPa, (2.00 kgf/cm²), 29 psi REAR : 225 kPa, (2.25 kgf/cm²), 33 psi • 90kg (198 lbs) ~ maximum load FRONT : 200 kPa, (2.00 kgf/cm²), 29 psi - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 10
should: G Obtain thorough instructions from a competent source on all aspects of motorcycle operation. G Observe the warnings and maintenance requirements in this Owner's Manual. G Obtain qualified training in safe and proper riding techniques. G Obtain professional technical service as indicated in - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 11
SAFETY INFORMATION due to excessive speed or undercornering (insufficient lean angle for the speed). • Always obey the speed limit and never travel faster than warranted by road and traffic conditions. • Always signal before turning or changing lanes. Make sure that other motorists can see you. The - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 12
SAFETY INFORMATION G G 2 Do not run engine in poorly ventilated or partially enclosed areas such as barns, garages, or carports. Do not run engine outdoors where engine exhaust can be drawn into a building through openings such as windows and doors. Maximum load: XVS65A 180 kg (397 lb) XVS65AC - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 13
not be appropriate. Refer to page 7-18 for tire specifications and more information on replacing your tires. Transporting the Motorcycle Be sure to observe following instructions before transporting the motorcycle in another vehicle. G Remove all loose items from the motorcycle. - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 14
ahead on the trailer or in the truck bed, and choke it in a rail to prevent movement. Shift the transmission in gear (for models with a manual transmission). Secure the motorcycle with tiedowns or suitable straps that are attached to solid parts of the motorcycle, such as the frame or upper front - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 15
DESCRIPTION EAU10410 Left view 3 4 5 3 2 1 6,7 1. 2. 3. 4. 5. 6. 7. Shift pedal (page 4-5) Fuel cock (page 4-8) Starter (choke) knob (page 4-9) Shock absorber assembly spring preload adjusting ring (page 4-12) Helmet holder (page 4-11) Owner's tool kit (page 7-2) Storage compartment (page 4-11) - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 16
DESCRIPTION EAU10420 Right view 3 4 2,3 1 5 6 1. 2. 3. 4. 5. 6. Engine oil filter element (page 7-12) Battery (page 7-29) Fuses (page 7-30) Main switch/steering lock (page 4-1) Air filter element (page 7-15) Brake pedal (page 4-5) 3-2 - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 17
DESCRIPTION EAU10430 Controls and instruments 3 1. 2. 3. 4. 5. 6. 7. Clutch lever (page 4-4) Left handlebar switches (page 4-3) Speedometer unit (page 4-3) Fuel tank cap (page 4-6) Right handlebar switches (page 4-3) Throttle grip (page 7-17) Brake lever (page 4-5) 3-3 - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 18
INSTRUMENT AND CONTROL FUNCTIONS EAU10460 EAU10661 Main switch/steering lock OFF All electrical systems are off. The key can be removed. EWA10061 To lock the steering WARNING Never turn the key to "OFF" or "LOCK" while the vehicle is moving. Otherwise the electrical systems will be switched off, - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 19
indicator light " " This indicator light comes on when the transmission is in the neutral position. Engine trouble warning light " " This warning light comes on or flashes if a problem is detected in the electrical circuit monitoring the engine. If this occurs, have a Yamaha dealer check the - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 20
Speedometer unit Self-diagnosis device This model is equipped with a self-diagnosis device for various electrical circuits. If a problem is detected in any of those circuits, the engine trouble warning light will come on or flash. If this occurs, have a Yamaha dealer check the vehicle. Handlebar - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 21
15 seconds. However, the turn signal lights can also be canceled manually by pushing the switch in after it has returned to the center position switch to crank the engine with the starter. See page 6-1 for starting instructions prior to starting the engine. 1. Clutch lever The clutch lever is - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 22
INSTRUMENT AND CONTROL FUNCTIONS EAU12871 EAU12890 EAU12941 Shift pedal Brake lever Brake pedal 4 1. Shift pedal 2. Neutral position 1. Brake lever 1. Brake pedal The shift pedal is located on the left side of the motorcycle and is used in combination with the clutch lever when shifting the - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 23
WARNING Gasoline and gasoline vapors are extremely flammable. To avoid fires and explosions and to reduce the risk of injury when refueling, follow these instructions. 1. Before refueling, turn off the engine and be sure that no one is sitting on the vehicle. Never refuel while smoking, or while in - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 24
exceed 10% (E10). Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. NOTICE Use only unleaded gasoline. The use of leaded gasoline will cause severe damage to internal engine parts, such as the valves and piston - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 25
INSTRUMENT AND CONTROL FUNCTIONS EAU13445 ECA10701 EAU13550 Catalytic converters This vehicle is equipped with catalytic converters in the exhaust system. EWA10862 NOTICE Use only unleaded gasoline. The use of leaded gasoline will cause unrepairable damage to the catalytic converter. Fuel cock - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 26
INSTRUMENT AND CONTROL FUNCTIONS ON This indicates reserve. With the fuel cock lever in this position, the fuel reserve is made available. Turn the fuel cock lever to this position if you run out of fuel while riding. When this occurs, refuel as soon as possible and be sure to turn the fuel cock - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 27
INSTRUMENT AND CONTROL FUNCTIONS EAU14184 Seats Passenger seat To remove the passenger seat Remove the nut and washer, and then pull the passenger seat up. Tightening torque: Passenger seat nut: 13 Nm (1.3 m·kgf, 9.4 ft·lbf) 1. Bolt 2. Passenger seat holder 4 1. Passenger seat holder 2. - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 28
INSTRUMENT AND CONTROL FUNCTIONS 2. Install the passenger seat holder by installing its bolts. 3. Install the passenger seat. TIP Make sure that the seats are properly secured before riding. EAU14282 EAU14481 Helmet holder Storage compartment The storage compartment is located on the left side of - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 29
INSTRUMENT AND CONTROL FUNCTIONS EAU14865 Adjusting the shock absorber assembly This shock absorber assembly is equipped with a spring preload adjusting ring. ECA10101 G Use the special wrench and extension bar included in the owner's tool kit to make the adjustment. NOTICE To avoid damaging the - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 30
performance. G Do not dispose of a damaged or worn-out shock absorber assembly yourself. Take the shock absorber assembly to a Yamaha dealer for any service. Luggage strap holders Sidestand The sidestand is located on the left side of the frame. Raise the sidestand or lower it with your foot while - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 31
INSTRUMENT AND CONTROL FUNCTIONS this system regularly and have a Yamaha dealer repair it if it does not function properly. EAU15314 Ignition circuit cut-off system The ignition circuit cut-off system (comprising the sidestand switch, clutch switch and neutral switch) has the following functions. G - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 32
INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is set to " 3. Turn the key on. 4. Shift the transmission into the neutral position. 5. Push the start switch. Does the engine start? WARNING ". If a malfunction is - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 33
inspection and maintenance procedures and schedules described in the Owner's Manual. EWA11151 WARNING Failure to inspect or maintain the vehicle operate the vehicle if you find any problem. If a problem cannot be corrected by the procedures provided in this manual, have the vehicle inspected by a - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 34
FOR YOUR SAFETY - PRE-OPERATION CHECKS ITEM Check operation. Lubricate cable if necessary. Check lever free play. Adjust if necessary. CHECKS PAGE Clutch 7-20 Throttle grip • Make sure that operation is smooth. • Check cable free play. • If necessary, have Yamaha dealer adjust cable free play - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 35
OPERATION AND IMPORTANT RIDING POINTS EAU15951 EAU15999 Read the Owner's Manual carefully to become familiar with all controls. If there is a control or function you do not understand, ask your Yamaha dealer. EWA10271 Starting and warming - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 36
OPERATION AND IMPORTANT RIDING POINTS ECA11042 EAU16640 EAU16671 NOTICE For maximum engine life, never accelerate hard when the engine is cold! Starting a warm engine Follow the same procedure as for starting a cold engine with the exception that the starter (choke) is not required when the engine - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 37
OPERATION AND IMPORTANT RIDING POINTS ECA10260 NOTICE G G Even with the transmission in the neutral position, do not coast for long periods of time with the engine off, and do not tow the motorcycle for long distances. The transmission is properly lubricated only when the engine is running. - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 38
the engine, remove the key from the main switch, and then turn the fuel cock lever to "OFF". EWA10311 WARNING G NOTICE If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. G 6 G Since the engine and exhaust system can become - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 39
periodic maintenance charts should be simply considered as a general guide under normal riding conditions. However, depending on the weather electrical parts that can cause shocks or fires. G Running the engine while servicing can lead to eye injury, burns, fire, or carbon monoxide poisoning - - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 40
Owner's tool kit 1. Owner's tool kit 7 The owner's tool kit is located inside the storage compartment. (See page 4-11.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and minor - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 41
8000 mi (13000 km) or 12 months. Items marked with an asterisk require special tools, data and technical skills, have a Yamaha dealer perform the service. EAU17601 Periodic maintenance chart for the emission control system INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 42
PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months √ √ ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 7 * Idle speed • Check - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 43
PERIODIC MAINTENANCE AND ADJUSTMENT EAU32186 General maintenance and lubrication chart INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 44
PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 9 * Swingarm pivot bearings • - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 45
PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months √ ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 18 * Front fork • Check - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 46
PERIODIC MAINTENANCE AND ADJUSTMENT EAU17620 TIP G G The air filter needs more frequent service if you are riding in unusually wet or dusty areas. Hydraulic brake system • When disassembling the master cylinder or caliper cylinder, always replace the brake - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 47
PERIODIC MAINTENANCE AND ADJUSTMENT EAU18771 Removing and installing panels The panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a panel needs to be removed and installed. 1. Panel B EAU19193 To install the panel - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 48
the same color. TIP If any spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 1. Spark plug cap 2. Remove the spark plug as shown, with the spark plug wrench - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 49
PERIODIC MAINTENANCE AND ADJUSTMENT 3. Check each spark plug for electrode erosion and excessive carbon or other deposits, and replace it if necessary. Specified spark plug: NGK/DPR7EA-9 DENSO/X22EPR-U9 To install a spark plug 1. Clean the surface of the spark plug gasket and its mating surface, - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 50
PERIODIC MAINTENANCE AND ADJUSTMENT EAU19745 Engine oil and oil filter element The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil filter element replaced at the intervals specified in the periodic maintenance and lubrication chart. To check the - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 51
PERIODIC MAINTENANCE AND ADJUSTMENT Tightening torque: Engine oil drain bolt: 43 Nm (4.3 m·kgf, 31 ft·lbf) 9. Refill with the specified amount of the recommended oil, and then install and tighten the oil filler cap. Recommended engine oil: See page 9-1. Oil quantity: Without oil filter element - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 52
PERIODIC MAINTENANCE AND ADJUSTMENT er quality than specified. In addition, do not use oils labeled "ENERGY CONSERVING II" or higher. Make sure that no foreign material enters the crankcase. EAU20026 Final gear oil The final gear case must be checked for oil leakage before each ride. If any leakage - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 53
PERIODIC MAINTENANCE AND ADJUSTMENT EAU33383 Tightening torque: Final gear oil filler bolt: 23 Nm (2.3 m·kgf, 17 ft·lbf) Tightening torque: Final gear oil drain bolt: 23 Nm (2.3 m·kgf, 17 ft·lbf) Cleaning the air filter element The air filter element should be cleaned at the intervals specified - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 54
PERIODIC MAINTENANCE AND ADJUSTMENT 1 TIP If dust or water collects in the air filter check hose, remove the clamp from it, and then remove the plug to drain the hose. 2 1. Air filter element 3 7 4. Insert the air filter element into the air filter case as shown. NOTICE: Make sure that the air - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 55
PERIODIC MAINTENANCE AND ADJUSTMENT EAU21271 EAU44734 EAU21383 Carburetors The carburetors are important parts of the engine and emission control system, which require very sophisticated adjustment. Therefore, all carburetor adjustments should be left to a Yamaha dealer, who has the necessary - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 56
PERIODIC MAINTENANCE AND ADJUSTMENT EAU21401 EAU32524 Valve clearance The valve clearance changes with use, resulting in improper air-fuel mixture and/or engine noise. To prevent this from occurring, the valve clearance must be adjusted by a Yamaha dealer at the intervals specified in the periodic - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 57
PERIODIC MAINTENANCE AND ADJUSTMENT Tire inspection WARNING G EWA10562 EWA10461 WARNING The front and rear tires should be of the same make and design, otherwise the handling characteristics of the vehicle may be different, which could lead to an accident. After extensive tests, only the tires - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 58
PERIODIC MAINTENANCE AND ADJUSTMENT EAU21942 EAU22043 Spoke wheels EWA10610 WARNING The wheels on this model are not designed for use with tubeless tires. Do not attempt to use tubeless tires on this model. To maximize the performance, durability, and safe operation of your motorcycle, note the - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 59
PERIODIC MAINTENANCE AND ADJUSTMENT 6. To increase the clutch lever free play, turn the adjusting nut in direction (a). To decrease the clutch lever free play, turn the adjusting nut in direction (b). 7. Tighten the locknut at the crankcase. 8. Tighten the locknut at the clutch lever and then slide - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 60
PERIODIC MAINTENANCE AND ADJUSTMENT G A soft or spongy feeling in the brake lever can indicate the presence of air in the hydraulic system. If there is air in the hydraulic system, have a Yamaha dealer bleed the system before operating the motorcycle. Air in the hydraulic system will diminish the - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 61
PERIODIC MAINTENANCE AND ADJUSTMENT EWA11230 EAU22273 EAU22380 WARNING After adjusting the brake pedal position, the brake pedal free play must be adjusted. Brake pedal free play The brake pedal free play should measure 20.0-30.0 mm (0.79-1.18 in) at the brake pedal end. Periodically check the - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 62
PERIODIC MAINTENANCE AND ADJUSTMENT indicator grooves have almost disappeared, have a Yamaha dealer replace the brake pads as a set. EAU22540 EAU32344 Checking the brake fluid level G Rear brake shoes Use only the recommended quality brake fluid, otherwise the rubber seals may deteriorate, - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 63
PERIODIC MAINTENANCE AND ADJUSTMENT EAU22721 EAU23093 EAU49920 Changing the brake fluid Have a Yamaha dealer change the brake fluid at the intervals specified in the TIP after the periodic maintenance and lubrication chart. In addition, have the oil seals of the brake master cylinder and caliper as - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 64
PERIODIC MAINTENANCE AND ADJUSTMENT EAU44272 EAU23142 Checking and lubricating the brake and shift pedals Checking and lubricating the brake and clutch levers Brake lever Recommended lubricants: Brake lever: Silicone grease Clutch lever: Lithium-soap-based grease The operation of the brake and - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 65
oil leakage. To check the operation 1. Place the vehicle on a level surface and hold it in an upright position. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over. [EWA10751] 2. While applying the front brake, push down hard on the handlebars several - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 66
chart. 1. Place a stand under the engine to raise the front wheel off the ground. (See page 7-33 for more information.) WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over. [EWA10751] 2. Hold the lower ends of the front fork legs and try to move - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 67
PERIODIC MAINTENANCE AND ADJUSTMENT EAU23387 EWA10760 Battery G WARNING Electrolyte is poisonous and dangerous since it contains sulfuric acid, which causes severe burns. Avoid any contact with skin, eyes or clothing and always shield your eyes when working near batteries. In case of contact, - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 68
PERIODIC MAINTENANCE AND ADJUSTMENT nect the negative lead before disconnecting the positive lead. [ECA16302] EAU23526 Replacing the fuses avoid causing extensive damage to the electrical system and possibly a fire. [EWA15131] 2. If the battery will be stored for more than two months, check it at - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 69
PERIODIC MAINTENANCE AND ADJUSTMENT EAU23795 Specified fuses: Main fuse: 30.0 A Signaling system fuse: 10.0 A Ignition fuse: 10.0 A Headlight fuse: 15.0 A Carburetor heater fuse: 15.0 A Ignitor unit fuse: 5.0 A Replacing the headlight bulb This model is equipped with a quartz bulb headlight. If - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 70
PERIODIC MAINTENANCE AND ADJUSTMENT 5. Install the headlight bulb cover, and then connect the coupler. 6. Install the headlight unit by installing the screws. 7. Have a Yamaha dealer adjust the headlight beam if necessary. EAU24283 Replacing a turn signal light bulb or the tail/brake light bulb 1. - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 71
the screws, otherwise the lens may break. [ECA10681] EAU24350 Supporting the motorcycle Since this model is not equipped with a wheel. 2. Raise the front wheel off the ground by using a motorcycle stand. To service the rear wheel Raise the rear wheel off the ground by using a motorcycle stand or - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 72
retainer on the fork leg. 1. Wheel axle 2. Front wheel axle pinch bolt To remove the front wheel EWA10821 WARNING To avoid injury, securely support the vehicle so there is no danger of it falling over. 1. Disconnect the speedometer cable from the front wheel. 7 1. Speedometer cable 3. Lift the - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 73
EWA10821 4. Remove the brake pedal free play adjusting nut, and then disconnect the brake rod from the brake camshaft lever. WARNING To avoid injury, securely support the vehicle so there is no danger of it falling over. 1. Loosen the axle nut. 7. While applying the front brake, push down hard on - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 74
, wheel axle, final gear case, and drive shaft. TIP Make sure to support the drive shaft as it is being pulled out. EAU25512 To install the rear , final gear case, and drive shaft by pushing the wheel forward and guiding the drive shaft into the middle gear universal joint. 2. Install the final - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 75
ft·lbf) Troubleshooting Although Yamaha motorcycles receive a thorough inspection before shipment from the factory, trouble may occur during operation. Any problem in the Yamaha parts, but they are often inferior, have a shorter service life and can lead to expensive repair bills. EWA15141 heaters - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 76
PERIODIC MAINTENANCE AND ADJUSTMENT EAU25892 Troubleshooting chart 1. Fuel There is enough fuel. Check the fuel level in the fuel tank. There is no fuel. Supply fuel. Check the compression. The engine - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 77
spoked wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. Improper cleaning can damage plastic parts (such - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 78
MOTORCYCLE CARE AND STORAGE off any detergent residue using plenty of water, as it is harmful to plastic parts. Do not use any harsh chemical products on plastic parts. Be sure to avoid using cloths or sponges which have been in contact with strong or abrasive cleaning products, solvent or thinner, - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 79
(because of the presence of ammonia) and areas where strong chemicals are stored. 8 Long-term Before storing your motorcycle for several months: 1. Follow all the instructions in the "Care" section of this chapter. 8-3 - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 80
MOTORCYCLE CARE AND STORAGE 2. For motorcycles equipped with a fuel cock that has an "OFF" position: Turn the fuel cock lever to "OFF". 3. Drain the carburetor float chambers by loosening the drain bolts; this will prevent fuel deposits from building up. Pour the drained fuel into the fuel tank. 4. - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 81
81.0 × 63.0 mm (3.19 × 2.48 in) Compression ratio: 9.00 :1 Starting system: Electric starter Lubrication system: Wet sump Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter element replacement: 2.60 L (2.75 US qt, 2.29 Imp.qt) With - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 82
SPECIFICATIONS Gear ratio: 1st: 38/14 (2.714) 2nd: 38/20 (1.900) 3rd: 35/24 (1.458) 4th: 28/24 (1.167) 5th: 29/30 (0.967) Manufacturer/model: DUNLOP/K555 Front brake: Type: Single disc brake Operation: Right hand operation Recommended fluid: DOT 4 Loading: Maximum load: XVS65A 180 kg (397 lb) - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 83
lighting: 12 V, 1.7 W × 1 Neutral indicator light: 12 V, 1.7 W × 1 High beam indicator light: 12 V, 1.7 W × 1 Turn signal indicator light: 12 V, 1.7 W × 1 Engine trouble warning light: 12 V, 1.7 W × 1 Fuses: Main fuse: 30.0 A Headlight fuse: 15.0 A Signaling system fuse: 10.0 A Ignition fuse: 10 - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 84
CONSUMER INFORMATION EAU26352 EAU26381 EAU26400 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 85
CONSUMER INFORMATION EAU26470 EAU48061 Model label Vehicle Emission Control Information label 1. Model label 1 1. Vehicle Emission Control Information label The model label is affixed to the frame under the rider seat. (See page 4-10.) Record the information on this label in the space provided. - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 86
that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327 - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 87
CONSUMER INFORMATION EAU26560 Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 88
months 24000 mi (37000 km) or 36 months 28000 mi (43000 km) or 42 months 32000 mi (49000 km) or 48 months 10-5 Date of service Mileage Servicing dealer name and address Remarks 10 - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 89
CONSUMER INFORMATION Maintenance interval 36000 mi (55000 km) or 54 months 40000 mi (61000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 10 10-6 - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 90
1. Operate and maintain the motorcycle as specified in the appropriate Owner's Manual, and 2. Give notice to an authorized Yamaha motorcycle dealer of any . An inspection and registration fee will be charged for this service. EMISSION CONTROL SYSTEM WARRANTY: Yamaha Motor Corporation, U.S.A. also - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 91
in the Owner's and Service Manual. We do recommend, however service, you must take it to any authorized Yamaha motorcycle dealer within the continental United States. Be sure to bring your warranty registration card or other valid proof of the original date of purchase. If a question or problem - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 92
no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 93
isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 10 10-10 - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 94
Storage...8-3 Storage compartment...4-11 Supporting the motorcycle ...7-33 Swingarm 25 Tires ...7-18 Tool kit...7-2 Troubleshooting ...7-37 Troubleshooting chart ...7-38 Turn signal indicator light warm ...6-2 Engine stop switch ...4-4 Engine trouble warning light...4-2 N Neutral indicator light - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 95
INDEX Turn signal switch...4-4 V Valve clearance ...7-18 Vehicle Emission Control Information label...10-2 Vehicle identification number...10-1 W Warranty, extended ...10-9 Warranty, limited...10-7 Wheel bearings, checking ...7-28 Wheel (front) ...7-34 Wheel (rear)...7-35 Wheels...7-20 - 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 96
- 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 97
- 2011 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 98
YAMAHA MOTOR CO., LTD. PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2010.04-0.3×1 CR (E)
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
 |
 |
1BF-28199-11
XVS65A(C)
OWNER’S MANUAL
Read this manual carefully before operating this vehicle.
LIT-11626-24-10