2012 Yamaha Motorsports Majesty Owners Manual

2012 Yamaha Motorsports Majesty Manual

Get 2012 Yamaha Motorsports Majesty PDF manuals and user guides View all 2012 Yamaha Motorsports Majesty manuals

2012 Yamaha Motorsports Majesty manual content summary:

  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 1
    Read this manual carefully before operating this vehicle. OWNER'S MANUAL YP400B LIT-11626-25-05 34B-28199-13
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 2
    EAU10042 Q Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold.
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 3
    Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. Yamaha continually seeks advancements in product design and quality. Therefore, while this manual contains the most current product information available at the time of
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 4
    INFORMATION EAU10132 Particularly important information is distinguished in this manual by the following notations: This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 5
    INFORMATION EAU10193 YP400B OWNER'S MANUAL ©2011 by Yamaha Motor Corporation, U.S.A. 1st edition, March 2011 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A.
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 6
    TABLE OF CONTENTS LOCATION OF IMPORTANT LABELS ...1-1 SAFETY INFORMATION ...2-1 Further safe-riding points ...2-5 DESCRIPTION ...Left view ...Right view ...Controls and instruments...3-1 3-1 3-2 3-3 Ignition circuit cut-off system ...4-17 FOR YOUR SAFETY - PRE-OPERATION CHECKS ...5-1 OPERATION AND
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 7
    rear turn signal light bulb ...Replacing the license plate light bulb ...Troubleshooting ...Troubleshooting charts ...7-37 7-37 7-38 7-39 8-1 8-1 8-1 8-3 SCOOTER CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...YAMAHA EXTENDED SERVICE (Y.E.S.) ...10-1 10-1 10-3 10-4 10-5 10-7
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 8
    LOCATION OF IMPORTANT LABELS EAU10384 1 Read and understand all of the labels on your vehicle. They contain important information for safe and proper operation of your vehicle. Never remove any labels from your vehicle. If a label becomes difficult to read or comes off, a replacement label is
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 9
    , gasoline or solvent will damage windshield. Use neutral detergent. 8ET-2815K-00 WARNING BEFORE YOU OPERATE THIS VEHICLE, READ THE OWNER'S MANUAL AND ALL LABELS. ALWAYS WEAR AN APPROVED MOTORCYCLE HELMET, eye protection, and protective clothing. 5GK-2118K-00 1 2 3 3 4 5 LOAD LIMIT 2 kg {4 lbs
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 10
    should:  Obtain thorough instructions from a competent source on all aspects of scooter operation.  Observe the warnings and maintenance requirements in this Owner's Manual.  Obtain qualified training in safe and proper riding techniques.  Obtain professional technical service as indicated in
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 11
    SAFETY INFORMATION ed by road and traffic conditions. • Always signal before turning or changing lanes. Make sure that other motorists can see you.  The posture of the operator and passenger is important for proper control. • The operator should keep both hands on the handlebar and both feet on the
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 12
    SAFETY INFORMATION Loading Adding accessories or cargo to your scooter can adversely affect stability and handling if the weight distribution of the scooter is changed. To avoid the possibility of an accident, use extreme caution when adding cargo or accessories to your scooter. Use extra care when
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 13
    . Refer to page 7-23 for tire 2-4 specifications and more information on replacing your tires. Transporting the Scooter Be sure to observe following instructions before transporting the scooter in another vehicle.  Remove all loose items from the scooter.  Point the front wheel straight ahead on
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 14
    SAFETY INFORMATION Further safe-riding points 1 2 3  EAU10373  Be sure to signal clearly when making turns.  Braking can be extremely difficult 4 5 6 7 8 9     on a wet road. Avoid hard braking, because the scooter could slide. Apply the brakes slowly when stopping on a wet surface.
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 15
    DESCRIPTION Left view 1 2 3 4 5 6 7 2 3 4 5 6 7 EAU10410 11 1. Headlight (page 7-35) 2. Fuel tank cap (page 4-9) 3. Rear storage compartment (page 4-14) 4. V-belt case air filter element (page 7-20) 5. Owner's tool kit (page 7-2) 6. Fuses (page 7-34) 7. Battery (page 7-32) 3-1 10 9 8 8 9 8.
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 16
    DESCRIPTION Right view 1 2 3 4 5 6 7 8 9 1. Grab bar (page 6-2) 2. Passenger seat (page 4-12) 3. Rider seat (page 4-12) 4. Coolant reservoir (page 7-19) 5. Radiator 6. Centerstand (page 7-30) 7. Air filter element (right) (page 7-20) 3-2 EAU10420 1 2 3 4 8 7 6 5 8. Shock absorber assembly
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 17
    DESCRIPTION Controls and instruments 1 2 3 4 5 6 7 8 2 3 4 5 6 7 EAU10430 12 1. Rear brake lever (page 4-8) 2. Left handlebar switches (page 4-7) 3. Rear brake lock lever (page 4-8) 4. Speedometer (page 4-2) 5. Multi-function display (page 4-3) 6. Tachometer (page 4-3) 7. Right handlebar switches (
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 18
    INSTRUMENT AND CONTROL FUNCTIONS Main switch/steering lock 1 2 3 4 5 6 7 8 9 The main switch/steering lock controls the ignition and lighting systems, is used to lock the steering, and is used to open the rider seat. (See page 4-12.) The various positions are described below. EAU36070 EAU49871
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 19
    light 1 2 3 EAU11006 EAU11484 1. Turn signal indicator lights " 2. High beam indicator light " 3. Engine trouble warning light " " and " " " " Engine trouble warning light " " This warning light comes on if a problem is detected in the electrical circuit monitoring the engine. If this occurs
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 20
    INSTRUMENT AND CONTROL FUNCTIONS Tachometer 1 2 EAU11872 Multi-function display EAU3610C 1 EWA12312 2 3 4 1 2 3 4 5 6 7 8 9 1. Tachometer 2. Tachometer red zone WARNING Be sure to stop the vehicle before making any setting changes to the multi-function display. Changing settings while
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 21
    and odometer modes in the following order: Trip F  Trip (top)  Trip (bottom)  Odo  Trip F second. If you do not reset the fuel reserve tripmeter manually, it will reset itself automatically and the display will return to the prior mode after refueling and traveling 5 km (3 mi). TIP The display
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 22
    Yamaha dealer check the electrical circuit. Self-diagnosis device This model is equipped with a self-diagnosis device for various electrical circuits. If a problem is detected in any of those circuits, the multi-function display will indicate an error code. If the multi-function display indicates an
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 23
    INSTRUMENT AND CONTROL FUNCTIONS 3. Push the "SELECT" button, and the minute digits will start flashing. 4. Push the "RESET" button to set the minutes. 5. Push the "SELECT" button and then release it to start the clock. Pushing the "SELECT" button for at least two seconds switches the clock display
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 24
    low beam. EAU12460 while applying the front or rear brake to crank the engine with the starter. See page 6-1 for starting instructions prior to starting the engine. 1 2 3 1. Dimmer switch " 2. Turn signal switch " 3. Horn switch " " / / " " Turn signal switch " / " To signal a right-hand turn
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 25
    INSTRUMENT AND CONTROL FUNCTIONS Front brake lever 1 EAU12900 Rear brake lever 1 EAU12950 Rear brake lock lever EAU12962 1 2 3 4 1. Front brake lever 1. Rear brake lever 1. Rear brake lock lever The front brake lever is located on the right handlebar grip. To apply the front brake, pull
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 26
    INSTRUMENT AND CONTROL FUNCTIONS rear brake lock lever is applied.  To provide secure locking of the rear wheel, apply the rear brake lever first before moving the rear brake lock lever to the left. EWA12361 Fuel tank cap EAU13163 1 2 3 4 5 6 To open the fuel tank cap 1. Open the lid by sliding
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 27
    WARNING Gasoline and gasoline vapors are extremely flammable. To avoid fires and explosions and to reduce the risk of injury when refueling, follow these instructions. 1. Before refueling, turn off the engine and be sure that no one is sitting on the vehicle. Never refuel while smoking, or while in
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 28
    % (E10). Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. Catalytic converter EAU13433 This model is equipped with a catalytic converter in the exhaust system. EWA10862 NOTICE Use only unleaded gasoline. The
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 29
    INSTRUMENT AND CONTROL FUNCTIONS converter. Seats 1 EAU34141 1 2 2 3 1. Open. 1. Rider seat 2. Passenger seat 4 5 6 7 8 9 TIP Do not push inward when turning the key. 3. Fold the rider seat up. Rider seat To open the rider seat 1. Place the scooter on the centerstand. 2. Insert the key into
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 30
    INSTRUMENT AND CONTROL FUNCTIONS To close the rider seat 1. Fold the rider seat down, and then push it down to lock it in place. 2. Remove the key from the main switch if the scooter will be left unattended. To install the passenger seat 1. Insert the projections on the passenger seat into the seat
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 31
    INSTRUMENT AND CONTROL FUNCTIONS 3. Slide the rider seat forward or backward to the desired position. 4. Install bolts and securely tighten them. 5. Close the rider seat. Storage compartments EAU14495 1 Front storage compartment A To open the storage compartment when it is locked, insert the key
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 32
    INSTRUMENT AND CONTROL FUNCTIONS To close the storage compartment, push the lid into the original position. WARNING! Do not store heavy items in this compartment.[EWA11161] Rear storage compartment Two helmets can be stored in the storage compartment under the seats. (See page 4-12.) ables or
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 33
    INSTRUMENT AND CONTROL FUNCTIONS Adjusting the shock absorber assemblies EAU14892 EWA10210 dicator on the shock absorber.  Use the spring preload adjusting tool included in the owner's tool kit to make this adjustment. Sidestand EAU15305 WARNING Always adjust both shock absorber assemblies
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 34
    INSTRUMENT AND CONTROL FUNCTIONS Yamaha dealer repair it if it does not function properly. 1 2 3 4 5 6 7 8 9 Ignition circuit cut-off system EAU45051 The ignition circuit cut-off system (comprising the sidestand switch and brake light switches) has the following functions.  It prevents starting
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 35
    INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is turned on. 3. Turn the key on. 4. Keep the front or rear brake applied. 5. Push the start switch. Does the engine start? WARNING If a malfunction is noted, have a
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 36
    inspection and maintenance procedures and schedules described in the Owner's Manual. EWA11151 WARNING Failure to inspect or maintain the vehicle operate the vehicle if you find any problem. If a problem cannot be corrected by the procedures provided in this manual, have the vehicle inspected by a
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 37
    FOR YOUR SAFETY - PRE-OPERATION CHECKS ITEM CHECKS Check operation. If soft or spongy, have Yamaha dealer bleed hydraulic system. Check brake pads for wear. Replace if necessary. Check fluid level in reservoir. If necessary, add recommended brake fluid to specified level. Check hydraulic system for
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 38
    5 6 7 8 9 Read the Owner's Manual carefully to become familiar with all controls. If NOTICE See page 6-3 for engine break-in instructions prior to operating the vehicle for the first for a few seconds, then go off.  Engine trouble warning light  V-belt replacement indicator  Oil change
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 39
    OPERATION AND IMPORTANT RIDING POINTS 2. Close the throttle completely. 3. Start the engine by pushing the start switch while applying the front or rear brake. If the engine does not start, release the start switch, wait a few seconds, and then try again. Each starting attempt should be as short as
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 40
    OPERATION AND IMPORTANT RIDING POINTS Braking 1 2 3 4 5 6    EAU16793 Front Engine break-in EAU16841 EWA10300 7 8 9  WARNING Avoid braking hard or suddenly (especially when leaning over to one side), otherwise the scooter may skid or overturn. Railroad crossings, streetcar rails, iron
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 41
    and then remove the key from the main switch. EWA10311 NOTICE  Keep the engine speed out of the tachometer red zone.  If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. WARNING  Since the engine and exhaust system can become
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 42
    periodic maintenance charts should be simply considered as a general guide under normal riding conditions. However, depending on the weather electrical parts that can cause shocks or fires.  Running the engine while servicing can lead to eye injury, burns, fire, or carbon monoxide poisoning -
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 43
    the rear storage compartment. (See page 4-14.) Pull up the storage compartment mat, and then remove the owner's tool kit. The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and minor
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 44
    8000 mi (13000 km) or 12 months.  Items marked with an asterisk require special tools, data and technical skills, have a Yamaha dealer perform the service. EAU17601 Periodic maintenance chart for the emission control system INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 45
    PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi (13000 km) or 12 months 12000 mi (19000 km) or 18 months  16000 mi (25000 km) or 24 months 20000 mi (31000 km) or 30 months  7 * Air induction system
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 46
    PERIODIC MAINTENANCE AND ADJUSTMENT General maintenance and lubrication chart 1 No. ITEM ROUTINE INITIAL 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi (13000 km) or 12 months   12000 mi (19000 km) or 18 months   16000 mi (25000 km) or 24 months   20000 mi
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 47
    PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month  4000 mi (7000 km) or 6 months  ODOMETER READINGS 8000 mi (13000 km) or 12 months  12000 mi (19000 km) or 18 months  16000 mi (25000 km) or 24 months  20000 mi (31000 km) or 30 months  10 * Steering
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 48
    PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months  ODOMETER READINGS 8000 mi (13000 km) or 12 months  12000 mi (19000 km) or 18 months  16000 mi (25000 km) or 24 months  20000 mi (31000 km) or 30 months  1 2 3 4 5 20 * 21 22
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 49
    air filter elements need to be replaced and the V-belt air filter element needs to be serviced more frequently when riding in unusually wet or dusty areas.  Hydraulic brake service • After disassembling the brake master cylinders and calipers, always change the fluid. Regularly check the brake
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 50
    PERIODIC MAINTENANCE AND ADJUSTMENT Removing and installing cowlings and panels 1 2 3 4 5 6 7 8 9 1. Panel A 2. Cowling C 3. Cowling A 4. Cowling B 5. Panel B 6. Cowling E EAU18712 1 1 The cowlings and panels shown need to be removed to perform some of the maintenance jobs described in this
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 51
    PERIODIC MAINTENANCE AND ADJUSTMENT Cowling B To remove the cowling 1. Remove the screws. To install the cowling Place the cowling in the original position, and then install the screws. Cowlings C and D 1 2 3 1. Screw access cover 1 To remove one of the cowlings 1. Remove cowlings A and B. 2.
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 52
    PERIODIC MAINTENANCE AND ADJUSTMENT 1 2 3 4 5 6 7 8 9 2. Install the screw access cover by placing it in its original position. 3. Install the grab bar by installing the collars and grab bar bolts. Tightening torque: Grab bar bolt: 23 Nm (2.3 m·kgf, 17 ft·lbf) 1 1. Left floorboard mat 1. Cowling E
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 53
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU34290 1 Panel A To remove the panel 1. Remove the bolts. 2 2 To install the panel Place the panel in the original position, and then install the bolts. 1. Panel B 2. Screw 2 3 4 5 6 7 8 9 1 1. Bolt 2. Panel A To install the panel Place the panel in the
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 54
    normally). 1 TIP If the spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 2. Check the spark plug for electrode erosion and excessive carbon or other deposits
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 55
    PERIODIC MAINTENANCE AND ADJUSTMENT necessary. Specified spark plug: NGK/CR7E spark plug wrench, and then tighten it to the specified torque. Tightening torque: Spark plug: 13 Nm (1.3 m·kgf, 9.4 ft·lbf) 1 3. Measure the spark plug gap with a wire thickness gauge and, if necessary, adjust the gap
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 56
    PERIODIC MAINTENANCE AND ADJUSTMENT Canister 1 2 3 4 5 6 7 8 9 This model is equipped with a canister to prevent the discharging of fuel vapor into the atmosphere. Before operating this vehicle, make sure to check the following:  Check each hose connection.  Check each hose and canister for cracks
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 57
    PERIODIC MAINTENANCE AND ADJUSTMENT 2. Start the engine, warm it up for several minutes, and then turn it off. 3. Place an oil pan under the engine to collect the used oil. 4. Remove the engine oil filler cap, the engine oil drain bolt and its gasket to drain the oil from the crankcase. spring will
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 58
    PERIODIC MAINTENANCE AND ADJUSTMENT the bolt to the specified torque. 1 2 3 4 5 6 7 8 9 Tightening torque: Engine oil drain bolt: 20 Nm (2.0 m·kgf, 14 ft·lbf) "ENERGY CONSERVING II" or higher.  Be sure no foreign material enters the crankcase. 10. Start the engine, and then let it idle for several
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 59
    PERIODIC MAINTENANCE AND ADJUSTMENT Final transmission oil EAU20065 tire or wheel.[EWA11311] The final transmission case must be checked for oil leakage before each ride. If any leakage is found, have a Yamaha dealer check and repair the scooter. In addition, the final transmission oil must be
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 60
    PERIODIC MAINTENANCE AND ADJUSTMENT Coolant 1 2 3 4 5 6 7 8 9 EAU20070 The coolant level should be checked before each ride. In addition, the coolant must be changed at the intervals specified in the periodic maintenance and lubrication chart. EAU34193 1 TIP The coolant should be between the
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 61
    mark 3. Coolant reservoir cap The air filter elements and the V-belt case air filter element should be serviced at the intervals specified in the periodic maintenance and lubrication chart. Service all air filter elements more frequently if you are riding in unusually wet or dusty areas. Replacing
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 62
    PERIODIC MAINTENANCE AND ADJUSTMENT Left 1 ment is properly seated in its case. Always replace both air filter elements at the same time, otherwise poor engine performance or damage to the engine may result. The engine should never be operated without the filter elements installed, otherwise the
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 63
    PERIODIC MAINTENANCE AND ADJUSTMENT 1 2 1 1 1. Screw 2. V-belt air filter case cover dust and dirt, and then blow out the dirt with compressed air as shown. Checking the throttle grip free play EAU21384 2 1 3 4 5. Remove the V-belt case air filter element by removing the screws. 1 1 2 1.
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 64
    PERIODIC MAINTENANCE AND ADJUSTMENT Valve clearance 1 2 3 4 5 6 7 8 9 EAU21401 Tires EAU21865 The valve clearance changes with use, resulting in improper air-fuel mixture and/or engine noise. To prevent this from occurring, the valve clearance must be adjusted by a Yamaha dealer at the intervals
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 65
    control. Have excessively worn tires replaced by a Yamaha dealer immediately. Brakes, tires, and related wheel parts replacement should be left to a Yamaha Service Technician. After extensive tests, only the tires listed below have been approved for this model by Yamaha Motor Co., Ltd. Front tire
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 66
    PERIODIC MAINTENANCE AND ADJUSTMENT characteristics. 1 2 3 4 5 6 7 8 9 Cast wheels EAU21994 To maximize the performance, durability, and safe operation of your vehicle, note the following points regarding the specified wheels.  The wheel rims should be checked for cracks, bends, warpage or other
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 67
    PERIODIC MAINTENANCE AND ADJUSTMENT Checking the front and rear brake lever free play Front EAU50860 brake lever ends. If there is free play, have a Yamaha dealer inspect the brake system. EWA14211 Adjusting the rear brake lock lever cable 1 (a) 2 EAU33473 1 1. No brake lever free play WARNING
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 68
    PERIODIC MAINTENANCE AND ADJUSTMENT To decrease the rear brake lock lever cable length, turn the adjusting nut in direction (b). EWA10650 Checking the front and rear brake pads EAU22392 peared, have a Yamaha dealer replace the brake pads as a set. EAU34210 1 2 3 4 5 6 7 8 9 WARNING If proper
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 69
    PERIODIC MAINTENANCE AND ADJUSTMENT Checking the brake fluid level EAU22581 Rear brake Before riding, check that the brake fluid is above the minimum level mark. Check the brake fluid level with the top of the reservoir level. Replenish the brake fluid if necessary. Front brake 1 1 1. Minimum
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 70
    PERIODIC MAINTENANCE AND ADJUSTMENT Changing the brake fluid 1 2 3 4 5 6 7 8 9 EAU22731 Have a Yamaha dealer change the brake fluid at the intervals specified in the TIP after the periodic maintenance and lubrication chart. In addition, have the oil seals of the master cylinders and calipers as
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 71
    PERIODIC MAINTENANCE AND ADJUSTMENT Lubricating the front and rear brake levers Front brake lever 2 3 4 5 Rear brake lever 6 7 8 The operation of the centerstand and sidestand should be checked before each ride, and the pivots and metal-to-metal contact surfaces should be lubricated if necessary. 7-
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 72
    oil leakage. To check the operation 1. Place the vehicle on a level surface and hold it in an upright position. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over.[EWA10751] 2. While applying the front brake, push down hard on the handlebars several times
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 73
    as follows at the intervals specified in the periodic maintenance and lubrication chart. 1. Place the vehicle on the centerstand. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over.[EWA10751] 2. Hold the lower ends of the front fork legs and try to move
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 74
    PERIODIC MAINTENANCE AND ADJUSTMENT working near batteries. In case of contact, administer the following FIRST AID. • EXTERNAL: Flush with plenty of water. • INTERNAL: Drink large quantities of water or milk and immediately call a physician. • EYES: Flush with water for 15 minutes and seek prompt
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 75
    PERIODIC MAINTENANCE AND ADJUSTMENT Replacing the fuses EAU34234 The main fuse and the fuse box, which contains the fuses for the individual circuits, are located behind cowling A. (See page 7-9.) If a fuse is blown, replace it as follows. 1. Turn the key to "OFF" and turn off the electrical
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 76
    PERIODIC MAINTENANCE AND ADJUSTMENT Specified fuses: Main fuse: 40.0 A Ignition fuse: 10.0 A Signaling system fuse: 10.0 A Headlight fuse: 20.0 A Taillight fuse: 10.0 A Radiator fan fuse: 10.0 A Fuel injection system fuse: 10.0 A Backup fuse: 10.0 A Replacing a headlight bulb EAU34241 Tail/brake
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 77
    PERIODIC MAINTENANCE AND ADJUSTMENT Replacing a front turn signal light bulb EAU36125 1 1. Place the scooter on the centerstand. 2. Remove panel A. (See page 7-9.) 3. Remove the windshield by removing the screws. 2 1. Screw 2. Front turn signal light unit 2 1 clockwise. 7. Insert a new bulb
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 78
    PERIODIC MAINTENANCE AND ADJUSTMENT Replacing a rear turn signal light bulb 1 2 3 4 5 6 7 8 9 1. Turn signal light bulb socket EAU34263 1. Place the scooter on the centerstand. 2. Remove cowling C for replacing the left turn signal light bulb or cowling D for replacing the right turn signal light
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 79
    trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause poor starting and loss of power. The following troubleshooting parts, but they are often inferior, have a shorter service life and can lead to expensive repair bills. EWA15141
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 80
    PERIODIC MAINTENANCE AND ADJUSTMENT Troubleshooting charts 1 2 3 4 5 6 7 8 Starting problems or poor engine performance EAU42704 1. Fuel There is enough fuel. Check the fuel level in the fuel tank. There is no fuel. Supply fuel. Check
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 81
    PERIODIC MAINTENANCE AND ADJUSTMENT Engine overheating EWAT1040 WARNING  Do not remove the radiator cap when the engine and radiator are hot. Scalding hot fluid and steam may be blown out under pressure, which could cause serious injury. Be sure to wait until the engine has cooled.  Place a
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 82
    on spoked wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray.  Improper cleaning can damage plastic parts
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 83
    SCOOTER CARE AND STORAGE plenty of water, as it is harmful to plastic parts.  Do not use any harsh chemical products on plastic parts. Be sure to avoid using cloths or sponges which have been in contact with strong or abrasive cleaning products, solvent or thinner, fuel (gasoline), rust removers or
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 84
    (because of the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your scooter for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. Fill up the fuel tank and add fuel NOTICE  Apply spray oil and wax sparingly and make
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 85
    SCOOTER CARE AND STORAGE stabilizer (if available) to prevent the fuel tank from rusting and the fuel from deteriorating. 3. Perform the following steps to protect the cylinder, piston rings, etc. from corrosion. a. Remove the spark plug cap and spark plug. b. Pour a teaspoonful of engine oil into
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 86
     73.0 mm (3.27  2.87 in) Compression ratio: 10.60 : 1 Starting system: Electric starter Lubrication system: Wet sump Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter element replacement: 1.50 L (1.59 US qt, 1.32 Imp.qt) With oil
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 87
    SPECIFICATIONS Transmission type: V-belt automatic Chassis: Frame type: Backbone Caster angle: 27.00  Trail: 100 mm (3.9 in) Tire air pressure (measured on cold tires): Loading condition: 0-90 kg (0-198 lb) Front: 200 kPa (2.00 kgf/cm2, 29 psi) Rear: 250 kPa (2.50 kgf/cm2, 36 psi) Loading
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 88
    : 12 V, 5.0 W  1 Meter lighting: 12 V, 2.0 W  3 High beam indicator light: 12 V, 1.4 W  1 Turn signal indicator light: 12 V, 1.4 W  2 Engine trouble warning light: 12 V, 1.4 W  1 1 2 3 4 5 6 7 8 9 Fuses: Main fuse: 40.0 A Headlight fuse: 20.0 A Taillight fuse: 10.0 A Signaling system fuse
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 89
    CONSUMER INFORMATION Identification numbers EAU26353 EAU26381 EAU26410 Key identification number Vehicle identification number Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 90
    CONSUMER INFORMATION EAU26500 EAU48061 Model label 1 2 3 4 1. Model label Vehicle Emission Control Information label 1 1 5 6 7 8 9 10 The model label is affixed to the inside of the rear storage compartment. (See page 4-14.) Record the information on this label in the space provided. This
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 91
    that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 92
    CONSUMER INFORMATION Scooter noise regulation 1 2 3 4 5 6 7 8 9 10 EAU26580 TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 93
    months 24000 mi (37000 km) or 36 months 28000 mi (43000 km) or 42 months 32000 mi (49000 km) or 48 months 10-5 Date of service Mileage Servicing dealer name and address Remarks 2 3 4 5 6 7 8 9 10
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 94
    CONSUMER INFORMATION Maintenance interval Date of service Mileage Servicing dealer name and address Remarks 36000 mi (55000 km) or 54 months 40000 mi (61000 km) or 60 months 1 2 3 4 5 6 7 8 9 10 10-6
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 95
    1. Operate and maintain the motorcycle as specified in the appropriate Owner's Manual, and 2. Give notice to an authorized Yamaha motorcycle dealer of any . An inspection and registration fee will be charged for this service. EMISSION CONTROL SYSTEM WARRANTY: Yamaha Motor Corporation, U.S.A. also
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 96
    in the Owner's and Service Manual. We do recommend, however service, you must take it to any authorized Yamaha motorcycle dealer within the continental United States. Be sure to bring your warranty registration card or other valid proof of the original date of purchase. If a question or problem
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 97
    no extra cost. TRIP gives you up to $250 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 98
    isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 1 2 3 4 5 6 7 8 9 10 10-10
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 99
    play, checking...7-22 Tires ...7-23 Tool kit ...7-2 Troubleshooting ...7-38 Troubleshooting charts ...7-39 Turn signal indicator lights ...4-2 Turn Engine oil and oil filter element...7-15 Engine stop switch...4-7 Engine trouble warning light ...4-2 N Noise regulation ...10-4 F Final transmission
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 100
    INDEX Vehicle Emission Control Information label ...10-2 Vehicle identification number ...10-1 W Warranty, extended...10-9 Warranty, limited ...10-7 Wheel bearings, checking...7-32 Wheels ...7-25
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 101
    Yamaha engineering teams that know your Yamaha from the inside out. Genuine Yamaha Service Manuals - Get the same factory manual for your vehicle that the technicians at your authorized Yamaha dealer use. Service manuals are available through your Yamaha dealer or you can order them directly through
  • 2012 Yamaha Motorsports Majesty | Owners Manual - Page 102
    YAMAHA MOTOR CO., LTD. PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2011.06-0.2×1 ! (E)
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
  • 93
  • 94
  • 95
  • 96
  • 97
  • 98
  • 99
  • 100
  • 101
  • 102
OWNER’S MANUAL
34B-28199-13
YP400B
Read this manual carefully before operating this vehicle.
LIT-11626-25-05