2011 Yamaha Motorsports Zuma 125 Owners Manual

2011 Yamaha Motorsports Zuma 125 Manual

Get 2011 Yamaha Motorsports Zuma 125 PDF manuals and user guides View all 2011 Yamaha Motorsports Zuma 125 manuals

2011 Yamaha Motorsports Zuma 125 manual content summary:

  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 1
    Read this manual carefully before operating this vehicle. OWNER'S MANUAL YW125A LIT-11626-24-60 32S-F8199-12
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 2
    EAU10042 Q Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold.
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 3
    Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. Yamaha continually seeks advancements in product design and quality. Therefore, while this manual contains the most current product information available at the time of
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 4
    INFORMATION EAU10132 Particularly important information is distinguished in this manual by the following notations: Q This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 5
    INFORMATION EAUT2191 YW125A OWNER'S MANUAL ©2010 by Yamaha Motor Corporation, U.S.A. 1st edition, July 2010 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A.
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 6
    bearings ...6-25 Battery...6-26 Replacing the fuses...6-27 Replacing a headlight bulb...6-28 Tail/brake light...6-29 Replacing a turn signal light bulb ...6-29 Troubleshooting ...6-30 Troubleshooting chart ...6-31 SCOOTER CARE AND STORAGE ...7-1 Matte color caution...7-1 Care ...7-1 Storage...7-3
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 7
    INFORMATION ...9-1 Identification numbers ...9-1 Vehicle Emission Control Information label ...9-2 Reporting safety defects ...9-3 Motorcycle noise regulation ...9-4 Maintenance record ...9-5 YAMAHA MOTOR CORPORATION, U.S.A. RIVA LIMITED WARRANTY ...9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...9-9
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 8
    EAU45762 Q LOCATION OF IMPORTANT SAFETY INFORMATION LABELS EAU10384 Read and understand all of the labels on your vehicle. They contain important information for safe and proper operation of your vehicle. Never remove any labels from your vehicle. If a label becomes difficult to read or comes off,
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 9
    EAU45762 Q SAFETY INFORMATION LOCATION OF IMPORTANT LABELS 1 175kpa, {1.75kgf/cm2},25psi 200kpa, {2.00kgf/cm2},29psi 200kpa, {2.00kgf/cm2},29psi 225kpa, {2.25kgf/cm2},33psi 24P-F1668-00 4 4JK-F8446-01 1 2 2 5 3 4 5 6 7 8 9 3 1-2
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 10
    should: ● Obtain thorough instructions from a competent source on all aspects of scooter operation. ● Observe the warnings and maintenance requirements in this Owner's Manual. ● Obtain qualifi ed training in safe and proper riding techniques. ● Obtain professional technical service as indicated in
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 11
    Q angle for the speed). • Always obey the speed limit and never travel faster than warranted by road and traffi c conditions. • Always signal before turning or changing lanes. Make sure that other motorists can see you. The posture of the operator and passenger is important for proper control. • The
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 12
    Q ● SAFETY INFORMATION rapidly reach dangerous levels. Do not run engine in poorly ventilated or partially enclosed areas such as barns, garages, or carports. Do not run engine outdoors where engine exhaust can be drawn into a building through openings such as windows and doors. limit. Operation of
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 13
    be appropriate. Refer to page 6-15 for tire specifications and more information on replacing your tires. Transporting the Scooter Be sure to observe following instructions before transporting the scooter in another vehicle.
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 14
    Q ● ● SAFETY INFORMATION Remove all loose items from the scooter. Point the front wheel straight ahead on the trailer or in the truck bed, and choke it in a rail to prevent movement. Secure the scooter with tie-downs or suitable straps that are attached to solid parts of the scooter, such as the
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 15
    Q SAFETY INFORMATION 1 2 3 4 5 6 7 8 9 1-8
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 16
    EAU10401 DESCRIPTION EAU10410 Left view 1 2 1 3 3 4 4 5 6 7 8 2 5 6 7 8 9 1. 2. 3. 4. 5. 6. 7. Front turn signal light (page 6-29) Battery (page 6-26) Helmet holder (page 3-9) Sidestand (page 3-10) V-belt case air filter cover (page 6-14) Centerstand (page 6-23) Air filter (page 6-14) 8. Rear
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 17
    EAU10401 DESCRIPTION EAU10420 Right view 1 2 2 1 3 4 5 7 3 6 4 5 6 7 8 9 1. 2. 3. 4. 5. 6. 7. Tail/brake light (page 6-29) Muffler (page 3-7) Storage compartment (page 3-9) Seat (page 3-8) Fuel tank cap (page 3-5) Spark plug (page 6-10) Headlight (page 6-28) 2-2
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 18
    EAU10401 DESCRIPTION EAU10430 Controls and instruments 1 2 3 4 5 6 7 8 9 1. 2. 3. 4. 5. 6. 7. Rear brake lever (page 6-19) Left handlebar switches (page 3-4) Speedometer unit (page 3-3) Fuel gauge (page 3-3) Brake fluid reservoir (page 6-21) Right handlebar switches (page 3-4) Front brake lever (
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 19
    EAU1044E INSTRUMENT AND CONTROL FUNCTIONS EAU45440 Main switch/steering lock TIP The headlight comes on automatically when the engine is started and stays on until the key is turned to "OFF". EAU10661 EAU10683 LOCK The steering is locked, and all electrical systems are off. The key can be
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 20
    Push the keyhole cover lever inward and the keyhole cover will close. 1. Turn signal indicator light "4 6" 2. High beam indicator light "&" 3. Engine trouble warning light " " Turn signal indicator light "4 6" This indicator light fl ashes when the turn signal switch is pushed to the left or right
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 21
    EAU1044E INSTRUMENT AND CONTROL FUNCTIONS EAUT1934 EAUT1821 EAU12140 Engine trouble warning light " " This warning light flashes or stays on if an electrical circuit monitoring the engine is not working correctly. If this occurs, have a Yamaha
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 22
    to sound the horn. EAU12460 Start switch "," Push this switch to crank the engine with the starter. See page 5-1 for starting instructions prior to starting the engine. EAU12711 EAU12500 Right 1 2 1. Engine stop switch "#/$" 2. Start switch "," Engine stop switch "#/$" Set this switch to
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 23
    EAU1044E INSTRUMENT AND CONTROL FUNCTIONS EAU12900 EAU12950 EAU13041 Front brake lever 1 Rear brake lever 1 Fuel tank cap 1 1 LO CK 2 3 1. Front brake lever 1. Rear brake lever 1. Fuel tank cap 4 5 6 7 8 9 The front brake lever is located on the right handlebar grip. To apply the front
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 24
    WARNING Gasoline and gasoline vapors are extremely flammable. To avoid fires and explosions and to reduce the risk of injury when refueling, follow these instructions. 1. Before refueling, turn off the engine and be sure that no one is sitting on the vehicle. Never refuel while smoking, or while in
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 25
    containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. EAU13433 Catalytic converter This model is equipped with a catalytic converter in the exhaust system. EWA10862 1 2 3 4 5 6 7 8 9 Recommended fuel UNLEADED GASOLINE
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 26
    EAU1044E INSTRUMENT AND CONTROL FUNCTIONS ECA10701 EAUT2670 1 2 NOTICE Use only unleaded gasoline. The use of leaded gasoline will cause unrepairable damage to the catalytic converter. Seat 1 1 PUSH "ON" to "OPEN". To close the seat 1. Fold the seat down, and then push it down to lock it in
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 27
    5 kg (11 lb) for the storage compartment. Do not exceed the maximum load of 155 kg (342 lb) for the vehicle. When storing the Owner's Manual or other documents in the storage compartment, be sure to wrap them in a plastic bag so that they will not get wet. When washing the
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 28
    EAU1044E INSTRUMENT AND CONTROL FUNCTIONS careful not to let any water enter the storage compartment. 1 2 EAU15304 EWA10241 Sidestand 1 3 4 5 6 7 8 9 1. Sidestand The sidestand is located on the left side of the frame. Raise the sidestand or lower it with your foot while holding the vehicle
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 29
    EAU1044E INSTRUMENT AND CONTROL FUNCTIONS EAU45051 Ignition circuit cut-off system The ignition circuit cut-off system (comprising the sidestand switch and brake light switches) has the following functions. ● It prevents starting when the sidestand is up, but neither brake is applied. ● It
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 30
    EAU1044E INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is turned on. 3. Turn the key on. 4. Keep the front or rear brake applied. 5. Push the start switch. Does the engine start? WARNING If a malfunction is noted,
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 31
    inspect or maintain the vehicle properly increases the possibility of an accident or equipment damage. Do not operate the vehicle if you find any problem. If a problem cannot be corrected by the procedures provided in this manual, have the vehicle inspected by a Yamaha dealer. 1 2 3 4 5 6 7 8 9 4-1
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 32
    EAU15582 FOR YOUR SAFETY - PRE-OPERATION CHECKS Before using this vehicle, check the following points: ITEM Fuel • Check fuel level in fuel tank. • Refuel if necessary. • Check fuel line for leakage. • Check oil level in engine. • If necessary, add recommended oil to specified level. • Check vehicle
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 33
    EAU15582 FOR YOUR SAFETY - PRE-OPERATION CHECKS ITEM Brake levers Centerstand, sidestand Chassis fasteners Instruments, lights, signals and switches Engine stop switch Sidestand switch CHECKS • Make sure that operation is smooth. • Lubricate lever pivoting points if necessary. • Make sure that
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 34
    7 8 9 Read the Owner's Manual carefully to become familiar with all EAU45310 NOTICE See page 5-3 for engine break-in instructions prior to operating the vehicle for the first sure that the engine stop switch is set to "#". The engine trouble warning light should come on for a few seconds, then go
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 35
    EAU15943 OPERATION AND IMPORTANT RIDING POINTS EAU16761 EAU16780 EAU16793 Starting off TIP Before starting off, allow the engine to warm up. 1. While pulling the rear brake lever with your left hand and holding the grab bar with your right hand, push the scooter off the centerstand. 2. Sit astride
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 36
    to ten minutes. Vary the engine speed from time to time. Do not operate the engine at one set throttle position. NOTICE If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. 5-3
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 37
    EAU15943 OPERATION AND IMPORTANT RIDING POINTS EAU17213 Parking When parking, stop the engine, and then remove the key from the main switch. EWA10311 1 2 3 4 5 6 7 8 9 ● ● ● WARNING Since the engine and exhaust system can become very hot, park in a place where pedestrians or children are not
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 38
    periodic maintenance charts should be simply considered as a general guide under normal riding conditions. However, depending on the weather, and electrical parts that can cause shocks or fires. ● Running the engine while servicing can lead to eye injury, burns, fi re, or carbon monoxide poisoning -
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 39
    1. Owner's tool kit 4 5 6 7 8 9 The owner's tool kit is located inside the storage compartment under the seat. (See page 3-8.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 40
    mi (7000 km) or 12 months. Items marked with an asterisk require special tools, data and technical skills, have a Yamaha dealer perform the service. EAU17561 Periodic maintenance chart for the emission control system 3 4 5 1 * Fuel line NO. ITEM ROUTINE INITIAL 600 mi (1000 km) or 1 month 2000 mi
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 41
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL NO. ITEM ROUTINE 600 mi (1000 km) or 1 month √ 2000 mi (4000 km) or 6 months √ ODOMETER READING 4000 mi (7000 km) or 12 months √ 6000 mi (10000 km) or 18 months √ 8000 mi (13000 km) or 24 months √ 10000 mi (16000 km) or 30 months √ 1 2 3 4 5 6 7
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 42
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU32126 General maintenance and lubrication chart INITIAL ODOMETER READING 2000 mi (4000 km) or 6 months 4000 mi (7000 km) or 12 months 6000 mi (10000 km) or 18 months 8000 mi (13000 km) or 24 months 10000 mi (16000 km) or 30 months 1 NO. ITEM
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 43
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL NO. ITEM ROUTINE 600 mi (1000 km) or 1 month 2000 mi (4000 km) or 6 months ODOMETER READING 4000 mi (7000 km) or 12 months 6000 mi (10000 km) or 18 months 8000 mi (13000 km) or 24 months 10000 mi (16000 km) or 30 months 1 2 3 9 * Steering
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 44
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL NO. ITEM ROUTINE 600 mi (1000 km) or 1 month √ √ 2000 mi (4000 km) or 6 months ODOMETER READING 4000 mi (7000 km) or 12 months √ √ Every 10500 mi (18000 km 6000 mi (10000 km) or 18 months 8000 mi (13000 km) or 24 months √ √ 10000 mi (16000 km)
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 45
    damaging it. • The air filter element needs to be replaced and V-belt filter needs to be serviced more frequently when riding in unusually wet or dusty areas. Hydraulic brake service • After disassembling the brake master cylinder and caliper, always change the fluid. Regularly check the brake fluid
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 46
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU18771 EAU19272 EAUT2532 Removing and installing pan- Panel A To remove the panel els 1 2 3 4 5 6 7 8 9 1. Panel A 2. Panel B The panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 47
    normally). TIP If the spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 2. Check the spark plug for electrode erosion and excessive 6-10 2. Clean the surface of
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 48
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT when installing a spark plug, a good estimate of the correct torque is 1/4-1/2 turn past finger tight. However, the spark plug should be tightened to the specified torque as soon as possible. 4. Install the spark plug cap. 5. Install the panel. EAUT2592
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 49
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT 3. Remove the engine oil fi ller cap and the engine oil drain bolt to drain the oil from the crankcase. Tightening torque: Engine oil drain bolt: 20 Nm (2.0 m·kgf, 14.5 ft·lbf) 5. Refi ll with the specifi ed amount of the recommended engine oil, and then
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 50
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU20065 Final transmission oil 1 2 3 4 5 6 7 8 9 The fi nal transmission case must be checked for oil leakage before each ride. If any leakage is found, have a Yamaha dealer check and repair the scooter. In addition, the final transmission oil must be
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 51
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT 8. Install the fi nal transmission oil filler cap and its new O-ring, and then tighten the oil filler cap. 9. Check the final transmission case for oil leakage. If oil is leaking, check for the cause. EAUT2660 Air fi lter and V-belt case air filter elements
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 52
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT Cleaning the V-belt case air fi lter element 1 2 3 2. Remove the filter element holder by removing the screw. type to the entire surface of the sponge material, and then squeeze the excess oil out. TIP The air fi lter element should be wet but not
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 53
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU44734 EAU21384 EAU21401 Checking the engine idling speed Check the engine idling speed and, if necessary, have it corrected by a Yamaha dealer. Engine idling speed: 1700 - 1900 r/min Checking the throttle grip free play Valve clearance The valve
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 54
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAUT1703 Tires 1 2 3 4 5 6 7 8 9 Tire inspection Tire air pressure (measured on cold tires): Up to 90 kg (198 lb): Front: 175 kPa (1.75 kgf/cm2, 25 psi) Rear: 200 kPa (2.00 kgf/cm2, 29 psi) 90 kg (198 lb) to maximum load: Front: 200 kPa (2.00 kgf/cm2,
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 55
    . Have excessively worn tires replaced by a Yamaha dealer immediately. Brakes, tires, and related wheel parts replacement should be left to a Yamaha Service Technician. After extensive tests, only the tires listed below have been approved for this model by Yamaha Motor Co., Ltd. ● ● WARNING
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 56
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU49350 Checking the front brake lever free play 1 2 3 4 control and an accident. EAU22170 Adjusting the rear brake lever free play 1 There should be no free play at the brake lever end. If there is free play, have a Yamaha dealer inspect the brake
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 57
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU22380 C h e ck i n g t h e f ro n t b r a k e pads and rear brake shoes (b) 1 (a) 1. Adjusting nut The front brake pads and the rear brake shoes must be checked for wear at the intervals specifi ed in the periodic maintenance and lubrication chart.
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 58
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT shoes as a set. EAU32344 Checking the brake fluid level ● 1 2 3 4 5 6 7 8 9 the handlebars. Use only the recommended quality brake fl uid, otherwise the rubber seals may deteriorate, causing leakage and poor braking performance. 1 Recommended brake fl
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 59
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT check the cause. EAU22721 EAU23093 Changing the brake fluid Checking and lubricating the Have a Yamaha dealer change the cables brake fluid at the intervals specified in the TIP after the periodic maintenance and lubrication chart. In addition, have the
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 60
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU23113 EAU43641 EAU23213 Checking and lubricating the Lubricating the front and rear Checking and lubricating the throttle grip and cable brake levers centerstand and sidestand 1 2 3 4 5 6 7 8 9 The operation of the throttle grip should be checked
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 61
    oil leakage. To check the operation 1. Place the vehicle on a level surface and hold it in an upright position. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over.[EWA10751] 2. While applying the front brake, push down hard on the handlebars several times
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 62
    as follows at the intervals specified in the periodic maintenance and lubrication chart. 1. Place the vehicle on the centerstand. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over.[EWA10751] 2. Hold the lower ends of the front fork legs and try to move
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 63
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAUT2691 EWA10760 Battery ● 1 1. Battery This model is equipped with a VRLA (Valve Regulated Lead Acid) battery. There is no need to check the electrolyte or to add distilled water. However, the battery lead connections need to be checked and, if
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 64
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT more than one month, remove the battery, fully charge it, and then place it in a cool, dry place. NOTICE: When removing the battery, be sure the key is turned to "OFF", then disconnect the negative lead before disconnecting the positive lead.[ECA16302]
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 65
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU34240 1 1. Spare fuse Specified fuses: Main fuse: 20 A Ignition fuse: 10 A Signaling system fuse: 15 A Headlight fuse: 10 A Fuel injection system fuse: 10 A Replacing a headlight bulb 1 1 2 3 1. Headlight 2. Remove the blown fuse, and then install
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 66
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU43040 EAU24204 Tail/brake light 1 2 3 1. Tail/brake light Replacing a turn signal light bulb 1 1. Remove the turn signal light lens by removing the screw. 1 terclockwise. 3. Insert a new bulb into the socket, push it in, and then turn it clockwise
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 67
    trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause poor starting and loss of power. The following troubleshooting parts, but they are often inferior, have a shorter service life and can lead to expensive repair bills. EWA15141 the
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 68
    EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAUT1981 Troubleshooting chart 1. Fuel 1 Check the fuel level in the fuel tank. There is enough fuel. Check the compression. The engine does not start. Check the compression. 2 3 4 5 6 7
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 69
    on spoked wheels. If such products are used on hard-toremove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. ● Improper cleaning can damage plastic parts
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 70
    EAU25991 SCOOTER CARE AND STORAGE with water, diluted mild detergent with water may be used. Be sure to rinse off any detergent residue using plenty of water, as it is harmful to plastic parts. Do not use any harsh chemical products on plastic parts. Be sure to avoid using cloths or sponges which
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 71
    (because of the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your scooter for several months: 1. Follow all the instructions in the "Care" section of this chapter. 7-3
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 72
    EAU25991 SCOOTER CARE AND STORAGE 2. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from rusting and the fuel from deteriorating. 3. Perform the following steps to protect the cylinder, piston rings, etc. from corrosion. a. Remove the spark plug cap and spark
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 73
    stroke 52.4 x 57.9 mm (2.06 x 2.28 in) Compression ratio 10.00 :1 Starting system Electric starter Lubrication system Wet sump Recommended engine oil grade API service SG type or higher, JASO standard MA Engine oil quantity Without oil filter element removal 0.85 L (0.90 US qt, 0.75 Imp.qt) Final
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 74
    12 V, 5.0 W x 1 (Use with T/L) Meter lighting 12 V, 1.7W × 2 High beam indicator light 12 V, 1.7W × 1 Turn signal indicator light 12 V, 1.7W × 1 Engine trouble warning light 12 V, 1.7 W x 1 Loading Maximum load 155 kg (342 lb) Rear brake Type Drum brake Operation Left hand operation Tire air
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 75
    SPECIFICATIONS Signaling system fuse 15.0 A Ignition fuse 10.0 A Fuel injection system fuse 10.0 A Spare fuse 20.0 A x × 1 Spare fuse 10.0 A x × 1 Spare fuse 15.0 A x × 1 1 2 3 4 5 6 7 8 9 8-3
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 76
    EAU26343 CONSUMER INFORMATION EAU26352 EAU26381 EAU26410 Identification numbers 1 2 3 4 5 6 7 8 Key identification number Vehicle identification number Record the key identifi cation number, vehicle identification number and model label information in the spaces provided below for assistance when
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 77
    EAU26343 CONSUMER INFORMATION EAU26480 EAU48270 Model label Vehicle Emission Control Information label 1 1 1 2 3 1. Model label 4 1. Vehicle Emission Control Information label The model label is affixed to the frame under the seat. (See page 3-8.) Record the information on this label in the
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 78
    that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 79
    EAU26343 CONSUMER INFORMATION EAU26560 Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 80
    24 months 10000 mi (16000 km) or 30 months 12000 mi (19000 km) or 36 months 14000 mi (22000 km) or 42 months Date of service Mileage Servicing dealer name and address Remarks 9-5
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 81
    EAU26343 CONSUMER INFORMATION Maintenance interval 16000 mi (25000 km) or 48 months 18000 mi (28000 km) or 54 months 20000 mi (31000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 1 2 3 4 5 6 7 8 9 9-6
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 82
    EAU26343 CONSUMER INFORMATION EAU26681 YAMAHA MOTOR CORPORATION, U.S.A. RIVA LIMITED WARRANTY 1 2 3 4 5 6 7 8 9 9-7
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 83
    EAU26343 CONSUMER INFORMATION 1 2 3 4 5 6 7 8 9 9-8
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 84
    no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 85
    isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 1 2 3 4 5 6 7 8 9 9-10
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 86
    free play, checking...6-16 Tires ...6-17 Tool kit ...6-2 Troubleshooting ...6-30 Troubleshooting chart ...6-31 Turn signal indicator light ...3-2 Turn signal ...6-16 Engine oil ...6-11 Engine stop switch ...3-4 Engine trouble warning light...3-3 V Valve clearance ...6-16 Vehicle Emission Control
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 87
    INDEX
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 88
    INDEX
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 89
    INDEX
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 90
    INDEX
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 91
    INDEX
  • 2011 Yamaha Motorsports Zuma 125 | Owners Manual - Page 92
    YAMAHA MOTOR TAIWAN CO., LTD PRINTED IN TAIWAN 2010.07-0.8 × 1 ! (E)
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
32S-F8199-12
YW125A
OWNER’S MANUAL
Read this manual carefully before operating this vehicle.
LIT-11626-24-60