2011 Yamaha Motorsports Stryker Owners Manual
2011 Yamaha Motorsports Stryker Manual
2011 Yamaha Motorsports Stryker manual content summary:
- 2011 Yamaha Motorsports Stryker | Owners Manual - Page 1
Read this manual carefully before operating this vehicle. OWNER'S MANUAL XVS13CA(C) LIT-11626-24-50 27D-28199-10 - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 2
EAU10042 Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold. - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 3
Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. Yamaha continually seeks advancements in product design and quality. Therefore, while this manual contains the most current product information available at the time of - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 4
INFORMATION EAU10132 Particularly important information is distinguished in this manual by the following notations: This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 5
INFORMATION EAU10193 XVS13CA(C) OWNER'S MANUAL ©2010 by Yamaha Motor Corporation, U.S.A. 1st edition, July 2010 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A. - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 6
TABLE OF CONTENTS LOCATION OF IMPORTANT LABELS ...1-1 SAFETY INFORMATION ...2-1 DESCRIPTION ...3-1 Left view ...3-1 Right view ...3-2 Controls and instruments...3-3 INSTRUMENT AND CONTROL FUNCTIONS ...4-1 Main switch/steering lock ...4-1 Indicator lights and warning lights ...4-2 Multi-function - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 7
light bulb ...7-32 License plate light ...7-33 Supporting the motorcycle ...7-33 Troubleshooting ...7-34 Troubleshooting charts ...7-35 MOTORCYCLE CARE AND STORAGE ...8-1 Matte MOTOR CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...10-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...10-9 - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 8
LOCATION OF IMPORTANT LABELS EAU10384 1 Read and understand all of the labels on your vehicle. They contain important information for safe and proper operation of your vehicle. Never remove any labels from your vehicle. If a label becomes difficult to read or comes off, a replacement label is - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 9
LOCATION OF IMPORTANT LABELS 1 2 California only 1 3 TIRE INFORMATION Cold tire normal pressure should be set as follows. • Up to 90 kg (198 lbs) load FRONT : 250 kPa, (2.50 kgf/cm²), 36 psi REAR : 280 kPa, (2.80 kgf/cm²), 41 psi • 90kg (198 lbs) ~ maximum load FRONT : 250 kPa, (2.50 kgf/cm²), 36 - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 10
should: G Obtain thorough instructions from a competent source on all aspects of motorcycle operation. G Observe the warnings and maintenance requirements in this Owner's Manual. G Obtain qualified training in safe and proper riding techniques. G Obtain professional technical service as indicated in - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 11
SAFETY INFORMATION due to excessive speed or undercornering (insufficient lean angle for the speed). • Always obey the speed limit and never travel faster than warranted by road and traffic conditions. • Always signal before turning or changing lanes. Make sure that other motorists can see you. The - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 12
SAFETY INFORMATION G G 2 Do not run engine in poorly ventilated or partially enclosed areas such as barns, garages, or carports. Do not run engine outdoors where engine exhaust can be drawn into a building through openings such as windows and doors. Maximum load: 204 kg (450 lb) Loading Adding - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 13
not be appropriate. Refer to page 7-17 for tire specifications and more information on replacing your tires. Transporting the Motorcycle Be sure to observe following instructions before transporting the motorcycle in another vehicle. G Remove all loose items from the motorcycle. 2-4 - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 14
ahead on the trailer or in the truck bed, and choke it in a rail to prevent movement. Shift the transmission in gear (for models with a manual transmission). Secure the motorcycle with tiedowns or suitable straps that are attached to solid parts of the motorcycle, such as the frame or upper front - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 15
DESCRIPTION EAU10410 Left view 1 2 3,4,5 6 3 10 1. 2. 3. 4. 5. 6. 7. 8. Spark plug (page 7-9) Seat lock (page 4-13) Fuel injection system fuse (page 7-29) Fuse box (page 7-29) Main fuse (page 7-29) Helmet holder (page 4-14) Engine oil level check window (page 7-11) Engine oil drain bolt (page 7- - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 16
DESCRIPTION EAU10420 Right view 1 2,3 4 5 6 7 3 11 1. 2. 3. 4. 5. 6. 7. 8. Rear brake fluid reservoir (page 7-21) Owner's tool kit (page 7-2) Battery (page 7-28) Shock absorber assembly spring preload adjusting ring (page 4-14) Spark plug (page 7-9) Fuel tank cap (page 4-10) Air filter element ( - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 17
DESCRIPTION EAU10430 Controls and instruments 1 2 3 4 5 6 7 8 3 1. 2. 3. 4. 5. 6. 7. 8. Clutch lever (page 4-8) Left handlebar switches (page 4-7) Multi-function meter unit (page 4-4) Main switch/steering lock (page 4-1) Front brake fluid reservoir (page 7-21) Right handlebar switches (page 4-7) - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 18
INSTRUMENT AND CONTROL FUNCTIONS EAU10460 EAU10661 Main switch/steering lock OFF All electrical systems are off. The key can be removed. EWA10061 To lock the steering 1 2 WARNING Never turn the key to "OFF" or "LOCK" while the vehicle is moving. Otherwise the electrical systems will be - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 19
beam of the headlight is switched on. EAU11254 3 2 1 1. 2. 3. 4. 5. 6. 7. Engine trouble warning light " " Coolant temperature warning light " Neutral indicator light " " High beam indicator light " " device for the oil level detection circuit. If a problem is detected in the oil level detection - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 20
the radiator. If the engine overheats, see page 7-35 for further instructions. EAU42774 NOTICE Do not continue to operate the engine if it is overheating. Engine trouble warning light " " This warning light comes on if a problem is detected in the electrical circuit monitoring the engine. If this - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 21
INSTRUMENT AND CONTROL FUNCTIONS EAU50692 Multi-function meter unit 1 2 G G G G G G 1. Speedometer 2. Odometer/tripmeter/fuel reserve tripmeter/fuel meter/clock EWA12422 two tripmeters (which show the distance traveled since they were last set to zero) a fuel reserve tripmeter (which shows the - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 22
by pushing the "SELECT" switch, and then push the "RESET" switch for at least one second. If you do not reset the fuel reserve tripmeter manually, it will reset itself automatically, and the display will return to the prior mode after refueling and traveling 5 km (3 mi). Fuel meter 1 1. Fuel meter - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 23
minute digits will start flashing. This model is equipped with a self-diagnosis device for various electrical circuits. If a problem is detected in any of those circuits, the engine trouble warning light will come on and the display will indicate an error code. If the display indicates any error - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 24
INSTRUMENT AND CONTROL FUNCTIONS 3. Turn the key to "ON", and then release the "SELECT" switch after five seconds. 4. Adjust the multi-function meter unit panel brightness level by pushing the "SELECT" switch. 5. Push the "RESET" switch. The display will change to the prior mode. 4 EAU12348 - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 25
15 seconds. However, the turn signal lights can also be canceled manually by pushing the switch in after it has returned to the center the starter. See page 6-1 for starting instructions prior to starting the engine. EAU41700 Clutch lever 1 The engine trouble warning light will come on when the - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 26
INSTRUMENT AND CONTROL FUNCTIONS EAU12871 EAU12890 EAU12941 Shift pedal Brake lever 1 Brake pedal 1 1 4 1. Shift pedal 1. Brake lever 1. Brake pedal The shift pedal is located on the left side of the motorcycle and is used in combination with the clutch lever when shifting the gears of the 5- - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 27
WARNING Gasoline and gasoline vapors are extremely flammable. To avoid fires and explosions and to reduce the risk of injury when refueling, follow these instructions. 1. Before refueling, turn off the engine and be sure that no one is sitting on the vehicle. Never refuel while smoking, or while in - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 28
exceed 10% (E10). Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. NOTICE Use only unleaded gasoline. The use of leaded gasoline will cause severe damage to internal engine parts, such as the valves and piston - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 29
INSTRUMENT AND CONTROL FUNCTIONS EAU48760 EAU13433 ECA10701 Fuel tank breather/overflow hose Catalytic converter This model is equipped with a catalytic converter in the exhaust system. EWA10862 NOTICE Use only unleaded gasoline. The use of leaded gasoline will cause unrepairable damage to the - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 30
INSTRUMENT AND CONTROL FUNCTIONS EAU50680 Seat To remove the seat 1. Insert the key into the seat lock, turn it counterclockwise, and then lift the front of the seat up. 1 2. Slide the seat rearward to fit the slot in its bottom over the center seat holder. 3. Push the front of the seat down to - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 31
INSTRUMENT AND CONTROL FUNCTIONS EAU14311 Helmet holder 1 To release the helmet from the helmet holder Remove the seat, remove the helmet from the helmet holder, and then install the seat. EAU42545 Adjusting the shock absorber assembly This shock absorber assembly is equipped with a spring - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 32
damping performance. G Do not dispose of a damaged or worn-out shock absorber assembly yourself. Take the shock absorber assembly to a Yamaha dealer for any service. Sidestand The sidestand is located on the left side of the frame. Raise the sidestand or lower it with your foot while holding the - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 33
INSTRUMENT AND CONTROL FUNCTIONS this system regularly and have a Yamaha dealer repair it if it does not function properly. EAU44892 Ignition circuit cut-off system The ignition circuit cut-off system (comprising the sidestand switch, clutch switch and neutral switch) has the following functions. G - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 34
INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is set to " 3. Turn the key on. 4. Shift the transmission into the neutral position. 5. Push the start switch. Does the engine start? WARNING ". If a malfunction is - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 35
the possibility of an accident or equipment damage. Do not operate the vehicle if you find any problem. If a problem cannot be corrected by the procedures provided in this manual, have the vehicle inspected by a Yamaha dealer. Before using this vehicle, check the following points: ITEM CHECKS - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 36
FOR YOUR SAFETY - PRE-OPERATION CHECKS ITEM CHECKS Check operation. If soft or spongy, have Yamaha dealer bleed hydraulic system. Check brake pads for wear. Replace if necessary. Check fluid level in reservoir. If necessary, add recommended brake fluid to specified level. Check hydraulic system for - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 37
FOR YOUR SAFETY - PRE-OPERATION CHECKS ITEM Sidestand switch CHECKS • Check operation of ignition circuit cut-off system. • If system is not working correctly, have Yamaha dealer check vehicle. PAGE 4-15 5 5-3 - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 38
AND IMPORTANT RIDING POINTS EAU15951 EAU48710 EAU46125 Starting the engine Read the Owner's Manual carefully to become familiar with all controls. If there is a control or G Oil level warning light G Fuel level warning light G Coolant temperature warning light G Engine trouble warning light 6-1 - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 39
OPERATION AND IMPORTANT RIDING POINTS ECA15484 EAU16671 ECA10260 NOTICE If a warning light does not come on initially when the key is turned to "ON", or if a warning light remains on, see page 4-2 for the corresponding warning light circuit check. 2. Shift the transmission into the neutral position - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 40
OPERATION AND IMPORTANT RIDING POINTS 4. At the recommended shift points shown in the following table, close the throttle, and at the same time, quickly pull the clutch lever in. 5. Shift the transmission into second gear. (Make sure not to shift the transmission into the neutral position.) 6. Open - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 41
. ECA10270 EAU17213 Parking When parking, stop the engine, and then remove the key from the main switch. EWA10311 NOTICE If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. WARNING G G G Since the engine and exhaust system - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 42
periodic maintenance charts should be simply considered as a general guide under normal riding conditions. However, depending on the weather electrical parts that can cause shocks or fires. G Running the engine while servicing can lead to eye injury, burns, fire, or carbon monoxide poisoning - - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 43
ADJUSTMENT EAU17381 Owner's tool kit 1 1. Owner's tool kit The owner's tool kit is located under the seat. (See page 4-13.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 44
8000 mi (13000 km) or 12 months. Items marked with an asterisk require special tools, data and technical skills, have a Yamaha dealer perform the service. EAU17601 Periodic maintenance chart for the emission control system INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 45
PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months √ √ 7 * Evaporative emission - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 46
PERIODIC MAINTENANCE AND ADJUSTMENT EAU32186 General maintenance and lubrication chart INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 47
PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 9 * Swingarm pivot bearings • - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 48
PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month √ 4000 mi (7000 km) or 6 months √ √ ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 18 * Sidestand switch - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 49
avoid damaging it. • The air filter element needs to be replaced more frequently when riding in unusually wet or dusty areas. Hydraulic brake service • After disassembling the brake master cylinders and calipers, always change the fluid. Regularly check the brake fluid levels and fill the reservoirs - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 50
PERIODIC MAINTENANCE AND ADJUSTMENT EAU18751 EAU42431 Removing and installing the panel The panel shown needs to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time the panel needs to be removed and installed. 1 Checking the spark plugs - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 51
color. TIP If any spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 3. Check each spark plug for electrode erosion and excessive carbon or other deposits, and - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 52
PERIODIC MAINTENANCE AND ADJUSTMENT EAU19681 EAU42599 TIP If a torque wrench is not available when installing a spark plug, a good estimate of the correct torque is 1/4-1/2 turn past finger tight. However, the spark plug should be tightened to the specified torque as soon as possible. 3. Install - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 53
PERIODIC MAINTENANCE AND ADJUSTMENT 1 2 3 4 4. Remove the engine oil filler cap, the engine oil drain bolt and its gasket to drain the oil from the crankcase. 1. 2. 3. 4. Engine oil filler cap Engine oil level check window Maximum level mark Minimum level mark 1. Engine oil drain bolt 2. Gasket 2 - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 54
PERIODIC MAINTENANCE AND ADJUSTMENT Recommended engine oil: See page 9-1. Oil quantity: Without oil filter cartridge replacement: 3.20 L (3.38 US qt, 2.82 Imp.qt) With oil filter cartridge replacement: 3.40 L (3.59 US qt, 2.99 Imp.qt) 1. O-ring 1. Torque wrench TIP Make sure that the O-ring is - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 55
PERIODIC MAINTENANCE AND ADJUSTMENT 10. Start the engine, and then let it idle for several minutes while checking it for oil leakage. If oil is leaking, immediately turn the engine off and check for the cause. TIP After the engine is started, the engine oil level warning light should go off if the - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 56
of the coolant will be reduced. [ECA10472] EAU42442 TIP Make sure that the coolant reservoir breather hose is properly routed through the guide. Replacing the air filter element The air filter element should be replaced at the intervals specified in the periodic maintenance and lubrication chart - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 57
PERIODIC MAINTENANCE AND ADJUSTMENT EAU21384 EAU21401 Checking the throttle grip free play Valve clearance The valve clearance changes with use, resulting in improper air-fuel mixture and/or engine noise. To prevent this from occurring, the valve clearance must be adjusted by a Yamaha dealer at - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 58
PERIODIC MAINTENANCE AND ADJUSTMENT EAU32544 Tires To maximize the performance, durability, and safe operation of your motorcycle, note the following points regarding the specified tires. Tire air pressure The tire air pressure should be checked and, if necessary, adjusted before each ride. - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 59
PERIODIC MAINTENANCE AND ADJUSTMENT EWA10521 WARNING G G It is dangerous to ride with a worn-out tire. When a tire tread begins to show lines, have a Yamaha dealer replace the tire immediately. Brakes, tires and related wheel parts replacement should also be left to a Yamaha dealer. Ride at - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 60
PERIODIC MAINTENANCE AND ADJUSTMENT EAU50700 Adjusting the clutch lever free play 1 23 TIP If the specified clutch lever free play could be obtained as described above, skip steps 3-6. 3. Fully turn the adjusting bolt in direction (a) to loosen the clutch cable. 4. Slide the rubber covers apart, - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 61
PERIODIC MAINTENANCE AND ADJUSTMENT EAU37913 Checking the brake lever free play 1 braking performance, which may result in loss of control and an accident. EAU22273 Brake light switches 1 (a) 2 (b) 1. No brake lever free play 1. Rear brake light switch 2. Rear brake light switch adjusting nut - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 62
PERIODIC MAINTENANCE AND ADJUSTMENT EAU22392 Checking the front and rear brake pads The front and rear brake pads must be checked for wear at the intervals specified in the periodic maintenance and lubrication chart. EAU22430 indicator grooves have almost disappeared, have a Yamaha dealer replace - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 63
PERIODIC MAINTENANCE AND ADJUSTMENT Before riding, check that the brake fluid is above the minimum level mark and replenish if necessary. A low brake fluid level may indicate worn brake pads and/or brake system leakage. If the brake fluid level is low, be sure to check the brake pads for wear and - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 64
PERIODIC MAINTENANCE AND ADJUSTMENT EAU23040 Drive belt slack The drive belt slack should be checked and adjusted at the intervals specified in the periodic maintenance and lubrication chart. EAU38410 3. Note the position of the drive belt with a force of 45 N (4.5 kgf, 10 lbf) applied to the belt - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 65
PERIODIC MAINTENANCE AND ADJUSTMENT EAU23095 EAU49920 EAU44272 Checking and lubricating the cables The operation of all control cables and the condition of the cables should be checked before each ride, and the cables and cable ends should be lubricated if necessary. If a cable is damaged or does - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 66
PERIODIC MAINTENANCE AND ADJUSTMENT EAU23142 Recommended lubricant: Lithium-soap-based grease Checking and lubricating the brake and clutch levers Brake lever Recommended lubricants: Brake lever: Silicone grease Clutch lever: Lithium-soap-based grease Clutch lever 7 The operation of the brake - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 67
PERIODIC MAINTENANCE AND ADJUSTMENT EAU23202 EAUM1651 EAU23251 Checking and lubricating the sidestand Lubricating the swingarm pivots Lubricating the rear suspension The operation of the sidestand should be checked before each ride, and the sidestand pivot and metal-to-metal contact surfaces - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 68
ground. (See page 7-33 for more information.) WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over. [EWA10751] 2. and hold it in an upright position. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over. [EWA10751] - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 69
PERIODIC MAINTENANCE AND ADJUSTMENT EAU23291 EAU50710 Checking the wheel bearings Battery 1 2 3 The front and rear wheel bearings must be checked at the intervals specified in the periodic maintenance and lubrication chart. If there is play in the wheel hub or if the wheel does not turn smoothly, - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 70
PERIODIC MAINTENANCE AND ADJUSTMENT To charge the battery Have a Yamaha dealer charge the battery as soon as possible if it seems to have discharged. Keep in mind that the battery tends to discharge more quickly if the vehicle is equipped with optional electrical accessories. ECA16521 NOTICE To - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 71
PERIODIC MAINTENANCE AND ADJUSTMENT 2 1 3 Specified fuses: Main fuse: 50.0 A Headlight fuse: 20.0 A Taillight fuse: 10.0 A Signaling system fuse: 10.0 A Ignition fuse: 15.0 A Radiator fan fuse: 20.0 A Fuel injection system fuse: 10.0 A Backup fuse: 10.0 A 1. 2. 3. 4. 5. 6. 7. Signaling system fuse - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 72
PERIODIC MAINTENANCE AND ADJUSTMENT EAU48511 Replacing the headlight bulb This model is equipped with a quartz bulb headlight. If the headlight bulb burns out, replace it as follows. ECA10650 1 2 NOTICE Take care not to damage the following parts: G Headlight bulb Do not touch the glass part of - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 73
PERIODIC MAINTENANCE AND ADJUSTMENT 4. Place a new headlight bulb into position, and then secure it with the bulb holder. 5. Install the headlight bulb cover, and then connect the coupler. TIP When installing the headlight bulb cover, make sure the "TOP" mark faces upwards. EAU24181 EAU24212 Tail/ - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 74
Yamaha dealer check the electrical circuit or replace the bulb. Supporting the motorcycle Since this model is not equipped with a centerstand 2. Raise the front wheel off the ground by using a motorcycle stand. To service the rear wheel Raise the rear wheel off the ground by using a motorcycle stand - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 75
EAU25871 Troubleshooting Although Yamaha motorcycles receive a thorough inspection before shipment from the factory, trouble may occur during operation. Any problem in Yamaha parts, but they are often inferior, have a shorter service life and can lead to expensive repair bills. EWA15141 heaters or - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 76
PERIODIC MAINTENANCE AND ADJUSTMENT EAU42502 Troubleshooting charts Starting problems or poor engine performance 1. Fuel There is enough fuel. Check the fuel level in the fuel tank. There is no fuel. Supply fuel. Check the - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 77
PERIODIC MAINTENANCE AND ADJUSTMENT Engine overheating EWAT1040 WARNING G G Do not remove the radiator cap when the engine and radiator are hot. Scalding hot fluid and steam may be blown out under pressure, which could cause serious injury. Be sure to wait until the engine has cooled. Place a - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 78
spoked wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. Improper cleaning can damage plastic parts (such - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 79
MOTORCYCLE CARE AND STORAGE off any detergent residue using plenty of water, as it is harmful to plastic parts. Do not use any harsh chemical products on plastic parts. Be sure to avoid using cloths or sponges which have been in contact with strong or abrasive cleaning products, solvent or thinner, - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 80
(because of the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your motorcycle for several months: 1. Follow all the instructions in the "Care" section of this chapter. - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 81
MOTORCYCLE CARE AND STORAGE 2. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from rusting and the fuel from deteriorating. 3. Perform the following steps to protect the cylinders, piston rings, etc. from corrosion. a. Remove the spark plug caps and spark plugs - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 82
: 100.0 × 83.0 mm (3.94 × 3.27 in) Compression ratio: 9.50 :1 Starting system: Electric starter Lubrication system: Wet sump Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter cartridge replacement: 3.20 L (3.38 US qt, 2.82 Imp.qt - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 83
SPECIFICATIONS 2nd: 1.778 (32/18) 3rd: 1.381 (29/21) 4th: 1.115 (29/26) 5th: 0.960 (24/25) (Total weight of rider, passenger, cargo and accessories) Rear brake: Type: Single disc brake Operation: Right foot operation Recommended fluid: DOT 4 Tire air pressure (measured on cold tires): Loading - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 84
: LED Oil level warning light: LED Turn signal indicator light: LED Fuel level warning light: LED Coolant temperature warning light: LED Engine trouble warning light: LED Signaling system fuse: 10.0 A Ignition fuse: 15.0 A Radiator fan fuse: 20.0 A Fuel injection system fuse: 10.0 A Backup fuse: 10 - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 85
CONSUMER INFORMATION EAU26352 EAU26381 EAU26400 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 86
CONSUMER INFORMATION EAU26480 EAU48270 Model label Vehicle Emission Control Information label 1 1 1. Model label The model label is affixed to the frame under the seat. (See page 4-13.) Record the information on this label in the space provided. This information will be needed when ordering - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 87
that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327 - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 88
CONSUMER INFORMATION EAU26560 Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 89
months 24000 mi (37000 km) or 36 months 28000 mi (43000 km) or 42 months 32000 mi (49000 km) or 48 months 10-5 Date of service Mileage Servicing dealer name and address Remarks 10 - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 90
CONSUMER INFORMATION Maintenance interval 36000 mi (55000 km) or 54 months 40000 mi (61000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 10 10-6 - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 91
1. Operate and maintain the motorcycle as specified in the appropriate Owner's Manual, and 2. Give notice to an authorized Yamaha motorcycle dealer of any . An inspection and registration fee will be charged for this service. EMISSION CONTROL SYSTEM WARRANTY: Yamaha Motor Corporation, U.S.A. also - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 92
in the Owner's and Service Manual. We do recommend, however service, you must take it to any authorized Yamaha motorcycle dealer within the continental United States. Be sure to bring your warranty registration card or other valid proof of the original date of purchase. If a question or problem - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 93
no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 94
isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 10 10-10 - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 95
Start switch ...4-8 Steering, checking ...7-27 Storage ...8-3 Supporting the motorcycle ...7-33 Swingarm pivots, lubricating ...7-26 I Troubleshooting ...7-34 Troubleshooting charts ...7-35 E Engine break-in ...6-3 Engine oil and oil filter cartridge ...7-11 Engine stop switch...4-8 Engine trouble - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 96
INDEX Turn signal indicator light ...4-2 Turn signal light bulb, replacing ...7-32 Turn signal switch ...4-7 V Valve clearance ...7-16 Vehicle Emission Control Information label ...10-2 Vehicle identification number ...10-1 W Warranty, extended...10-9 Warranty, limited ...10-7 Wheel bearings, - 2011 Yamaha Motorsports Stryker | Owners Manual - Page 97
- 2011 Yamaha Motorsports Stryker | Owners Manual - Page 98
YAMAHA MOTOR CO., LTD. PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2010.07-1.5×1 CR (E)
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
 |
 |
27D-28199-10
XVS13CA(C)
OWNER’S MANUAL
Read this manual carefully before operating this vehicle.
LIT-11626-24-50