2010 Yamaha Motorsports V Star Classic Owners Manual
2010 Yamaha Motorsports V Star Classic Manual
2010 Yamaha Motorsports V Star Classic manual content summary:
- 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 1
Read this manual carefully before operating this vehicle. OWNER'S MANUAL XVS65Z(C) XVS65AZ(C) XVS65ATZ(C) LIT-11626-23-20 1BF-28199-10 - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 2
EAU10042 Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold. - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 3
Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. Yamaha continually seeks advancements in product design and quality. Therefore, while this manual contains the most current product information available at the time of - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 4
INFORMATION EAU10132 Particularly important information is distinguished in this manual by the following notations: This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 5
INFORMATION EAU10193 XVS65Z(C)/XVS65AZ(C)/XVS65ATZ(C) OWNER'S MANUAL ©2009 by Yamaha Motor Corporation, U.S.A. 1st edition, March 2009 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A. - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 6
TABLE OF CONTENTS LOCATION OF IMPORTANT LABELS ...1-1 SAFETY INFORMATION ...2-1 DESCRIPTION ...3-1 Left view ...3-1 Right view ...3-2 Controls and instruments...3-3 INSTRUMENT AND CONTROL FUNCTIONS ...4-1 Main switch/steering lock ...4-1 Indicator and warning lights ...4-2 Speedometer unit ...4-3 - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 7
tail/brake light bulb ...7-34 Supporting the motorcycle ...7-34 Front wheel ...7-35 Rear wheel ...7-36 Troubleshooting ...7-38 Troubleshooting chart ...7-39 MOTORCYCLE CARE AND STORAGE CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...10-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...10-9 - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 8
LOCATION OF IMPORTANT LABELS EAU10383 1 Read and understand all of the labels on your vehicle. They contain important information for safe and proper operation of your vehicle. Never remove any labels from your vehicle. If a label becomes difficult to read or comes off, a replacement label is - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 9
LOCATION OF IMPORTANT LABELS 1 3 XVS65AZ/XVS65ATZ TIRE INFORMATION Cold tire normal pressure should be set as follows. • Up to 90 kg (198 lbs) load FRONT : 225 kPa, (2.25 kgf/cm²), 33 psi REAR : 225 kPa, (2.25 kgf/cm²), 33 psi • 90kg (198 lbs) ~ maximum load FRONT : 225 kPa, (2.25 kgf/cm²), 33 psi - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 10
LOCATION OF IMPORTANT LABELS 5 1 A1 6 California only EMISSION HOSE ROUTING CARB. FROM FUEL TANK CANISTER TO ATMOSPHERE 1BF-21686-00 1-3 - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 11
should: G Obtain thorough instructions from a competent source on all aspects of motorcycle operation. G Observe the warnings and maintenance requirements in this Owner's Manual. G Obtain qualified training in safe and proper riding techniques. G Obtain professional technical service as indicated in - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 12
SAFETY INFORMATION due to excessive speed or undercornering (insufficient lean angle for the speed). • Always obey the speed limit and never travel faster than warranted by road and traffic conditions. • Always signal before turning or changing lanes. Make sure that other motorists can see you. The - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 13
SAFETY INFORMATION G G Do not run engine in poorly ventilated or partially enclosed areas such as barns, garages, or carports. Do not run engine outdoors where engine exhaust can be drawn into a building through openings such as windows and doors. Maximum load: XVS65ATZ 200 kg (441 lb) XVS65ATZC - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 14
SAFETY INFORMATION Many companies with no connection to Yamaha manufacture parts and accessories or offer other modifications for Yamaha vehicles. Yamaha is not in a position to test the products that these aftermarket companies produce. Therefore, Yamaha can neither endorse nor recommend the use of - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 15
DESCRIPTION EAU10410 Left view 3 1. 2. 3. 4. 5. 6. 7. Shift pedal (page 4-5) Fuel cock (page 4-9) Starter (choke) knob (page 4-10) Shock absorber assembly spring preload adjusting ring (page 4-14) Helmet holder (page 4-13) Owner's tool kit (page 7-2) Storage compartment (page 4-13) 3-1 - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 16
DESCRIPTION EAU10420 Right view 3 1. 2. 3. 4. 5. 6. Engine oil filter element (page 7-11) Battery (page 7-30) Fuses (page 7-31) Main switch/steering lock (page 4-1) Air filter element (page 7-14) Brake pedal (page 4-6) 3-2 - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 17
DESCRIPTION EAU10430 Controls and instruments 3 1. 2. 3. 4. 5. 6. 7. Clutch lever (page 4-4) Left handlebar switches (page 4-3) Speedometer unit (page 4-3) Fuel tank cap (page 4-6) Right handlebar switches (page 4-3) Throttle grip (page 7-16) Brake lever (page 4-5) 3-3 - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 18
INSTRUMENT AND CONTROL FUNCTIONS EAU10460 EAU10661 Main switch/steering lock OFF All electrical systems are off. The key can be removed. EWA10061 To lock the steering WARNING Never turn the key to "OFF" or "LOCK" while the vehicle is moving. Otherwise the electrical systems will be switched off, - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 19
indicator light " " This indicator light comes on when the transmission is in the neutral position. Engine trouble warning light " " This warning light comes on or flashes if a problem is detected in the electrical circuit monitoring the engine. If this occurs, have a Yamaha dealer check the - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 20
Speedometer unit Self-diagnosis device This model is equipped with a self-diagnosis device for various electrical circuits. If a problem is detected in any of those circuits, the engine trouble warning light will come on or flash. If this occurs, have a Yamaha dealer check the vehicle. Handlebar - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 21
15 seconds. However, the turn signal lights can also be canceled manually by pushing the switch in after it has returned to the center position switch to crank the engine with the starter. See page 6-1 for starting instructions prior to starting the engine. 1. Clutch lever The clutch lever is - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 22
INSTRUMENT AND CONTROL FUNCTIONS EAU12870 EAU12880 EAU12890 Shift pedal (XVS65Z) Shift pedal (XVS65AZ/XVS65ATZ) Brake lever 4 1. Shift pedal 2. Neutral position 1. Brake lever 1. Shift pedal 2. Neutral position The shift pedal is located on the left side of the engine and is used in combination - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 23
INSTRUMENT AND CONTROL FUNCTIONS EAU12941 EAU13121 Brake pedal XVS65Z Fuel tank cap 2. Turn the key counterclockwise to the original position, remove it, and then close the lock cover. TIP The fuel tank cap cannot be installed unless the key is in the lock. In addition, the key cannot be removed - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 24
WARNING Gasoline and gasoline vapors are extremely flammable. To avoid fires and explosions and to reduce the risk of injury when refueling, follow these instructions. 1. Before refueling, turn off the engine and be sure that no one is sitting on the vehicle. Never refuel while smoking, or while in - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 25
E10). Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. EAU13445 ECA10701 Catalytic converters This vehicle is equipped with catalytic converters in the exhaust system. EWA10862 NOTICE Use only unleaded gasoline - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 26
INSTRUMENT AND CONTROL FUNCTIONS EAU13550 Fuel cock The fuel cock supplies fuel from the tank to the carburetors while also filtering it. The fuel cock lever positions are explained as follows and shown in the illustrations. OFF 4 ON This indicates reserve. With the fuel cock lever in this - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 27
INSTRUMENT AND CONTROL FUNCTIONS EAU13620 EAU14184 Starter (choke) knob " " Seats (XVS65Z) Passenger seat To remove the passenger seat Remove the nut and washer, and then pull the passenger seat up. Tightening torque: Passenger seat nut: 13 Nm (1.3 m·kgf, 9.4 ft·lbf) 4 1. Starter (choke) knob " - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 28
INSTRUMENT AND CONTROL FUNCTIONS 2. Install the passenger seat holder by installing its bolts. 3. Install the passenger seat. TIP Make sure that the seats are properly secured before riding. EAU14192 Seats (XVS65AZ/XVS65ATZ) Passenger seat To remove the passenger seat Remove the nut and washer, and - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 29
INSTRUMENT AND CONTROL FUNCTIONS Tightening torque: Passenger seat nut: 13 Nm (1.3 m·kgf, 9.4 ft·lbf) 2. Install the passenger seat. TIP Make sure that the seats are properly secured before riding. 1. Bolt 4 1. Passenger seat holder 2. Projection Rider seat To remove the rider seat 1. Remove - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 30
INSTRUMENT AND CONTROL FUNCTIONS EAU14282 EAU14481 Helmet holder Storage compartment The storage compartment is located on the left side of the vehicle. To open the storage compartment 1. Slide the lock cover open, insert the key into the lock, and then turn it clockwise. 4 1. Helmet holder 2. - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 31
. G Do not dispose of a damaged or worn-out shock absorber assembly yourself. Take the shock absorber assembly to a Yamaha dealer for any service. 4 This shock absorber assembly is equipped with a spring preload adjusting ring. ECA10101 NOTICE To avoid damaging the mechanism, do not attempt to - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 32
INSTRUMENT AND CONTROL FUNCTIONS EAU15151 EAU15303 Luggage strap holders Sidestand The sidestand is located on the left side of the frame. Raise the sidestand or lower it with your foot while holding the vehicle upright. TIP The built-in sidestand switch is part of the ignition circuit cut-off - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 33
INSTRUMENT AND CONTROL FUNCTIONS EAU15314 Ignition circuit cut-off system The ignition circuit cut-off system (comprising the sidestand switch, clutch switch and neutral switch) has the following functions. G It prevents starting when the transmission is in gear and the sidestand is up, but the - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 34
INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is set to " 3. Turn the key on. 4. Shift the transmission into the neutral position. 5. Push the start switch. Does the engine start? WARNING ". If a malfunction is - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 35
inspection and maintenance procedures and schedules described in the Owner's Manual. EWA11151 WARNING Failure to inspect or maintain the vehicle operate the vehicle if you find any problem. If a problem cannot be corrected by the procedures provided in this manual, have the vehicle inspected by a - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 36
FOR YOUR SAFETY - PRE-OPERATION CHECKS ITEM Check operation. Lubricate cable if necessary. Check lever free play. Adjust if necessary. CHECKS PAGE Clutch 7-20 Throttle grip • Make sure that operation is smooth. • Check cable free play. • If necessary, have Yamaha dealer adjust cable free play - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 37
OPERATION AND IMPORTANT RIDING POINTS EAU15951 EAU15997 Read the Owner's Manual carefully to become familiar with all controls. If there is a control or function you do not understand, ask your Yamaha dealer. EWA10271 Starting and warming - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 38
OPERATION AND IMPORTANT RIDING POINTS (choke) turned on, then about 2.5 minutes with the starter (choke) in the halfway position. EAU16640 EAU16671 Starting a warm engine Follow the same procedure as for starting a cold engine with the exception that the starter (choke) is not required when the - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 39
OPERATION AND IMPORTANT RIDING POINTS Shifting gears lets you control the amount of engine power available for starting off, accelerating, climbing hills, etc. The gear positions are shown in the illustration. TIP To shift the transmission into the neutral position, press the shift pedal down - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 40
prolonged operation above 1/2 throttle. 1600 km (1000 mi) and beyond The vehicle can now be operated normally. ECA10270 NOTICE If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. 6 0-1000 km (0-600 mi) Avoid prolonged operation - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 41
OPERATION AND IMPORTANT RIDING POINTS EAU17181 Parking When parking, stop the engine, remove the key from the main switch, and then turn the fuel cock lever to "OFF". EWA10311 WARNING G G G Since the engine and exhaust system can become very hot, park in a place where pedestrians or children - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 42
has moving parts that can catch on body parts or clothing and electrical parts that can cause shocks or fires. Running the engine while servicing can lead to eye injury, burns, fire, or carbon monoxide poisoning - possibly leading to death. See page 2-1 for more information about carbon monoxide - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 43
EAU17451 Owner's tool kit 1. Owner's tool kit The owner's tool kit is located inside the storage compartment. (See page 4-13.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 44
speed 7 5 * 6 * 7 * 8 * Exhaust system Evaporative emission control system (for California only) 9 * √ √ * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 7-3 - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 45
PERIODIC MAINTENANCE AND ADJUSTMENT EAU32185 General maintenance and lubrication chart INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 46
PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 9 * Swingarm pivot bearings • - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 47
* Throttle grip housing and cable √ √ √ √ √ 26 * Lights, signals and switches √ √ √ √ √ * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 7-6 - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 48
months, repeat the maintenance intervals starting from 8000 mi (13000 km) or 12 months. EAU17620 TIP G G The air filter needs more frequent service if you are riding in unusually wet or dusty areas. Hydraulic brake system • When disassembling the master cylinder or caliper cylinder, always replace - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 49
PERIODIC MAINTENANCE AND ADJUSTMENT EAU18771 Removing and installing panels The panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a panel needs to be removed and installed. XVS65Z XVS65AZ/XVS65ATZ XVS65Z 1. Panel A - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 50
the same color. TIP If any spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 1. Spark plug cap 2. Remove the spark plug as shown, with the spark plug wrench - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 51
PERIODIC MAINTENANCE AND ADJUSTMENT 3. Check each spark plug for electrode erosion and excessive carbon or other deposits, and replace it if necessary. Specified spark plug: NGK/DPR7EA-9 DENSO/X22EPR-U9 2. Clean the surface of the spark plug gasket and its mating surface, and then wipe off any - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 52
PERIODIC MAINTENANCE AND ADJUSTMENT EAU19744 Engine oil and oil filter element The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil filter element replaced at the intervals specified in the periodic maintenance and lubrication chart. To check the - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 53
PERIODIC MAINTENANCE AND ADJUSTMENT Tightening torque: Engine oil drain bolt: 43 Nm (4.3 m·kgf, 31 ft·lbf) 9. Refill with the specified amount of the recommended oil, and then install and tighten the oil filler cap. Recommended engine oil: See page 9-1. Oil quantity: Without oil filter element - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 54
PERIODIC MAINTENANCE AND ADJUSTMENT er quality than specified. In addition, do not use oils labeled "ENERGY CONSERVING II" or higher. Make sure that no foreign material enters the crankcase. EAU20024 Final gear oil The final gear case must be checked for oil leakage before each ride. If any leakage - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 55
PERIODIC MAINTENANCE AND ADJUSTMENT Tightening torque: Final gear oil filler bolt: 23 Nm (2.3 m·kgf, 17 ft·lbf) 5. Install the oil filler bolt, and then tighten it to the specified torque. Tightening torque: Final gear oil filler bolt: 23 Nm (2.3 m·kgf, 17 ft·lbf) EAU33383 Cleaning the air filter - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 56
PERIODIC MAINTENANCE AND ADJUSTMENT TIP If dust or water collects in the air filter check hose, remove the clamp from it, and then remove the plug to drain the hose. 1. Air filter element 7 4. Insert the air filter element into the air filter case as shown. NOTICE: Make sure that the air filter - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 57
PERIODIC MAINTENANCE AND ADJUSTMENT EAU21271 EAU44734 EAU21382 Carburetors The carburetors are important parts of the engine and emission control system, which require very sophisticated adjustment. Therefore, all carburetor adjustments should be left to a Yamaha dealer, who has the necessary - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 58
PERIODIC MAINTENANCE AND ADJUSTMENT EAU21401 EAU32521 Valve clearance The valve clearance changes with use, resulting in improper air-fuel mixture and/or engine noise. To prevent this from occurring, the valve clearance must be adjusted by a Yamaha dealer at the intervals specified in the periodic - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 59
PERIODIC MAINTENANCE AND ADJUSTMENT EWA10511 Tire air pressure (measured on cold tires): XVS65AZ 0-90 kg (0-198 lb): Front: 225 kPa (2.25 kgf/cm², 33 psi) Rear: 225 kPa (2.25 kgf/cm², 33 psi) 90-200 kg (198-441 lb): Front: 225 kPa (2.25 kgf/cm², 33 psi) Rear: 250 kPa (2.50 kgf/cm², 36 psi) XVS65AZC - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 60
PERIODIC MAINTENANCE AND ADJUSTMENT EWA10461 Minimum tire tread depth (front and rear): 1.0 mm (0.04 in) EWA10560 WARNING The front and rear tires should be of the same make and design, otherwise the handling characteristics of the vehicle may be different, which could lead to an accident. After - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 61
PERIODIC MAINTENANCE AND ADJUSTMENT EAU21940 EAU22043 Rear tire: Size: 170/80-15M/C 77S Manufacturer/model: XVS65ATZ BRIDGESTONE/EXEDRA G702 XVS65ATZC BRIDGESTONE/EXEDRA G702 XVS65AZ BRIDGESTONE/EXEDRA G702 XVS65AZC BRIDGESTONE/EXEDRA G702 XVS65Z BRIDGESTONE/EXEDRA G546 XVS65ZC BRIDGESTONE/EXEDRA - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 62
PERIODIC MAINTENANCE AND ADJUSTMENT The clutch lever free play should measure XVS65ATZ 5.0-10.0 mm (0.20-0.39 in) XVS65ATZC 5.0-10.0 mm (0.20-0.39 in) XVS65AZ 5.0-10.0 mm (0.20-0.39 in) XVS65AZC 5.0-10.0 mm (0.20-0.39 in) XVS65Z 10.0-15.0 mm (0.39-0.59 in) XVS65ZC 10.0-15.0 mm (0.39-0.59 in) as - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 63
PERIODIC MAINTENANCE AND ADJUSTMENT EAU22093 Adjusting the brake lever free play G 1. Locknut 2. Brake lever free play adjusting screw 1. Brake lever free play A soft or spongy feeling in the brake lever can indicate the presence of air in the hydraulic system. If there is air in the hydraulic - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 64
PERIODIC MAINTENANCE AND ADJUSTMENT EAU22231 EWA10670 Adjusting the brake pedal position and free play XVS65Z WARNING It is advisable to have a Yamaha dealer make these adjustments. TIP The brake pedal position should be adjusted before adjusting the brake pedal free play. Brake pedal position The - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 65
PERIODIC MAINTENANCE AND ADJUSTMENT To increase the brake pedal free play, turn the adjusting nut at the brake rod in direction (a). To decrease the brake pedal free play, turn the adjusting nut in direction (b). EAU22272 EAU22380 Adjusting the rear brake light switch Checking the front brake pads - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 66
PERIODIC MAINTENANCE AND ADJUSTMENT indicator grooves have almost disappeared, have a Yamaha dealer replace the brake pads as a set. EAU22540 EAU32344 Checking the brake fluid level G Rear brake shoes Use only the recommended quality brake fluid, otherwise the rubber seals may deteriorate, - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 67
PERIODIC MAINTENANCE AND ADJUSTMENT EAU22721 EAU23093 EAU23111 Changing the brake fluid Have a Yamaha dealer change the brake fluid at the intervals specified in the TIP after the periodic maintenance and lubrication chart. In addition, have the oil seals of the brake master cylinder and caliper as - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 68
PERIODIC MAINTENANCE AND ADJUSTMENT EAU44271 EAU23142 Checking and lubricating the brake and shift pedals Recommended lubricant: Lithium-soap-based grease Checking and lubricating the brake and clutch levers Brake lever Clutch lever 7 The operation of the brake and shift pedals should be - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 69
PERIODIC MAINTENANCE AND ADJUSTMENT EAU23202 EAUM1650 Recommended lubricants: Brake lever: Silicone grease Clutch lever: Lithium-soap-based grease Checking and lubricating the sidestand Lubricating the swingarm pivots The swingarm pivots must be lubricated at the intervals specified in the - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 70
ground. (See page 7-34 for more information.) WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over. [EWA10751] 2. and hold it in an upright position. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over. [EWA10751] - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 71
PERIODIC MAINTENANCE AND ADJUSTMENT EAU23290 EAU23385 EWA10760 Checking the wheel bearings The front and rear wheel bearings must be checked at the intervals specified in the periodic maintenance and lubrication chart. If there is play in the wheel hub or if the wheel does not turn smoothly, have a - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 72
PERIODIC MAINTENANCE AND ADJUSTMENT G KEEP THIS AND ALL BATTERIES OUT OF THE REACH OF CHILDREN. battery, be sure the key is turned to "OFF", then disconnect the negative lead before disconnecting the positive lead. [ECA16302] EAU23526 Replacing the fuses To charge the battery Have a Yamaha - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 73
PERIODIC MAINTENANCE AND ADJUSTMENT avoid causing extensive damage to the electrical system and possibly a fire. [EWA15131] EAU23795 Specified fuses: Main fuse: 30.0 A Signaling system fuse: 10.0 A Ignition fuse: 10.0 A Headlight fuse: 15.0 A Carburetor heater fuse: 15.0 A Ignitor unit fuse: 5.0 A - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 74
PERIODIC MAINTENANCE AND ADJUSTMENT 5. Install the headlight bulb cover, and then connect the coupler. 6. Install the headlight unit by installing the screws. 7. Have a Yamaha dealer adjust the headlight beam if necessary. 1. Do not touch the glass part of the bulb. 1. Remove the headlight unit by - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 75
the lens by removing the screws. XVS65AZ/XVS65ATZ EAU24350 Supporting the motorcycle Since this model is not equipped with a wheel. 2. Raise the front wheel off the ground by using a motorcycle stand. To service the rear wheel Raise the rear wheel off the ground by using a motorcycle stand or - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 76
rear wheel or under each side of the swingarm. EAU24360 Front wheel EAU24601 To remove the front wheel EWA10821 WARNING To avoid injury, securely support the vehicle so there is no danger of it falling over. 1. Disconnect the speedometer cable from the front wheel. 1. Wheel axle 2. Front wheel - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 77
torque. Tightening torque: Front wheel axle pinch bolt: 20 Nm (2.0 m·kgf, 14 ft·lbf) To remove the rear wheel EWA10821 WARNING To avoid injury, securely support the vehicle so there is no danger of it falling over. 1. Loosen the axle nut. 7. While applying the front brake, push down hard on the - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 78
axle, final gear case, and drive shaft by pushing the wheel forward and guiding the drive shaft into the middle gear universal joint. 1. Bolt 2. Final , wheel axle, final gear case, and drive shaft. TIP Make sure to support the drive shaft as it is being pulled out. 1. Middle gear universal joint - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 79
EAU25851 Troubleshooting Although Yamaha motorcycles receive a thorough inspection before shipment from the factory, trouble may occur during operation. Any problem in the parts, but they are often inferior, have a shorter service life and can lead to expensive repair bills. EWA15141 heaters - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 80
PERIODIC MAINTENANCE AND ADJUSTMENT EAU25892 Troubleshooting chart 1. Fuel There is enough fuel. Check the fuel level in the fuel tank. There is no fuel. Supply fuel. Check the compression. The engine - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 81
spoked wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. Improper cleaning can damage plastic parts (such - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 82
MOTORCYCLE CARE AND STORAGE off any detergent residue using plenty of water, as it is harmful to plastic parts. Do not use any harsh chemical products on plastic parts. Be sure to avoid using cloths or sponges which have been in contact with strong or abrasive cleaning products, solvent or thinner, - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 83
of the presence of ammonia) and areas where strong chemicals are stored. 8 Long-term Before storing your motorcycle for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. For motorcycles equipped with a fuel cock that has an "OFF" position: Turn the fuel cock - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 84
MOTORCYCLE CARE AND STORAGE 3. Drain the carburetor float chambers by loosening the drain bolts; this will prevent fuel deposits from building up. Pour the drained fuel into the fuel tank. 4. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from rusting and the - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 85
: 649 cm³ Bore × stroke: 81.0 × 63.0 mm (3.19 × 2.48 in) Compression ratio: 9.00 :1 Starting system: Electric starter Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter element replacement: 2.60 L (2.75 US qt, 2.29 Imp.qt) With oil - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 86
SPECIFICATIONS Air filter: Air filter element: Dry element Operation: Left foot operation Gear ratio: 1st: 38/14 (2.714) 2nd: 38/20 (1.900) 3rd: 35/24 (1.458) 4th: 28/24 (1.167) 5th: 29/30 (0.967) XVS65AZC 130/90-16M/C 67S XVS65Z 100/90-19M/C 57S XVS65ZC 100/90-19M/C 57S Manufacturer/model: XVS65ATZ - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 87
SPECIFICATIONS Manufacturer/model: XVS65ATZ BRIDGESTONE/EXEDRA G702 XVS65ATZC BRIDGESTONE/EXEDRA G702 XVS65AZ BRIDGESTONE/EXEDRA G702 XVS65AZC BRIDGESTONE/EXEDRA G702 XVS65Z BRIDGESTONE/EXEDRA G546 XVS65ZC BRIDGESTONE/EXEDRA G546 Manufacturer/model: XVS65ATZ DUNLOP/D404G XVS65ATZC DUNLOP/D404G - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 88
mm (3.39 in) Neutral indicator light: 12 V, 1.7 W × 1 High beam indicator light: 12 V, 1.7 W × 1 Turn signal indicator light: 12 V, 1.7 W × 1 Engine trouble warning light: 12 V, 1.7 W × 1 Fuses: Main fuse: 30.0 A Headlight fuse: 15.0 A Signaling system fuse: 10.0 A Ignition fuse: 10.0 A Carburetor - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 89
CONSUMER INFORMATION EAU26352 EAU26381 EAU26400 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 90
CONSUMER INFORMATION EAU26470 EAU48060 Model label Vehicle Emission Control Information label 1. Model label 1 1. Vehicle Emission Control Information label The model label is affixed to the frame under the rider seat. (See page 4-10.) Record the information on this label in the space provided. - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 91
that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327 - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 92
CONSUMER INFORMATION EAU26560 Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 93
months 24000 mi (37000 km) or 36 months 28000 mi (43000 km) or 42 months 32000 mi (49000 km) or 48 months 10-5 Date of service Mileage Servicing dealer name and address Remarks 10 - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 94
CONSUMER INFORMATION Maintenance interval 36000 mi (55000 km) or 54 months 40000 mi (61000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 10 10-6 - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 95
1. Operate and maintain the motorcycle as specified in the appropriate Owner's Manual, and 2. Give notice to an authorized Yamaha motorcycle dealer of any . An inspection and registration fee will be charged for this service. EMISSION CONTROL SYSTEM WARRANTY: Yamaha Motor Corporation, U.S.A. also - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 96
in the Owner's and Service Manual. We do recommend, however service, you must take it to any authorized Yamaha motorcycle dealer within the continental United States. Be sure to bring your warranty registration card or other valid proof of the original date of purchase. If a question or problem - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 97
no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 98
isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 10 10-10 - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 99
Steering, checking ...7-29 Storage ...8-3 Storage compartment ...4-13 Supporting the motorcycle ...7-34 Swingarm pivots, lubricating ...7-28 element...7-11 Engine, starting a warm...6-2 Engine stop switch...4-4 Engine trouble warning light ...4-2 T Throttle cable free play, checking ...7-16 - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 100
INDEX Troubleshooting ...7-38 Troubleshooting chart ...7-39 Turn signal indicator light ...4-2 Turn signal light bulb or tail/brake light bulb, replacing ...7-34 Turn signal switch ...4-4 V Valve clearance ...7-17 Vehicle Emission - 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 101
- 2010 Yamaha Motorsports V Star Classic | Owners Manual - Page 102
YAMAHA MOTOR CO., LTD. PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2009.05-1.8×1 CR (E)
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
 |
 |
1BF-28199-10
XVS65Z(C)
XVS65AZ(C)
XVS65ATZ(C)
OWNER’S MANUAL
Read this manual carefully before operating this vehicle.
LIT-11626-23-20