2007 Yamaha Motorsports Virago 250 Owners Manual

2007 Yamaha Motorsports Virago 250 Manual

Get 2007 Yamaha Motorsports Virago 250 PDF manuals and user guides View all 2007 Yamaha Motorsports Virago 250 manuals

2007 Yamaha Motorsports Virago 250 manual content summary:

  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 1
    OWNER'S MANUAL XV250W1(C) LIT-11626-20-26 2UJ-28199-1F
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 2
    EAU10041
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 3
    of craftsmanship and reliability that have made Yamaha a leader in these fields. This manual will give you an understanding of the operation, inspection, and basic maintenance of this close attention to the recommended maintenance schedules and operating instructions contained within this manual.
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 4
    manual by the following notations: The Safety Alert Symbol means ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED! Failure to follow WARNING instructions procedures easier or clearer. WARNING CAUTION: NOTE: NOTE: G This manual should be considered a permanent part of this motorcycle and should
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 5
    IMPORTANT MANUAL INFORMATION AND UNTIL YOU HAVE BEEN TRAINED IN SAFE AND PROPER RIDING TECHNIQUES. REGULAR INSPECTIONS AND CAREFUL MAINTENANCE, ALONG WITH GOOD RIDING SKILLS, WILL ENSURE
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 6
    INFORMATION EAU10192 AFFIX DEALER LABEL HERE XV250W1(C) OWNER'S MANUAL ©2006 by Yamaha Motor Corporation, U.S.A. 1st edition, May 2006 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A.
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 7
    TABLE OF CONTENTS SAFETY INFORMATION ...1-1 Location of important labels ...1-5 DESCRIPTION ...2-1 Left view ...2-1 Right view ...2-2 Controls and instruments ...2-3 INSTRUMENT AND CONTROL FUNCTIONS ...3-1 Main switch ...3-1 Indicator lights ...3-1 Speedometer unit ...3-2 Handlebar switches ...3-2
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 8
    signal light bulb ...6-34 Supporting the motorcycle ...6-35 Front wheel ...6-35 Rear wheel ...6-37 Troubleshooting ...6-39 Troubleshooting chart ...6-40 MOTORCYCLE CARE AND YAMAHA MOTOR CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...9-9
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 9
    SHOULD: G OBTAIN THOROUGH INSTRUCTIONS FROM A COMPETENT SOURCE ON ALL ASPECTS OF MOTORCYCLE OPERATION. G OBSERVE THE WARNINGS AND MAINTENANCE REQUIREMENTS IN THE OWNER'S MANUAL. G OBTAIN QUALIFIED TRAINING IN SAFE AND PROPER RIDING TECHNIQUES. G OBTAIN PROFESSIONAL TECHNICAL SERVICE AS INDICATED BY
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 10
    SAFETY INFORMATION wide on a turn due to EXCESSIVE SPEED or undercornering (insufficient lean angle for the speed). • Always obey the speed limit and never travel faster than warranted by road and traffic conditions. • Always signal before turning or changing lanes. Make sure that other motorists
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 11
    SAFETY INFORMATION Loading The total weight of the operator, passenger, accessories and cargo must not exceed the maximum load limit. Maximum load: 195 kg (430 lb) (CAL) 196 kg (432 lb) (U49) When loading within this weight limit, keep the following in mind: G Cargo and accessory weight should be
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 12
    another vehicle, make sure that it is kept upright and that the fuel cock is turned to "ON" or "RES" (for vacuum type) / "OFF" (for manual type). If it should lean over, gasoline may leak out of the carburetor or fuel tank. If you should swallow any gasoline, inhale a lot of
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 13
    SAFETY INFORMATION EAU10381 Location of important labels Please read the following important labels carefully before operating this vehicle. 1 1-5
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 14
    SAFETY INFORMATION 1 1 4 California only 2 5 3 Cold tire normal pressure should be set as follows. 175 200 200 225 1.75 2.00 2.00 2.25 25 29 29 33 3CK-21668-A1 California only 1-6
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 15
    DESCRIPTION EAU10410 Left view 2 1. 2. 3. 4. 5. 6. 7. 8. Headlight (page 6-32) Steering lock (page 3-8) Fuel tank (page 3-5) Battery (page 6-30) Fuses (page 6-31) Helmet holder (page 3-9) Shock absorber assembly spring preload adjusting ring (page 3-9) Main switch (page 3-1) 2-1 9. Fuel cock (
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 16
    DESCRIPTION EAU10420 Right view 2 1. 2. 3. 4. 5. 6. 7. 8. Tail/brake light (page 6-33) Rear turn signal lights (page 6-34) Rider seat (page 3-8) Air filter element (page 6-13) Front turn signal/position lights (page 6-34) Brake pedal (page 3-4) Footrest Owner's tool kit (page 6-1) 2-2 9. Shock
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 17
    DESCRIPTION EAU10430 Controls and instruments 2 1. 2. 3. 4. 5. 6. 7. 8. Clutch lever (page 3-3) Left handlebar switches (page 3-2) Speedometer unit (page 3-2) Indicator lights (page 3-1) Right handlebar switches (page 3-2) Brake lever (page 3-4) Throttle grip (page 6-15) Fuel tank cap (page 3-5)
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 18
    INSTRUMENT AND CONTROL FUNCTIONS EAU10450 EAU10810 EAU10980 Main switch P (Parking) The taillight and position lights are on, but all other electrical systems are off. The key can be removed. The key must be pushed in from the "OFF" position to be turned to "P". ECA11020 Indicator lights 3
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 19
    INSTRUMENT AND CONTROL FUNCTIONS EAU11090 EAU11630 EAU12346 High beam indicator light "HIGH BEAM" This indicator light comes on when the high beam of the headlight is switched on. Speedometer unit Handlebar switches Left 3 1. 2. 3. 4. Odometer Tripmeter Tripmeter reset knob Speedometer 1.
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 20
    switch "LIGHTS" Set the switch to "HI" for the high beam and to "LO" for the low beam. EAU12440 CAUTION: See page 5-1 for starting instructions prior to starting the engine. Clutch lever 3 Turn signal switch "TURN" To signal a right-hand turn, push this switch to the right. To signal a left
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 21
    INSTRUMENT AND CONTROL FUNCTIONS EAU12870 EAU12890 EAU12941 Shift pedal Brake lever Brake pedal 3 1. Shift pedal 1. Brake lever 1. Brake pedal The shift pedal is located on the left side of the engine and is used in combination with the clutch lever when shifting the gears of the 5-speed
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 22
    INSTRUMENT AND CONTROL FUNCTIONS EAU13040 EAU13211 Fuel tank cap NOTE: The fuel tank cap cannot be closed unless the key is in the lock. In addition, the key cannot be removed if the cap is not properly closed and locked. EWA11090 Fuel WARNING 3 Make sure that the fuel tank cap is properly
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 23
    does not exceed 10%. Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. EAU13581 Fuel cock This model is equipped with a negative pressure fuel cock. The fuel cock supplies fuel from the tank to the carburetor
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 24
    INSTRUMENT AND CONTROL FUNCTIONS RES PRI EAU13630 Starter (choke) lever 3 1. Arrow mark positioned over "RES" 1. Arrow mark positioned over "PRI" 1. Starter (choke) lever This indicates reserve. With the fuel cock lever in this position, the fuel reserve is made available. Quickly turn the fuel
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 25
    INSTRUMENT AND CONTROL FUNCTIONS EAU13730 Steering lock To unlock the steering 1. Open the steering lock cover, and then insert the key. 2. Push the key in, turn it 1/8 turn counterclockwise so that it moves out, and then release it. 3. Remove the key, and then close the lock cover. EAU14220
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 26
    INSTRUMENT AND CONTROL FUNCTIONS EAU14281 EAU14880 Helmet holder Adjusting the shock absorber assemblies 3 1. Projection 2. Seat holder 2. Place the rider seat in the original position, and then tighten the bolts. NOTE: Make sure that the rider seat is properly secured before riding. 1. Helmet
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 27
    INSTRUMENT AND CONTROL FUNCTIONS EWA10210 EAU15301 WARNING Always adjust both shock absorber assemblies equally, otherwise poor handling and loss of stability may result. Adjust the spring preload as follows. To increase the spring preload and thereby harden the suspension, turn the adjusting ring
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 28
    INSTRUMENT AND CONTROL FUNCTIONS EAU15311 Ignition circuit cut-off system The ignition circuit cut-off system (comprising the sidestand switch, clutch switch and neutral switch) has the following functions. G It prevents starting when the transmission is in gear and the sidestand is up, but the
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 29
    INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is turned on. 3. Turn the key on. 4. Shift the transmission into the neutral position. 5. Push the start switch. Does the engine start? NOTE: This check is most reliable
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 30
    PRE-OPERATION CHECKS EAU15591 The condition of a vehicle is the owner's responsibility. Vital components can start to deteriorate quickly and unexpectedly, even if the vehicle remains unused (for example, as a result of exposure to the elements). Any damage, fluid leakage or loss of tire air
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 31
    PRE-OPERATION CHECKS EAU15605 Pre-operation check list ITEM Fuel • Check fuel level in fuel tank. • Refuel if necessary. • Check fuel line for leakage. • Check oil level in engine. • If necessary, add recommended oil to specified level. • Check vehicle for oil leakage Check operation. If soft or
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 32
    PRE-OPERATION CHECKS ITEM Check chain slack. Adjust if necessary. Check chain condition. Lubricate if necessary. Check for damage. Check tire condition and tread depth. Check air pressure. Correct if necessary. CHECKS PAGE Drive chain 6-23, 6-25 Wheels and tires 6-15, 6-17 Brake and shift
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 33
    OPERATION AND IMPORTANT RIDING POINTS EAU15950 EAU32620 EWA10270 WARNING G Starting and warming up a cold engine In order for the ignition circuit cut-off system to enable starting, one of the following conditions must be met: G The transmission is in the neutral position. G The transmission is in
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 34
    OPERATION AND IMPORTANT RIDING POINTS ECA11130 EAU16640 EAU16671 CAUTION: For maximum engine life, always warm the engine up before starting off. Never accelerate hard when the engine is cold! 7. When the engine is warm, turn the starter (choke) off. NOTE: The engine is warm when it responds
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 35
    OPERATION AND IMPORTANT RIDING POINTS ECA10260 CAUTION: G G Even with the transmission in the neutral position, do not coast for long periods of time with the engine off, and do not tow the motorcycle for long distances. The transmission is properly lubricated only when the engine is running.
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 36
    . ECA10270 Parking When parking, stop the engine, and then remove the key from the main switch. EWA10310 WARNING G CAUTION: If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. G 5 Since the engine and exhaust system can
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 37
    , AND EQUIPMENT. YAMAHA DEALERS ARE TRAINED AND EQUIPPED TO PERFORM THESE PARTICULAR SERVICES. 1. Owner's tool kit The owner's tool kit is located behind panel A. (See page 6-8.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 38
    PERIODIC MAINTENANCE AND MINOR REPAIR EWA10340 WARNING Modifications not approved by Yamaha may cause loss of performance, excessive emissions, and render the vehicle unsafe for use. Consult a Yamaha dealer before attempting any changes. 6 6-2
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 39
    speed √ √ √ √ √ √ 6 4 * 5 * √ √ √ √ √ √ √ √ 6 * Exhaust system Evaporative emission control system (For California only) 7 * √ √ * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 6-3
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 40
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU32162 General maintenance and lubrication chart INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (6000 km) or 6 months ODOMETER READINGS 7000 mi 10000 mi 13000 mi 16000 mi (11000 km) (16000 km) (21000 km) (26000 km) or or or or 12 months 18
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 41
    PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (6000 km) or 6 months √ ODOMETER READINGS 7000 mi 10000 mi 13000 mi 16000 mi (11000 km) (16000 km) (21000 km) (26000 km) or or or or 12 months 18 months 24 months 30 months 9 * Wheel bearings •
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 42
    * Throttle grip housing and cable √ √ √ √ √ 25 * Lights, signals and switches √ √ √ √ √ √ * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 6-6
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 43
    or 36 months, repeat the maintenance intervals starting from 7000 mi (11000 km) or 12 months. EAU17620 NOTE: G The air filter needs more frequent service if you are riding in unusually wet or dusty areas. G Hydraulic brake system • When disassembling the master cylinder or caliper cylinder, always
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 44
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU18751 EAU19544 Removing and installing the panel The panel shown needs to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time the panel needs to be removed and installed. Checking the spark plugs The
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 45
    same color. NOTE: If any spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. To install a spark plug 1. Measure the spark plug gap with a wire thickness gauge and
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 46
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU19681 Canister (for California only) G Make sure that the canister breather is not blocked, and if necessary, clean it. EAU19751 Engine oil and oil filter element The engine oil level should be checked before each ride. In addition, the oil must be
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 47
    PERIODIC MAINTENANCE AND MINOR REPAIR NOTE: The engine oil should be between the minimum and maximum level marks. 2. Place an oil pan under the engine to collect the used oil. 3. Remove the engine oil filler cap and drain bolt to drain the oil from the crankcase. NOTE: Skip steps 4-6 if the oil
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 48
    PERIODIC MAINTENANCE AND MINOR REPAIR Tightening torque: Engine oil drain bolt: 34 Nm (3.4 m·kgf, 24 ft·lbf) G Make sure that no foreign material enters the crankcase. 8. Add the specified amount of the recommended engine oil, and then install and tighten the oil filler cap. Recommended engine oil
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 49
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU32733 Cleaning the air filter element The air filter element should be cleaned at the intervals specified in the periodic maintenance and lubrication chart. Clean the air filter element more frequently if you are riding in unusually wet or dusty areas. 1.
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 50
    PERIODIC MAINTENANCE AND MINOR REPAIR 5. Remove the sponge material from the air filter element frame, clean it with solvent, and then squeeze the remaining solvent out. 7. Pull the sponge material over the air filter element frame. 8. Insert the element into the air filter case, and then tighten
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 51
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU21381 EAU21401 EAU32520 Checking the throttle cable free play Valve clearance The valve clearance changes with use, resulting in improper air-fuel mixture and/or engine noise. To prevent this from occurring, the valve clearance must be adjusted by a Yamaha
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 52
    PERIODIC MAINTENANCE AND MINOR REPAIR Tire air pressure (measured on cold tires): 0-90 kg (0-198 lb): Front: 175 kPa (25 psi) (1.75 kgf/cm²) Rear: 200 kPa (29 psi) (2.00 kgf/cm²) 90-195 kg (198-430 lb) (CAL) 90-196 kg (198-432 lb) (U49): Front: 200 kPa (29 psi) (2.00 kgf/cm²) Rear: 225 kPa (33 psi)
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 53
    PERIODIC MAINTENANCE AND MINOR REPAIR Tire information This motorcycle is equipped with spoke wheels and tube tires. EWA10460 EAU21940 EAU22011 Spoke wheels To maximize the performance, durability, and safe operation of your motorcycle, note the following points regarding the specified wheels. G
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 54
    PERIODIC MAINTENANCE AND MINOR REPAIR any consequences caused by the use of items which have not been approved by Yamaha. EAU22041 Adjusting the clutch lever free play NOTE: If the specified clutch lever free play could be obtained as described above, tighten the locknut and skip the rest of the
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 55
    PERIODIC MAINTENANCE AND MINOR REPAIR 5. To increase the clutch lever free play, turn the adjusting nut in direction (a). To decrease the clutch lever free play, turn the adjusting nut in direction (b). 6. Tighten the locknut at the clutch lever and the crankcase. EAU22092 EWA10630 Adjusting the
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 56
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU22201 Adjusting the brake pedal position and free play 1. Loosen the locknut at the brake pedal. 2. To raise the brake pedal, turn the adjusting bolt in direction (a). To lower the brake pedal, turn the adjusting bolt in direction (b). Brake pedal free
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 57
    PERIODIC MAINTENANCE AND MINOR REPAIR G G If proper adjustment cannot be obtained as described, have a Yamaha dealer make this adjustment. After adjusting the brake pedal free play, check the operation of the brake light. EAU22270 EAU22380 Adjusting the rear brake light switch Checking the
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 58
    PERIODIC MAINTENANCE AND MINOR REPAIR indicator groove has almost disappeared, have a Yamaha dealer replace the brake pads as a set. EAU22540 EAU32343 Checking the front brake fluid level G Rear brake shoes G When checking the fluid level, make sure that the top of the master cylinder is level
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 59
    PERIODIC MAINTENANCE AND MINOR REPAIR brake fluid level goes down suddenly, have a Yamaha dealer check the cause. EAU22720 EAU22760 Changing the brake fluid Have a Yamaha dealer change the brake fluid at the intervals specified in the NOTE after the periodic maintenance and lubrication chart. In
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 60
    PERIODIC MAINTENANCE AND MINOR REPAIR 2. Remove the cotter pin from the axle nut, and then loosen the axle nut. 3. Loosen the chain puller locknut at each end of the swingarm. 4. To tighten the drive chain, turn the adjusting nut at each end of the swingarm in direction (a). To loosen the drive
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 61
    intervals specified in the periodic maintenance and lubrication chart, otherwise it will quickly wear out, especially when riding in dusty or wet areas. Service the drive chain as follows. ECA10581 WARNING After adjusting the brake pedal free play, check the operation of the brake light. 6. Insert
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 62
    PERIODIC MAINTENANCE AND MINOR REPAIR making sure that all side plates and rollers have been sufficiently oiled. EAU23091 EAU23111 Checking and lubricating the cables The operation of all control cables and the condition of the cables should be checked before each ride, and the cables and cable
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 63
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU23131 EAU23140 EAU23200 Checking and lubricating the brake and shift pedals The operation of the brake and shift pedals should be checked before each ride, and the pedal pivots should be lubricated if necessary. Recommended lubricant: Lithium-soap-based
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 64
    fork must be checked as follows at the intervals specified in the periodic maintenance and lubrication chart. To check the condition EWA10750 WARNING Securely support the vehicle so that there is no danger of it falling over. Check the inner tubes for scratches, damage and excessive oil leakage
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 65
    . If there is play in the wheel hub or if the wheel does not turn smoothly, have a Yamaha dealer check the wheel bearings. WARNING Securely support the vehicle so that there is no danger of it falling over. 2. Hold the lower ends of the front fork legs and try to move
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 66
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU23310 Battery A poorly maintained battery will corrode and discharge quickly. The electrolyte level, battery lead connections and breather hose routing should be checked before each ride and at the intervals specified in the periodic maintenance and
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 67
    PERIODIC MAINTENANCE AND MINOR REPAIR that the breather hose is properly routed, in good condition, and not obstructed. ECA10600 EAU23600 Replacing the fuses CAUTION: If the breather hose is positioned in such a way that the frame is exposed to electrolyte or gas expelled from the battery, the
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 68
    PERIODIC MAINTENANCE AND MINOR REPAIR ECA10640 EAU23780 CAUTION: Do not use a fuse of a higher amperage rating than recommended to avoid causing extensive damage to the electrical system and possibly a fire. 3. Turn the key to "ON" and turn on the electrical circuit in question to check if the
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 69
    PERIODIC MAINTENANCE AND MINOR REPAIR EWA10790 EAU24131 WARNING Headlight bulbs get very hot. Therefore, keep flammable products away from a lit headlight bulb, and do not touch the bulb until it has cooled down. 4. Place a new headlight bulb into position, and then secure it with the bulb holder.
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 70
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU24210 Replacing a turn signal light bulb 1. Remove the turn signal lens by removing the screws. 1. Tail/brake light bulb 1. Turn signal light bulb 6 3. Insert a new bulb into the socket, push it in, and then turn it clockwise until it stops. 4. Install
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 71
    side of the swingarm. EAU24360 Front wheel EAU24600 To remove the front wheel EWA10820 WARNING G G It is advisable to have a Yamaha dealer service the wheel. Securely support the motorcycle so that there is no danger of it falling over. 1. Disconnect the speedometer cable from the front wheel
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 72
    PERIODIC MAINTENANCE AND MINOR REPAIR 1. Wheel axle 2. Front wheel axle pinch bolt 1. Speedometer gear unit 6 3. Lift the front wheel off the ground according to the procedure on page 6-35. 4. Pull the wheel axle out, and then remove the wheel. ECA11070 2. Lift the wheel up between the fork
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 73
    the speedometer cable. EAU25080 Rear wheel EAU32750 To remove the rear wheel EWA10820 WARNING G G It is advisable to have a Yamaha dealer service the wheel. Securely support the motorcycle so that there is no danger of it falling over. 1. Remove the axle nut cotter pin. 2. Loosen the chain
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 74
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU32760 1. 2. 3. 4. 5. Brake torque rod Brake torque rod bolt and nut Brake rod Brake pedal free play adjusting nut Brake camshaft lever To install the rear wheel 1. Install the drive chain onto the rear sprocket, and then install the wheel by inserting the
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 75
    a thorough inspection before shipment from the factory, trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause poor starting and loss of power. The following troubleshooting chart represents a quick and easy procedure for checking
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 76
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU25931 Troubleshooting chart EWA10840 WARNING Keep away open flames and do not smoke while checking or working on the fuel system. 1. Fuel There is enough fuel. Check
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 77
    wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. Improper cleaning can damage windshields, cowlings
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 78
    MOTORCYCLE CARE AND STORAGE After normal use Remove dirt with warm water, a mild detergent, and a soft, clean sponge, and then rinse thoroughly with clean water. Use a toothbrush or bottlebrush for hard-to-reach areas. Stubborn dirt and insects will come off more easily if the area is covered with a
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 79
    of the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your motorcycle for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. Turn the fuel cock lever to "ON". 3. Drain the carburetor float chambers by loosening the
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 80
    MOTORCYCLE CARE AND STORAGE EWA10950 WARNING To prevent damage or injury from sparking, make sure to ground the spark plug electrodes while turning the engine over. 6. Lubricate all control cables and the pivoting points of all levers and pedals as well as of the sidestand/centerstand. 7. Check and
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 81
    × 66.0 mm (1.93 × 2.60 in) Compression ratio: 10.00 :1 Starting system: Electric starter Lubrication system: Wet sump Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter element replacement: 1.40 L (1.48 US qt) (1.23 Imp.qt) With oil
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 82
    SPECIFICATIONS 3rd: 29/23 (1.261) 4th: 26/26 (1.000) 5th: 23/28 (0.821) Tire air pressure (measured on cold tires): Loading condition: 0-90 kg (0-198 lb) Front: 175 kPa (25 psi) (1.75 kgf/cm²) Rear: 200 kPa (29 psi) (2.00 kgf/cm²) Loading condition: 90-195 kg (198-430 lb) (CAL) 90-196 kg (198-432
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 83
    SPECIFICATIONS Bulb voltage, wattage × quantity: Headlight: 12 V, 60 W/55.0 W × 1 Tail/brake light: 12 V, 8.0 W/27.0 W × 1 Front turn signal/position light: 12 V, 27 W/8.0 W × 2 Rear turn signal light: 12 V, 27.0 W × 2 Meter lighting: 14 V, 3.0 W × 1 Neutral indicator light: 14 V, 3.0 W × 1 High
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 84
    CONSUMER INFORMATION EAU26351 EAU26390 EAU26400 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 85
    CONSUMER INFORMATION EAU26470 Model label 1. Model label The model label is affixed to the frame under the rider seat. (See page 3-8.) Record the information on this label in the space provided. This information will be needed when ordering spare parts from a Yamaha dealer. 9 9-2
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 86
    that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1-800
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 87
    CONSUMER INFORMATION EAU26560 Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 88
    30 months 19000 mi (31000 km) or 36 months 22000 mi (36000 km) or 42 months 25000 mi (41000 km) or 48 months 9-5 Date of service Mileage Servicing dealer name and address Remarks 9
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 89
    CONSUMER INFORMATION Maintenance interval 28000 mi (46000 km) or 54 months 31000 mi (51000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 9 9-6
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 90
    CONSUMER INFORMATION EAU26662 YAMAHA MOTOR CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY 9 9-7
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 91
    CONSUMER INFORMATION 9 9-8
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 92
    no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 93
    isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 9 9-10
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 94
    ...3-3 Steering, checking...6-29 Steering lock ...3-8 Storage...7-3 Supporting the motorcycle ...6-35 Swingarm pivots, lubricating ...6-28 checking and lubricating ...6-26 Tires ...6-15 Tool kit...6-1 Troubleshooting ...6-39 Troubleshooting chart ...6-40 E Engine break-in...5-4 Engine oil and
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 95
    INDEX Turn signal indicator light...3-1 Turn signal light bulb, replacing...6-34 Turn signal switch...3-3 V Valve clearance ...6-15 Vehicle identification number...9-1 W Warranty, extended ...9-9 Warranty, limited...9-7 Wheel bearings, checking ...6-29 Wheel (front) ...6-35 Wheel (rear)...6-37
  • 2007 Yamaha Motorsports Virago 250 | Owners Manual - Page 96
    YAMAHA MOTOR CO., LTD. PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2006.05-0.5×1 CR (E)
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
  • 93
  • 94
  • 95
  • 96
2UJ-28199-1F
XV250W1(C)
OWNER’S MANUAL
LIT-11626-20-26