2008 Yamaha Motorsports Vino 125 Owners Manual

2008 Yamaha Motorsports Vino 125 Manual

Get 2008 Yamaha Motorsports Vino 125 PDF manuals and user guides View all 2008 Yamaha Motorsports Vino 125 manuals

2008 Yamaha Motorsports Vino 125 manual content summary:

  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 1
    OWNER'S MANUAL YJ125X LIT-11626-21-54 5YR-F8199-14
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 2
    1 2 3 EAU10041 4 5 6 7 8 9
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 3
    of craftsmanship and reliability that have made Yamaha a leader in these fields. 1 This manual will give you an understanding of the operation, inspection, and basic maintenance of this to the recommended maintenance schedules and operating instructions contained within this manual. 2 3 4 5 6 7 8 9
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 4
    Particularly important information is distinguished in this manual by the following notations: EAU10122 EAU35821 Q 1 2 3 4 5 6 7 8 9 The Safety Alert Symbol means ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED! Failure to follow WARNING instructions could result in severe injury or death
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 5
    EAU10122 1 2 AFFIX DEALER LABEL HERE 3 4 5 EAUT2190 6 7 8 9 VINO125 OWNER'S MANUAL ©2007 by Yamaha Motor Corporation, U.S.A. 1st edition, July 2007 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A.
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 6
    ...6-23 Battery ...6-23 Replacing the fuse ...6-25 Replacing the headlight bulb ...6-25 Replacing the tail/brake light bulb 6-27 Replacing a turn signal light bulb . 6-27 Troubleshooting ...6-28 Troubleshooting chart ...6-29 SCOOTER CARE AND STORAGE ...7-1 Care ...7-1 Storage ...7-3
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 7
    ...8-1 CONSUMER INFORMATION ...9-1 Identification numbers ...9-1 Reporting safety defects ...9-3 Motorcycle noise regulation ...9-4 Maintenance record ...9-5 YAMAHA MOTOR CORPORATION, U.S.A. RIVA LIMITED WARRANTY ...9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...9-9 EAU10210 1 2 3 4 5 6 7 8 9
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 8
    SHOULD: 8 OBTAIN THOROUGH INSTRUCTIONS FROM A COMPETENT SOURCE ON ALL ASPECTS OF SCOOTER OPERATION. 8 OBSERVE THE WARNINGS AND MAINTENANCE REQUIREMENTS IN THE OWNER'S MANUAL. 8 OBTAIN QUALIFIED TRAINING IN SAFE AND PROPER RIDING TECHNIQUES. 8 OBTAIN PROFESSIONAL TECHNICAL SERVICE AS INDICATED BY THE
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 9
    Q SAFETY INFORMATION 9 Always signal before turning or changing lanes. Make sure that other motorists can see you. 8 The posture of the operator and passenger is important for proper control. 9 The operator should keep both hands on the handlebar and both feet on the footboard during operation to
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 10
    Q SAFETY INFORMATION When loading within this weight limit, keep the following in mind: 8 Cargo and accessory weight should be kept as low and close to the scooter as possible. Make sure to distribute the weight as evenly as possible on both sides of the scooter to minimize imbalance or instability.
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 11
    Safe-riding points Q SAFETY INFORMATION 9 Take care not to spill any gasoline on the engine or exhaust system when refueling. 9 Never refuel while smoking or in the vicinity of an open flame. 8 Never start the engine or let it run for any length of time in a closed area. The exhaust fumes are
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 12
    Q SAFETY INFORMATION bright colored jacket. 8 Do not carry too much luggage on the scooter. An overloaded scooter is unstable. Use a strong cord to secure any luggage to the carriers. A loose load will affect the stability of the scooter and could divert your attention from the road. (See page 1-1.)
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 13
    Labels, location of Q SAFETY INFORMATION EAU10381 Location of important labels Please read the following important labels carefully before operating this vehicle. 1 2 3 1 6 2 3 4 5 5 6 4 7 8 9 1-6
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 14
    Q SAFETY INFORMATION 1 1 2 3 4 5 6 7 8 9 4 2 5 3 6 1-7
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 15
    Q SAFETY INFORMATION 1 2 3 4 5 6 7 8 9 1-8
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 16
    Part locations EAU10400 DESCRIPTION EAU10410 Left view 1 2 2 3 4 5 6 3 4 1 5 6 7 9 8 9 1. 2. 3. 4. 5. 6. 7. 8. 9. Front turn signal light (page 6-27) Luggage hook (page 3-9) Helmet holder (page 3-7) Storage compartment (page 3-8) Rear turn signal light (page 6-27) Brake lever free play
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 17
    DESCRIPTION EAU10420 Right view 1 2 3 4 5 1 6 2 3 4 5 6 7 9 1. 2. 3. 4. 5. 6. 7. 8. 9. Tail/brake light (page 6-27) Carrier (page 3-9) Fuel tank cap (page 3-4) Seat (page 3-7) Front brake master cylinder (page 6-19) Headlight (page 6-25) Spark plug (page 6-8) Centerstand (page 6-21) Muffler 8
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 18
    DESCRIPTION EAU10430 Controls and instruments 1 2 3 1 2 3 4 5 4 5 8 6 7 8 9 1. 2. 3. 4. 5. 6. 7. 8. Rear brake lever (page 3-4) Left handlebar switches (page 3-3) Speedometer unit (page 3-2) Right handlebar switches (page 3-3) Front brake lever (page 3-4) Throttle grip (page 6-14) Main switch
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 19
    Main switch/steering lock INSTRUMENT AND CONTROL FUNCTIONS EAU10460 EAU10660 EAU10444 Main switch/steering lock OFF All electrical systems are off. The key can be removed. EAU10680 To unlock the steering LOCK The steering is locked, and all electrical systems are off. The key can be
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 20
    Fuel gauge INSTRUMENT AND CONTROL FUNCTIONS EAU10980 EAUT1820 EAU12150 Indicator lights 1 40 Speedometer unit 2 50 60 80 Fuel gauge 1 1 1 2 3 4 5 6 7 8 9 ZAUM00** 30 40 20 20 60 100 2 20 10 40 30 40 100 50 60 80 60 10 0 MPH 120 0 70 80 20 120 0 70 80 0 MPH ZAUM00** ZAUM00**
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 21
    START" Push this switch while applying the front or rear brake to crank the engine with the starter. ECA10050 cC See page 5-1 for starting instructions prior to starting the engine. Turn signal switch "4/6" To signal a right-hand turn, push this switch to "4". To signal a left-hand turn, push this
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 22
    Fuel tank cap INSTRUMENT AND CONTROL FUNCTIONS EAU12900 EAU12950 EAU32483 Front brake lever 1 2 3 4 5 6 7 8 9 ZAUM00** Rear brake lever 1 Fuel tank cap 2 1 1 ZAUM00** ZAUM00** 1. Front brake lever 1. Rear brake lever 1. Fuel tank cap lock cover 2. Match marks The front brake lever is
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 23
    Fuel INSTRUMENT AND CONTROL FUNCTIONS NOTE: The fuel tank cap cannot be installed unless the key is in the lock. In addition, the key cannot be removed if the cap is not properly installed and locked. EWA10130 EAU13211 Fuel 1 deteriorate painted surfaces or plastic parts. EAU36080 1 2 3 w
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 24
    10%. Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. EAU13431 EAU13680 Catalytic converter This model is equipped with a catalytic converter in the exhaust system. EWA10860 Kickstarter 1 2 3 4 w The exhaust
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 25
    Helmet holder INSTRUMENT AND CONTROL FUNCTIONS EAU13932 Seat To open the seat 1. Place the scooter on the centerstand. 2. Insert the key into the main switch, and then turn it counterclockwise to "OPEN". 2. Remove the key from the main switch if the scooter will be left unattended. NOTE:
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 26
    Storage compartment INSTRUMENT AND CONTROL FUNCTIONS To release the helmet from the helmet holder Open the seat, remove the helmet from the helmet holder, and then close the seat. EAU14510 Storage compartment 1 1 2 3 4 5 6 7 8 9 ZAUM00** 1. Storage compartment There is a storage
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 27
    Luggage hook INSTRUMENT AND CONTROL FUNCTIONS tended with the seat open. EAU15110 EAUT1070 Carrier 1 Luggage hook 1 1 2 3 4 EWAT1030 ZAUM00** ZAUM00** 1. Rear carrier EWA10170 1. Luggage hook 5 6 7 8 9 w 8 Do not exceed the load limit of 3 kg (7 lb) for the carrier. 8 Do not exceed
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 28
    Ignition circuit cut-off system INSTRUMENT AND CONTROL FUNCTIONS EAU15301 Sidestand 1 2 3 4 5 The sidestand is located on the left side of the frame. Raise the sidestand or lower it with your foot while holding the motorcycle upright. NOTE: The built-in sidestand switch is part of the
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 29
    INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is turned on. 3. Turn the key on. 4. Keep the front or rear brake applied. 5. Push the start switch. Does the engine start? NO YES NOTE: This check is most reliable if
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 30
    EAU15580 PRE-OPERATION CHECKS EAU15593 1 2 3 The condition of a vehicle is the owner's responsibility. Vital components can start to deteriorate quickly and unexpectedly, even if the vehicle remains unused (for example, as a result of exposure to the elements). Any damage, fluid leakage or loss
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 31
    Pre-operation check list PRE-OPERATION CHECKS EAU15605 Pre-operation check list ITEM Fuel • Check fuel level in fuel tank. • Refuel if necessary. • Check fuel line for leakage. • Check oil level in engine. • If necessary, add recommended oil to specified level. • Check vehicle for oil leakage
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 32
    PRE-OPERATION CHECKS ITEM Centerstand, sidestand CHECKS • Make sure that operation is smooth. • Lubricate pivot if necessary. • Make sure that all nuts, bolts and screws are properly tightened. • Tighten if necessary. • Check operation. • Correct if necessary. • Check operation. • Check operation of
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 33
    ventilation. 8 For safety, always start the engine with the centerstand down. Starting a cold engine ECA10250 cC See page 5-3 for engine break-in instructions prior to operating the vehicle for the first time. In order for the ignition circuit cut-off system to enable starting, the sidestand must
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 34
    Braking OPERATION AND IMPORTANT RIDING POINTS EAU16770 EAU16780 EAU16792 Starting off 1 2 3 4 5 6 7 ZAUM00** Acceleration and deceleration a 40 30 40 Braking 1. Close the throttle completely. 2. Apply both front and rear brakes simultaneously while gradually increasing the pressure.
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 35
    EAU17212 Parking When parking, stop the engine, and then remove the key from the main switch. 1 2 3 4 5 6 7 8 9 EWA10310 cC If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. 0~500 km (0~300 mi) Avoid prolonged operation above
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 36
    OPERATION AND IMPORTANT RIDING POINTS park in a place where pedestrians or children are not likely to touch them. 8 Do not park on a slope or on soft ground, otherwise the vehicle may overturn. ECA10380 1 2 3 4 5 6 7 8 9 cC Never park in an area where there are fire hazards such as grass or other
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 37
    with maintenance work, have a Yamaha dealer do it for you. The owner's tool kit is located under the seat. (See page 3-7.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and minor
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 38
    PERIODIC MAINTENANCE AND MINOR REPAIR EWA10340 w 1 2 3 4 5 6 7 8 9 Modifications not approved by Yamaha may cause loss of performance, excessive emissions, and render the vehicle unsafe for use. Consult a Yamaha dealer before attempting any changes. 6-2
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 39
    Crankcase breather system Idle speed Exhaust system √ 6 7 8 9 7 Air induction system * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 6-3
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 40
    Maintenance and lubrication, periodic PERIODIC MAINTENANCE AND MINOR REPAIR EAU32125 General maintenance and lubrication chart INITIAL ODOMETER READING 2,000 mi (4,000 km) or 6 months 10,000 mi 8,000 mi 6,000 mi 4,000 mi (7,000 km) (10,000 km) (13,000 km) (16,000 km) or or or or 30 24 18 12
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 41
    PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL NO. ITEM ROUTINE 600 mi (1,000 km) or 1 month 2,000 mi (4,000 km) or 6 months ODOMETER READING 10,000 mi 8,000 mi 6,000 mi 4,000 mi (7,000 km) (10,000 km) (13,000 km) (16,000 km) or or or or 30 24 18 12 months months months months 1 2 3 4 5 9 10 11
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 42
    headlight beam. * — — — — — 5 23 6 7 8 9 * switches — — — — — — * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. NOTE: From 12000 mi (19000 km) or 36 months, repeat the maintenance intervals starting from 4000 mi (7000 km
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 43
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU17620 NOTE: 8 The air filter needs more frequent service if you are riding in unusually wet or dusty areas. Hydraulic brake system 9 When disassembling the master cylinder or caliper cylinder, always replace the brake
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 44
    Spark plug, checking PERIODIC MAINTENANCE AND MINOR REPAIR EAU18771 Removing and installing panels 1 2 3 4 5 The panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a panel needs to be removed and installed. ZAUM00
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 45
    normally). NOTE: If the spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 2. Check the spark plug for electrode erosion and excessive carbon or other deposits
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 46
    PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 1 2 3 ZAUM00** 5. Clean the oil strainer with solvent, and then check it for damage and replace it if necessary. 3 4 1 1. Engine oil level check window 2. Maximum level mark 3. Minimum level mark ZAUM00** 3 2 1 4 5 6 7 8 9 1. Engine oil filler cap 1
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 47
    Final transmission oil PERIODIC MAINTENANCE AND MINOR REPAIR Tightening torque: Engine oil drain bolt A: 23 Nm (2.3 m•kgf, 16.6 ft•lbf) Engine oil drain bolt B: 32 Nm (3.2 m•kgf, 23.1 ft•lbf) 8 Be sure no foreign material enters the crankcase. 9. Start the engine, and then let it idle for
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 48
    Air filter and V-belt case air filter elements PERIODIC MAINTENANCE AND MINOR REPAIR 1 1 2 3 ZAUM00** Tightening torque: Final transmission oil drain bolt: 23 Nm (2.3 m•kgf, 16.6 ft•lbf) EAUT1301 Air filter and V-belt case air filter elements The air filter and V-belt case air filter
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 49
    PERIODIC MAINTENANCE AND MINOR REPAIR then blow the dirt out with compressed air as shown. ECA10480 cC 8 Make sure that the air filter element is properly seated in the air filter case. 8 The engine should never be operated without the air filter element installed, otherwise the piston(s) and/or
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 50
    Throttle cable free play, checking PERIODIC MAINTENANCE AND MINOR REPAIR 9. Install the kickstarter lever by installing the bolt, then tightening the bolt to the specified torque. 1 2 3 4 5 6 7 8 9 Tightening torque: Kickstarter bolt: 23 Nm (2.3 m•kgf, 16.6ft•lbf) EAU21251 EAU21382 Carburetor
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 51
    Tires PERIODIC MAINTENANCE AND MINOR REPAIR EAUT1701 Tires To maximize the performance, durability, and safe operation of your scooter, note the following points regarding the specified tires. Tire air pressure The tire air pressure should be checked and, if necessary, adjusted before each
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 52
    to loss of control. Have excessively worn tires replaced by a Yamaha dealer immediately. Brakes, tires, and related wheel parts replacement should be left to a Yamaha Service Technician. 6-16
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 53
    Rear brake lever free play, adjusting PERIODIC MAINTENANCE AND MINOR REPAIR EAUT1220 EAU22170 Checking the front brake lever free play Adjusting the rear brake lever free play 1 1 2 1 1 (b) ZAUM00** (a) 3 4 EWA10650 1. Adjusting nut ZAUM0107 ZAUM0108 w If proper adjustment cannot be
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 54
    Brake pads and shoes, checking PERIODIC MAINTENANCE AND MINOR REPAIR EAU22380 Checking the front brake pads and rear brake shoes 1 2 3 4 5 6 7 ZAUM00** The front brake pads and the rear brake shoes must be checked for wear at the intervals specified in the periodic maintenance and
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 55
    Brake fluid level, checking PERIODIC MAINTENANCE AND MINOR REPAIR EAU32344 Checking the brake fluid level 1 LOWER MIN Observe these precautions: 8 When checking the fluid level, make sure that the top of the master cylinder is level by turning the handlebars. 8 Use only the recommended
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 56
    Throttle grip and cable, checking and lubricating PERIODIC MAINTENANCE AND MINOR REPAIR EAU22720 EAU23091 EAU23111 Changing the brake fluid 1 2 3 4 5 6 7 8 9 Have a Yamaha dealer change the brake fluid at the intervals specified in the NOTE after the periodic maintenance and lubrication chart
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 57
    Centerstand and sidestand, checking and lubricating PERIODIC MAINTENANCE AND MINOR REPAIR EAU43640 EAU23211 Lubricating the front and rear brake levers Checking and lubricating the centerstand and sidestand Recommended lubricant: Lithium-soap-based grease (allpurpose grease) 1 2 3 4 ZAUM00
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 58
    maintenance and lubrication chart. 3 4 5 6 7 8 9 w Securely support the motorcycle so that there is no danger of it falling over. Check the does not operate smoothly, have a Yamaha dealer check or repair it. w Securely support the motorcycle so that there is no danger of it falling over. 2. Hold
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 59
    Battery PERIODIC MAINTENANCE AND MINOR REPAIR EAU23290 EAUT1230 Checking the wheel bearings The front and rear wheel bearings must be checked at the intervals specified in the periodic maintenance and lubrication chart. If there is play in the wheel hub or if the wheel does not turn smoothly,
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 60
    PERIODIC MAINTENANCE AND MINOR REPAIR acid, which causes severe burns. Avoid any contact with skin, eyes or clothing and always shield your eyes when working near batteries. In case of contact, administer the following FIRST AID. 9 EXTERNAL: Flush with plenty of water. 9 INTERNAL: Drink large
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 61
    Headlight bulb, replacing PERIODIC MAINTENANCE AND MINOR REPAIR EAUT1240 ECA10640 EAU23780 Replacing the fuse cC Do not use a fuse of a higher amperage rating than recommended to avoid causing extensive damage to the electrical system and possibly a fire. 3. Turn the key to "ON" and turn on
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 62
    PERIODIC MAINTENANCE AND MINOR REPAIR 1 1 1 2 3 4 5 6 7 8 9 4. Place a new headlight bulb into position, and then secure it with the bulb holder. ECA10660 ZAUM00** ZAUM00** Thoroughly clean off any dirt and fingerprints on the headlight bulb using a cloth moistened with alcohol or thinner. 5.
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 63
    Turn signal light bulb, replacing PERIODIC MAINTENANCE AND MINOR REPAIR EAU24131 Replacing the tail/brake light bulb 2 wise the lens may break. EAU24202 Replacing a turn signal light bulb 1. Remove the turn signal light lens by removing the screw. 1 2 1 2 1 3 4 ZAUM00** 5 1. Tail/
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 64
    a thorough inspection before shipment from the factory, trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause poor starting and loss of power. The following troubleshooting chart represents a quick and easy procedure for checking
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 65
    chart PERIODIC MAINTENANCE AND MINOR REPAIR EAU25901 Troubleshooting chart EWA10840 w Keep away open flames and do not smoke while checking or working on the fuel system. 1 2 1. Fuel There is enough fuel. Check the
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 66
    spoked wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. Improper cleaning can damage plastic parts such
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 67
    SCOOTER CARE AND STORAGE After normal use Remove dirt with warm water, a mild detergent, and a soft, clean sponge, and then rinse thoroughly with clean water. Use a toothbrush or bottlebrush for hard-to-reach areas. Stubborn dirt and insects will come off more easily if the area is covered with a
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 68
    of the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your scooter for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. Drain the carburetor float chamber by loosening the drain bolt; this will prevent fuel deposits
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 69
    SCOOTER CARE AND STORAGE spark plug electrodes while turning the engine over. 5. Lubricate all control cables and the pivoting points of all levers and pedals as well as of the sidestand/ centerstand. 6. Check and, if necessary, correct the tire air pressure, and then lift the scooter so that both
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 70
    system Spur gear Secondary reduction ratio 38/13 (2.923) Transmission type V-belt automatic Operation Centrifugal automatic type Recommended engine oil grade API service SG type or higher, JASO standard MA Weight With oil and fuel 109.0 kg (240 lb) Engine oil quantity Periodic oil change
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 71
    SPECIFICATIONS Manufacturer/model CHENG SHIN/C-922L Front brake Type Single disc brake Operation Right hand operation Recommended fluid DOT 3 or 4 Voltage, capacity 12 V, 6.0 Ah Rear tire Type Tubeless Size 3.50-10 51J Manufacturer/model CHENG SHIN/C-6007 Headlight Bulb type Halogen bulb Bulb
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 72
    Vehicle identification number CONSUMER INFORMATION EAU26351 EAU26390 EAU26342 EAU26410 Identification numbers 1 2 3 4 5 6 7 8 9 MODEL LABEL INFORMATION: VEHICLE IDENTIFICATION NUMBER: Record the key identification number, vehicle identification number and model label information in the
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 73
    Model label CONSUMER INFORMATION EAU26460 Model label 1 1 2 3 ZAUM00** 4 5 6 7 8 9 1. Model label The model label is affixed to the location shown. Record the information on this label in the space provided. This information will be needed when ordering spare parts from a Yamaha dealer.
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 74
    that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 75
    Noise regulation CONSUMER INFORMATION EAU26560 Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 76
    24 months 10000 mi (16000 km) or 30 months 12000 mi (19000 km) or 36 months 14000 mi (22000 km) or 42 months Date of service Mileage Servicing dealer name and address Remarks 9-5
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 77
    CONSUMER INFORMATION Maintenance interval 16000 mi (25000 km) or 48 months 18000 mi (28000 km) or 54 months 20000 mi (31000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 1 2 3 4 5 6 7 8 9 9-6
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 78
    Warranty, limited CONSUMER INFORMATION EAU26681 YAMAHA MOTOR CORPORATION, U.S.A. RIVA LIMITED WARRANTY 1 2 3 4 5 6 7 8 9 9-7
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 79
    CONSUMER INFORMATION 1 2 3 4 5 6 7 8 9 9-8
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 80
    no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 81
    isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 1 2 3 4 5 6 7 8 9 9-10
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 82
    cable free play, checking ...6-14 Throttle grip and cable, checking and lubricating ...6-20 Tires ...6-15 Tool kit ...6-1 Troubleshooting ...6-8 Troubleshooting chart ...6-29 Turn signal indicator light ...3-2 Turn signal light bulb, replacing ...6-27 Turn signal switch ...3-3 M Main switch
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 83
    INDEX
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 84
    1 2 3 4 5 6 7 8 9
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 85
    1 2 3 4 5 6 7 8 9
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 86
    1 2 3 4 5 6 7 8 9
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 87
    1 2 3 4 5 6 7 8 9
  • 2008 Yamaha Motorsports Vino 125 | Owners Manual - Page 88
    YAMAHA MOTOR TAIWAN CO., LTD PRINTED IN TAIWAN 2007.07-0.8×1! (E)
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
OWNER’S MANUAL
5YR-F8199-14
LIT-11626-21-54
YJ125X