2013 Yamaha Motorsports Road Star S Owners Manual
2013 Yamaha Motorsports Road Star S Manual
2013 Yamaha Motorsports Road Star S manual content summary:
- 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 1
Read this manual carefully before operating this vehicle. OWNER'S MANUAL XV17ASD(C) XV17ATSD(C) LIT-11626-26-24 1BH-28199-13 - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 2
EAU10042 Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold. - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 3
Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. Yamaha continually seeks advancements in product design and quality. Therefore, while this manual contains the most current product information available at the time of - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 4
INFORMATION EAU10133 Particularly important information is distinguished in this manual by the following notations: This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 5
INFORMATION EAU10193 XV17ASD(C)/XV17ATSD(C) OWNER'S MANUAL ©2012 by Yamaha Motor Corporation, U.S.A. 1st edition, May 2012 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A. - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 6
TABLE OF CONTENTS LOCATION OF IMPORTANT LABELS ...1-1 SAFETY INFORMATION ...2-1 DESCRIPTION ...3-1 Left view ...3-1 Right view ...3-3 Controls and instruments...3-5 INSTRUMENT AND CONTROL FUNCTIONS ...4-1 Main switch/steering lock ...4-1 Indicator lights and warning lights ...4-2 Multi-function - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 7
35 Replacing a license plate light bulb ...7-35 Supporting the motorcycle ...7-36 Troubleshooting ...7-37 Troubleshooting chart ...7-38 MOTORCYCLE CARE AND STORAGE ...8-1 Matte MOTOR CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...10-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...10-9 - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 8
LOCATION OF IMPORTANT LABELS EAU10384 1 Read and understand all of the labels on your vehicle. They contain important information for safe and proper operation of your vehicle. Never remove any labels from your vehicle. If a label becomes difficult to read or comes off, a replacement label is - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 9
• 2C5-F815K-00 6 WARNING INTAKE MANIFOLD 34B-21684-00 This unit contains high pressure nitrogen gas. Mishandling can cause explosion. Read owner's manual for instructions. Do not incinerate, puncture or open. 4AA-22259-80 3 California only EMISSION HOSE ROUTING FUEL TANK THROTTLE BODY 7 XV17ATSD - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 10
in safe and proper riding techniques. ● Obtain professional technical service as indicated in this Owner's Manual and/or when made necessary by mechanical conditions. Never operate a motorcycle without proper training or instruction. Take a training course. Beginners should receive training from - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 11
SAFETY INFORMATION ● ● Many accidents involve inexperienced operators. In fact, many operators who have been involved in accidents do not even have a current motorcycle license. • Make sure that you are qualified and that you only lend your motorcycle to other qualified operators. • Know your - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 12
SAFETY INFORMATION Avoid Carbon Monoxide Poisoning All engine exhaust contains carbon monoxide, a deadly gas. Breathing carbon monoxide can cause headaches, dizziness, drowsiness, nausea, confusion, and eventually death. Carbon Monoxide is a colorless, odorless, tasteless gas which may be present - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 13
SAFETY INFORMATION • Never attach any large or heavy items to the handlebar, front fork, or front fender. These items, including such cargo as sleeping bags, duffel bags, or tents, can create unstable handling or a slow steering response. This vehicle is not designed to pull a trailer or to be - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 14
● Transporting the Motorcycle Be sure to observe following instructions before transporting the motorcycle in another vehicle. ● to prevent movement. Shift the transmission in gear (for models with a manual transmission). Secure the motorcycle with tiedowns or suitable straps that are attached - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 15
DESCRIPTION EAU32220 Left view XV17ASD(C) 1 2 3 3 5 1. 2. 3. 4. 5. Engine oil filler cap (page 7-12) Battery (page 7-30) Owner's tool kit (page 7-2) Fuse box (page 7-32) Shift pedal (page 4-8) 4 3-1 - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 16
DESCRIPTION XV17ATSD(C) 1 2 3 3 5 1. 2. 3. 4. 5. Engine oil filler cap (page 7-12) Battery (page 7-30) Owner's tool kit (page 7-2) Fuse box (page 7-32) Shift pedal (page 4-8) 4 3-2 - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 17
DESCRIPTION EAU32230 Right view XV17ASD(C) 1 2 3 3 9 1. 2. 3. 4. 5. 6. 7. Main fuse and fuel injection system fuse (page 7-32) Fuel tank (page 4-9) Fuel tank cap (page 4-9) Brake pedal (page 4-9) Rear brake light switch (page 7-22) Engine oil filter cartridge (page 7-12) Air filter element ( - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 18
DESCRIPTION XV17ATSD(C) 1 2 3 4 3 10 9 1. 2. 3. 4. 5. 6. 7. 8. 9. Main fuse and fuel injection system fuse (page 7-32) Fuel tank (page 4-9) Fuel tank cap (page 4-9) Windshield (page 4-14/4-6) Brake pedal (page 4-9) Rear brake light switch (page 7-22) Engine oil filter cartridge (page 7-12) Air - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 19
DESCRIPTION EAU32240 Controls and instruments XV17ASD(C) 3 1 1. 2. 3. 4. 5. 6. 7. Clutch lever (page 4-8) Left handlebar switches (page 4-6) Multi-function meter unit (page 4-3) Main switch/steering lock (page 4-1) Right handlebar switches (page 4-6) Throttle grip (page 7-18) Brake lever (page - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 20
DESCRIPTION XV17ATSD(C) 3 1 1. 2. 3. 4. 5. 6. 7. Clutch lever (page 4-8) Left handlebar switches (page 4-6) Multi-function meter unit (page 4-3) Main switch/steering lock (page 4-1) Right handlebar switches (page 4-6) Throttle grip (page 7-18) Brake lever (page 4-8) 2 3 4 5 6 7 3-6 - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 21
INSTRUMENT AND CONTROL FUNCTIONS EAU10461 EAU10661 Main switch/steering lock OFF All electrical systems are off. The key can be removed. EWA10061 To lock the steering 1 2 WARNING Never turn the key to "OFF" or "LOCK" while the vehicle is moving. Otherwise the electrical systems will be - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 22
" " Left turn signal indicator light " " Right turn signal indicator light " " Engine trouble warning light " " Fuel level warning light " " Push the key in, and then turn selfdiagnosis device for the fuel level detection circuit. If a problem is detected in the fuel level detection circuit, the - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 23
If this occurs, have a Yamaha dealer check the vehicle. EAU11534 EAU45683 Multi-function meter unit ● ● Engine trouble warning light " " This warning light comes on or flashes if a problem is detected in the electrical circuit monitoring the engine. If this occurs, have a Yamaha dealer check the - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 24
INSTRUMENT AND CONTROL FUNCTIONS Speedometer Fuel gauge Odometer, tripmeters and fuel reserve tripmeter 1 1 1 4 1. Speedometer 1. Fuel gauge When the key is turned to "ON", the speedometer needle will sweep once across the speed range and then return to zero in order to test the electrical - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 25
for at least one second. If you do not reset the fuel reserve tripmeter manually, it will reset itself automatically, and the display will return to the prior mode for various electrical circuits. If a problem is detected in any of those circuits, the engine trouble warning light will come on or - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 26
INSTRUMENT AND CONTROL FUNCTIONS ECA11590 NOTICE If the display indicates an error code, the vehicle should be checked as soon as possible in order to avoid engine damage. Brightness control mode 3. Turn the key to "ON", and then release the "SELECT" switch after five seconds or more. 4. Push the - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 27
seconds. However, the turn signal lights can also be canceled manually by pushing the switch in after it has returned to the engine with the starter. See page 6-1 for starting instructions prior to starting the engine. EAU41700 The engine trouble warning light will come on when the key is turned - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 28
INSTRUMENT AND CONTROL FUNCTIONS EAU12820 EAU12881 EAU12891 Clutch lever Shift pedal Brake lever 4 1. Clutch lever The clutch lever is located at the left handlebar grip. To disengage the clutch, pull the lever toward the handlebar grip. To engage the clutch, release the lever. The lever should - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 29
INSTRUMENT AND CONTROL FUNCTIONS EAU12941 EAU13122 Brake pedal Fuel tank cap 2. Turn the key counterclockwise to the original position, remove it, and then close the lock cover. TIP The fuel tank cap cannot be installed unless the key is in the lock. In addition, the key cannot be removed if the - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 30
WARNING Gasoline and gasoline vapors are extremely flammable. To avoid fires and explosions and to reduce the risk of injury when refueling, follow these instructions. 1. Before refueling, turn off the engine and be sure that no one is sitting on the vehicle. Never refuel while smoking, or while in - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 31
(E10). Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. EAU48760 EAU13445 Fuel tank breather/overflow hose Catalytic converters This vehicle is equipped with catalytic converters in the exhaust system. EWA10862 - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 32
INSTRUMENT AND CONTROL FUNCTIONS ECA10701 EAU13780 EAU14154 NOTICE Use only unleaded gasoline. The use of leaded gasoline will cause unrepairable damage to the catalytic converter. Locking the steering with a padlock Rider seat To remove the rider seat 1. Turn the key to "OFF", and then turn it - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 33
INSTRUMENT AND CONTROL FUNCTIONS EAU14324 Helmet holder To release the helmet from the helmet holder Remove the rider seat, remove the helmet from the helmet holder, and then install the seat. 1 1. Projection 2. Seat holder 1. Helmet holder 4 The helmet holder is located under the rider seat. To - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 34
INSTRUMENT AND CONTROL FUNCTIONS EAU14583 Windshield [XV17ATSD(C)] To suit the rider's preference, the windshield angle can be adjusted and the height can be changed to one of two positions. To adjust the windshield angle 1. Loosen the bolts on each side of the windshield. 4 Tightening torque: - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 35
INSTRUMENT AND CONTROL FUNCTIONS ● Open the throttle and make sure that the throttle grip returns properly when released, otherwise an accident or injury could result. EAU35890 Sidecases [XV17ATSD(C)] EWA12520 WARNING Improper loading or overloading can cause loss of control and possibly an - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 36
INSTRUMENT AND CONTROL FUNCTIONS To close a sidecase 1. Fold the sidecase lid down. 2. Turn the key clockwise, and then remove it. TIP Push the lid down so that the latch snaps into place. ECA13090 EAU14817 Adjusting the shock absorber assembly This shock absorber assembly is equipped with a spring - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 37
not dispose of a damaged or worn-out shock absorber assembly yourself. Take the shock absorber assembly to a Yamaha dealer for any service. 4-17 1. Distance A 4 Spring preload: Minimum (soft): Distance A = 42.5 mm (1.67 in) Standard: XV17ASD(C) Distance A = 42.5 mm (1.67 in) XV17ATSD(C) Distance - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 38
INSTRUMENT AND CONTROL FUNCTIONS this system regularly and have a Yamaha dealer repair it if it does not function properly. EAU44892 Ignition circuit cut-off system The ignition circuit cut-off system (comprising the sidestand switch, clutch switch and neutral switch) has the following functions. ● - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 39
INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is set to " 3. Turn the key on. 4. Shift the transmission into the neutral position. 5. Push the start switch. Does the engine start? WARNING ". If a malfunction is - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 40
INSTRUMENT AND CONTROL FUNCTIONS EAU45693 Auxiliary DC connector ECA15311 NOTICE The accessory connected to the auxiliary DC connector should not be used with the engine turned off, and the load must never exceed 36 W (3 A), otherwise the fuse may blow or the battery may discharge. 4 WARNING To - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 41
the possibility of an accident or equipment damage. Do not operate the vehicle if you find any problem. If a problem cannot be corrected by the procedures provided in this manual, have the vehicle inspected by a Yamaha dealer. Before using this vehicle, check the following points: ITEM CHECKS - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 42
FOR YOUR SAFETY - PRE-OPERATION CHECKS ITEM CHECKS Check operation. If soft or spongy, have Yamaha dealer bleed hydraulic system. Check brake pads for wear. Replace if necessary. Check fluid level in reservoir. If necessary, add specified brake fluid to specified level. Check hydraulic system for - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 43
FOR YOUR SAFETY - PRE-OPERATION CHECKS ITEM Sidestand switch CHECKS • Check operation of ignition circuit cut-off system. • If system is not working correctly, have Yamaha dealer check vehicle. PAGE 4-17 5 5-3 - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 44
EAU47150 EAU16247 Starting the engine Read the Owner's Manual carefully to become familiar with all controls. If should come on for a few seconds, then go off. ● Fuel level warning light ● Engine trouble warning light ECA15484 NOTICE If a warning light does not come on initially when the key is - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 45
OPERATION AND IMPORTANT RIDING POINTS 2. Shift the transmission into the neutral position. The neutral indicator light should come on. If not, ask a Yamaha dealer to check the electrical circuit. 3. Start the engine by pushing the start switch. If the engine fails to start, release the start switch, - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 46
OPERATION AND IMPORTANT RIDING POINTS 4. At the recommended shift points shown in the following table, close the throttle, and at the same time, quickly pull the clutch lever in. 5. Shift the transmission into second gear. (Make sure not to shift the transmission into the neutral position.) 6. Open - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 47
ECA10270 EAU17213 Parking When parking, stop the engine, and then remove the key from the main switch. EWA10311 WARNING ● NOTICE If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. ● ● Since the engine and exhaust system can - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 48
periodic maintenance charts should be simply considered as a general guide under normal riding conditions. However, depending on the weather electrical parts that can cause shocks or fires. ● Running the engine while servicing can lead to eye injury, burns, fire, or carbon monoxide poisoning - - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 49
EAU17361 Owner's tool kit 1 1. Owner's tool kit The owner's tool kit is located under the rider seat. (See page 4-12.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and minor - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 50
8000 mi (13000 km) or 12 months. Items marked with an asterisk require special tools, data and technical skills, have a Yamaha dealer perform the service. EAU17601 Periodic maintenance chart for the emission control system INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 51
PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months √ √ 6 * Evaporative emission - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 52
PERIODIC MAINTENANCE AND ADJUSTMENT EAU32187 General maintenance and lubrication chart INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 53
PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 9 * Swingarm pivot bearings • - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 54
PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month √ 4000 mi (7000 km) or 6 months √ √ ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 18 * Sidestand switch - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 55
28 * Lights, signals and switches √ √ √ √ √ EAU17630 TIP ● ● The air filter needs more frequent service if you are riding in unusually wet or dusty areas. Hydraulic brake service • After disassembling the brake master cylinders and calipers, always change the fluid. Regularly check the brake - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 56
PERIODIC MAINTENANCE AND ADJUSTMENT EAU18771 Removing and installing panels The panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a panel needs to be removed and installed. 1 2. Remove the bolts, and then take the - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 57
the same color. TIP If any spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 7 1. Spark plug cap 2. Remove the spark plug as shown, with the spark plug wrench - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 58
PERIODIC MAINTENANCE AND ADJUSTMENT 3. Check each spark plug for electrode erosion and excessive carbon or other deposits, and replace it if necessary. Specified spark plug: NGK/DPR7EA-9 DENSO/X22EPR-U9 To install a spark plug 1. Clean the surface of the spark plug gasket and its mating surface, - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 59
, but this is not a malfunction. Simply turn the main switch to "OFF", and then back to "ON" to restart the engine and reset the engine trouble warning light. 4. Wait a few minutes until the oil settles, remove the engine oil filler cap, wipe the engine oil dipstick clean, insert it back into - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 60
PERIODIC MAINTENANCE AND ADJUSTMENT ECA10900 NOTICE Make sure that the oil filler cap is securely tightened, otherwise oil may seep out when the engine is running. To change the engine oil (with or without oil filter cartridge replacement) 1. Remove the rider seat. (See page 4-12.) 2. Start the - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 61
PERIODIC MAINTENANCE AND ADJUSTMENT through the filler hole, insert the dipstick, and then tighten the oil filler cap. 12. Start the engine, rev it several times, and then turn it off. 13. Remove the oil filler cap, and then gradually fill the oil tank with the remaining oil quantity while regularly - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 62
PERIODIC MAINTENANCE AND ADJUSTMENT mix any chemical additives. Do not use oils with a diesel specification of "CD" or oils of a higher quality than specified. In addition, do not use oils labeled "ENERGY CONSERVING II" or higher. Make sure that no foreign material enters the crankcase. EAU20046 - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 63
PERIODIC MAINTENANCE AND ADJUSTMENT To change the transfer case oil 1. Place an oil pan under the transfer case to collect the used oil. 2. Remove the transfer case oil drain bolt, the oil level check bolt and their gasket to drain the oil from the transfer case. 5. Install the oil level check bolt - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 64
PERIODIC MAINTENANCE AND ADJUSTMENT 5. Remove the air filter element by removing the screws, and then disconnect the hose shown. 2 1. Bolt 2. Air filter case 1 3 1. Air filter element 2. Screw 3. Hose 3. Disconnect the hose. 4. Remove the air filter case cover by removing the screws. 7. Install - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 65
PERIODIC MAINTENANCE AND ADJUSTMENT EAU21384 EAU21401 1 Checking the throttle grip free play Valve clearance The valve clearance changes with use, resulting in improper air-fuel mixture and/or engine noise. To prevent this from occurring, the valve clearance must be adjusted by a Yamaha dealer at - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 66
PERIODIC MAINTENANCE AND ADJUSTMENT EAU42715 Tires Tires are the only contact between the vehicle and the road. Safety in all conditions of riding depends on a relatively small area of road contact. Therefore, it is essential to maintain the tires in good condition at all times and replace them at - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 67
PERIODIC MAINTENANCE AND ADJUSTMENT EWA10581 WARNING ● ● ● It is dangerous to ride with a worn-out tire. When a tire tread begins to show crosswise lines, have a Yamaha dealer replace the tire immediately. The replacement of all wheeland brake-related parts, including the tires, should be left - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 68
PERIODIC MAINTENANCE AND ADJUSTMENT EAU51700 Adjusting the clutch lever free play The clutch lever free play should measure 10.0-15.0 mm (0.39-0.59 in) as shown. Periodically check the clutch lever free play and, if necessary, adjust it as follows. 1. Slide the rubber cover back at the clutch lever - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 69
PERIODIC MAINTENANCE AND ADJUSTMENT EAU22093 Adjusting the brake lever free play 3 3. Tighten the locknut. EWA10630 EAU22273 Brake light switches WARNING ● ● 1. Locknut 2. Brake lever free play adjusting screw 3. Brake lever free play The brake lever free play should measure 2.0-5.0 mm (0.08 - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 70
PERIODIC MAINTENANCE AND ADJUSTMENT EAU22392 Checking the front and rear brake pads The front and rear brake pads must be checked for wear at the intervals specified in the periodic maintenance and lubrication chart. EAU36890 the point that a wear indicator almost touches the brake disc, have a - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 71
PERIODIC MAINTENANCE AND ADJUSTMENT Rear brake ● 1 1 ● ● 1. Minimum level mark Specified brake fluid: DOT 4 EWA15990 Use only the specified brake fluid; otherwise, the rubber seals may deteriorate, causing leakage. Refill with the same type of brake fluid. Adding a brake fluid other than DOT 4 - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 72
PERIODIC MAINTENANCE AND ADJUSTMENT EAU22731 EAU23040 Changing the brake fluid Have a Yamaha dealer change the brake fluid at the intervals specified in the TIP after the periodic maintenance and lubrication chart. In addition, have the oil seals of the master cylinders and calipers as well as the - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 73
PERIODIC MAINTENANCE AND ADJUSTMENT 5. If the drive belt slack is incorrect, have a Yamaha dealer adjust it. EAU23095 EAU49920 Checking and lubricating the cables The operation of all control cables and the condition of the cables should be checked before each ride, and the cables and cable ends - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 74
PERIODIC MAINTENANCE AND ADJUSTMENT EAU44273 EAU23143 Checking and lubricating the brake and shift pedals The operation of the brake and shift pedals should be checked before each ride, and the pedal pivots should be lubricated if necessary. Brake pedal Recommended lubricant: Lithium-soap-based - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 75
PERIODIC MAINTENANCE AND ADJUSTMENT EAU23202 EAU23251 Recommended lubricants: Brake lever: Silicone grease Clutch lever: Lithium-soap-based grease Checking and lubricating the sidestand Lubricating the rear suspension The operation of the sidestand should be checked before each ride, and the - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 76
. ECA10590 7 To check the operation 1. Place the vehicle on a level surface and hold it in an upright position. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over. [EWA10751] 2. While applying the front brake, push down hard on the handlebars several - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 77
chart. 1. Place a stand under the engine to raise the front wheel off the ground. (See page 7-36 for more information.) WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over. [EWA10751] 2. Hold the lower ends of the front fork legs and try to move - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 78
PERIODIC MAINTENANCE AND ADJUSTMENT skin, eyes or clothing and always shield your eyes when working near batteries. In case of contact, administer the following FIRST AID. • EXTERNAL: Flush with plenty of water. • INTERNAL: Drink large quantities of water or milk and immediately call a physician. • - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 79
PERIODIC MAINTENANCE AND ADJUSTMENT EAU45661 Replacing the fuses The main fuse and fuel injection system fuse are located in the starter relay case behind panel B. (See page 7-9.) To access the fuses, remove the quick fastener and push the starter relay case cover inward to unhook it from the slot, - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 80
PERIODIC MAINTENANCE AND ADJUSTMENT EAU23798 Specified fuses: Main fuse: 50.0 A Headlight fuse: 20.0 A Signaling system fuse: 15.0 A Ignition fuse: 20.0 A Fuel injection system fuse: 15.0 A Auxiliary DC connector fuse: 3.0 A Backup fuse: 3.0 A Auto-decompression fuse: 15.0 A Replacing the - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 81
PERIODIC MAINTENANCE AND ADJUSTMENT 5. Install the bulb cover, and then connect the coupler. 6. Install the headlight unit by installing the screws. 7. Have a Yamaha dealer adjust the headlight beam if necessary. EAU24181 Tail/brake light This model is equipped with an LEDtype tail/brake light. If - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 82
PERIODIC MAINTENANCE AND ADJUSTMENT EAU24213 EAU31964 Replacing a turn signal light bulb 1. Remove the turn signal light lens by removing the screws. Replacing a license plate light bulb 1. Remove the license plate light unit by removing the bolts. 1 1 1. License plate light bulb socket 3. - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 83
license plate light unit by installing the bolts. EAU24350 Supporting the motorcycle Since this model is not equipped with rear wheel. 2. Raise the front wheel off the ground by using a motorcycle stand. To service the rear wheel Raise the rear wheel off the ground by using a motorcycle stand or, if - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 84
trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause poor starting and loss of power. The following troubleshooting parts, but they are often inferior, have a shorter service life and can lead to expensive repair bills. EWA15141 - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 85
PERIODIC MAINTENANCE AND ADJUSTMENT EAU42602 Troubleshooting chart 1. Fuel There is enough fuel. Check the fuel level in the fuel tank. There is no fuel. Supply fuel. Check the compression. The engine - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 86
spoked wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. Improper cleaning can damage plastic parts (such - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 87
MOTORCYCLE CARE AND STORAGE off any detergent residue using plenty of water, as it is harmful to plastic parts. Do not use any harsh chemical products on plastic parts. Be sure to avoid using cloths or sponges which have been in contact with strong or abrasive cleaning products, solvent or thinner, - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 88
MOTORCYCLE CARE AND STORAGE windshield. Before using them, make a test by polishing an area which does not affect your visibility. Cleaning the sidecases Water can be harmful to untreated leather. Use Yamaha Saddle Soap or another quality brand according to the manufacturer's directions to clean the - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 89
of the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your motorcycle for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 90
MOTORCYCLE CARE AND STORAGE TIP Make any necessary repairs before storing the motorcycle. 8 8-5 - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 91
4-stroke, OHV Cylinder arrangement: V-type 2-cylinder Displacement: 1670 cm³ Bore × stroke: 97.0 × 113.0 mm (3.82 × 4.45 in) Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter cartridge replacement: 3.70 L (3.91 US qt, 3.26 Imp.qt - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 92
SPECIFICATIONS Final drive: Belt Secondary reduction ratio: 2.393 (35/32 x 70/32) Transmission type: Constant mesh 5-speed Operation: Left foot operation Gear ratio: 1st: 2.375 (38/16) 2nd: 1.579 (30/19) 3rd: 1.160 (29/25) 4th: 0.906 (29/32) 5th: 0.750 (21/28) Rear tire: Type: Tubeless Size: 150/ - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 93
: Coil spring/gas-oil damper Wheel travel: 110.0 mm (4.33 in) Turn signal indicator light: LED Fuel level warning light: LED Engine trouble warning light: LED Electrical system: Ignition system: TCI Charging system: AC magneto Fuses: Main fuse: 50.0 A Headlight fuse: 20.0 A Signaling system fuse - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 94
CONSUMER INFORMATION EAU26353 EAU26381 EAU26400 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 95
CONSUMER INFORMATION EAU26470 EAU48270 Model label Vehicle Emission Control Information label 1 1. Model label The model label is affixed to the frame under the rider seat. (See page 4-12.) Record the information on this label in the space provided. This information will be needed when ordering - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 96
that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327 - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 97
CONSUMER INFORMATION EAU26560 Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 98
months 24000 mi (37000 km) or 36 months 28000 mi (43000 km) or 42 months 32000 mi (49000 km) or 48 months 10-5 Date of service Mileage Servicing dealer name and address Remarks 10 - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 99
CONSUMER INFORMATION Maintenance interval 36000 mi (55000 km) or 54 months 40000 mi (61000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 10 10-6 - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 100
1. Operate and maintain the motorcycle as specified in the appropriate Owner's Manual, and 2. Give notice to an authorized Yamaha motorcycle dealer of any . An inspection and registration fee will be charged for this service. EMISSION CONTROL SYSTEM WARRANTY: Yamaha Motor Corporation, U.S.A. also - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 101
in the Owner's and Service Manual. We do recommend, however service, you must take it to any authorized Yamaha motorcycle dealer within the continental United States. Be sure to bring your warranty registration card or other valid proof of the original date of purchase. If a question or problem - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 102
no extra cost. TRIP gives you up to $250 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 103
isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 10 10-10 - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 104
Steering, locking with a padlock...4-12 Storage...8-4 Supporting the motorcycle ...7-36 Swingarm pivots, lubricating ...7-29 Troubleshooting chart ...7-38 Turn signal indicator lights ...4-2 E Engine break-in...6-3 Engine oil and oil filter cartridge...7-12 Engine stop switch ...4-7 Engine trouble - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 105
INDEX Turn signal light bulb, replacing...7-35 Turn signal switch...4-7 V Valve clearance ...7-18 Vehicle Emission Control Information label...10-2 Vehicle identification number...10-1 W Warranty, extended ...10-9 Warranty, limited...10-7 Wheel bearings, checking ...7-30 Wheels...7-20 Windshield [ - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 106
- 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 107
Yamaha engineering teams that know your Yamaha from the inside out. Genuine Yamaha Service Manuals - Get the same factory manual for your vehicle that the technicians at your authorized Yamaha dealer use. Service manuals are available through your Yamaha dealer or you can order them directly through - 2013 Yamaha Motorsports Road Star S | Owners Manual - Page 108
PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2012.07-0.3×1 CR (E)
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
-
105
-
106
-
107
-
108
 |
 |
1BH-28199-13
XV17ASD(C)
XV17ATSD(C)
OWNER’S MANUAL
Read this manual carefully before operating this vehicle.
LIT-11626-26-24