2010 Yamaha Motorsports Zuma 125 Owners Manual

2010 Yamaha Motorsports Zuma 125 Manual

Get 2010 Yamaha Motorsports Zuma 125 PDF manuals and user guides View all 2010 Yamaha Motorsports Zuma 125 manuals

2010 Yamaha Motorsports Zuma 125 manual content summary:

  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 1
    Read this manual carefully before operating this vehicle. OWNER'S MANUAL YW125Z LIT-11626-23-66 32S-F8199-11
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 2
    1 2 3 EAU10042 4 5 6 7 8 9 Q Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold.
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 3
    Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. Yamaha continually seeks advancements in product design and quality. Therefore, while this manual contains the most current product information available at the time of
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 4
    INFORMATION Particularly important information is distinguished in this manual by the following notations: 1 2 WARNING 3 4 5 6 7 8 9 EAU10122 EAU10132 Q This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 5
    INFORMATION EAU10122 1 2 3 4 5 EAUT2191 6 7 8 9 YW125Z OWNER'S MANUAL ©2009 by Yamaha Motor Corporation, U.S.A. 1st edition, July 2009 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A.
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 6
    Checking the wheel bearings ...6-24 Battery ...6-25 Replacing the fuses ...6-26 Replacing a headlight bulb ...6-27 Tail/brake light ...6-28 Replacing a turn signal light bulb . 6-28 Troubleshooting ...6-29 Troubleshooting chart ...6-30
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 7
    ...8-1 EAU10210 1 2 CONSUMER INFORMATION ...9-1 Identification numbers ...9-1 Reporting safety defects ...9-3 Motorcycle noise regulation ...9-4 Maintenance record ...9-5 YAMAHA MOTOR CORPORATION, U.S.A. RIVA LIMITED WARRANTY ...9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...9-9 3 4 5 6 7 8 9
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 8
    Labels, location LOCATION OF IMPORTANT LABELS EAU45762 EAU10383 1 2 3 4 5 Read and understand all of the labels on your vehicle. They contain important information for safe and proper operation of your vehicle. Never remove any labels from your vehicle. If a label becomes difficult to read
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 9
    LOCATION OF IMPORTANT LABELS EAU45762 1 1 175kpa, {1.75kgf/cm },25psi 200kpa, {2.00kgf/cm2},29psi 200kpa, {2.00kgf/cm2},29psi 225kpa, {2.25kgf/cm2},33psi 24P-F1668-00 4 2 2 4JK-F8446-01 3 4 2 5 5 6 7 8 3 9 1-9 1-2
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 10
    should: ● Obtain thorough instructions from a competent source on all aspects of scooter operation. ● Observe the warnings and maintenance requirements in this Owner's Manual. ● Obtain qualified training in safe and proper riding techniques. ● Obtain professional technical service as indicated in
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 11
    Q SAFETY INFORMATION excessive speed or undercornering (insufficient lean angle for the speed). • Always obey the speed limit and never travel faster than warranted by road and traffic conditions. • Always signal before turning or changing lanes. Make sure that other motorists can see you. The
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 12
    Q SAFETY INFORMATION you try to ventilate engine exhaust with fans or open windows and doors, carbon monoxide can rapidly reach dangerous levels. Do not run engine in poorly ventilated or partially enclosed areas such as barns, garages, or carports. Do not run engine outdoors where engine exhaust
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 13
    Q SAFETY INFORMATION aftermarket companies produce. Therefore, Yamaha can neither endorse nor recommend the use of accessories not sold by Yamaha or modifications not specifically recommended by Yamaha, even if sold and installed by a Yamaha dealer. Aftermarket Parts, Accessories, and Modifications
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 14
    Safe-riding points Q SAFETY INFORMATION ate. Refer to page 6-16 for tire specifications and more information on replacing your tires. 1 2 3 ● EAUT2030 EAU10221 Further safe-riding points ● ● 4 ● 5 6 7 8 9 ● ● ● Make sure to signal clearly when making turns. Braking can be extremely
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 15
    Q SAFETY INFORMATION EAU10221 1 2 3 4 5 6 7 8 9 1-15 1-8
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 16
    Part locations DESCRIPTION Left view 1 1 2 EAU10401 EAU10410 3 3 4 5 6 7 8 9 1. 2. 3. 4. 5. 6. 7. 8. Front turn signal light (page 6-28) Battery (page 6-25) Helmet holder (page 3-9) Sidestand (page 3-10) V-belt case air filter cover (page 6-13) Centerstand (page 6-22) Air filter (page 6-13)
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 17
    DESCRIPTION EAU10420 EAU10401 Right view 1 2 2 1 3 4 5 7 3 4 6 5 6 7 8 9 1. 2. 3. 4. 5. 6. 7. Tail/brake light (page 6-28) Muffler (page 3-7) Storage compartment (page 3-9) Seat (page 3-8) Fuel tank cap (page 3-5) Spark plug (page 6-9) Headlight (page 6-27) 2-17 2-2
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 18
    DESCRIPTION Controls and instruments 1 EAU10401 EAU10430 1 2 3 4 5 6 7 8 9 1. 2. 3. 4. 5. 6. 7. 8. 9. Rear brake lever (page 6-18) Left handlebar switches (page 3-4) Speedometer unit (page 3-3) Fuel gauge (page 3-3) Brake fluid reservoir (page 6-20) Right handlebar switches (page 3-4) Front brake
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 19
    Main switch/steering lock INSTRUMENT AND CONTROL FUNCTIONS EAU45440 EAUT2270 EAU10681 EAU1044D Main switch/steering lock ON All electrical circuits are supplied with power, and the meter lighting and taillight come on, and the engine can be started. The key cannot be removed. TIP The
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 20
    shown, and then turn the key to the right to open the cover. 1. Turn signal indicator light "4 6" 2. High beam indicator light"&" 3. Engine trouble warning light " " EAU11020 Turn signal indicator light "4 6" This indicator light flashes when the turn signal switch is pushed to the left or right
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 21
    Fuel gauge INSTRUMENT AND CONTROL FUNCTIONS EAUT1934 EAUT1821 EAU12140 EAU1044D Engine trouble warning light " " This warning light flashes or stays on if an electrical circuit monitoring the engine is not working correctly. If this occurs, have a Yamaha
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 22
    beam and to "%" for the low beam. EAU12460 Start switch "," Push this switch to crank the engine with the starter. See page 5-1 for starting instructions prior to starting the engine. Turn signal switch "4/6" To signal a right-hand turn, push this switch to "6". To signal a left-hand turn, push
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 23
    Fuel tank cap INSTRUMENT AND CONTROL FUNCTIONS EAU12900 EAU12950 EAU13041 EAU1044D Front brake lever 1 Rear brake lever 1 Fuel tank cap 1 1 LO CK 2 3 4 1. Front brake lever 1. Rear brake lever 1. Fuel tank cap The front brake lever is located on the right handlebar grip. To apply the
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 24
    WARNING Gasoline and gasoline vapors are extremely flammable. To avoid fires and explosions and to reduce the risk of injury when refueling, follow these instructions. 1. Before refueling, turn off the engine and be sure that no one is sitting on the vehicle. Never refuel while smoking, or while in
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 25
    Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. EAU13433 Catalytic converter This model is equipped with a catalytic converter in the exhaust system. EWA10862 1 2 3 4 5 6 7 8 9 WARNING The exhaust system is
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 26
    Seat INSTRUMENT AND CONTROL FUNCTIONS ECA10701 EAUT2670 EAU1044D NOTICE 1 2 3 4 Use only unleaded gasoline. The use of leaded gasoline will cause unrepairable damage to the catalytic converter. Seat 1 1 PUSH from "OFF" to "OPEN" or from "ON" to "OPEN". To close the seat 1. Fold the seat
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 27
    5 kg (11 lb) for the storage compartment. 8 Do not exceed the maximum load of 155 kg (342 lb) for the vehicle. When storing the Owner's Manual or other documents in the storage compart- 3-27 3-9
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 28
    Sidestand INSTRUMENT AND CONTROL FUNCTIONS ment, be sure to wrap them in a plastic bag so that they will not get wet. When washing the vehicle, be careful not to let any water enter the storage compartment. EAU15303 EAU1044D EWA10240 Sidestand w The vehicle must not be ridden with the
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 29
    Ignition circuit cut-off system INSTRUMENT AND CONTROL FUNCTIONS EAU45051 EAU1044D Ignition circuit cut-off system The ignition circuit cut-off system (comprising the sidestand switch and brake light switches) has the following functions. 8 It prevents star ting when the sidestand is up, but
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 30
    INSTRUMENT AND CONTROL FUNCTIONS WARNING If a malfunction is noted, have a Yamaha dealer check the system before riding. EAU1044D 1 2 3 4 5 6 7 8 9 With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is turned on. 3. Turn the key on. 4. Keep the front
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 31
    or maintain the vehicle properly increases the possibility of an accident or equipment damage. Do not operate the vehicle if you find any problem. If a problem cannot be corrected by the procedures provided in this manual, have the vehicle inspected by a Yamaha dealer. 1 2 3 4 5 6 7 8 9 4-31 4-1
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 32
    FOR YOUR SAFETY - PRE-OPERATION CHECKS Before using this vehicle, check the following points: ITEM Fuel • Check fuel level in fuel tank. • Refuel if necessary. • Check fuel line for leakage. • Check oil level in engine. • If necessary, add recommended oil to specified level. • Check vehicle for oil
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 33
    FOR YOUR SAFETY - PRE-OPERATION CHECKS ITEM Brake levers Centerstand, sidestand Chassis fasteners Instruments, lights, signals and switches Engine stop switch Sidestand switch CHECKS • Make sure that operation is smooth. • Lubricate lever pivoting points if necessary. • Make sure that operation is
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 34
    EAU15943 1 2 3 4 5 6 7 8 9 Read the Owner's Manual carefully to become familiar with all controls. If there is a control or function you do not understand, ask your Yamaha dealer. EWA10271 Starting the engine ECA10250 NOTICE See page 5-3 for engine break-in instructions prior to operating the
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 35
    Braking OPERATION AND IMPORTANT RIDING POINTS EAU16761 EAU16780 EAU16793 EAU15943 Starting off TIP Before starting off, allow the engine to warm up. 1. While pulling the rear brake lever with your left hand and holding the grab bar with your right hand, push the scooter off the centerstand.
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 36
    to ten minutes. Vary the engine speed from time to time. Do not operate the engine at one set throttle position. NOTICE If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. 5-36 5-3
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 37
    Parking OPERATION AND IMPORTANT RIDING POINTS EAU17213 EAU15943 Parking When parking, stop the engine, and then remove the key from the main switch. EWA10311 1 2 3 4 5 6 7 8 9 WARNING ● ● ● Since the engine and exhaust system can become very hot, park in a place where pedestrians or
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 38
    The most important points of vehicle inspection, adjustment, and lubrication are explained on the following pages. EWA10321 ● Running the engine while servicing can lead to eye injury, burns, fire, or carbon monoxide poisoning possibly leading to death. See page 1-3 for more information about
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 39
    you. 1 2 3 4 1 1. Owner's tool kit The owner's tool kit is located inside the storage compartment under the seat. (See page 3-8.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 40
    . — Replace. — 5 3 6 4 * Valve clearance * system Crankcase breather — — — — — — — — — — — — — — — — — — — — 7 5 * Fuel injection * Exhaust system 8 9 6 * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 6-40 6-3
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 41
    Maintenance and lubrication, periodic PERIODIC MAINTENANCE AND ADJUSTMENT EAU32125 EAU1722A General maintenance and lubrication chart INITIAL NO. ITEM ROUTINE 600 mi (1,000 km) or 1 month 2,000 mi (4,000 km) or 6 months ODOMETER READING 4,000 mi 6,000 mi 8,000 mi 10,000 mi (7,000 km) (10,
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 42
    PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL NO. ITEM ROUTINE 600 mi (1,000 km) or 1 month 2,000 mi (4,000 km) or 6 months ODOMETER READING EAU1722A 1 2 9 • Check bearing assemblies for looseness. • Moderately repack with lithiumsoap-based grease every 8000 mi (13000 km) or 24 months. • Check all
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 43
    headlight beam. — — — — — — 6 7 8 9 24 * switches — — — — — * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. TIP From 12000 mi (19000 km) or 36 months, repeat the maintenance intervals starting from 4000 mi (7000 km) or 12
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 44
    damaging it. 9 The air filter element needs to be replaced and V-belt filter needs to be serviced more frequently when riding in unusually wet or dusty areas. 8 Hydraulic brake service 9 After disassembling the brake master cylinder and caliper, always change the fluid. Regularly check the brake
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 45
    Panel, removing and installing PERIODIC MAINTENANCE AND ADJUSTMENT EAU18771 EAU19272 EAUT2532 EAU1722A Removing and installing panels The panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a panel needs to be
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 46
    normally). TIP If the spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. To install the spark plug 1. Measure the spark plug gap with a wire thickness gauge
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 47
    Engine oil PERIODIC MAINTENANCE AND ADJUSTMENT TIP If a torque wrench is not available when installing a spark plug, a good estimate of the correct torque is 1/4 ~ 1/2 turn past finger tight. However, the spark plug should be tightened to the specified torque as soon as possible. 4. Install
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 48
    PERIODIC MAINTENANCE AND ADJUSTMENT Tightening torque: Engine oil drain bolt: 20 Nm (2.0 m • kgf, 14.5 ft • lbf) EAU1722A 1 2 1 3 1. Oil filler cap 5. Refill with the specified amount of the recommended engine oil, and then install and tighten the oil filler cap. Recommended engine oil: See page
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 49
    Final transmission oil PERIODIC MAINTENANCE AND ADJUSTMENT EAU20064 EAU1722A Final transmission oil The final transmission case must be checked for oil leakage before each ride. If any leakage is found, have a Yamaha dealer check and repair the scooter. In addition, the final transmission
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 50
    Air filter and V-belt case air filter elements PERIODIC MAINTENANCE AND ADJUSTMENT 7. Check the final transmission case for oil leakage. If oil is leaking, check for the cause. 1 2 3 4 5 6 7 8 EAUT2660 EAU1722A Air filter and V-belt case air filter elements The air filter and V-belt case air
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 51
    PERIODIC MAINTENANCE AND ADJUSTMENT Cleaning the V-belt case air filter element 2. Remove the filter element holder by removing the screw. 4. Apply oil of the recommended type to the entire surface of the sponge material, and then squeeze the excess oil out. TIP The air filter element should be wet
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 52
    Valve clearance PERIODIC MAINTENANCE AND ADJUSTMENT EAU44734 EAU21382 EAU1722A EAU21401 Checking the engine idling speed 1 2 3 4 5 6 7 8 9 Check the engine idling speed and, if necessary, have it corrected by a Yamaha dealer. Engine idling speed: 1700 ~ 1900 r/min Checking the throttle
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 53
    Tires PERIODIC MAINTENANCE AND ADJUSTMENT EAUT1702 EAU1722A Tires To maximize the performance, durability, and safe operation of your scooter, note the following points regarding the specified tires. Tire air pressure The tire air pressure should be checked and, if necessary, adjusted before
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 54
    control. Have excessively worn tires replaced by a Yamaha dealer immediately. Brakes, tires, and related wheel parts replacement should be left to a Yamaha Service Technician. After extensive tests, only the tires listed below have been approved for this model by Yamaha Motor Co., Ltd. Front tire
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 55
    Rear brake lever free play, adjusting PERIODIC MAINTENANCE AND ADJUSTMENT EAU37912 EAU1722A Checking the front brake lever free play 1 hydraulic system will diminish the braking performance, which may result in loss of control and an accident. EAU22170 Adjusting the rear brake lever free
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 56
    Brake pads and shoes, checking PERIODIC MAINTENANCE AND ADJUSTMENT EAU22380 EAU1722A Checking the front brake pads and rear brake shoes 1 (b) 2 3 1. Adjusting nut 1 (a) To increase the brake lever free play, turn the adjusting nut at the brake shoe plate in direction (a). To decrease the
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 57
    Brake fluid level, checking PERIODIC MAINTENANCE AND ADJUSTMENT that the wear indicator reaches the wear limit line, have a Yamaha dealer replace the brake shoes as a set. EAU32344 EAU1722A Checking the brake fluid level 1 Observe these precautions: 8 When checking the fluid level, make
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 58
    Cables, checking and lubricating PERIODIC MAINTENANCE AND ADJUSTMENT mal for the brake fluid level to gradually go down. However, if the brake fluid level goes down suddenly, have a Yamaha dealer check the cause. EAU22721 EAU1722A EAU23093 Changing the brake fluid Have a Yamaha dealer
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 59
    Centerstand and sidestand, checking and lubricating PERIODIC MAINTENANCE AND ADJUSTMENT EAU23111 EAU43641 EAU23213 EAU1722A Checking and lubricating the throttle grip and cable The operation of the throttle grip should be checked before each ride. In addition, the cable should be lubricated
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 60
    oil leakage. To check the operation 1. Place the vehicle on a level surface and hold it in an upright position. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over.[EWA10751] 2. While applying the front brake, push down hard on the handlebars several times
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 61
    as follows at the intervals specified in the periodic maintenance and lubrication chart. 1. Place the vehicle on the centerstand. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over.[EWA10751] 2. Hold the lower ends of the front fork legs and try to move
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 62
    Battery PERIODIC MAINTENANCE AND ADJUSTMENT EAUT2691 EWA10760 EAU1722A Battery 1 2 3 4 1. Battery WARNING OUT OF THE REACH OF CHILDREN. The battery is located under panel A. Remove the panel to access the battery. (See page 6-8.) To charge the battery Have a Yamaha dealer charge the
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 63
    Fuses, replacing PERIODIC MAINTENANCE AND ADJUSTMENT To store the battery 1. If the vehicle will not be used for more than one month, remove the battery, fully charge it, and then place it in a cool, dry place. NOTICE: When removing the battery, be sure the key is turned to "OFF", then
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 64
    Headlight bulb, replacing PERIODIC MAINTENANCE AND ADJUSTMENT 1 1 2 3 1. Spare fuse EAU1722A EAU34240 Specified fuses: Main fuse: 20 A Ignition fuse: 10 A Signaling system fuse: 15 A Headlight fuse: 10 A Fuel injection system fuse: 10 A Replacing a headlight bulb 1 4 5 6 7 8 9 2. Remove
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 65
    Turn signal light bulb, replacing PERIODIC MAINTENANCE AND ADJUSTMENT EAU43040 EAU24204 EAU1722A Tail/brake light 1 Replacing a turn signal light bulb 1. Remove the turn signal light lens by removing the screw. 1 1 2 1 3 1. Turn signal light Bulb 1. Tail/brake light If the tail/brake
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 66
    trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause poor starting and loss of power. The following troubleshooting parts, but they are often inferior, have a shorter service life and can lead to expensive repair bills. EWA15141
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 67
    chart PERIODIC MAINTENANCE AND ADJUSTMENT EAUT1981 EAU1722A Troubleshooting chart 1 1. Fuel There is enough fuel. Check the fuel level in the fuel tank. There is no fuel. Supply fuel. Check the compression. The engine
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 68
    spoked wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. Improper cleaning can damage plastic parts (such
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 69
    SCOOTER CARE AND STORAGE any detergent residue using plenty of water, as it is harmful to plastic parts. Do not use any harsh chemical products on plastic parts. Be sure to avoid using cloths or sponges which have been in contact with strong or abrasive cleaning products, solvent or thinner, fuel (
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 70
    of the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your scooter for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 71
    SCOOTER CARE AND STORAGE from deteriorating. 3. Perform the following steps to protect the cylinder, piston rings, etc. from corrosion. a. Remove the spark plug cap and spark plug. b. Pour a teaspoonful of engine oil into the spark plug bore. c. Install the spark plug cap onto the spark plug, and
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 72
    x stroke 52.4 x 57.9 mm (2.06 x 2.28 in) Compression ratio 10.00 :1 Starting system Electric starter Lubrication system Wet sump Recommended engine oil grade API service SG type or higher JASO standard MA Engine oil quantity Without oil filter element removal 0.85 L (0.90 US qt, 0.75 Imp.qt) Final
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 73
    SPECIFICATIONS Size 120 / 70 - 12 51L Manufacturer/model KENDA / K761A Rim size J12 X MT3.00 EAU26320 Battery Model MF (YT7B-BS) Voltage, capacity 12 V, 6.5 Ah Front brake Type Single disc brake Operation Right hand operation Recommended fluid DOT 4 Rear tire Type Tubeless Size 130 / 70 - 12 56L
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 74
    Vehicle identification number CONSUMER INFORMATION EAU26352 EAU26381 EAU26343 EAU26410 Identification numbers 1 2 3 KEY IDENTIFICATION NUMBER: 4 Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 75
    Vehicle Emission Control Information label CONSUMER INFORMATION EAU26480 EAU48060 EAU26343 Model label Vehicle Emission Control Information label 1 2 1 1 3 4 1. Model label The model label is affixed to the frame under the seat. (See page 3-8.) Record the information on this label in
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 76
    that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 77
    Noise regulation CONSUMER INFORMATION Motorcycle noise regulation EAU26343 EAU26560 TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance,
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 78
    18 months 8000 mi (13000 km) or 24 months 10000 mi (16000 km) or 30 months 12000 mi (19000 km) or 36 months Date of service Mileage Servicing dealer name and address Remarks 9-78 9-5
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 79
    CONSUMER INFORMATION Maintenance interval 14000 mi (22000 km) or 42 months 16000 mi (25000 km) or 48 months 18000 mi (28000 km) or 54 months 20000 mi (31000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks EAU26343 1 2 3 4 5 6 7 8 9 9-79 9-6
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 80
    Warranty, limited CONSUMER INFORMATION YAMAHA MOTOR CORPORATION, U.S.A. RIVA LIMITED WARRANTY 1 2 3 4 5 6 7 8 9 EAU26343 EAU26681 9-80 9-7
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 81
    CONSUMER INFORMATION EAU26343 1 2 3 4 5 6 7 8 9 9-81 9-8
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 82
    no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 83
    isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) EAU26343 1 2 3 4 5 6 7 8 9 9-83 9-10
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 84
    and lubricating ...6-22 Tires ...6-16 Tool kit ...6-2 Troubleshooting ...6-29 Troubleshooting chart ...6-30 Turn signal indicator light ...3-2 Turn Engine oil and oil strainer ...6-11 Engine stop switch ...3-4 Engine trouble warning light ...3-3 N Noise regulation ...9-4 F Final transmission oil
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 85
    INDEX V Valve clearance ...6-15 Vehicle Emission Control Information label ...9-2 Vehicle identification number ...9-1 1 2 3 4 5 6 7 8 9 W Warranty, extended ...9-9 Warranty, limited ...9-7 Wheel bearings, checking ...6-24 Wheels ...6-17
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 86
    1 2 3 4 5 6 7 8 9
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 87
    1 2 3 4 5 6 7 8 9
  • 2010 Yamaha Motorsports Zuma 125 | Owners Manual - Page 88
    YAMAHA MOTOR TAIWAN CO., LTD PRINTED IN TAIWAN 2010.01-0.8× 1! (E)
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
Read this manual carefully before operating this vehicle.
YW125Z
OWNER’S MANUAL
32S-F8199-11
LIT-11626-23-66