Ariens Deluxe 28 Owners Manual

Ariens Deluxe 28 Manual

Get Ariens Deluxe 28 PDF manuals and user guides View all Ariens Deluxe 28 manuals
Add to My Manuals
Save this manual to your list of manuals

Ariens Deluxe 28 manual content summary:

  • Ariens Deluxe 28 | Owners Manual - Page 1
    -Thro ® Owner/Operator Manual Manuel Du Propriétaire/Utilisateur Models 921023 - Deluxe 28 Track (SN 095000 +) 921024 - Deluxe 24 (SN 000101 +) 921028 - Deluxe 24 Platinum (SN 000101 +) 921029 - Deluxe 30 Platinum (SN 000101 +) 921030 - Deluxe 28 (SN 000101 +) 921032 - Deluxe 30 (SN 000101 +) 921035
  • Ariens Deluxe 28 | Owners Manual - Page 2
    and FEATURES 15 OPERATION 17 MAINTENANCE 24 SERVICE AND ADJUSTMENTS . . . . . 27 STORAGE 35 SERVICE PARTS 35 ACCESSORIES 35 TROUBLESHOOTING 36 SPECIFICATIONS 37 WARRANTY 39 INTRODUCTION MANUALS Before operation of unit, carefully and completely read your manuals. If used improperly, this
  • Ariens Deluxe 28 | Owners Manual - Page 3
    of the unit. Do not operate the Sno-Thro unless all controls function as described in this manual. 4. Review recommended lubrication, maintenance and adjustments. 5. Review Limited Warranty Policy. 6. Fill out a Product Registration Card and return the card to the Ariens Company or go to www
  • Ariens Deluxe 28 | Owners Manual - Page 4
    engine, and wait for all movement to stop before unclogging or working on snow thrower. Hand contact with the rotating impeller is the most common cause of injury associated with snow and maintenance practices. manual. REQUIRED OPERATOR TRAINING Original purchaser of this unit was instructed
  • Ariens Deluxe 28 | Owners Manual - Page 5
    discharge opening. Wait for all moving parts to stop before removing clogs or servicing. 3. DANGER! Danger! Read Owner/Operator Manual. Wear appropriate hearing protection. ROTATING PARTS. Keep clear of auger while engine is running. • Read Operator's Manual. • Allow operation only by properly
  • Ariens Deluxe 28 | Owners Manual - Page 6
    all safety practices in Owner/Operator Manual before beginning assembly or operating. Failure to follow instructions could result in personal injury and/or damage to unit. ALWAYS remove key and/or wire from spark plug before assembly, maintenance or service. Unintentional engine start up can cause
  • Ariens Deluxe 28 | Owners Manual - Page 7
    dispensing spout. NO smoking, NO sparks, NO flames. ALWAYS allow engine to cool before servicing. NEVER fill fuel tank when engine is running or hot from operation. NEVER fill or drain fuel tank indoors. Replace fuel cap securely and clean up spilled fuel. Never fill containers inside a vehicle
  • Ariens Deluxe 28 | Owners Manual - Page 8
    15. 06305200 16. 02483859 17. 06212000 1 Upper Handlebar Assembly 1 Discharge Chute Assembly 1 Chute Crank Assembly 1 Literature Pack 1 Trigger Cable Assembly (921023) 1 1/4" x 1-1/2 Oval Head Machine Screw (921023) 1 1/4" Locking Washer (921023) 2 Skid Shoe, Reversible (921029, 032) 4 Bolt, Round
  • Ariens Deluxe 28 | Owners Manual - Page 9
    • Open-End Wrenches: 3/8, 7/16, 1/2, 9/16" and/or Adjustable Wrench • Tire Gauge • Torque Wrench (Optional) • Phillips Screwdriver Unfold Lower Handlebar (Figure 4) IMPORTANT: Be sure to block wheels or secure unit so it does not move during assembly. 1. Rotate lower handlebar out from unit so lower
  • Ariens Deluxe 28 | Owners Manual - Page 10
    hole in the frame near the engine electrical plug. 4. Secure the wire harness to the handlebars using the cable ties attached to the wire harness. Install Trigger Cable Assembly (921023) (Figure 9) NOTICE: Trigger cable assembly comes attached to the Sno-thro unit. 1. Attach remote trigger cable
  • Ariens Deluxe 28 | Owners Manual - Page 11
    tighten the mounting hardware removed in step 2. NOTICE: Leave discharge chute pedestal loose to help install the chute crank. . 2 921023, 024, 030, 032, 035 3 1 1 2 3 5 4 1. Mounting Holes 2. Discharge Chute 3. Chute Pedestal 4. Discharge Chute Ring 5. Mounting Hardware Figure 10 4. Insert the
  • Ariens Deluxe 28 | Owners Manual - Page 12
    Chute 3. Chute Pedestal 4. Discharge Chute Ring 5. Mounting Hardware Figure 12 4. Remove the gear cover from top of chute pedestal. 5. Release the lock arm on the gear assembly with your finger and rotate the discharge chute so it points straight ahead. NOTICE: Make sure alignment markers on gear
  • Ariens Deluxe 28 | Owners Manual - Page 13
    engine or muffler guard. Make sure this cable stays connected while unit is in operation. 13. Check to make sure the chute control cable ends are properly seated in control assembly and lock adjust as directed in Discharge Chute on page 28 or repair before operation. Remote Deflector Control (
  • Ariens Deluxe 28 | Owners Manual - Page 14
    gearcase (see Check Auger Gearcase on page 25). Check Engine Crankcase Oil IMPORTANT: The engine may be shipped with oil in crankcase. Refer to Engine Manual for detailed instructions. Fill Engine Fuel Tank Fill fuel tank. DO NOT OVERFILL! See FILLING FUEL TANK on page 20 If Applicable - remove the
  • Ariens Deluxe 28 | Owners Manual - Page 15
    CONTROLS AND FEATURES 921028, 029 9 8 3 6 2 5 8 4 3 6 2 5 7 4 1 7 1 Figure 17 1. Skid Shoe 2. Clean-Out Tool 3. Remote Discharge Chute Deflector 4. Belt Cover 5. Headlight 6. Discharge Chute 7. Impeller 8. Chute Crank 9. Quick Turn Chute Control (921028, 029) EN - 15
  • Ariens Deluxe 28 | Owners Manual - Page 16
    (921023) 6. Handwarmers (921028, 029) 7. Handwarmers Switch (921028, 029) 8. Oil Drain 9. Fuel Shut-Off Valve 10. Primer Bulb 11 16 17 8 Figure 18 8 16 11. Recoil Starter Handle 12. Throttle 13. Choke Control Knob 14. Ignition Key 15. Fuel Tank and Cap 16. Oil Fill/Dipstick 17. Electric Start
  • Ariens Deluxe 28 | Owners Manual - Page 17
    shutoff switch to the run position ("Run") to start and operate the engine. 2. Set the engine shutoff switch to the stop position ("Stop") to shut off a running engine. Primer Bulb Pushing the primer bulb in adds fuel for easier engine start. Refer to Starting and Shut Off on page 22. EN - 17
  • Ariens Deluxe 28 | Owners Manual - Page 18
    after engine starts. Throttle (921023, 035) 3 21 Electric Starter The electric starter will start a properly choked and cranked engine when the starter button is pushed. Refer to Starting and Shut Off on page 22. Recoil Starter Handle When pulled, recoil starter handle will turn engine over
  • Ariens Deluxe 28 | Owners Manual - Page 19
    Crank (921023, 024, 030, 032, 035) (Figure 20) IMPORTANT: If chute does not stay in set position, adjust as directed in SERVICE AND ADJUSTMENTS on page 27, or repair before operation. Rotate the chute with Discharge Chute Crank. Axle Lock Pin (921024) (Figure 22) Use the axle lock pin to lock or
  • Ariens Deluxe 28 | Owners Manual - Page 20
    engine and allow to cool. 3. Clean Fuel Cap and surrounding area to prevent dirt from entering Fuel Tank. 4. Remove fuel cap. IMPORTANT: Refer to Engine Manual for correct type and grade of fuel. 5. Fill fuel tank to the bottom of filler neck. See SPECIFICATIONS on page 37 for fuel tank capacity
  • Ariens Deluxe 28 | Owners Manual - Page 21
    Axle Lock Pins (921024) Use the axle lock pins to lock or unlock the wheels. Lock both wheels to increase traction; unlock one wheel to allow for easier turning of add fuel if required. Check that the engine crankcase oil is full using dipstick. Refer to Engine Manual for detailed instructions. TO
  • Ariens Deluxe 28 | Owners Manual - Page 22
    is cold, apply choke. See Engine Manual for detailed instructions. NOTICE: A warm engine requires less choking than a cold engine. 5. Set throttle to proper starting position. 6. 921023, 035: Put the ignition key in the ignition switch and turn it to the "Start" position. 921024, 028, 029, 030
  • Ariens Deluxe 28 | Owners Manual - Page 23
    for all moving parts to come to a complete stop. 4. Move Throttle to the "Slow" position. 5. 921023, 035: Turn ignition key into the "Stop" position and remove key. 921024, 028, 029, 030, 032: Turn off the engine shut-off switch ("STOP"). SNOW REMOVAL IMPORTANT: Allow unit and engine to adjust to
  • Ariens Deluxe 28 | Owners Manual - Page 24
    over during maintenance. 1. Shut off engine, remove key, disconnect spark plug wire and allow unit to cool completely. 2. Close fuel shut-off valve (see Fuel ShutOff Valve on page 21) or (see on page 21). 3. Drain fuel tank and fuel system (see Engine Manual for complete instructions). 4. Place unit
  • Ariens Deluxe 28 | Owners Manual - Page 25
    (See Engine Manual). Park unit on a level surface. Refer to Engine Manual for detailed instructions. CHANGE ENGINE OIL Refer to Engine Manual for detailed instructions. NOTICE: Run engine just prior to changing oil, warm oil will flow more freely and carry away more contaminants. CHECK TIRE PRESSURE
  • Ariens Deluxe 28 | Owners Manual - Page 26
    clean before and after lubrication. IMPORTANT: DO NOT allow grease or oil to get on friction disc, friction plate or belts. NOTICE: Apply Ariens Hi-Temp Grease or equivalent to the lubrication fittings. See SERVICE PARTS on page 35. Sno-Thro should be lubricated (Figure 26) at beginning of season
  • Ariens Deluxe 28 | Owners Manual - Page 27
    Tip unit back onto handlebar, support housing and loosen nuts retaining blade. 2. Reposition scraper blade and tighten lock nuts. 3. Ajust skid 28) IMPORTANT: Use only Ariens OEM shear bolts for replacement. Use of any other type of shear bolt may result in severe damage to unit. See SERVICE PARTS
  • Ariens Deluxe 28 | Owners Manual - Page 28
    while throwing snow. If snow or if chute does not rotate freely, adjust the cable under the gear cover so the chute lock fingers engage or disengage the locking adjusting nuts on cable support bracket underneath the control panel lock arm engages teeth (Figure 30). DISCHARGE CHUTE CONTROL (921023,
  • Ariens Deluxe 28 | Owners Manual - Page 29
    panel in the fastest forward speed position. 3. Turn the speed selector lever straight down towards the ground position. 7. Check forward and reverse speeds: a. Start unit. b. Shift speed selector into the first forward Slack 1. Shut off engine, remove key, disconnect spark plug wire and allow unit
  • Ariens Deluxe 28 | Owners Manual - Page 30
    attachment idler arm should lightly touch the frame. Figure 34 Check Attachment Idler Arm Roller Clearance (Figure 35) 1. Place the unit into the service position. Remove the bottom cover. 2. With the attachment clutch lever engaged, check the clearance between the frame and plastic roller on the
  • Ariens Deluxe 28 | Owners Manual - Page 31
    attachment drive belts: 1. Shut off engine, remove key, disconnect spark plug wire and allow unit to cool Support Sno-Thro frame and housing. CAUTION: Always support SnoThro frame and blower housing when loosening the cap screws holding them together. Never loosen cap screws while unit is in service
  • Ariens Deluxe 28 | Owners Manual - Page 32
    921023, 024, 030, 032, 035 2 3 1 1 2 4 921028, 029 2 3 1 4 1. Belt Cover 2. Chute Gear Cover 3. Discharge Chute Rod 4. Chute Lock and frame back together and secure with hex bolts. 3. Place belts onto engine sheave. 4. Reposition and secure belt finger. IMPORTANT: With attachment clutch
  • Ariens Deluxe 28 | Owners Manual - Page 33
    REPLACEMENT 1. Shut off engine, remove key, disconnect spark plug wire and allow unit to cool completely. 2. Place unit into service position on a level friction disc and carrier bearing. Torque to 5 - 6 lbf-ft (6.78 - 8.14 N•m). 13. Insert new friction disc assembly into frame. Install washers onto
  • Ariens Deluxe 28 | Owners Manual - Page 34
    should be approximately 3/8" (9.6 mm) (Figure 42). If deflection is excessive, tighten the track tension. Track Adjusters Figure 43 HEIGHT ADJUSTER CABLE ADJUSTMENT (921023) (Figure 44) 1. Make sure that height adjustment lock finger is fully engaged (Figure 44). 2. Loosen jam nuts on cable mount
  • Ariens Deluxe 28 | Owners Manual - Page 35
    . 6. Slow the engine to an idle speed. 7. Repeat step 1 above. SERVICE PARTS Order the following parts through your Dealer: Part No. Description 00036800 Ariens Hi-Temp Grease (3.3 oz cartridges ) 00592900 Fuel Stabilizer (4 oz.) 21534100 Spark Plug (921023, 035) 21547400 Spark Plug (921024, 028
  • Ariens Deluxe 28 | Owners Manual - Page 36
    -off valve. 3. Turn off engine, remove key, and wait for all moving parts to stop. Check for and remove obstruction and repair before restart. 4. Replace with clean fuel. 5. Replace or clean spark plug. 6. Replace fuel cap. Engine problems. 1. See Engine Manual. 1. See Engine Manual. Does not
  • Ariens Deluxe 28 | Owners Manual - Page 37
    Engine Engine Ariens AX Gross Torque* - lbf-ft (N•m) 14.5 (19.66) 20.0 (27.12) *Engine output stated in gross torque per SAE J1940 as rated by engine manufacturer Displacement - in. (cc) 17.76 (291) 25.26 (414) High Idle - RPM (min) 3600 ± 50 Electric Start 120 V Fuel Tank Capacity
  • Ariens Deluxe 28 | Owners Manual - Page 38
    Description Engine Engine Model SPECIFICATIONS 921030 921023 Deluxe 28 Deluxe 28 Track 921035 Deluxe 28 921024 Deluxe 24 Ariens AX Briggs & Stratton Polar Force 1150 Ariens AX Gross Torque* - lbf-ft (N•m) 12.5 (16.95) 11.5 (15.59) 12.5 (16.95) *Engine output stated in gross torque per
  • Ariens Deluxe 28 | Owners Manual - Page 39
    Powered Brushes Tillers Vacuums, Blowers, Sweepers, Truck Loaders, Lawn Rakes, Sprayers, Aerators, etc. Pressure Washer, Generators Professional Sno-Thro® Compact, Deluxe, Platinum, AMP™ Sno-Thro®, Path-Pro® Sno-Tek® Utility Vehicles Service (Replacement) Parts Warranty Period Consumer Use
  • Ariens Deluxe 28 | Owners Manual - Page 40
    Perform the maintenance and adjustments explained in the Owner's Manual. • Promptly notify Ariens or an authorized Ariens, Gravely, Parker or Countax service representative of the need for warranty service. • Transport the product to and from the place of warranty service at owner's expense. • Have
  • Ariens Deluxe 28 | Owners Manual - Page 41
    , spark plugs, oil, oil filters, air filters, fuel filters, brake linings, brake arms, brake shoes, skid shoes, scraper blades, shear bolts, mower blades, mower vanes, brushes, headlights, light bulbs, knives, cutters, and single-stage impellers. • Any misuse, alteration, improper assembly, improper
  • Ariens Deluxe 28 | Owners Manual - Page 42
    Ariens 655 West Ryan Street Brillion, WI 54110 920-756-4688 www.ariens.com
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
04585100B 7/13
Printed in USA
Owner/Operator Manual
Manuel Du Propriétaire/Utilisateur
E10
The use of any gasoline exceeding 10% ethanol (E10) or
10% MTBE will void the product warranty.
L’utilisation d’une essence contenant plus de 10% d’éthanol
(E10) ou de 10% de MTBE annulent la garantie.
Models
921023 – Deluxe 28 Track
(SN 095000 +)
921024 – Deluxe 24
(SN 000101 +)
921028 – Deluxe 24 Platinum
(SN 000101 +)
921029 – Deluxe 30 Platinum
(SN 000101 +)
921030 – Deluxe 28
(SN 000101 +)
921032 – Deluxe 30
(SN 000101 +)
921035 – Deluxe 28
(SN 000101 +)
921 Series
Sno-Thro
®
ENGLISH
FRANÇAIS