2009 Yamaha Motorsports V Star Silverado Owners Manual

2009 Yamaha Motorsports V Star Silverado Manual

Get 2009 Yamaha Motorsports V Star Silverado PDF manuals and user guides View all 2009 Yamaha Motorsports V Star Silverado manuals

2009 Yamaha Motorsports V Star Silverado manual content summary:

  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 1
    OWNER'S MANUAL XVS65Y(C) XVS65AY(C) XVS65ATY(C) LIT-11626-22-20 3B6-28199-13
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 2
    EAU10042 Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold.
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 3
    Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. Yamaha continually seeks advancements in product design and quality. Therefore, while this manual contains the most current product information available at the time of
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 4
    INFORMATION EAU10132 Particularly important information is distinguished in this manual by the following notations: This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 5
    INFORMATION EAU10193 XVS65Y(C)/XVS65AY(C)/XVS65ATY(C) OWNER'S MANUAL ©2008 by Yamaha Motor Corporation, U.S.A. 1st edition, March 2008 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A.
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 6
    TABLE OF CONTENTS LOCATION OF IMPORTANT LABELS ...1-1 SAFETY INFORMATION ...2-1 DESCRIPTION ...3-1 Left view ...3-1 Right view ...3-2 Controls and instruments...3-3 INSTRUMENT AND CONTROL FUNCTIONS ...4-1 Main switch/steering lock ...4-1 Indicator and warning lights ...4-2 Speedometer unit ...4-3
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 7
    tail/brake light bulb ...7-33 Supporting the motorcycle ...7-34 Front wheel ...7-34 Rear wheel ...7-36 Troubleshooting ...7-37 Troubleshooting chart ...7-39 MOTORCYCLE CARE AND STORAGE CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...10-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...10-9
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 8
    LOCATION OF IMPORTANT LABELS EAU10382 1 Read and understand all of the labels on your vehicle. They contain important information for safe and proper operation of your vehicle. Never remove any labels from your vehicle. If a label becomes difficult to read or comes off, a replacement label is
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 9
    LOCATION OF IMPORTANT LABELS 1 3 XVS65AY/ATY 1 2 4 3 XVS65Y 5FB-21668-01 1-2
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 10
    LOCATION OF IMPORTANT LABELS 5 1 A1 6 California only 1-3
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 11
    should: G Obtain thorough instructions from a competent source on all aspects of motorcycle operation. G Observe the warnings and maintenance requirements in this Owner's Manual. G Obtain qualified training in safe and proper riding techniques. G Obtain professional technical service as indicated in
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 12
    SAFETY INFORMATION due to excessive speed or undercornering (insufficient lean angle for the speed). • Always obey the speed limit and never travel faster than warranted by road and traffic conditions. • Always signal before turning or changing lanes. Make sure that other motorists can see you. The
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 13
    SAFETY INFORMATION G G Do not run engine in poorly ventilated or partially enclosed areas such as barns, garages, or carports. Do not run engine outdoors where engine exhaust can be drawn into a building through openings such as windows and doors. Maximum load: XVS65ATY 200 kg (441 lb) XVS65ATYC
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 14
    SAFETY INFORMATION Many companies with no connection to Yamaha manufacture parts and accessories or offer other modifications for Yamaha vehicles. Yamaha is not in a position to test the products that these aftermarket companies produce. Therefore, Yamaha can neither endorse nor recommend the use of
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 15
    DESCRIPTION EAU10410 Left view 3 1. 2. 3. 4. 5. 6. 7. Shift pedal (page 4-5) Fuel cock (page 4-9) Starter (choke) knob (page 4-10) Shock absorber assembly spring preload adjusting ring (page 4-14) Helmet holder (page 4-13) Owner's tool kit (page 7-2) Storage compartment (page 4-13) 3-1
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 16
    DESCRIPTION EAU10420 Right view 3 1. 2. 3. 4. 5. 6. Engine oil filter element (page 7-11) Battery (page 7-30) Fuses (page 7-31) Main switch/steering lock (page 4-1) Air filter element (page 7-14) Brake pedal (page 4-6) 3-2
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 17
    DESCRIPTION EAU10430 Controls and instruments 3 1. 2. 3. 4. 5. 6. 7. Clutch lever (page 4-4) Left handlebar switches (page 4-3) Speedometer unit (page 4-3) Fuel tank cap (page 4-6) Right handlebar switches (page 4-3) Throttle grip (page 7-16) Brake lever (page 4-5) 3-3
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 18
    INSTRUMENT AND CONTROL FUNCTIONS EAU10460 EAU10661 Main switch/steering lock OFF All electrical systems are off. The key can be removed. EWA10061 To lock the steering WARNING Never turn the key to "OFF" or "LOCK" while the vehicle is moving. Otherwise the electrical systems will be switched off,
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 19
    EAU11020 Turn signal indicator light " " This indicator light flashes when the turn signal switch is pushed to the left or right. EAU11060 Engine trouble warning light " " This warning light comes on or flashes if an electrical circuit monitoring the engine is not working correctly. If this occurs
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 20
    model is equipped with a self-diagnosis device for various electrical circuits. If any of those circuits are not working correctly, the engine trouble warning light will come on or flash. If this occurs, have a Yamaha dealer check the vehicle. Handlebar switches Left 4 1. 2. 3. 4. Tripmeter reset
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 21
    15 seconds. However, the turn signal lights can also be canceled manually by pushing the switch in after it has returned to the center position switch to crank the engine with the starter. See page 6-1 for starting instructions prior to starting the engine. 1. Clutch lever The clutch lever is
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 22
    INSTRUMENT AND CONTROL FUNCTIONS EAU12870 EAU12880 EAU12890 Shift pedal (XVS65Y) Shift pedal (XVS65AY/ATY) Brake lever 4 1. Shift pedal 1. Shift pedal 1. Brake lever The shift pedal is located on the left side of the engine and is used in combination with the clutch lever when shifting the
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 23
    INSTRUMENT AND CONTROL FUNCTIONS EAU12941 EAU13121 Brake pedal XVS65Y Fuel tank cap TIP The fuel tank cap cannot be installed unless the key is in the lock. In addition, the key cannot be removed if the cap is not properly installed and locked. EWA10131 WARNING Make sure that the fuel tank cap
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 24
    WARNING Gasoline and gasoline vapors are extremely flammable. To avoid fires and explosions and to reduce the risk of injury when refueling, follow these instructions. 1. Before refueling, turn off the engine and be sure that no one is sitting on the vehicle. Never refuel while smoking, or while in
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 25
    E10). Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. EAU13444 ECA10701 Catalytic converters This vehicle is equipped with catalytic converters in the exhaust system. EWA10861 NOTICE Use only unleaded gasoline
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 26
    INSTRUMENT AND CONTROL FUNCTIONS EAU13550 Fuel cock The fuel cock supplies fuel from the tank to the carburetors while also filtering it. The fuel cock lever positions are explained as follows and shown in the illustrations. OFF 4 ON This indicates reserve. With the fuel cock lever in this
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 27
    INSTRUMENT AND CONTROL FUNCTIONS EAU13620 EAU14184 Starter (choke) knob " " Seats (XVS65Y) Passenger seat To remove the passenger seat Remove the nut and washer, and then pull the passenger seat up. Tightening torque: Passenger seat nut: 13 Nm (1.3 m·kgf, 9.4 ft·lbf) 4 1. Starter (choke) knob "
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 28
    INSTRUMENT AND CONTROL FUNCTIONS 2. Install the passenger seat holder by installing its bolts. 3. Install the passenger seat. TIP Make sure that the seats are properly secured before riding. EAU14192 Seats (XVS65AY/ATY) Passenger seat To remove the passenger seat Remove the nut and washer, and then
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 29
    INSTRUMENT AND CONTROL FUNCTIONS Tightening torque: Passenger seat nut: 13 Nm (1.3 m·kgf, 9.4 ft·lbf) 2. Install the passenger seat. TIP Make sure that the seats are properly secured before riding. 1. Bolt 4 1. Seat holder 2. Projection Rider seat To remove the rider seat 1. Remove the
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 30
    INSTRUMENT AND CONTROL FUNCTIONS EAU14282 EAU14481 Helmet holder Storage compartment The storage compartment is located on the left side of the vehicle. To open the storage compartment 1. Slide the lock cover open, insert the key into the lock, and then turn it clockwise. 4 1. Helmet holder 2.
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 31
    INSTRUMENT AND CONTROL FUNCTIONS EAU14862 Adjusting the shock absorber assembly 1. 2. 3. 4. Position indicator Spring preload adjusting ring Extension bar Special wrench 2. To increase the spring preload and thereby harden the suspension, turn the adjusting ring in direction (a). To decrease the
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 32
    INSTRUMENT AND CONTROL FUNCTIONS EAU15301 Sidestand The sidestand is located on the left side of the frame. Raise the sidestand or lower it with your foot while holding the vehicle upright. TIP The built-in sidestand switch is part of the ignition circuit cut-off system, which cuts the ignition in
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 33
    INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is turned on. 3. Turn the key on. 4. Shift the transmission into the neutral position. 5. Push the start switch. Does the engine start? WARNING If a malfunction is noted
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 34
    increases the possibility of an accident or equipment damage. Do not operate the vehicle if you find any problem. If a problem cannot be corrected by the procedures provided in this manual, have the vehicle inspected by a Yamaha dealer. Before using this vehicle, check the following points: 5 5-1
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 35
    FOR YOUR SAFETY - PRE-OPERATION CHECKS EAU15605 Pre-operation check list ITEM Fuel • Check fuel level in fuel tank. • Refuel if necessary. • Check fuel line for leakage. • Check oil level in engine. • If necessary, add recommended oil to specified level. • Check vehicle for oil leakage. • Check
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 36
    FOR YOUR SAFETY - PRE-OPERATION CHECKS ITEM CHECKS Check for damage. Check tire condition and tread depth. Check air pressure. Correct if necessary. PAGE Wheels and tires 7-17, 7-20 Brake and shift pedals Brake and clutch levers Sidestand Chassis fasteners • Make sure that operation is smooth.
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 37
    AND IMPORTANT RIDING POINTS EAU15951 EAU16392 Read the Owner's Manual carefully to become familiar with all controls. If key is turned to "ON", and then go off after a few seconds. If the engine trouble warning light comes on or flashes after starting, immediately stop the engine, and have a Yamaha
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 38
    OPERATION AND IMPORTANT RIDING POINTS EAU16640 EAU16671 6 TIP The engine is warm when it responds normally to the throttle with the starter (choke) turned off. To avoid the possibility of excessive exhaust emissions, never leave the starter (choke) on longer than necessary. The time necessary for
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 39
    OPERATION AND IMPORTANT RIDING POINTS Shifting gears lets you control the amount of engine power available for starting off, accelerating, climbing hills, etc. The gear positions are shown in the illustration. TIP To shift the transmission into the neutral position, press the shift pedal down
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 40
    overheating must be avoided. EAU17042 1600 km (1000 mi) and beyond The vehicle can now be operated normally. ECA10270 NOTICE If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. 6 0-1000 km (0-600 mi) Avoid prolonged operation
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 41
    OPERATION AND IMPORTANT RIDING POINTS EAU17181 Parking When parking, stop the engine, remove the key from the main switch, and then turn the fuel cock lever to "OFF". EWA10311 WARNING G G G Since the engine and exhaust system can become very hot, park in a place where pedestrians or children
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 42
    has moving parts that can catch on body parts or clothing and electrical parts that can cause shocks or fires. Running the engine while servicing can lead to eye injury, burns, fire, or carbon monoxide poisoning - possibly leading to death. See page 2-1 for more information about carbon monoxide
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 43
    EAU17451 Owner's tool kit 1. Owner's tool kit The owner's tool kit is located inside the storage compartment. (See page 4-13.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 44
    speed 7 5 * 6 * 7 * 8 * Exhaust system Evaporative emission control system (For California only) 9 * √ √ * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 7-3
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 45
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU32185 General maintenance and lubrication chart INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 46
    PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 9 * Swingarm pivot bearings •
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 47
    * Throttle grip housing and cable √ √ √ √ √ 26 * Lights, signals and switches √ √ √ √ √ * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 7-6
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 48
    months, repeat the maintenance intervals starting from 8000 mi (13000 km) or 12 months. EAU17620 TIP G G The air filter needs more frequent service if you are riding in unusually wet or dusty areas. Hydraulic brake system • When disassembling the master cylinder or caliper cylinder, always replace
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 49
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU18771 Removing and installing panels The panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a panel needs to be removed and installed. XVS65Y XVS65AY/ATY XVS65Y 1. Panel A 1.
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 50
    the same color. TIP If any spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 1. Spark plug cap 2. Remove the spark plug as shown, with the spark plug wrench
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 51
    PERIODIC MAINTENANCE AND ADJUSTMENT 3. Check each spark plug for electrode erosion and excessive carbon or other deposits, and replace it if necessary. Specified spark plug: NGK/DPR7EA-9 DENSO/X22EPR-U9 2. Clean the surface of the spark plug gasket and its mating surface, and then wipe off any
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 52
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU19744 Engine oil and oil filter element The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil filter element replaced at the intervals specified in the periodic maintenance and lubrication chart. To check the
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 53
    PERIODIC MAINTENANCE AND ADJUSTMENT Tightening torque: Engine oil drain bolt: 43 Nm (4.3 m·kgf, 31 ft·lbf) 9. Refill with the specified amount of the recommended oil, and then install and tighten the oil filler cap. Recommended engine oil: See page 9-1. Oil quantity: Without oil filter element
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 54
    PERIODIC MAINTENANCE AND ADJUSTMENT er quality than specified. In addition, do not use oils labeled "ENERGY CONSERVING II" or higher. Make sure that no foreign material enters the crankcase. EAU20023 Final gear oil The final gear case must be checked for oil leakage before each ride. If any leakage
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 55
    PERIODIC MAINTENANCE AND ADJUSTMENT 2. Remove the oil filler bolt and drain bolt to drain the oil from the final gear case. 3. Install the final gear oil drain bolt, and then tighten it to the specified torque. Tightening torque: Final gear oil drain bolt: 23 Nm (2.3 m·kgf, 17 ft·lbf) 6. Check the
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 56
    PERIODIC MAINTENANCE AND ADJUSTMENT TIP If dust or water collects in the air filter check hose, remove the clamp from it, and then remove the plug to drain the hose. 1. Air filter element 7 4. Insert the air filter element into the air filter case as shown. NOTICE: Make sure that the air filter
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 57
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU21271 EAU21311 EAU21382 Carburetors The carburetors are important parts of the engine and emission control system, which require very sophisticated adjustment. Therefore, all carburetor adjustments should be left to a Yamaha dealer, who has the necessary
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 58
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU21401 EAU32521 Valve clearance The valve clearance changes with use, resulting in improper air-fuel mixture and/or engine noise. To prevent this from occurring, the valve clearance must be adjusted by a Yamaha dealer at the intervals specified in the periodic
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 59
    PERIODIC MAINTENANCE AND ADJUSTMENT EWA10511 Tire air pressure (measured on cold tires): XVS65ATY 90-200 kg (198-441 lb) XVS65ATYC 90-198 kg (198-437 lb) XVS65AY 90-200 kg (198-441 lb) XVS65AYC 90-198 kg (198-437 lb) XVS65Y 90-180 kg (198-397 lb) XVS65YC 90-178 kg (198-392 lb): Front: XVS65ATY 225
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 60
    PERIODIC MAINTENANCE AND ADJUSTMENT EWA10461 WARNING The front and rear tires should be of the same make and design, otherwise the handling characteristics of the vehicle may be different, which could lead to an accident. After extensive tests, only the tires listed below have been approved for
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 61
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU21940 EAU22041 Spoke wheels To maximize the performance, durability, and safe operation of your motorcycle, note the following points regarding the specified wheels. G The wheel rims should be checked for cracks, bends or warpage, and the spokes for looseness
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 62
    PERIODIC MAINTENANCE AND ADJUSTMENT TIP If the specified clutch lever free play could be obtained as described above, tighten the locknut and skip the rest of the procedure, otherwise proceed as follows. 3. Fully turn the adjusting bolt at the clutch lever in direction (a) to loosen the clutch cable
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 63
    PERIODIC MAINTENANCE AND ADJUSTMENT G 1. Locknut 2. Brake lever free play adjusting screw A soft or spongy feeling in the brake lever can indicate the presence of air in the hydraulic system. If there is air in the hydraulic system, have a Yamaha dealer bleed the system before operating the
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 64
    PERIODIC MAINTENANCE AND ADJUSTMENT EWA10670 WARNING It is advisable to have a Yamaha dealer make these adjustments. TIP The brake pedal position should be adjusted before adjusting the brake pedal free play. Brake pedal position The brake pedal should be positioned approximately XVS65ATY 108.0 mm
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 65
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU22271 EAU22380 Adjusting the rear brake light switch Checking the front brake pads and rear brake shoes The front brake pads and the rear brake shoes must be checked for wear at the intervals specified in the periodic maintenance and lubrication chart.
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 66
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU32344 Checking the brake fluid level G Use only the recommended quality brake fluid, otherwise the rubber seals may deteriorate, causing leakage and poor braking performance. EAU22721 Changing the brake fluid Have a Yamaha dealer change the brake fluid at
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 67
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU23093 EAU23111 EAU44271 Checking and lubricating the cables The operation of all control cables and the condition of the cables should be checked before each ride, and the cables and cable ends should be lubricated if necessary. If a cable is damaged or does
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 68
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU23142 Recommended lubricant: Lithium-soap-based grease Checking and lubricating the brake and clutch levers Brake lever Recommended lubricants: Brake lever: Silicone grease Clutch lever: Lithium-soap-based grease Clutch lever 7 The operation of the brake
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 69
    oil leakage. To check the operation 1. Place the vehicle on a level surface and hold it in an upright position. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over. [EWA10751] 2. While applying the front brake, push down hard on the handlebars several
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 70
    lubrication chart. 1. Place a stand under the engine to raise the front wheel off the ground. (See page 7-1 for more information.) WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over. [EWA10751] 2. Hold the lower ends of the front fork legs and try to move
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 71
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU23383 EWA10760 Battery G WARNING Electrolyte is poisonous and dangerous since it contains sulfuric acid, which causes severe burns. Avoid any contact with skin, eyes or clothing and always shield your eyes when working near batteries. In case of contact,
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 72
    PERIODIC MAINTENANCE AND ADJUSTMENT 3. Fully charge the battery before installation. 4. After installation, make sure that the battery leads are properly connected to the battery terminals. ECA10631 EAU23526 Replacing the fuses avoid causing extensive damage to the electrical system and possibly a
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 73
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU23794 Specified fuses: Main fuse: 30.0 A Signaling system fuse: 10.0 A Ignition fuse: 10.0 A Headlight fuse: 15.0 A Carburetor heater fuse: 15.0 A Ignitor unit fuse: 5.0 A Replacing the headlight bulb This model is equipped with a quartz bulb headlight. If
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 74
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU24283 Replacing a turn signal light bulb or the tail/brake light bulb 1. Remove the lens by removing the screws. XVS65AY/ATY 1. Headlight bulb holder 1. Screw 7 4. Place a new headlight bulb into position, and then secure it with the bulb holder. 5.
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 75
    . 2. Raise the front wheel off the ground by using a motorcycle stand. To service the rear wheel Raise the rear wheel off the ground by using a motorcycle stand or To remove the front wheel EWA10821 WARNING To avoid injury, securely support the vehicle so there is no danger of it falling over.
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 76
    PERIODIC MAINTENANCE AND ADJUSTMENT 2. Lift the wheel up between the fork legs. TIP Make sure that there is enough space between the brake pads before inserting the brake disc and that the slot in the speedometer gear unit fits over the retainer on the fork leg. 1. Wheel axle 2. Front wheel axle
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 77
    bolts that secure the final gear case to the swingarm. 7. Lift the rear wheel off the ground according to the procedure on page 7-34. 8. While supporting the drive shaft, pull the rear wheel back to remove the following parts as an assembly: wheel, wheel axle, final gear case, and drive shaft
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 78
    shaft by pushing the wheel forward and guiding the drive shaft into the middle gear Troubleshooting Although Yamaha motorcycles receive a thorough inspection before shipment from the factory, trouble may occur during operation. Any problem often inferior, have a shorter service life and can lead to
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 79
    PERIODIC MAINTENANCE AND ADJUSTMENT heaters or furnaces. Gasoline or gasoline vapors can ignite or explode, causing severe injury or property damage. 7 7-38
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 80
    PERIODIC MAINTENANCE AND ADJUSTMENT EAU25892 Troubleshooting chart 1. Fuel There is enough fuel. Check the fuel level in the fuel tank. There is no fuel. Supply fuel. Check the compression. The engine
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 81
    spoked wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. Improper cleaning can damage plastic parts such
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 82
    MOTORCYCLE CARE AND STORAGE cleaning products, solvent or thinner, fuel (gasoline), rust removers or inhibitors, brake fluid, antifreeze or electrolyte. Do not use high-pressure washers or steam-jet cleaners since they cause water seepage and deterioration in the following areas: seals (of wheel and
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 83
    of the presence of ammonia) and areas where strong chemicals are stored. 8 Long-term Before storing your motorcycle for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. For motorcycles equipped with a fuel cock that has an "OFF" position: Turn the fuel cock
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 84
    MOTORCYCLE CARE AND STORAGE 3. Drain the carburetor float chambers by loosening the drain bolts; this will prevent fuel deposits from building up. Pour the drained fuel into the fuel tank. 4. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from rusting and the
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 85
    649.0 cm³ Bore × stroke: 81.0 × 63.0 mm (3.19 × 2.48 in) Compression ratio: 9.00 :1 Starting system: Electric starter Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter element replacement: 2.60 L (2.75 US qt, 2.29 Imp.qt) With oil
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 86
    SPECIFICATIONS Fuel: Recommended fuel: Unleaded gasoline only Fuel tank capacity: 16.0 L (4.23 US gal, 3.52 Imp.gal) Fuel reserve amount: 3.0 L (0.79 US gal, 0.66 Imp.gal) Operation: Left foot operation Gear ratio: 1st: 38/14 (2.714) 2nd: 38/20 (1.900) 3rd: 35/24 (1.458) 4th: 28/24 (1.167) 5th: 29/
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 87
    SPECIFICATIONS Manufacturer/model: XVS65ATY BRIDGESTONE/EXEDRA G702 XVS65ATYC BRIDGESTONE/EXEDRA G702 XVS65AY BRIDGESTONE/EXEDRA G702 XVS65AYC BRIDGESTONE/EXEDRA G702 XVS65Y BRIDGESTONE/EXEDRA G546 XVS65YC BRIDGESTONE/EXEDRA G546 Manufacturer/model: XVS65ATY DUNLOP/D404G XVS65ATYC DUNLOP/D404G
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 88
    lighting: 12 V, 1.7 W × 1 Neutral indicator light: 12 V, 1.7 W × 1 High beam indicator light: 12 V, 1.7 W × 1 Turn signal indicator light: 12 V, 1.7 W × 1 Engine trouble warning light: 12 V, 1.7 W × 1 Fuses: Main fuse: 30.0 A Headlight fuse: 15.0 A Signaling system fuse: 10.0 A Ignition fuse: 10
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 89
    CONSUMER INFORMATION EAU26351 EAU26381 EAU26400 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 90
    CONSUMER INFORMATION EAU26470 Model label 1. Model label The model label is affixed to the frame under the rider seat. (See page 4-10.) Record the information on this label in the space provided. This information will be needed when ordering spare parts from a Yamaha dealer. 10 10-2
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 91
    that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 92
    CONSUMER INFORMATION EAU26560 Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 93
    months 24000 mi (37000 km) or 36 months 28000 mi (43000 km) or 42 months 32000 mi (49000 km) or 48 months 10-5 Date of service Mileage Servicing dealer name and address Remarks 10
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 94
    CONSUMER INFORMATION Maintenance interval 36000 mi (55000 km) or 54 months 40000 mi (61000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 10 10-6
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 95
    1. Operate and maintain the motorcycle as specified in the appropriate Owner's Manual, and 2. Give notice to an authorized Yamaha motorcycle dealer of any . An inspection and registration fee will be charged for this service. EMISSION CONTROL SYSTEM WARRANTY: Yamaha Motor Corporation, U.S.A. also
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 96
    in the Owner's and Service Manual. We do recommend, however service, you must take it to any authorized Yamaha motorcycle dealer within the continental United States. Be sure to bring your warranty registration card or other valid proof of the original date of purchase. If a question or problem
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 97
    no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 98
    isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 10 10-10
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 99
    Steering, checking ...7-29 Storage ...8-3 Storage compartment ...4-13 Supporting the motorcycle ...7-34 Swingarm pivots, lubricating ...7-28 H element...7-11 Engine, starting a warm...6-2 Engine stop switch...4-4 Engine trouble warning light ...4-2 T Throttle cable free play, checking ...7-16
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 100
    INDEX Troubleshooting ...7-37 Troubleshooting chart ...7-39 Turn signal indicator light ...4-2 Turn signal light bulb or tail/brake light bulb, replacing...7-33 Turn signal switch ...4-4 V Valve clearance ...7-17 Vehicle identification
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 101
  • 2009 Yamaha Motorsports V Star Silverado | Owners Manual - Page 102
    YAMAHA MOTOR CO., LTD. PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2008.04-1.0×1 CR (E)
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
  • 93
  • 94
  • 95
  • 96
  • 97
  • 98
  • 99
  • 100
  • 101
  • 102
3B6-28199-13
XVS65Y(C)
XVS65AY(C)
XVS65ATY(C)
OWNER’S MANUAL
LIT-11626-22-20