2013 Yamaha Motorsports Zuma 50F Owners Manual

2013 Yamaha Motorsports Zuma 50F Manual

Get 2013 Yamaha Motorsports Zuma 50F PDF manuals and user guides View all 2013 Yamaha Motorsports Zuma 50F manuals

2013 Yamaha Motorsports Zuma 50F manual content summary:

  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 1
    Read this manual carefully before operating this vehicle. OWNER'S MANUAL YW50FD LIT-11626-26-39 1CD-F8199-11
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 2
    EAU10042 Q Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold.
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 3
    Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. Yamaha continually seeks advancements in product design and quality. Therefore, while this manual contains the most current product information available at the time of
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 4
    INFORMATION EAU10133 Particularly important information is distinguished in this manual by the following notations: Q This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 5
    INFORMATION EAUT2191 YW50FD OWNER'S MANUAL ©2012 by Yamaha Motor Corporation, U.S.A. 1st edition, June 2012 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A.
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 6
    the wheel bearings ...6-25 Battery...6-25 Replacing the fuse ...6-27 Replacing a headlight bulb...6-27 Tail/brake light...6-28 Replacing a turn signal light bulb ...6-28 Troubleshooting ...6-29 Troubleshooting charts...6-30 SCOOTER CARE AND STORAGE ...7-1 Matte color caution...7-1 Care ...7-1
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 7
    INFORMATION ...9-1 Identification numbers ...9-1 Vehicle Emission Control Information label ...9-2 Reporting safety defects ...9-3 Scooter noise regulation ...9-4 Maintenance record ...9-5 YAMAHA MOTOR CORPORATION, U.S.A. RIVA LIMITED WARRANTY ...9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...9-9
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 8
    EAU45762 Q LOCATION OF IMPORTANT SAFETY INFORMATION LABELS EAU10384 Read and understand all of the labels on your vehicle. They contain important information for safe and proper operation of your vehicle. Never remove any labels from your vehicle. If a label becomes difficult to read or comes off,
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 9
    EAU45762 Q SAFETY INFORMATION LOCATION OF IMPORTANT LABELS 1 LOAD LIMIT HOOK COMPARTMENT 1 kg {2lbs} 1.5 kg {3lbs} 5 TIRE INFORMATION 1 3B3-F1668-00 CHARGE LIMITE CROCHET COMPARTIMENT 1 kg {2lbs} 1.5 kg {3lbs} 3D1-F4877-11 2 3 4 5 6 7 8 9 2 WARNING AVERTISSEMENT 6 LOAD LIMIT 3 kg {7lbs} 5PJ-
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 10
    in safe and proper riding techniques. ● Obtain professional technical service as indicated in this Owner's Manual and/or when made necessary by mechanical conditions. ● Never operate a scooter without proper training or instruction. Take a training course. Beginners should receive training from
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 11
    Q erators. • Know your skills and limits. Staying within your limits may help you to avoid an accident. • We recommend that you practice riding your scooter where there is no traffic until you have become thoroughly familiar with the scooter and all of its controls. Many accidents have been caused by
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 12
    Q ● SAFETY INFORMATION Do not run engine indoors. Even if you try to ventilate engine exhaust with fans or open windows and doors, carbon monoxide can rapidly reach dangerous levels. Do not run engine in poorly ventilated or partially enclosed areas such as barns, garages, or carports. Do not run
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 13
    Q duce. Therefore, Yamaha can neither endorse nor recommend the use of accessories not sold by Yamaha or modifications not specifi cally recommended by Yamaha, even if sold and installed by a Yamaha dealer. Aftermarket Parts, Accessories, and Modifications While you may find aftermarket products similar
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 14
    Q SAFETY INFORMATION EAU45371 1 2 3 4 5 6 7 8 9 Transporting the Scooter Be sure to observe following instructions before transporting the scooter in another vehicle. ● Remove all loose items from the scooter. ● Point the front wheel straight ahead on the trailer or in
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 15
    Q SAFETY INFORMATION 1 2 3 4 5 6 7 8 9 1-8
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 16
    EAU10401 DESCRIPTION EAU10410 Left view 1 2 3 4 5 6 7 8 9 1. 2. 3. 4. 5. 6. 7. Front turn signal light (page 6-28) Fuel tank cap (page 3-6) Helmet holder (page 3-9) Battery (page 6-25) Storage compartment (page 3-10) Air filter (page 6-15) Rear turn signal light (page 6-28) 8. Centerstand (page 6-
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 17
    EAU10401 DESCRIPTION EAU10420 Right view 1 1 2 3 4 5 6 7 8 2 3 4 5 6 7 8 9 1. 2. 3. 4. 5. 6. 7. Rear wheel (page 6-17) Tail/brake light (page 6-28) Muffler (page 3-8) Seat (page 3-8) Spark plug (page 6-9) Coolant reservoir (page 6-13) Headlight (page 6-27) 8. Front wheel (page 6-17) 2-2
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 18
    EAU10401 DESCRIPTION EAU10430 Controls and instruments 1 2 3 4 5 6 7 8 9 1. 2. 3. 4. 5. 6. 7. Rear brake lever (page 3-5) Left handlebar switches (page 3-4) Speedometer unit (page 3-3) Fuel gauge (page 3-4) Main switch/steering lock (page 3-1) Brake fluid reservoir (page 6-21) Right handlebar
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 19
    EAU1044E INSTRUMENT AND CONTROL FUNCTIONS EAU45440 Main switch/steering lock ON OFF TIP The headlight comes on automatically when the engine is started and stays on until the key is turned to "OFF", even if the engine stalls. EAU10661 EAU10684 LOCK The steering is locked, and all electrical
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 20
    and the keyhole cover will close. 1. 2. 3. 4. Coolant temperature warning light " Turn signal indicator light "4 6" High beam indicator light "&" Engine trouble warning light " " " Turn signal indicator light "4 6" This indicator light fl ashes when the turn signal switch is pushed to the left or
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 21
    the radiator. If the engine overheats, see page 6-31 for further instructions. EAUT1934 EAUT1821 Speedometer unit 1 2 1 2 3 1. Speedometer 2. Odometer NOTICE Do not continue to operate the engine if it is overheating. Engine trouble warning light " " This warning light flashes or stays on if an
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 22
    EAU1044E INSTRUMENT AND CONTROL FUNCTIONS EAUT3470 EAU1234A Fuel gauge 1 1 2 3 4 5 6 7 8 9 1. Fuel gauge Handlebar switches Left Dimmer switch "&/%" Set this switch to " & " for the high beam and to "%" for the low beam. EAU12400 1 2 3 1. Dimmer switch "%/&" 2. Turn signal switch "4/6" 3.
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 23
    Push this switch while applying the front or rear brake to crank the engine with the starter. See page 5-1 for starting instructions prior to starting the engine. EAUM1132 EAU12901 EAU12951 Front brake lever 1 Rear brake lever 1 1 2 3 1. Front brake lever 1. Rear brake lever 4 5 6 7 8 9 The
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 24
    WARNING Gasoline and gasoline vapors are extremely flammable. To avoid fires and explosions and to reduce the risk of injury when refueling, follow these instructions. 1. Before refueling, turn off the engine and be sure that no one is sitting on the vehicle. Never refuel while smoking, or while in
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 25
    10% (E10). Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. 1 2 3 4 5 6 7 8 9 WARNING Gasoline is poisonous and can cause injury or death. Handle gasoline with care. Never siphon gasoline by mouth. If you
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 26
    EAU1044E INSTRUMENT AND CONTROL FUNCTIONS EAU13445 ECA10701 EAUT2541 Catalytic converters This vehicle is equipped with catalytic converters in the exhaust system. 1 2 3 4 5 6 7 8 9 EWA10862 WARNING The exhaust system is hot after operation. To prevent a fire hazard or burns: ● Do not park the
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 27
    EAU1044E INSTRUMENT AND CONTROL FUNCTIONS 3. Fold the seat up. To close the seat 1. Fold the seat down, and then push it down to lock it in place. 2. Remove the key from the main switch if the scooter will be left unattended. TIP Make sure that the seat is properly secured before riding. 1. Helmet
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 28
    EAU1044E INSTRUMENT AND CONTROL FUNCTIONS EAUT1717 Storage compartments ECA17840 Front storage compartment 1 1 1 2 3 4 5 6 7 8 9 NOTICE Keep the following points in mind when using the storage compartments. ● Since the storage compartments accumulate heat when exposed to the sun and/or the
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 29
    EAU1044E INSTRUMENT AND CONTROL FUNCTIONS EAU15112 EAUT3480 Carrier Luggage holder 1 2 1 1 3 4 5 6 7 8 9 1. Carrier EWA10171 1. Luggage holder ● ● WARNING Do not exceed the load limit of 3 kg (6.6 lb) for the carrier. Do not exceed the maximum load of 85 kg (187 lb) for the vehicle. Pull
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 30
    Always follow the inspection and maintenance procedures and schedules described in the Owner's Manual. EWA11151 1 2 3 4 5 6 7 8 9 WARNING Failure to the vehicle if you find any problem. If a problem cannot be corrected by the procedures provided in this manual, have the vehicle inspected by a Yamaha
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 31
    EAU15582 FOR YOUR SAFETY - PRE-OPERATION CHECKS Before using this vehicle, check the following points: ITEM Fuel • Check fuel level in fuel tank. • Refuel if necessary. • Check fuel line for leakage. • Check oil level in engine. • If necessary, add recommended oil to specified level. • Check vehicle
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 32
    EAU15582 FOR YOUR SAFETY - PRE-OPERATION CHECKS ITEM Brake levers CHECKS • Make sure that operation is smooth. • Lubricate lever pivoting if necessary. • Make sure that operation is smooth. • Lubricate pivots if necessary. • Make sure that all nuts, bolts and screws are properly tightened. •
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 33
    AND IMPORTANT RIDING POINTS EAU15951 EAUT1513 Read the Owner's Manual carefully to become familiar with all controls. If which could cause an accident or injury. EAU45310 NOTICE See page 5-3 for engine break-in instructions prior to operating the vehicle for the first time. 1. Turn the key to "ON"
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 34
    EAU15943 OPERATION AND IMPORTANT RIDING POINTS EAU16761 EAU16780 EAU16793 Starting off TIP 1 2 3 4 5 6 7 8 9 Acceleration and decelera- Braking tion (b) ● EWA10300 Before starting off, allow the engine to warm up. 1. While pulling the rear brake lever with your left hand and holding the grab
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 35
    to ten minutes. Vary the engine speed from time to time. Do not operate the engine at one set throttle position. NOTICE If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. 5-3
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 36
    EAU15943 OPERATION AND IMPORTANT RIDING POINTS EAU17213 Parking 1 2 3 4 5 6 7 8 ZAUM00** ZAUM00** When parking, stop the engine, and then remove the key from the main switch. ● ● ans or children are not likely to touch them and be burned. Do not park on a slope or on soft ground, otherwise the
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 37
    periodic maintenance charts should be simply considered as a general guide under normal riding conditions. However, depending on the weather, and electrical parts that can cause shocks or fires. ● Running the engine while servicing can lead to eye injury, burns, fi re, or carbon monoxide poisoning -
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 38
    mi (7000 km) or 12 months. Items marked with an asterisk require special tools, data and technical skills, have a Yamaha dealer perform the service. EAU17561 Periodic maintenance chart for the emission control system 3 4 5 1 * Fuel line NO. ITEM ROUTINE INITIAL 600 mi (1000 km) or 1 month 2000 mi
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 39
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL NO. ITEM ROUTINE 600 mi (1000 km) or 1 month 2000 mi (4000 km) or 6 months √ ODOMETER READING 4000 mi (7000 km) or 12 months √ 6000 mi (10000 km) or 18 months √ 8000 mi (13000 km) or 24 months √ 10000 mi (16000 km) or 30 months √ 1 2 3 4 5 6 7 8
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 40
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU32126 General maintenance and lubrication chart INITIAL ODOMETER READING 2000 mi (4000 km) or 6 months 4000 mi (7000 km) or 12 months 6000 mi (10000 km) or 18 months 8000 mi (13000 km) or 24 months 10000 mi (16000 km) or 30 months 1 2 3 4 5 NO.
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 41
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL NO. ITEM ROUTINE 600 mi (1000 km) or 1 month 2000 mi (4000 km) or 6 months ODOMETER READING 4000 mi (7000 km) or 12 months 6000 mi (10000 km) or 18 months 8000 mi (13000 km) or 24 months 10000 mi (16000 km) or 30 months 1 2 3 8 * Steering
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 42
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL NO. ITEM ROUTINE 600 mi (1000 km) or 1 month 2000 mi (4000 km) or 6 months √ ODOMETER READING 4000 mi (7000 km) or 12 months √ 6000 mi (10000 km) or 18 months √ 8000 mi (13000 km) or 24 months √ 10000 mi (16000 km) or 30 months √ 1 2 3 4 5 6 22
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 43
    to avoid damaging it. • The air filter element needs to be replaced more frequently when riding in unusually wet or dusty areas. Hydraulic brake service • After disassembling the brake master cylinder and caliper, always change the fluid. Regularly check the brake fluid level and fill the reservoir as
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 44
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU18771 EAUT3490 Removing and installing pan- Panel A To remove the panel els 1 2 3 4 5 6 7 8 9 1. Panel C 2. Panel A 3. Panel B Pull the panel outward as shown. Panel B To remove the panel Remove the screw, and then take the panel off. 1 2 3 1 1.
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 45
    normally). TIP If the spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 2. Check the spark plug for electrode erosion and excessive carbon or other deposits, and
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 46
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT To install the spark plug 1. Measure the spark plug gap with a wire thickness gauge and, if necessary, adjust the gap to specification. Spark plug gap: 0.7 - 0.8 mm (0.028 - 0.031 in) specified torque as soon as possible. 4. Install the spark plug cap. 5.
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 47
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT 3. Wait a few minutes until the oil settles, remove the oil filler cap, wipe the dipstick clean, insert it back into the oil filler hole (without screwing it in), and then remove it again to check the oil level. TIP The engine oil should be between the
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 48
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT 7. Install engine oil drain bolt A, and then tighten both drain bolts to their specified torques. 1 2 3 4 5 6 7 8 9 Tightening torque: Engine oil drain bolt A: 23 Nm (2.3 m·kgf, 16.6 ft·lbf) Engine oil drain bolt B: 32 Nm (3.2 m·kgf, 23.1 ft·lbf) EAUT1561
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 49
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT 1 terial enters the final transmission case. Make sure that no oil gets on the tire or wheel.[EWA11311] Tightening torque: Final transmission oil filler bolt: 23 Nm (2.3 m·kgf, 16.6 ft·lbf) EAU20070 Coolant The coolant level should be checked before each
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 50
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT reading. 2. Check the coolant level in the coolant reservoir. TIP 2 3 1. Coolant reservoir cap 1 1 The coolant should be between the minimum and maximum level marks. 4 5 6 7 8 9 1 2 1. Maximum level mark 2. Minimum level mark 3. If the coolant is
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 51
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAUT1491 Replacing the air fi lter element and cleaning the check hose The air fi lter element should be replaced at the intervals specified in the periodic maintenance and lubrication chart. Replace the air fi lter element more frequently if you are riding
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 52
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU44734 EAU21384 EAU21401 Checking the engine idling speed 1 2 3 4 5 6 7 8 9 Engine idling speed: 2000 - 2200 r/min Checking the throttle grip free play The throttle grip free play should measure 3.0 - 5.0 mm (0.12 - 0.20 in) at the inner edge of the
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 53
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAUT2153 Tires Tires are the only contact between the vehicle and the road. Safety in all conditions of riding depends on a relatively small area of road contact. Therefore, it is essential to maintain the tires in good condition at all times and
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 54
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT worn-out tire. When a tire tread begins to show crosswise lines, have a Yamaha dealer replace the tire immediately. The replacement of all wheeland brake-related parts, including the tires, should be left to a Yamaha dealer, who has the necessary
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 55
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT control and an accident. EAU22170 Adjusting the rear brake lever free play 1 (b) (a) 1. Adjusting nut 1 2 1 3 4 5 6 7 8 9 1. Rear brake lever free play The brake lever free play should measure 10 ~ 20 mm (0.4 ~ 0.8 in) as shown. Periodically check
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 56
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU22380 C h e ck i n g t h e f ro n t b r a k e pads and rear brake shoes 1 2 3 The front brake pads and the rear brake shoes must be checked for wear at the intervals specifi ed in the periodic maintenance and lubrication chart. EAU22410 position of
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 57
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU32345 Checking the brake fluid level ● ● 1 ● 1. Minimum level mark Before riding, check that the brake fluid is above the minimum level mark. Check the brake fl uid level with the top of the reservoir level. Replenish the brake fluid if necessary.
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 58
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU22721 EAU23095 EAU23114 Changing the brake fluid 1 2 3 4 5 6 7 8 9 Checking and lubricating the Checking and lubricating the throttle grip and cable Have a Yamaha dealer change the cables brake fluid at the intervals specified in the TIP after the
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 59
    oil leakage. To check the operation 1. Place the vehicle on a level surface and hold it in an upright position. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over.[EWA10751] 2. While applying the front brake, push down hard on the handlebars several times
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 60
    as follows at the intervals specified in the periodic maintenance and lubrication chart. 1. Place the vehicle on the centerstand. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over.[EWA10751] 2. Hold the lower ends of the front fork legs and try to move
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 61
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU23291 EAUT2005 Checking the wheel bearings The front and rear wheel bearings must be checked at the intervals specified in the periodic maintenance and lubrication chart. If there is play in the wheel hub or if the wheel does not turn smoothly, have a
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 62
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT The battery is located under the seat. Remove panel C to access the battery. (See page 6-9.) 1 2 3 4 ECA16521 To charge the battery Have a Yamaha dealer charge the battery as soon as possible if it seems to have discharged. Keep in mind that the battery
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 63
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAUT2023 Replacing the fuse installing the main fuse, be sure to turn the main switch from "ON" to "OFF" three times in 3 seconds intervals to initialize the idle speed control system.[ECAT1062] Specified fuse: 15 A EAU34241 Replacing a headlight bulb
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 64
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU43040 EAU24204 Tail/brake light 1 Replacing a turn signal light bulb 1 1. Remove the turn signal light lens by removing the screw. 2 3 1 4 5 6 7 8 9 1. Tail/brake light 2 2. Remove the burnt-out bulb by pushing it in and turning it
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 65
    trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause poor starting and loss of power. The following troubleshooting parts, but they are often inferior, have a shorter service life and can lead to expensive repair bills. EWA15141 the
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 66
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU42704 Troubleshooting charts Starting problems or poor engine performance 1 2 3 1. Fuel There is enough fuel. Check the fuel level in the fuel tank. There is no fuel. Supply fuel. Check the
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 67
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT Engine overheating EWAT1040 ● ● WARNING Do not remove the radiator cap when the engine and radiator are hot. Scalding hot fluid and steam may be blown out under pressure, which could cause serious injury. Be sure to wait until the engine has cooled.
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 68
    on spoked wheels. If such products are used on hard-toremove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. ● Improper cleaning can damage plastic parts
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 69
    EAU25991 SCOOTER CARE AND STORAGE with water, diluted mild detergent with water may be used. Be sure to rinse off any detergent residue using plenty of water, as it is harmful to plastic parts. Do not use any harsh chemical products on plastic parts. Be sure to avoid using cloths or sponges which
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 70
    (because of the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your scooter for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. Fill up the fuel tank and add fuel 7-3
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 71
    EAU25991 SCOOTER CARE AND STORAGE stabilizer (if available) to prevent the fuel tank from rusting and the fuel from deteriorating. 3. Perform the following steps to protect the cylinder, piston rings, etc. from corrosion. a. Remove the spark plug cap and spark plug. b. Pour a teaspoonful of engine
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 72
    38.0 x 43.6 mm (1.50 x 1.72 in) Compression ratio 12.00 : 1 Starting system Electric starter Lubrication system Wet sump Recommended engine oil grade API service SG type or higher, JASO standard MA Periodic oil change 0.78 L (0.82 US qt, 0.69 Imp.qt) Clutch Clutch type Dry, centrifugal automatic
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 73
    lighting 12 V, 1.7 W x 1 High beam indicator light 12 V, 1.7 W x 1 Turn signal indicator light 14 V, 3.0 W x 1 Coolant temperature warning light 12 V, 1.7 W x 1 Engine trouble warning light 12 V, 1.7 W x 1 Rear tire Type Tubeless Size 120/90-10 57J Manufacturer/model CHENG SHIN / C-6022 Rear brake
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 74
    SPECIFICATIONS 1 2 3 4 5 6 7 8 9 8-3
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 75
    EAU26343 CONSUMER INFORMATION EAU26353 EAU26381 EAU26410 Identification numbers Record the key identifi cation number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 76
    EAU26343 CONSUMER INFORMATION EAUT1440 EAU48270 Model label 1 1 Vehicle Emission Control Information label 1 2 3 4 5 6 7 8 9 1. Model label The model label is affixed to the inside of the storage compartment. (See page 3-10.) Record the information on this label in the space provided. This
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 77
    that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 78
    EAU26343 CONSUMER INFORMATION EAU26580 Scooter noise regulation 1 2 3 4 5 Exhaust system TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance,
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 79
    24 months 10000 mi (16000 km) or 30 months 12000 mi (19000 km) or 36 months 14000 mi (22000 km) or 42 months Date of service Mileage Servicing dealer name and address Remarks 1 2 3 4 5 6 7 8 9 9-5
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 80
    EAU26343 CONSUMER INFORMATION Maintenance interval 16000 mi (25000 km) or 48 months 18000 mi (28000 km) or 54 months 20000 mi (31000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 1 2 3 4 5 6 7 8 9 9-6
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 81
    EAU26343 CONSUMER INFORMATION EAU26681 YAMAHA MOTOR CORPORATION, U.S.A. RIVA LIMITED WARRANTY 1 2 3 4 5 6 7 8 9 9-7
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 82
    EAU26343 CONSUMER INFORMATION 1 2 3 4 5 6 7 8 9 9-8
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 83
    no extra cost. TRIP gives you up to $250 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 84
    isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 9-10
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 85
    Throttle grip free play, checking...6-16 Tires ...6-17 Troubleshooting ...6-29 Troubleshooting charts ...6-30 Turn signal indicator light ...3-2 Turn checking ...6-16 Engine oil ...6-10 Engine stop switch ...3-4 Engine trouble warning light...3-3 N Noise regulation ...9-4 V Valve clearance ...6-
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 86
    INDEX Warranty, limited ...9-7 Wheels ...6-18 Wheel bearings, checking...6-25
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 87
    Yamaha engineering teams that know your Yamaha from the inside out. Genuine Yamaha Service Manuals - Get the same factory manual for your vehicle that the technicians at your authorized Yamaha dealer use. Service manuals are available through your Yamaha dealer or you can order them directly through
  • 2013 Yamaha Motorsports Zuma 50F | Owners Manual - Page 88
    PRINTED IN TAIWAN 2012.06-0.8 × 1 ! (E)
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
1CD-F8199-11
YW50FD
OWNER’S MANUAL
Read this manual carefully before operating this vehicle.
LIT-11626-26-39