2008 Yamaha Motorsports V Star Custom Owners Manual
2008 Yamaha Motorsports V Star Custom Manual
2008 Yamaha Motorsports V Star Custom manual content summary:
- 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 1
OWNER'S MANUAL XVS65X(C) XVS65AX(C) XVS65ATX(C) LIT-11626-21-09 3B6-28199-12 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 2
EAU10041 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 3
of craftsmanship and reliability that have made Yamaha a leader in these fields. This manual will give you an understanding of the operation, inspection, and basic maintenance of this close attention to the recommended maintenance schedules and operating instructions contained within this manual. - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 4
manual by the following notations: The Safety Alert Symbol means ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED! Failure to follow WARNING instructions procedures easier or clearer. WARNING CAUTION: NOTE: NOTE: G This manual should be considered a permanent part of this motorcycle and should - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 5
INFORMATION EWA10010 WARNING PLEASE READ THIS MANUAL AND THE "YOU AND YOUR MOTORCYCLE: RIDING TIPS" BOOKLET CAREFULLY AND COMPLETELY BEFORE OPERATING THIS MOTORCYCLE. DO NOT ATTEMPT TO OPERATE THIS MOTORCYCLE UNTIL YOU - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 6
INFORMATION EAU10192 AFFIX DEALER LABEL HERE XVS65X(C)/XVS65AX(C)/XVS65ATX(C) OWNER'S MANUAL ©2007 by Yamaha Motor Corporation, U.S.A. 1st edition, April 2007 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A. - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 7
TABLE OF CONTENTS SAFETY INFORMATION ...1-1 Location of important labels ...1-5 DESCRIPTION ...2-1 Left view ...2-1 Right view ...2-2 Controls and instruments ...2-3 INSTRUMENT AND CONTROL FUNCTIONS ...3-1 Main switch/steering lock ...3-1 Indicator and warning lights ...3-2 Speedometer unit ...3-2 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 8
tail/brake light bulb ...6-34 Supporting the motorcycle ...6-35 Front wheel ...6-36 Rear wheel ...6-37 Troubleshooting ...6-39 Troubleshooting chart ...6-40 MOTORCYCLE CARE AND MOTOR CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...9-9 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 9
SHOULD: G OBTAIN THOROUGH INSTRUCTIONS FROM A COMPETENT SOURCE ON ALL ASPECTS OF MOTORCYCLE OPERATION. G OBSERVE THE WARNINGS AND MAINTENANCE REQUIREMENTS IN THE OWNER'S MANUAL. G OBTAIN QUALIFIED TRAINING IN SAFE AND PROPER RIDING TECHNIQUES. G OBTAIN PROFESSIONAL TECHNICAL SERVICE AS INDICATED BY - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 10
SAFETY INFORMATION wide on a turn due to EXCESSIVE SPEED or undercornering (insufficient lean angle for the speed). • Always obey the speed limit and never travel faster than warranted by road and traffic conditions. • Always signal before turning or changing lanes. Make sure that other motorists - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 11
SAFETY INFORMATION Loading The total weight of the operator, passenger, accessories and cargo must not exceed the maximum load limit. Maximum load: XVS65ATX 200 kg (441 lb) XVS65ATXC 198 kg (437 lb) XVS65AX 200 kg (441 lb) XVS65AXC 198 kg (437 lb) XVS65X 180 kg (397 lb) XVS65XC 178 kg (392 lb) When - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 12
another vehicle, make sure that it is kept upright and that the fuel cock is turned to "ON" or "RES" (for vacuum type) / "OFF" (for manual type). If it should lean over, gasoline may leak out of the carburetor or fuel tank. If you should swallow any gasoline, inhale a lot of - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 13
SAFETY INFORMATION EAU10381 Location of important labels Please read the following important labels carefully before operating this vehicle. 1 1-5 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 14
SAFETY INFORMATION 1 1 3 XVS65AX /ATX 2 4 3 XVS65X 5FB-21668-01 1-6 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 15
SAFETY INFORMATION 5 1 A1 6 California only 1-7 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 16
DESCRIPTION EAU10410 Left view 2 1. 2. 3. 4. 5. 6. 7. Shift pedal (page 3-4) Fuel cock (page 3-7) Starter (choke) knob (page 3-8) Shock absorber assembly spring preload adjusting ring (page 3-12) Helmet holder (page 3-11) Owner's tool kit (page 6-1) Storage compartment (page 3-11) 2-1 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 17
DESCRIPTION EAU10420 Right view 2 1. 2. 3. 4. 5. 6. Engine oil filter element (page 6-11) Battery (page 6-31) Fuses (page 6-32) Main switch/steering lock (page 3-1) Air filter element (page 6-14) Brake pedal (page 3-5) 2-2 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 18
DESCRIPTION EAU10430 Controls and instruments 2 1. 2. 3. 4. 5. 6. 7. Clutch lever (page 3-4) Left handlebar switches (page 3-3) Speedometer unit (page 3-2) Fuel tank cap (page 3-5) Right handlebar switches (page 3-3) Throttle grip (page 6-16) Brake lever (page 3-5) 2-3 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 19
INSTRUMENT AND CONTROL FUNCTIONS EAU10460 EAU10660 Main switch/steering lock OFF All electrical systems are off. The key can be removed. EAU10680 To unlock the steering LOCK The steering is locked, and all electrical systems are off. The key can be removed. To lock the steering The main switch/ - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 20
" EAU11020 Turn signal indicator light " " This indicator light flashes when the turn signal switch is pushed to the left or right. EAU11060 Engine trouble warning light " " This warning light comes on or flashes when an electrical circuit monitoring the engine is defective. When this occurs, have - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 21
for approximately 15 seconds. However, the turn signal lights can also be canceled manually by pushing the switch in after it has returned to the center position. NOTE . ECA10050 CAUTION: See page 5-1 for starting instructions prior to starting the engine. 1. Engine stop switch " 2. Start switch " - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 22
INSTRUMENT AND CONTROL FUNCTIONS EAU12820 EAU12870 EAU12880 Clutch lever Shift pedal (XVS65X) Shift pedal (XVS65AX/ATX) 3 1. Clutch lever 1. Shift pedal 1. Shift pedal The clutch lever is located at the left handlebar grip. To disengage the clutch, pull the lever toward the handlebar grip. - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 23
INSTRUMENT AND CONTROL FUNCTIONS EAU12890 EAU12941 EAU13120 Brake lever Brake pedal XVS65X Fuel tank cap 3 1. Brake lever The brake lever is located at the right handlebar grip. To apply the front brake, pull the lever toward the handlebar grip. 1. Brake pedal XVS65AX/ATX To remove the fuel - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 24
INSTRUMENT AND CONTROL FUNCTIONS EAU13211 ECA10070 NOTE: The fuel tank cap cannot be installed unless the key is in the lock. In addition, the key cannot be removed if the cap is not properly installed and locked. EWA10130 Fuel CAUTION: Immediately wipe off spilled fuel with a clean, dry, soft - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 25
not exceed 10%. Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. EAU13441 EAU13550 Catalytic converter This vehicle is equipped with catalytic converters in the exhaust system. EWA10860 Fuel cock The fuel cock - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 26
INSTRUMENT AND CONTROL FUNCTIONS ON This indicates reserve. With the fuel cock lever in this position, the fuel reserve is made available. Turn the fuel cock lever to this position if you run out of fuel while riding. When this occurs, refuel as soon as possible and be sure to turn the fuel cock - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 27
INSTRUMENT AND CONTROL FUNCTIONS EAU14184 Seats (XVS65X) Passenger seat To remove the passenger seat Remove the nut and washer, and then pull the passenger seat up. Tightening torque: Passenger seat nut: 13 Nm (1.3 m·kgf, 9.4 ft·lbf) To install the rider seat 1. Insert the projection on the front - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 28
INSTRUMENT AND CONTROL FUNCTIONS EAU14191 Seats (XVS65AX/ATX) Passenger seat To remove the passenger seat Remove the nut and washer, and then pull the passenger seat up. 3 Tightening torque: Passenger seat nut: 13 Nm (1.3 m·kgf, 9.4 ft·lbf) 1. Bolt 1. Seat holder 2. Projection Rider seat 1. Nut - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 29
INSTRUMENT AND CONTROL FUNCTIONS 2. Install the passenger seat. NOTE: Make sure that the seats are properly secured before riding. EAU14281 EAU14481 Helmet holder Storage compartment The storage compartment is located on the left side of the vehicle. To open the storage compartment 1. Slide the - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 30
INSTRUMENT AND CONTROL FUNCTIONS EAU14860 Adjusting the shock absorber assembly 2. To increase the spring preload and thereby harden the suspension, turn the adjusting ring in direction (a). To decrease the spring preload and thereby soften the suspension, turn the adjusting ring in direction (b). - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 31
pressure. G Do not deform or damage the gas cylinder in any way, as this will result in poor damping performance. G Always have a Yamaha dealer service the shock absorber. Luggage strap holders Sidestand The sidestand is located on the left side of the frame. Raise the sidestand or lower it with - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 32
INSTRUMENT AND CONTROL FUNCTIONS below and have a Yamaha dealer repair it if it does not function properly. EAU15312 Ignition circuit cut-off system The ignition circuit cut-off system (comprising the sidestand switch, clutch switch and neutral switch) has the following functions. G It prevents - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 33
INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is turned on. 3. Turn the key on. 4. Shift the transmission into the neutral position. 5. Push the start switch. Does the engine start? NOTE: This check is most reliable - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 34
PRE-OPERATION CHECKS EAU15593 The condition of a vehicle is the owner's responsibility. Vital components can start to deteriorate quickly and unexpectedly, even if the vehicle remains unused (for example, as a result of exposure to the elements). Any damage, fluid leakage or loss of tire air - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 35
PRE-OPERATION CHECKS EAU15605 Pre-operation check list ITEM Fuel • Check fuel level in fuel tank. • Refuel if necessary. • Check fuel line for leakage. • Check oil level in engine. • If necessary, add recommended oil to specified level. • Check vehicle for oil leakage. • Check vehicle for oil - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 36
PRE-OPERATION CHECKS ITEM CHECKS Check for damage. Check tire condition and tread depth. Check air pressure. Correct if necessary. PAGE Wheels and tires 6-17, 6-20 Brake and shift pedals Brake and clutch levers Sidestand • Make sure that operation is smooth. • Lubricate pedal pivoting points if - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 37
the key to "ON" and make sure that the engine stop switch is set to " ". 3. Shift the transmission into the neutral position. CAUTION: The engine trouble warning light should come on when the key is turned to "ON", and then go off after a few seconds. If the engine - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 38
OPERATION AND IMPORTANT RIDING POINTS after starting, immediately stop the engine, and have a Yamaha dealer check the self-diagnosis system. 6. After starting the engine, move the starter (choke) back halfway. ECA11130 (choke) turned on, then about 2.5 minutes with the starter (choke) in the - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 39
OPERATION AND IMPORTANT RIDING POINTS EAU16671 Shifting XVS65X Shifting gears lets you control the amount of engine power available for starting off, accelerating, climbing hills, etc. The gear positions are shown in the illustration. NOTE: To shift the transmission into the neutral position, - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 40
OPERATION AND IMPORTANT RIDING POINTS EAU16841 NOTE: Always shift gears at the recommended shift points. EAU16700 5 To decelerate 1. Apply both the front and the rear brakes to slow the motorcycle. 2. Shift the transmission into first gear when the motorcycle reaches 25 km/h (15.5 mi/h). If the - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 41
the engine, remove the key from the main switch, and then turn the fuel cock lever to "OFF". EWA10310 WARNING G CAUTION: If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. G Since the engine and exhaust system can become very - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 42
. 1. Owner's tool kit The owner's tool kit is located inside the storage compartment. (See page 3-11.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and minor repairs. However - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 43
PERIODIC MAINTENANCE AND MINOR REPAIR EWA10340 WARNING Modifications not approved by Yamaha may cause loss of performance, excessive emissions, and render the vehicle unsafe for use. Consult a Yamaha dealer before attempting any changes. 6 6-2 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 44
speed 5 * 6 * 7 * 8 * Exhaust system Evaporative emission control system (For California only) 9 * √ √ * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 6-3 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 45
PERIODIC MAINTENANCE AND MINOR REPAIR EAU32185 General maintenance and lubrication chart INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 46
PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 9 * Swingarm pivot bearings - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 47
PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months √ ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 18 * Front fork • Check - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 48
36 months, repeat the maintenance intervals starting from 8000 mi (13000 km) or 12 months. EAU17620 6 NOTE: G The air filter needs more frequent service if you are riding in unusually wet or dusty areas. G Hydraulic brake system • When disassembling the master cylinder or caliper cylinder, always - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 49
PERIODIC MAINTENANCE AND MINOR REPAIR EAU18771 Removing and installing panels The panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a panel needs to be removed and installed. XVS65X XVS65AX/ATX XVS65X 1. Panel A 1. - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 50
the same color. NOTE: If any spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 1. Spark plug cap 2. Remove the spark plug as shown, with the spark plug wrench - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 51
PERIODIC MAINTENANCE AND MINOR REPAIR 3. Check each spark plug for electrode erosion and excessive carbon or other deposits, and replace it if necessary. Specified spark plug: NGK/DPR7EA-9 DENSO/X22EPR-U9 2. Clean the surface of the spark plug gasket and its mating surface, and then wipe off any - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 52
PERIODIC MAINTENANCE AND MINOR REPAIR EAU19743 Engine oil and oil filter element The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil filter element replaced at the intervals specified in the periodic maintenance and lubrication chart. To check - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 53
PERIODIC MAINTENANCE AND MINOR REPAIR Tightening torque: Engine oil drain bolt: 43 Nm (4.3 m·kgf, 31 ft·lbf) 9. Add the specified amount of the recommended oil, and then install and tighten the oil filler cap. Recommended engine oil: See page 8-1. Oil quantity: Without oil filter element - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 54
PERIODIC MAINTENANCE AND MINOR REPAIR er quality than specified. In addition, do not use oils labeled "ENERGY CONSERVING II" or higher. Make sure that no foreign material enters the crankcase. EAU20022 Final gear oil The final gear case must be checked for oil leakage before each ride. If any - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 55
PERIODIC MAINTENANCE AND MINOR REPAIR 2. Remove the oil filler bolt and drain bolt to drain the oil from the final gear case. 3. Install the final gear oil drain bolt, and then tighten it to the specified torque. Tightening torque: Final gear oil drain bolt: 23 Nm (2.3 m·kgf, 17 ft·lbf) 6. Check - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 56
PERIODIC MAINTENANCE AND MINOR REPAIR ECA10480 CAUTION: G G 1. Air filter element Make sure that the air filter element is properly seated in the air filter case. The engine should never be operated without the air filter element installed, otherwise the piston(s) and/or cylinder(s) may become - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 57
PERIODIC MAINTENANCE AND MINOR REPAIR EAU21271 EAU21311 EAU21382 Carburetors The carburetors are important parts of the engine and emission control system, which require very sophisticated adjustment. Therefore, all carburetor adjustments should be left to a Yamaha dealer, who has the necessary - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 58
PERIODIC MAINTENANCE AND MINOR REPAIR EAU21401 EAU32520 Valve clearance The valve clearance changes with use, resulting in improper air-fuel mixture and/or engine noise. To prevent this from occurring, the valve clearance must be adjusted by a Yamaha dealer at the intervals specified in the - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 59
PERIODIC MAINTENANCE AND MINOR REPAIR Tire air pressure (measured on cold tires): XVS65ATX 90-200 kg (198-441 lb) XVS65ATXC 90-198 kg (198-437 lb) XVS65AX 90-200 kg (198-441 lb) XVS65AXC 90-198 kg (198-437 lb) XVS65X 90-180 kg (198-397 lb) XVS65XC 90-178 kg (198-392 lb): Front: XVS65ATX 225 kPa (33 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 60
PERIODIC MAINTENANCE AND MINOR REPAIR EWA10560 EWA10460 WARNING G WARNING G G G 6 It is dangerous to ride with a worn-out tire. When a tire tread begins to show crosswise lines, have a Yamaha dealer replace the tire immediately. The replacement of all wheeland brake-related parts, including - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 61
PERIODIC MAINTENANCE AND MINOR REPAIR EAU21940 EAU22011 Rear tire: Size: 170/80-15M/C 77S Manufacturer/model: XVS65ATX BRIDGESTONE/EXEDRA G702 XVS65ATXC BRIDGESTONE/EXEDRA G702 XVS65AX BRIDGESTONE/EXEDRA G702 XVS65AXC BRIDGESTONE/EXEDRA G702 XVS65X BRIDGESTONE/EXEDRA G546 XVS65XC BRIDGESTONE/EXEDRA - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 62
PERIODIC MAINTENANCE AND MINOR REPAIR any consequences caused by the use of items which have not been approved by Yamaha. EAU22041 Adjusting the clutch lever free play 1. Loosen the locknut at the clutch lever. 2. To increase the clutch lever free play, turn the adjusting bolt in direction (a). To - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 63
PERIODIC MAINTENANCE AND MINOR REPAIR EAU22092 Adjusting the brake lever free play 1. Clutch lever free play adjusting nut (crankcase) 2. Locknut 1. Locknut 2. Brake lever free play adjusting screw 1. Brake lever free play 5. To increase the clutch lever free play, turn the adjusting nut in - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 64
PERIODIC MAINTENANCE AND MINOR REPAIR system. If there is air in the hydraulic system, have a Yamaha dealer bleed the system before operating the motorcycle. Air in the hydraulic system will diminish the braking performance, which may result in loss of control and an accident. EAU22231 EWA10670 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 65
PERIODIC MAINTENANCE AND MINOR REPAIR To increase the brake pedal free play, turn the adjusting nut at the brake rod in direction (a). To decrease the brake pedal free play, turn the adjusting nut in direction (b). EAU22270 Adjusting the rear brake light switch 1. Locknut 2. Brake pedal position - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 66
PERIODIC MAINTENANCE AND MINOR REPAIR EAU22380 Checking the front brake pads and rear brake shoes The front brake pads and the rear brake shoes must be checked for wear at the intervals specified in the periodic maintenance and lubrication chart. EAU22430 indicator grooves have almost disappeared, - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 67
PERIODIC MAINTENANCE AND MINOR REPAIR G G When checking the fluid level, make sure that the top of the master cylinder is level by turning the handlebars. Use only the recommended quality brake fluid, otherwise the rubber seals may deteriorate, causing leakage and poor braking performance. brake - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 68
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23091 EAU23111 EAU44270 Checking and lubricating the cables The operation of all control cables and the condition of the cables should be checked before each ride, and the cables and cable ends should be lubricated if necessary. If a cable is damaged or does - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 69
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23141 EAU23200 Checking and lubricating the brake and clutch levers Brake lever Recommended lubricants: Brake lever: Silicone grease Clutch lever: Lithium-soap-based grease (allpurpose grease) Checking and lubricating the sidestand Clutch lever The - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 70
fork must be checked as follows at the intervals specified in the periodic maintenance and lubrication chart. To check the condition EWA10750 WARNING Securely support the vehicle so that there is no danger of it falling over. Check the inner tubes for scratches, damage and excessive oil leakage - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 71
. If there is play in the wheel hub or if the wheel does not turn smoothly, have a Yamaha dealer check the wheel bearings. WARNING Securely support the vehicle so that there is no danger of it falling over. 2. Hold the lower ends of the front fork legs and try to move - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 72
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23380 EWA10760 Battery G WARNING Electrolyte is poisonous and dangerous since it contains sulfuric acid, which causes severe burns. Avoid any contact with skin, eyes or clothing and always shield your eyes when working near batteries. In case of contact, - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 73
PERIODIC MAINTENANCE AND MINOR REPAIR ECA10630 EAU23525 CAUTION: G Replacing the fuses G Always keep the battery charged. Storing a discharged battery can cause permanent battery damage. To charge a sealed-type (MF) battery, a special (constant-voltage) battery charger is required. Using a - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 74
PERIODIC MAINTENANCE AND MINOR REPAIR ECA10640 EAU23792 CAUTION: Do not use a fuse of a higher amperage rating than recommended to avoid causing extensive damage to the electrical system and possibly a fire. 3. Turn the key to "ON" and turn on the electrical circuit in question to check if the - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 75
PERIODIC MAINTENANCE AND MINOR REPAIR EWA10790 EAU24281 WARNING Headlight bulbs get very hot. Therefore, keep flammable products away from a lit headlight bulb, and do not touch the bulb until it has cooled down. 4. Place a new headlight bulb into position, and then secure it with the bulb holder. - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 76
MAINTENANCE AND MINOR REPAIR XVS65AX/ATX EAU24350 Supporting the motorcycle Since this model is not of the rear wheel. 2. Raise the front wheel off the ground by using a motorcycle stand. To service the rear wheel Raise the rear wheel off the ground by using a motorcycle stand or, if a motorcycle - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 77
1. Wheel axle 2. Front wheel axle pinch bolt To remove the front wheel EWA10820 WARNING G G It is advisable to have a Yamaha dealer service the wheel. Securely support the motorcycle so that there is no danger of it falling over. 1. Disconnect the speedometer cable from the front wheel. 3. Lift - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 78
to check if the front fork compresses and rebounds smoothly. 8. Connect the speedometer cable. It is advisable to have a Yamaha dealer service the wheel. Securely support the motorcycle so that there is no danger of it falling over. 1. Loosen the axle nut. 1. 2. 3. 4. 5. 6. Brake pedal free play - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 79
gear case, and drive shaft by pushing the wheel forward and guiding the drive shaft into the middle gear universal joint. 7. Tighten rear wheel off the ground according to the procedure on page 6-35. 8. While supporting the drive shaft, pull the rear wheel back to remove the following parts as an - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 80
a thorough inspection before shipment from the factory, trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause poor starting and loss of power. The following troubleshooting chart represents a quick and easy procedure for checking - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 81
PERIODIC MAINTENANCE AND MINOR REPAIR EAU25891 Troubleshooting chart EWA10840 WARNING Keep away open flames and do not smoke while checking or working on the fuel system. 1. Fuel There is enough fuel. Check - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 82
spoked wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. Improper cleaning can damage plastic parts such - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 83
MOTORCYCLE CARE AND STORAGE cleaning products, solvent or thinner, fuel (gasoline), rust removers or inhibitors, brake fluid, antifreeze or electrolyte. Do not use high-pressure washers or steam-jet cleaners since they cause water seepage and deterioration in the following areas: seals (of wheel and - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 84
rubber and plastic parts, but treat them with a suitable care product. 7-3 Long-term Before storing your motorcycle for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. For motorcycles equipped with a fuel cock that has an "OFF" position: Turn the fuel cock - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 85
MOTORCYCLE CARE AND STORAGE 3. Drain the carburetor float chambers by loosening the drain bolts; this will prevent fuel deposits from building up. Pour the drained fuel into the fuel tank. 4. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from rusting and the - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 86
649.0 cm³ Bore × stroke: 81.0 × 63.0 mm (3.19 × 2.48 in) Compression ratio: 9.00 :1 Starting system: Electric starter 8 Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter element replacement: 2.60 L (2.75 US qt) (2.29 Imp.qt) With - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 87
SPECIFICATIONS Fuel: Recommended fuel: Unleaded gasoline only Fuel tank capacity: 16.0 L (4.23 US gal) (3.52 Imp.gal) Fuel reserve amount: 3.0 L (0.79 US gal) (0.66 Imp.gal) Operation: Left foot operation Gear ratio: 1st: 38/14 (2.714) 2nd: 38/20 (1.900) 3rd: 35/24 (1.458) 4th: 28/24 (1.167) 5th: 29 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 88
SPECIFICATIONS Manufacturer/model: XVS65ATX BRIDGESTONE/EXEDRA G702 XVS65ATXC BRIDGESTONE/EXEDRA G702 XVS65AX BRIDGESTONE/EXEDRA G702 XVS65AXC BRIDGESTONE/EXEDRA G702 XVS65X BRIDGESTONE/EXEDRA G546 XVS65XC BRIDGESTONE/EXEDRA G546 Manufacturer/model: XVS65ATX DUNLOP/D404G XVS65ATXC DUNLOP/D404G - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 89
lighting: 12 V, 1.7 W × 1 Neutral indicator light: 12 V, 1.7 W × 1 High beam indicator light: 12 V, 1.7 W × 1 Turn signal indicator light: 12 V, 1.7 W × 1 Engine trouble warning light: 12 V, 1.7 W × 1 Fuses: Main fuse: 30.0 A Headlight fuse: 15.0 A Signaling system fuse: 10.0 A Ignition fuse: 10 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 90
CONSUMER INFORMATION EAU26351 EAU26381 EAU26400 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 91
CONSUMER INFORMATION EAU26470 Model label 1. Model label The model label is affixed to the frame under the rider seat. (See page 3-9.) Record the information on this label in the space provided. This information will be needed when ordering spare parts from a Yamaha dealer. 9 9-2 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 92
that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 93
CONSUMER INFORMATION EAU26560 Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 94
30 months 24000 mi (37000 km) or 36 months 28000 mi (43000 km) or 42 months 32000 mi (49000 km) or 48 months 9-5 Date of service Mileage Servicing dealer name and address Remarks 9 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 95
CONSUMER INFORMATION Maintenance interval 36000 mi (55000 km) or 54 months 40000 mi (61000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 9 9-6 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 96
1. Operate and maintain the motorcycle as specified in the appropriate Owner's Manual, and 2. Give notice to an authorized Yamaha motorcycle dealer of any . An inspection and registration fee will be charged for this service. EMISSION CONTROL SYSTEM WARRANTY: Yamaha Motor Corporation, U.S.A. also - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 97
in the Owner's and Service Manual. We do recommend, however service, you must take it to any authorized Yamaha motorcycle dealer within the continental United States. Be sure to bring your warranty registration card or other valid proof of the original date of purchase. If a question or problem - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 98
no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 99
isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 9 9-10 - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 100
Steering, checking...6-30 Storage...7-3 Storage compartment...3-11 Supporting the motorcycle ...6-35 Swingarm pivots, lubricating ...6-29 ...6-11 Engine, starting a warm ...5-2 Engine stop switch ...3-3 Engine trouble warning light...3-2 T Throttle cable free play, checking ...6-16 Throttle - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 101
INDEX Tires...6-17 Tool kit ...6-1 Troubleshooting...6-39 Troubleshooting chart ...6-40 Turn signal indicator light...3-2 Turn signal light bulb or tail/ brake light bulb, replacing ...6-34 Turn signal switch...3-3 V Valve clearance ...6-17 Vehicle identification - 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 102
- 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 103
- 2008 Yamaha Motorsports V Star Custom | Owners Manual - Page 104
YAMAHA MOTOR CO., LTD. PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2007.05-1.7×1 CR (E)
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
 |
 |
3B6-28199-12
XVS65X(C)
XVS65AX(C)
XVS65ATX(C)
OWNER’S MANUAL
LIT-11626-21-09