2009 Yamaha Motorsports Midnight Warrior Owners Manual

2009 Yamaha Motorsports Midnight Warrior Manual

Get 2009 Yamaha Motorsports Midnight Warrior PDF manuals and user guides View all 2009 Yamaha Motorsports Midnight Warrior manuals

2009 Yamaha Motorsports Midnight Warrior manual content summary:

  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 1
    Read this manual carefully before operating this vehicle. OWNER'S MANUAL XV17PCY(C) XV17PCMY(C) LIT-11626-22-34 5PX-28199-17
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 2
    EAU10042 Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold.
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 3
    Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. Yamaha continually seeks advancements in product design and quality. Therefore, while this manual contains the most current product information available at the time of
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 4
    INFORMATION EAU10132 Particularly important information is distinguished in this manual by the following notations: This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 5
    INFORMATION EAU10193 XV17PCY(C)/XV17PCMY(C) OWNER'S MANUAL ©2008 by Yamaha Motor Corporation, U.S.A. 1st edition, May 2008 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A.
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 6
    TABLE OF CONTENTS LOCATION OF IMPORTANT LABELS ...1-1 SAFETY INFORMATION ...2-1 DESCRIPTION ...3-1 Left view ...3-1 Right view ...3-2 Controls and instruments...3-3 INSTRUMENT AND CONTROL FUNCTIONS ...4-1 Main switch/steering lock ...4-1 Indicator and warning lights ...4-2 Speedometer ...4-3
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 7
    36 Replacing a license plate light bulb ...7-36 Supporting the motorcycle ...7-37 Troubleshooting ...7-38 Troubleshooting chart ...7-39 MOTORCYCLE CARE AND STORAGE ...8-1 Matte MOTOR CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...10-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...10-9
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 8
    LOCATION OF IMPORTANT LABELS EAU10383 1 Read and understand all of the labels on your vehicle. They contain important information for safe and proper operation of your vehicle. Never remove any labels from your vehicle. If a label becomes difficult to read or comes off, a replacement label is
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 9
    LOCATION OF IMPORTANT LABELS 1 2 1 California only 3 4 California only 5 1-2
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 10
    should: G Obtain thorough instructions from a competent source on all aspects of motorcycle operation. G Observe the warnings and maintenance requirements in this Owner's Manual. G Obtain qualified training in safe and proper riding techniques. G Obtain professional technical service as indicated in
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 11
    SAFETY INFORMATION due to excessive speed or undercornering (insufficient lean angle for the speed). • Always obey the speed limit and never travel faster than warranted by road and traffic conditions. • Always signal before turning or changing lanes. Make sure that other motorists can see you. The
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 12
    SAFETY INFORMATION G G 2 Do not run engine in poorly ventilated or partially enclosed areas such as barns, garages, or carports. Do not run engine outdoors where engine exhaust can be drawn into a building through openings such as windows and doors. Maximum load: 185 kg (408 lb) Loading Adding
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 13
    SAFETY INFORMATION Aftermarket Parts, Accessories, and Modifications While you may find aftermarket products similar in design and quality to genuine Yamaha accessories, recognize that some aftermarket accessories or modifications are not suitable because of potential safety hazards to you or others
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 14
    DESCRIPTION EAU10410 Left view 3 1. 2. 3. 4. 5. 6. Engine oil drain bolt (crankcase) (page 7-10) Shift pedal (page 4-7) Fuel tank cap (page 4-8) Helmet holder (page 4-10) Fuses (page 7-33) Owner's tool kit (page 7-2) 3-1
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 15
    DESCRIPTION EAU10420 Right view 3 1. 2. 3. 4. 5. 6. 7. 8. Rear brake fluid reservoir (page 7-24) Battery (page 7-32) Engine oil filler cap (page 7-10) Air filter element (page 7-14) Front fork spring preload adjusting bolt (page 4-11) Engine oil filter cartridge (page 7-10) Rear brake light
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 16
    DESCRIPTION EAU10430 Controls and instruments 3 1. 2. 3. 4. 5. 6. 7. 8. Clutch lever (page 4-6) Left handlebar switches (page 4-5) Speedometer (page 4-3) Tachometer unit (page 4-3) Main switch/steering lock (page 4-1) Right handlebar switches (page 4-5) Throttle grip (page 7-18) Brake lever (
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 17
    INSTRUMENT AND CONTROL FUNCTIONS EAU10460 EAU10661 Main switch/steering lock OFF All electrical systems are off. The key can be removed. EWA10061 To lock the steering WARNING Never turn the key to "OFF" or "LOCK" while the vehicle is moving. Otherwise the electrical systems will be switched off,
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 18
    " Right turn signal indicator light " " Fuel level warning light " " Engine trouble warning light " " Left turn signal indicator light " " Neutral indicator light " selfdiagnosis device for the fuel level detection circuit. If a problem is detected in the fuel level detection circuit, the following
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 19
    . If this occurs, have a Yamaha dealer check the vehicle. EAU11482 EAU11601 EAU34035 Speedometer Tachometer unit Engine trouble warning light " " This warning light comes on if a problem is detected in the electrical circuit monitoring the engine. If this occurs, have a Yamaha dealer check the
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 20
    by pushing the "SELECT" button, and then push the "RESET" button for at least one second. If you do not reset the fuel reserve tripmeter manually, it will reset itself automatically and the display will return to the prior mode after refueling and 90 seconds have passed. Meter lighting control mode
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 21
    the clock. Self diagnosis device This model is equipped with a self-diagnosis device for various electrical circuits. 4-5 If a problem is detected in any of those circuits, the engine trouble warning light will come on and the clock display will indicate a two-digit error code. If the clock display
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 22
    15 seconds. However, the turn signal lights can also be canceled manually by pushing the switch in after it has returned to the center the starter. See page 6-1 for starting instructions prior to starting the engine. EAU41700 1. Clutch lever The engine trouble warning light will come on when the
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 23
    INSTRUMENT AND CONTROL FUNCTIONS EAU12870 EAU12890 EAU12941 Shift pedal Brake lever Brake pedal 4 1. Shift pedal 1. Brake lever 1. Brake pedal The shift pedal is located on the left side of the engine and is used in combination with the clutch lever when shifting the gears of the 5-speed
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 24
    WARNING Gasoline and gasoline vapors are extremely flammable. To avoid fires and explosions and to reduce the risk of injury when refueling, follow these instructions. 1. Before refueling, turn off the engine and be sure that no one is sitting on the vehicle. Never refuel while smoking, or while in
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 25
    not exceed 10% (E10). Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. 4 NOTICE Use only unleaded gasoline. The use of leaded gasoline will cause severe damage to internal engine parts, such as the valves and
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 26
    INSTRUMENT AND CONTROL FUNCTIONS EAU34042 EAU14321 Rider seat To remove the rider seat 1. Insert the key into the seat lock, and then turn it counterclockwise. Helmet holder 4 1. Projection 2. Seat holder 1. Helmet holder 2. Push the front of the seat down to lock it in place. 3. Remove the key
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 27
    INSTRUMENT AND CONTROL FUNCTIONS To release the helmet from the helmet holder Remove the rider seat, remove the helmet from the helmet holder, and then install the seat. EAU14721 Adjusting the front fork EWA10180 WARNING Always adjust both fork legs equally, otherwise poor handling and loss of
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 28
    INSTRUMENT AND CONTROL FUNCTIONS EAU34063 Adjusting the shock absorber assembly This shock absorber assembly is equipped with a spring preload adjusting nut and a rebound damping force adjusting knob. ECA10101 NOTICE 4 To avoid damaging the mechanism, do not attempt to turn beyond the maximum or
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 29
    INSTRUMENT AND CONTROL FUNCTIONS 3. Tighten the locknut to the specified torque. NOTICE: Always tighten the locknut against the adjusting nut, and then tighten the locknut to the specified torque. [ECA11241] force and thereby soften the rebound damping, turn the adjusting knob in direction (b).
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 30
    INSTRUMENT AND CONTROL FUNCTIONS below and have a Yamaha dealer repair it if it does not function properly. EAU44891 Ignition circuit cut-off system The ignition circuit cut-off system (comprising the sidestand switch, clutch switch and neutral switch) has the following functions. G It prevents
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 31
    INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is turned on. 3. Turn the key on. 4. Shift the transmission into the neutral position. 5. Push the start switch. Does the engine start? WARNING If a malfunction is noted
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 32
    increases the possibility of an accident or equipment damage. Do not operate the vehicle if you find any problem. If a problem cannot be corrected by the procedures provided in this manual, have the vehicle inspected by a Yamaha dealer. Before using this vehicle, check the following points: 5 5-1
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 33
    FOR YOUR SAFETY - PRE-OPERATION CHECKS EAU15605 Pre-operation check list ITEM Fuel • Check fuel level in fuel tank. • Refuel if necessary. • Check fuel line for leakage. • Check oil level in oil tank. • If necessary, add recommended oil to specified level. • Check vehicle for oil leakage. • Check
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 34
    FOR YOUR SAFETY - PRE-OPERATION CHECKS ITEM CHECKS • Make sure that operation is smooth. • Check cable free play. • If necessary, have Yamaha dealer adjust cable free play and lubricate cable and grip housing. • Make sure that operation is smooth. • Lubricate if necessary Check for damage. Check
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 35
    EAU15951 EAU45310 EAU16244 Starting the engine Read the Owner's Manual carefully to become familiar with all controls. If there come on for a few seconds, then go off. G Fuel level warning light G Engine trouble warning light ECA15482 6 NOTICE If a warning light does not go off, see page 4-2 for
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 36
    OPERATION AND IMPORTANT RIDING POINTS 2. Shift the transmission into the neutral position. (See page 6-2.) The neutral indicator light should come on. If not, ask a Yamaha dealer to check the electrical circuit. 3. Start the engine by pushing the start switch. NOTICE: For maximum engine life, always
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 37
    OPERATION AND IMPORTANT RIDING POINTS 4. At the recommended shift points shown in the following table, close the throttle, and at the same time, quickly pull the clutch lever in. 5. Shift the transmission into second gear. (Make sure not to shift the transmission into the neutral position.) 6. Open
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 38
    then remove the key from the main switch. EWA10311 NOTICE G G Keep the engine speed out of the tachometer red zone. If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. WARNING G G 6 G Since the engine and exhaust system can
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 39
    has moving parts that can catch on body parts or clothing and electrical parts that can cause shocks or fires. Running the engine while servicing can lead to eye injury, burns, fire, or carbon monoxide poisoning - possibly leading to death. See page 2-1 for more information about carbon monoxide
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 40
    EAU17361 Owner's tool kit 1. Owner's tool kit 7 The owner's tool kit is located under the rider seat. (See page 4-10.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and minor
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 41
    injection √ √ √ √ √ √ √ √ √ √ √ √ √ 7 √ √ 5 * 6 * Exhaust system Evaporative emission control system (For California only) 7 * √ √ * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 7-3
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 42
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU32185 General maintenance and lubrication chart INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 43
    PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 9 * Swingarm pivot bearings •
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 44
    PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month √ 4000 mi (7000 km) or 6 months √ √ ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 18 * Sidestand switch
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 45
    damaging them. • The air filter elements need to be replaced more frequently when riding in unusually wet or dusty areas. Hydraulic brake service • After disassembling the brake master cylinders and calipers, always change the fluid. Regularly check the brake fluid levels and fill the reservoirs
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 46
    PERIODIC MAINTENANCE AND ADJUSTMENT • Replace the brake hoses every four years and if cracked or damaged. 7 7-8
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 47
    the same color. If any spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. If a spark plug shows signs of electrode erosion and excessive carbon or other deposits
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 48
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU19681 EAU46270 Canister (for California only) Engine oil and oil filter cartridge The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil filter cartridge replaced at the intervals specified in the periodic
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 49
    PERIODIC MAINTENANCE AND ADJUSTMENT ECA10900 NOTICE Make sure that the oil filler cap is securely tightened, otherwise oil may seep out when the engine is running. To change the engine oil (with or without oil filter cartridge replacement) 1. Remove the rider seat. (See page 4-10.) 2. Start the
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 50
    PERIODIC MAINTENANCE AND ADJUSTMENT TIP Skip steps 7-9 if the oil filter cartridge is not being replaced. 7. Remove the oil filter cartridge with an oil filter wrench. 1. O-ring 1. Oil filter cartridge 2. Torque wrench TIP Make sure that the O-ring is properly seated. 1. Oil filter cartridge 2.
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 51
    PERIODIC MAINTENANCE AND ADJUSTMENT through the filler hole, insert the dipstick, and then tighten the oil filler cap. 12. Start the engine, rev it several times, and then turn it off. 13. Remove the engine oil filler cap, and then gradually fill the oil tank with the remaining oil quantity while
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 52
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU20051 EAU34104 Transfer case oil The transfer case must be checked for oil leakage before each ride. If any leakage is found, have a Yamaha dealer check and repair the vehicle. In addition, the transfer case oil level should be checked and the oil must be
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 53
    PERIODIC MAINTENANCE AND ADJUSTMENT 1. Fuel hose A 1. Fuel hose B 1. Foam damper b. Remove the nuts. d. Remove the hoses as shown, and then remove the fuel tank by pulling it upward. 4. Remove the air filter case bolts. 7 1. Nut c. Disconnect fuel hose B from the joint as shown. 1. Air
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 54
    PERIODIC MAINTENANCE AND ADJUSTMENT 1. Air filter case joint clamp bolt 6. Remove the air filter case cover by removing the screws. 1. Air filter element 2. Screw 7 1. Screw 7. Remove the air filter element by removing the screws. 8. Install a new air filter element by inserting it into the
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 55
    PERIODIC MAINTENANCE AND ADJUSTMENT hoses are properly connected and routed, and are not pinched. WARNING! Before installing the fuel tank, make sure that the fuel hoses are not damaged. If any fuel hose is damaged, do not start the engine but have a Yamaha dealer replace the hose, otherwise fuel
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 56
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU44732 EAU21382 EAU21401 Checking the engine idling speed Check the engine idling speed and, if necessary, have it adjusted by a Yamaha dealer at the intervals specified in the periodic maintenance and lubrication chart. Engine idling speed: 850-950 r/min
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 57
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU21751 Tires To maximize the performance, durability, and safe operation of your motorcycle, note the following points regarding the specified tires. Tire air pressure The tire air pressure should be checked and, if necessary, adjusted before each ride.
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 58
    PERIODIC MAINTENANCE AND ADJUSTMENT EWA10580 WARNING G This motorcycle is equipped with cast wheels and tubeless tires with valves. EWA10481 G It is dangerous to ride with a worn-out tire. When a tire tread begins to show crosswise lines, have a Yamaha dealer replace the tire immediately. The
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 59
    PERIODIC MAINTENANCE AND ADJUSTMENT "broken in". Therefore, it is advisable before doing any highspeed riding to ride conservatively for approximately 100 km (60 mi) after installing a new tire. The tires must be warmed up before a high-speed run. Always adjust the tire air pressure according to the
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 60
    PERIODIC MAINTENANCE AND ADJUSTMENT TIP If the specified clutch lever free play could be obtained as described above, tighten the locknut and skip the rest of the procedure, otherwise proceed as follows. 3. Fully turn the adjusting bolt at the clutch lever in direction (a) to loosen the clutch cable
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 61
    PERIODIC MAINTENANCE AND ADJUSTMENT 3. Tighten the locknut. EWA10630 EAU22271 EAU22390 WARNING G Adjusting the rear brake light switch Checking the front and rear brake pads The front and rear brake pads must be checked for wear at the intervals specified in the periodic maintenance and
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 62
    PERIODIC MAINTENANCE AND ADJUSTMENT the point that a wear indicator almost touches the brake disc, have a Yamaha dealer replace the brake pads as a set. EAU34090 EAU22580 Checking the brake fluid level Front brake Rear brake pads 1. Remove the brake caliper bolt, and then tilt the caliper forward.
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 63
    PERIODIC MAINTENANCE AND ADJUSTMENT Before riding, check that the brake fluid is above the minimum level mark and replenish if necessary. A low brake fluid level may indicate worn brake pads and/or brake system leakage. If the brake fluid level is low, be sure to check the brake pads for wear and
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 64
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU23040 Drive belt slack The drive belt slack should be checked and adjusted at the intervals specified in the periodic maintenance and lubrication chart. EAU23062 3. Note the position of the drive belt with a force of 45 N (4.5 kgf, 10 lbf) applied to the belt
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 65
    PERIODIC MAINTENANCE AND ADJUSTMENT 3. To tighten the drive belt, turn the adjusting bolt on each side of the swingarm in direction (a). To loosen the drive belt, turn the adjusting bolt on each side of the swingarm in direction (b), and then push the rear wheel forward. NOTICE: Improper drive belt
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 66
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU23111 EAU44271 Checking and lubricating the throttle grip and cable The operation of the throttle grip should be checked before each ride. In addition, the cable should be lubricated at the intervals specified in the periodic maintenance chart. Checking and
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 67
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU23142 EAU23202 Checking and lubricating the brake and clutch levers Brake lever Recommended lubricants: Brake lever: Silicone grease Clutch lever: Lithium-soap-based grease Checking and lubricating the sidestand Clutch lever The operation of the sidestand
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 68
    oil leakage. To check the operation 1. Place the vehicle on a level surface and hold it in an upright position. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over. [EWA10751] 2. While applying the front brake, push down hard on the handlebars several
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 69
    chart. 1. Place a stand under the engine to raise the front wheel off the ground. (See page 7-37 for more information.) WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over. [EWA10751] 2. Hold the lower ends of the front fork legs and try to move
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 70
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU33653 Battery 1. Negative battery lead (black) 2. Battery 3. Positive battery lead (red) G 7 This model is equipped with a VRLA (Valve Regulated Lead Acid) battery. There is no need to check the electrolyte or to add distilled water. However, the battery
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 71
    PERIODIC MAINTENANCE AND ADJUSTMENT 2. If the battery will be stored for more than two months, check it at least once a month and fully charge it if necessary. 3. Fully charge the battery before installation. 4. After installation, make sure that the battery leads are properly connected to the
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 72
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU23794 1. 2. 3. 4. 5. 6. 7. 8. Headlight fuse Signaling system fuse Ignition fuse Fuel injection system fuse Backup fuse (for odometer and clock) Auto-decompression fuse Spare fuse ECU (Electronic Control Unit) fuse Specified fuses: Main fuse: 30.0 A
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 73
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU24181 Tail/brake light This model is equipped with an LEDtype tail/brake light. If the tail/brake light does not come on, have a Yamaha dealer check it. 1. Screw 1. Headlight bulb holder 2. Disconnect the headlight coupler, and then remove the bulb cover.
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 74
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU24212 EAU24323 Replacing a turn signal light bulb 1. Remove the turn signal lens by removing the screws. Replacing a license plate light bulb 1. Remove the license plate light unit by removing the nuts, washers and rubber dampers. 1. Turn signal light bulb
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 75
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU24350 Supporting the motorcycle Since this model is not front of the rear wheel. 2. Raise the front wheel off the ground by using a motorcycle stand. To service the rear wheel Raise the rear wheel off the ground by using a motorcycle stand or, if a motorcycle
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 76
    trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause poor starting and loss of power. The following troubleshooting parts, but they are often inferior, have a shorter service life and can lead to expensive repair bills. EWA15141
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 77
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU42601 Troubleshooting chart 1. Fuel There is enough fuel. Check the fuel level in the fuel tank. There is no fuel. Supply fuel. Check the compression. The engine
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 78
    spoked wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. Improper cleaning can damage plastic parts such
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 79
    MOTORCYCLE CARE AND STORAGE contact with strong or abrasive cleaning products, solvent or thinner, fuel (gasoline), rust removers or inhibitors, brake fluid, antifreeze or electrolyte. Do not use high-pressure washers or steam-jet cleaners since they cause water seepage and deterioration in the
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 80
    of the presence of ammonia) and areas where strong chemicals are stored. 8 Long-term Before storing your motorcycle for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 81
    MOTORCYCLE CARE AND STORAGE 3. Perform the following steps to protect the cylinders, piston rings, etc. from corrosion. a. Remove the spark plug caps and spark plugs. b. Pour a teaspoonful of engine oil into each spark plug bore. c. Install the spark plug caps onto the spark plugs, and then place
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 82
    mm (6.10 in) Minimum turning radius: 3400 mm (133.9 in) Engine oil: Type: YAMALUBE 4 20W-50 or SAE 20W-50 Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter cartridge replacement: 3.70 L (3.91 US qt, 3.26 Imp.qt) With oil filter
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 83
    SPECIFICATIONS Chassis: Frame type: Double cradle Caster angle: 29.25 ° Trail: 130.0 mm (5.12 in) Front: 250 kPa (2.50 kgf/cm², 36 psi) Rear: 250 kPa (2.50 kgf/cm², 36 psi) Loading condition: 90-185 kg (198-408 lb) Front: 250 kPa (2.50 kgf/cm², 36 psi) Rear: 290 kPa (2.90 kgf/cm², 42 psi) High-speed
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 84
    : LED Neutral indicator light: LED High beam indicator light: LED Turn signal indicator light: LED Fuel level warning light: LED Engine trouble warning light: LED Fuel injection system fuse: 15.0 A Backup fuse: 7.5 A Auto-decompression fuse: 15.0 A Fuses: Main fuse: 30.0 A Headlight fuse: 15
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 85
    CONSUMER INFORMATION EAU26351 EAU26381 EAU26400 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 86
    CONSUMER INFORMATION EAU26470 Model label 1. Model label The model label is affixed to the frame under the rider seat. (See page 4-10.) Record the information on this label in the space provided. This information will be needed when ordering spare parts from a Yamaha dealer. 10 10-2
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 87
    that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 88
    CONSUMER INFORMATION EAU26560 Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 89
    months 24000 mi (37000 km) or 36 months 28000 mi (43000 km) or 42 months 32000 mi (49000 km) or 48 months 10-5 Date of service Mileage Servicing dealer name and address Remarks 10
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 90
    CONSUMER INFORMATION Maintenance interval 36000 mi (55000 km) or 54 months 40000 mi (61000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 10 10-6
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 91
    1. Operate and maintain the motorcycle as specified in the appropriate Owner's Manual, and 2. Give notice to an authorized Yamaha motorcycle dealer of any . An inspection and registration fee will be charged for this service. EMISSION CONTROL SYSTEM WARRANTY: Yamaha Motor Corporation, U.S.A. also
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 92
    in the Owner's and Service Manual. We do recommend, however service, you must take it to any authorized Yamaha motorcycle dealer within the continental United States. Be sure to bring your warranty registration card or other valid proof of the original date of purchase. If a question or problem
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 93
    no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 94
    isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 10 10-10
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 95
    checking ...7-31 Storage ...8-3 Supporting the motorcycle ...7-37 Swingarm ...7-2 Transfer case oil ...7-14 Troubleshooting ...7-38 Troubleshooting chart ...7-39 Turn signal indicator filter cartridge ...7-10 Engine stop switch...4-6 Engine trouble warning light ...4-3 N Neutral indicator light
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 96
    INDEX Vehicle identification number ...10-1 W Warranty, extended...10-9 Warranty, limited ...10-7 Wheel bearings, checking...7-31 Wheels ...7-21
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 97
  • 2009 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 98
    YAMAHA MOTOR CO., LTD. PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2008.05-0.5×1 CR (E)
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
  • 93
  • 94
  • 95
  • 96
  • 97
  • 98
5PX-28199-17
XV17PCY(C)
XV17PCMY(C)
OWNER’S MANUAL
Read this manual carefully before operating this vehicle.
LIT-11626-22-34