2013 Yamaha Motorsports V Star 650 Custom Owners Manual
2013 Yamaha Motorsports V Star 650 Custom Manual
2013 Yamaha Motorsports V Star 650 Custom manual content summary:
- 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 1
Read this manual carefully before operating this vehicle. OWNER'S MANUAL XVS65D(C) LIT-11626-26-19 1BF-28199-12 - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 2
EAU10042 Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold. - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 3
Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. Yamaha continually seeks advancements in product design and quality. Therefore, while this manual contains the most current product information available at the time of - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 4
INFORMATION EAU10133 Particularly important information is distinguished in this manual by the following notations: This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 5
INFORMATION EAU10193 XVS65D(C) OWNER'S MANUAL ©2012 by Yamaha Motor Corporation, U.S.A. 1st edition, April 2012 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A. - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 6
TABLE OF CONTENTS LOCATION OF IMPORTANT LABELS ...1-1 SAFETY INFORMATION ...2-1 DESCRIPTION ...3-1 Left view ...3-1 Right view ...3-2 Controls and instruments...3-3 INSTRUMENT AND CONTROL FUNCTIONS ...4-1 Main switch/steering lock ...4-1 Indicator lights and warning light ...4-2 Speedometer unit - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 7
tail/brake light bulb ...7-33 Supporting the motorcycle ...7-34 Front wheel ...7-34 Rear wheel ...7-36 Troubleshooting ...7-38 Troubleshooting chart ...7-39 MOTORCYCLE CARE AND STORAGE CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...10-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...10-9 - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 8
LOCATION OF IMPORTANT LABELS EAU10384 1 Read and understand all of the labels on your vehicle. They contain important information for safe and proper operation of your vehicle. Never remove any labels from your vehicle. If a label becomes difficult to read or comes off, a replacement label is - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 9
LOCATION OF IMPORTANT LABELS 1 4 1 A1 2 TIRE INFORMATION Cold tire normal pressure should be set as follows. • Up to 90 kg (198 lbs) load FRONT : 200 kPa, (2.00 kgf/cm²), 29 psi REAR : 225 kPa, (2.25 kgf/cm²), 33 psi • 90kg (198 lbs) ~ maximum load FRONT : 200 kPa, (2.00 kgf/cm²), 29 psi REAR : 250 - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 10
in safe and proper riding techniques. ● Obtain professional technical service as indicated in this Owner's Manual and/or when made necessary by mechanical conditions. Never operate a motorcycle without proper training or instruction. Take a training course. Beginners should receive training from - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 11
SAFETY INFORMATION ● ● Many accidents involve inexperienced operators. In fact, many operators who have been involved in accidents do not even have a current motorcycle license. • Make sure that you are qualified and that you only lend your motorcycle to other qualified operators. • Know your - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 12
SAFETY INFORMATION Avoid Carbon Monoxide Poisoning All engine exhaust contains carbon monoxide, a deadly gas. Breathing carbon monoxide can cause headaches, dizziness, drowsiness, nausea, confusion, and eventually death. Carbon Monoxide is a colorless, odorless, tasteless gas which may be present - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 13
SAFETY INFORMATION tents, can create unstable handling or a slow steering response. This vehicle is not designed to pull a trailer or to be attached to a sidecar. Aftermarket Parts, Accessories, and Modifications While you may find aftermarket products similar in design and quality to genuine Yamaha - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 14
● Transporting the Motorcycle Be sure to observe following instructions before transporting the motorcycle in another vehicle. ● to prevent movement. Shift the transmission in gear (for models with a manual transmission). Secure the motorcycle with tiedowns or suitable straps that are attached - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 15
DESCRIPTION EAU10410 Left view 3 4 5 3 2 1 6,7 1. 2. 3. 4. 5. 6. 7. Shift pedal (page 4-5) Fuel cock (page 4-8) Starter (choke) knob (page 4-9) Shock absorber assembly spring preload adjusting ring (page 4-12) Helmet holder (page 4-11) Owner's tool kit (page 7-2) Storage compartment (page 4-11) - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 16
DESCRIPTION EAU10420 Right view 3 4 2,3 1 5 6 1. 2. 3. 4. 5. 6. Engine oil filter element (page 7-12) Battery (page 7-29) Fuses (page 7-31) Main switch/steering lock (page 4-1) Air filter element (page 7-15) Brake pedal (page 4-5) 3-2 - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 17
DESCRIPTION EAU10430 Controls and instruments 3 1. 2. 3. 4. 5. 6. 7. Clutch lever (page 4-4) Left handlebar switches (page 4-3) Speedometer unit (page 4-3) Fuel tank cap (page 4-6) Right handlebar switches (page 4-3) Throttle grip (page 7-17) Brake lever (page 4-5) 3-3 - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 18
INSTRUMENT AND CONTROL FUNCTIONS EAU10461 EAU10661 Main switch/steering lock OFF All electrical systems are off. The key can be removed. EWA10061 To lock the steering 1 2 WARNING Never turn the key to "OFF" or "LOCK" while the vehicle is moving. Otherwise the electrical systems will be - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 19
" " This indicator light flashes when the turn signal switch is pushed to the left or right. EAU11060 Engine trouble warning light " " This warning light comes on or flashes if a problem is detected in the electrical circuit monitoring the engine. If this occurs, have a Yamaha dealer check the self - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 20
to plan future fuel stops. This model is equipped with a self-diagnosis device for various electrical circuits. If a problem is detected in any of those circuits, the engine trouble warning light will come on or flash. If this occurs, have a Yamaha dealer check the vehicle. ECA11170 Right NOTICE - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 21
15 seconds. However, the turn signal lights can also be canceled manually by pushing the switch in after it has returned to the center position switch to crank the engine with the starter. See page 6-1 for starting instructions prior to starting the engine. 1. Clutch lever The clutch lever is - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 22
INSTRUMENT AND CONTROL FUNCTIONS EAU12871 EAU12891 EAU12941 Shift pedal Brake lever Brake pedal 4 1. Shift pedal 2. Neutral position 1. Brake lever 1. Brake pedal The shift pedal is located on the left side of the motorcycle and is used in combination with the clutch lever when shifting the - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 23
WARNING Gasoline and gasoline vapors are extremely flammable. To avoid fires and explosions and to reduce the risk of injury when refueling, follow these instructions. 1. Before refueling, turn off the engine and be sure that no one is sitting on the vehicle. Never refuel while smoking, or while in - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 24
exceed 10% (E10). Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. NOTICE Use only unleaded gasoline. The use of leaded gasoline will cause severe damage to internal engine parts, such as the valves and piston - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 25
INSTRUMENT AND CONTROL FUNCTIONS EAU13445 ECA10701 EAU13550 Catalytic converters This vehicle is equipped with catalytic converters in the exhaust system. EWA10862 NOTICE Use only unleaded gasoline. The use of leaded gasoline will cause unrepairable damage to the catalytic converter. Fuel cock - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 26
INSTRUMENT AND CONTROL FUNCTIONS ON This indicates reserve. With the fuel cock lever in this position, the fuel reserve is made available. Turn the fuel cock lever to this position if you run out of fuel while riding. When this occurs, refuel as soon as possible and be sure to turn the fuel cock - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 27
INSTRUMENT AND CONTROL FUNCTIONS EAU14185 Seats Passenger seat To remove the passenger seat Remove the nut and washer, and then pull the passenger seat up. Tightening torque: Passenger seat nut: 13 Nm (1.3 m·kgf, 9.4 ft·lbf) 1. Bolt 2. Seat holder 4 1. Seat holder 2. Projection Rider seat 1. - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 28
INSTRUMENT AND CONTROL FUNCTIONS 2. Install the seat holder by installing its bolts. 3. Install the passenger seat. TIP Make sure that the seats are properly secured before riding. EAU14282 EAU14481 Helmet holder Storage compartment The storage compartment is located on the left side of the - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 29
INSTRUMENT AND CONTROL FUNCTIONS EAU14865 Adjusting the shock absorber assembly This shock absorber assembly is equipped with a spring preload adjusting ring. ECA10101 ● Use the special wrench and extension bar included in the owner's tool kit to make the adjustment. NOTICE To avoid damaging the - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 30
performance. ● Do not dispose of a damaged or worn-out shock absorber assembly yourself. Take the shock absorber assembly to a Yamaha dealer for any service. Luggage strap holders Sidestand The sidestand is located on the left side of the frame. Raise the sidestand or lower it with your foot while - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 31
INSTRUMENT AND CONTROL FUNCTIONS this system regularly and have a Yamaha dealer repair it if it does not function properly. EAU15314 Ignition circuit cut-off system The ignition circuit cut-off system (comprising the sidestand switch, clutch switch and neutral switch) has the following functions. ● - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 32
INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is set to " 3. Turn the key on. 4. Shift the transmission into the neutral position. 5. Push the start switch. Does the engine start? WARNING ". If a malfunction is - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 33
inspection and maintenance procedures and schedules described in the Owner's Manual. EWA11151 WARNING Failure to inspect or maintain the vehicle operate the vehicle if you find any problem. If a problem cannot be corrected by the procedures provided in this manual, have the vehicle inspected by a - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 34
FOR YOUR SAFETY - PRE-OPERATION CHECKS ITEM Check operation. Lubricate cable if necessary. Check lever free play. Adjust if necessary. CHECKS PAGE Clutch 7-20 Throttle grip • Make sure that operation is smooth. • Check throttle grip free play. • If necessary, have Yamaha dealer adjust throttle - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 35
OPERATION AND IMPORTANT RIDING POINTS EAU15951 EAU15999 Read the Owner's Manual carefully to become familiar with all controls. If there is a control or function you do not understand, ask your Yamaha dealer. EWA10271 Starting and warming - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 36
OPERATION AND IMPORTANT RIDING POINTS ECA11042 EAU16640 EAU16671 NOTICE For maximum engine life, never accelerate hard when the engine is cold! Starting a warm engine Follow the same procedure as for starting a cold engine with the exception that the starter (choke) is not required when the engine - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 37
OPERATION AND IMPORTANT RIDING POINTS ECA10260 NOTICE ● ● Even with the transmission in the neutral position, do not coast for long periods of time with the engine off, and do not tow the motorcycle for long distances. The transmission is properly lubricated only when the engine is running. - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 38
the engine, remove the key from the main switch, and then turn the fuel cock lever to "OFF". EWA10311 WARNING ● NOTICE If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. ● 6 ● Since the engine and exhaust system can become - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 39
periodic maintenance charts should be simply considered as a general guide under normal riding conditions. However, depending on the weather electrical parts that can cause shocks or fires. ● Running the engine while servicing can lead to eye injury, burns, fire, or carbon monoxide poisoning - - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 40
Owner's tool kit 1. Owner's tool kit 7 The owner's tool kit is located inside the storage compartment. (See page 4-11.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and minor - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 41
8000 mi (13000 km) or 12 months. Items marked with an asterisk require special tools, data and technical skills, have a Yamaha dealer perform the service. EAU17601 Periodic maintenance chart for the emission control system INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 42
PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months √ √ ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 7 * Idle speed • Check - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 43
PERIODIC MAINTENANCE AND ADJUSTMENT EAU32187 General maintenance and lubrication chart INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 44
PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months √ ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 8 * Wheel bearings • - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 45
PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month √ 4000 mi (7000 km) or 6 months √ √ ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 17 * Sidestand switch - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 46
24 months 30 months EAU17620 26 * Lights, signals and switches • Check operation. • Adjust headlight beam. TIP ● ● The air filter needs more frequent service if you are riding in unusually wet or dusty areas. Hydraulic brake system • When disassembling the master cylinder or caliper cylinder - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 47
PERIODIC MAINTENANCE AND ADJUSTMENT EAU18771 Removing and installing panels The panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a panel needs to be removed and installed. 1. Panel B EAU19193 To install the panel - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 48
the same color. TIP If any spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 1. Spark plug cap 2. Remove the spark plug as shown, with the spark plug wrench - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 49
PERIODIC MAINTENANCE AND ADJUSTMENT 3. Check each spark plug for electrode erosion and excessive carbon or other deposits, and replace it if necessary. Specified spark plug: NGK/DPR7EA-9 DENSO/X22EPR-U9 To install a spark plug 1. Clean the surface of the spark plug gasket and its mating surface, - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 50
PERIODIC MAINTENANCE AND ADJUSTMENT EAU19747 Engine oil and oil filter element The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil filter element replaced at the intervals specified in the periodic maintenance and lubrication chart. To check the - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 51
PERIODIC MAINTENANCE AND ADJUSTMENT Tightening torque: Engine oil drain bolt: 43 Nm (4.3 m·kgf, 31 ft·lbf) 9. Refill with the specified amount of the recommended oil, and then install and tighten the oil filler cap. Recommended engine oil: See page 9-1. Oil quantity: Without oil filter element - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 52
PERIODIC MAINTENANCE AND ADJUSTMENT er quality than specified. In addition, do not use oils labeled "ENERGY CONSERVING II" or higher. Make sure that no foreign material enters the crankcase. EAU20026 Final gear oil The final gear case must be checked for oil leakage before each ride. If any leakage - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 53
PERIODIC MAINTENANCE AND ADJUSTMENT EAU33383 Tightening torque: Final gear oil filler bolt: 23 Nm (2.3 m·kgf, 17 ft·lbf) Tightening torque: Final gear oil drain bolt: 23 Nm (2.3 m·kgf, 17 ft·lbf) Cleaning the air filter element The air filter element should be cleaned at the intervals specified - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 54
PERIODIC MAINTENANCE AND ADJUSTMENT 1 TIP If dust or water collects in the air filter check hose, remove the clamp from it, and then remove the plug to drain the hose. 2 1. Air filter element 3 7 4. Insert the air filter element into the air filter case as shown. NOTICE: Make sure that the air - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 55
PERIODIC MAINTENANCE AND ADJUSTMENT EAU21271 EAU44734 EAU21384 Carburetors The carburetors are important parts of the engine and emission control system, which require very sophisticated adjustment. Therefore, all carburetor adjustments should be left to a Yamaha dealer, who has the necessary - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 56
PERIODIC MAINTENANCE AND ADJUSTMENT EAU21401 EAU32525 Valve clearance The valve clearance changes with use, resulting in improper air-fuel mixture and/or engine noise. To prevent this from occurring, the valve clearance must be adjusted by a Yamaha dealer at the intervals specified in the periodic - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 57
PERIODIC MAINTENANCE AND ADJUSTMENT Tire inspection WARNING ● EWA10562 ● 1. Tire sidewall 2. Tire wear indicator 3. Tire tread depth Always check the tires before operating the motorcycle. If a tire tread shows crosswise lines (minimum tread depth), if the tire has a nail or glass fragments in it - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 58
PERIODIC MAINTENANCE AND ADJUSTMENT EAU21943 EAU22043 Front tire: Size: 100/90-19M/C 57S Manufacturer/model: BRIDGESTONE/EXEDRA L309 DUNLOP/F24 Rear tire: Size: 170/80-15M/C 77S Manufacturer/model: BRIDGESTONE/EXEDRA G546 DUNLOP/K555 Spoke wheels EWA10610 WARNING The wheels on this model are not - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 59
PERIODIC MAINTENANCE AND ADJUSTMENT 3. To increase the clutch lever free play, turn the adjusting bolt in direction (a). To decrease the clutch lever free play, turn the adjusting bolt in direction (b). TIP If the specified clutch lever free play could be obtained as described above, skip steps 4-7. - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 60
PERIODIC MAINTENANCE AND ADJUSTMENT ● 1. Locknut 2. Brake lever free play adjusting screw A soft or spongy feeling in the brake lever can indicate the presence of air in the hydraulic system. If there is air in the hydraulic system, have a Yamaha dealer bleed the system before operating the - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 61
PERIODIC MAINTENANCE AND ADJUSTMENT Brake pedal height The brake pedal should be positioned approximately 82.0 mm (3.23 in) above the top of the footrest as shown. Periodically check the brake pedal height and, if necessary, adjust it as follows. 1. Loosen the locknut at the brake pedal. 2. To raise - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 62
PERIODIC MAINTENANCE AND ADJUSTMENT EAU22380 Checking the front brake pads and rear brake shoes The front brake pads and the rear brake shoes must be checked for wear at the intervals specified in the periodic maintenance and lubrication chart. EAU22430 indicator grooves have almost disappeared, - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 63
PERIODIC MAINTENANCE AND ADJUSTMENT ● ● ● ● ● Insufficient brake fluid may allow air to enter the brake system, reducing braking performance. Clean the filler cap before removing. Use only DOT 4 brake fluid from a sealed container. Use only the specified brake fluid; otherwise, the rubber seals - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 64
PERIODIC MAINTENANCE AND ADJUSTMENT EAU23095 EAU49920 EAU44273 Checking and lubricating the cables The operation of all control cables and the condition of the cables should be checked before each ride, and the cables and cable ends should be lubricated if necessary. If a cable is damaged or does - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 65
PERIODIC MAINTENANCE AND ADJUSTMENT EAU23143 EAU23202 Checking and lubricating the brake and clutch levers The operation of the brake and clutch levers should be checked before each ride, and the lever pivots should be lubricated if necessary. Brake lever Recommended lubricants: Brake lever: - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 66
. ECA10590 7 To check the operation 1. Place the vehicle on a level surface and hold it in an upright position. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over. [EWA10751] 2. While applying the front brake, push down hard on the handlebars several - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 67
chart. 1. Place a stand under the engine to raise the front wheel off the ground. (See page 7-34 for more information.) WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over. [EWA10751] 2. Hold the lower ends of the front fork legs and try to move - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 68
PERIODIC MAINTENANCE AND ADJUSTMENT ways shield your eyes when working near batteries. In case of contact, administer the following FIRST AID. • EXTERNAL: Flush with plenty of water. • INTERNAL: Drink large quantities of water or milk and immediately call a physician. • EYES: Flush with water for 15 - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 69
PERIODIC MAINTENANCE AND ADJUSTMENT EAU23526 Replacing the fuses avoid causing extensive damage to the electrical system and possibly a fire. [EWA15131] 1. Fuse box 2. Main fuse 3. Spare main fuse Specified fuses: Main fuse: 30.0 A Signaling system fuse: 10.0 A Ignition fuse: 10.0 A Headlight - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 70
PERIODIC MAINTENANCE AND ADJUSTMENT EAU23798 Replacing the headlight bulb This model is equipped with a halogen bulb headlight. If the headlight bulb burns out, replace it as follows. ECA10650 NOTICE Take care not to damage the following parts: ● Headlight bulb Do not touch the glass part of the - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 71
PERIODIC MAINTENANCE AND ADJUSTMENT 5. Install the bulb cover, and then connect the coupler. 6. Install the headlight unit by installing the screws. 7. Have a Yamaha dealer adjust the headlight beam if necessary. EAU24283 Replacing a turn signal light bulb or the tail/brake light bulb 1. Remove the - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 72
. 2. Raise the front wheel off the ground by using a motorcycle stand. To service the rear wheel Raise the rear wheel off the ground by using a motorcycle stand or To remove the front wheel EWA10821 WARNING To avoid injury, securely support the vehicle so there is no danger of it falling over. - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 73
wheel axle pinch bolt: 20 Nm (2.0 m·kgf, 14 ft·lbf) 3. Lift the front wheel off the ground according to the procedure in the previous section "Supporting the motorcycle". 4. Pull the wheel axle out, and then remove the wheel. NOTICE: Do not apply the brake after the wheel has been removed together - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 74
bolts that secure the final gear case to the swingarm. 7. Lift the rear wheel off the ground according to the procedure on page 7-34. 8. While supporting the drive shaft, pull the rear wheel back to remove the following parts as an assembly: wheel, wheel axle, final gear case, and drive shaft - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 75
free play, check the operation of the brake light. TIP Make sure to support the drive shaft as it is being pulled out. EAU25512 To install the axle, final gear case, and drive shaft by pushing the wheel forward and guiding the drive shaft into the middle gear universal joint. 2. Install the final - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 76
trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause poor starting and loss of power. The following troubleshooting parts, but they are often inferior, have a shorter service life and can lead to expensive repair bills. EWA15141 - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 77
PERIODIC MAINTENANCE AND ADJUSTMENT EAU25893 Troubleshooting chart 1. Fuel There is enough fuel. Check the fuel level in the fuel tank. There is no fuel. Supply fuel. Check the compression. The engine - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 78
spoked wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. Improper cleaning can damage plastic parts (such - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 79
MOTORCYCLE CARE AND STORAGE off any detergent residue using plenty of water, as it is harmful to plastic parts. Do not use any harsh chemical products on plastic parts. Be sure to avoid using cloths or sponges which have been in contact with strong or abrasive cleaning products, solvent or thinner, - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 80
(because of the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your motorcycle for several months: 1. Follow all the instructions in the "Care" section of this chapter. 8-3 - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 81
MOTORCYCLE CARE AND STORAGE 2. For motorcycles equipped with a fuel cock that has an "OFF" position: Turn the fuel cock lever to "OFF". 3. Drain the carburetor float chambers by loosening the drain bolts; this will prevent fuel deposits from building up. Pour the drained fuel into the fuel tank. 4. - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 82
81.0 × 63.0 mm (3.19 × 2.48 in) Compression ratio: 9.00 : 1 Starting system: Electric starter Lubrication system: Wet sump Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter element replacement: 2.60 L (2.75 US qt, 2.29 Imp.qt) With - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 83
SPECIFICATIONS Gear ratio: 1st: 2.714 (38/14) 2nd: 1.900 (38/20) 3rd: 1.458 (35/24) 4th: 1.167 (28/24) 5th: 0.967 (29/30) Manufacturer/model: DUNLOP/K555 Front brake: Type: Single disc brake Operation: Right hand operation Specified brake fluid: DOT 4 Loading: Maximum load: XVS65D 180 kg (397 lb) - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 84
12 V, 1.7 W × 1 Neutral indicator light: 12 V, 1.7 W × 1 High beam indicator light: 12 V, 1.7 W × 1 Turn signal indicator light: 12 V, 1.7 W × 1 Engine trouble warning light: 12 V, 1.7 W × 1 Fuses: 9 Main fuse: 30.0 A Headlight fuse: 15.0 A Signaling system fuse: 10.0 A Ignition fuse: 10.0 A 9-3 - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 85
CONSUMER INFORMATION EAU26353 EAU26381 EAU26400 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 86
CONSUMER INFORMATION EAU26470 EAU48061 Model label Vehicle Emission Control Information label 1. Model label 1 1. Vehicle Emission Control Information label The model label is affixed to the frame under the rider seat. (See page 4-10.) Record the information on this label in the space provided. - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 87
that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327 - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 88
CONSUMER INFORMATION EAU26560 Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 89
months 24000 mi (37000 km) or 36 months 28000 mi (43000 km) or 42 months 32000 mi (49000 km) or 48 months 10-5 Date of service Mileage Servicing dealer name and address Remarks 10 - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 90
CONSUMER INFORMATION Maintenance interval 36000 mi (55000 km) or 54 months 40000 mi (61000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 10 10-6 - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 91
1. Operate and maintain the motorcycle as specified in the appropriate Owner's Manual, and 2. Give notice to an authorized Yamaha motorcycle dealer of any . An inspection and registration fee will be charged for this service. EMISSION CONTROL SYSTEM WARRANTY: Yamaha Motor Corporation, U.S.A. also - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 92
in the Owner's and Service Manual. We do recommend, however service, you must take it to any authorized Yamaha motorcycle dealer within the continental United States. Be sure to bring your warranty registration card or other valid proof of the original date of purchase. If a question or problem - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 93
no extra cost. TRIP gives you up to $250 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 94
isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 10 10-10 - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 95
...4-11 Supporting the motorcycle Troubleshooting chart ...7-39 Turn signal indicator light ...4-2 D Dimmer switch ...4-4 E Engine break-in ...6-4 Engine idling speed, checking ...7-17 Engine oil and oil filter element...7-12 Engine, starting a warm...6-2 Engine stop switch...4-4 Engine trouble - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 96
INDEX Turn signal light bulb or tail/ brake light bulb, replacing...7-33 Turn signal switch ...4-4 V Valve clearance ...7-18 Vehicle Emission Control Information label ...10-2 Vehicle identification number ...10-1 W Warranty, extended...10-9 Warranty, limited ...10-7 Wheel bearings, checking...7- - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 97
Yamaha engineering teams that know your Yamaha from the inside out. Genuine Yamaha Service Manuals - Get the same factory manual for your vehicle that the technicians at your authorized Yamaha dealer use. Service manuals are available through your Yamaha dealer or you can order them directly through - 2013 Yamaha Motorsports V Star 650 Custom | Owners Manual - Page 98
PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2012.05-0.7×1 CR (E)
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
 |
 |
1BF-28199-12
XVS65D(C)
OWNER’S MANUAL
Read this manual carefully before operating this vehicle.
LIT-11626-26-19