2007 Yamaha Motorsports Midnight Warrior Owners Manual
2007 Yamaha Motorsports Midnight Warrior Manual
2007 Yamaha Motorsports Midnight Warrior manual content summary:
- 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 1
OWNER'S MANUAL XV17PCW(C) XV17PCMW(C) LIT-11626-20-22 5PX-28199-15 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 2
EAU10041 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 3
of craftsmanship and reliability that have made Yamaha a leader in these fields. This manual will give you an understanding of the operation, inspection, and basic maintenance of this close attention to the recommended maintenance schedules and operating instructions contained within this manual. - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 4
manual by the following notations: The Safety Alert Symbol means ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED! Failure to follow WARNING instructions procedures easier or clearer. WARNING CAUTION: NOTE: NOTE: G This manual should be considered a permanent part of this motorcycle and should - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 5
IMPORTANT MANUAL INFORMATION AND UNTIL YOU HAVE BEEN TRAINED IN SAFE AND PROPER RIDING TECHNIQUES. REGULAR INSPECTIONS AND CAREFUL MAINTENANCE, ALONG WITH GOOD RIDING SKILLS, WILL ENSURE - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 6
INFORMATION EAU10192 AFFIX DEALER LABEL HERE XV17PCW(C)/XV17PCMW(C) OWNER'S MANUAL ©2006 by Yamaha Motor Corporation, U.S.A. 1st edition, April 2006 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A. - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 7
TABLE OF CONTENTS SAFETY INFORMATION ...1-1 Location of important labels ...1-5 DESCRIPTION ...2-1 Left view ...2-1 Right view ...2-2 Controls and instruments ...2-3 INSTRUMENT AND CONTROL FUNCTIONS ...3-1 Main switch/steering lock ...3-1 Indicator and warning lights ...3-2 Speedometer ...3-3 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 8
a license plate light bulb ...6-36 Supporting the motorcycle ...6-37 Troubleshooting ...6-37 Troubleshooting chart ...6-38 MOTORCYCLE CARE AND STORAGE record ...9-5 YAMAHA MOTOR CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...9-9 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 9
SHOULD: G OBTAIN THOROUGH INSTRUCTIONS FROM A COMPETENT SOURCE ON ALL ASPECTS OF MOTORCYCLE OPERATION. G OBSERVE THE WARNINGS AND MAINTENANCE REQUIREMENTS IN THE OWNER'S MANUAL. G OBTAIN QUALIFIED TRAINING IN SAFE AND PROPER RIDING TECHNIQUES. G OBTAIN PROFESSIONAL TECHNICAL SERVICE AS INDICATED BY - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 10
SAFETY INFORMATION due to EXCESSIVE SPEED or undercornering (insufficient lean angle for the speed). • Always obey the speed limit and never travel faster than warranted by road and traffic conditions. • Always signal before turning or changing lanes. Make sure that other motorists can see you. The - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 11
SAFETY INFORMATION Loading The total weight of the operator, passenger, accessories and cargo must not exceed the maximum load limit. Maximum load: 185 kg (408 lb) When loading within this weight limit, keep the following in mind: G Cargo and accessory weight should be kept as low and close to the - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 12
SAFETY INFORMATION tor and may limit control ability, therefore, such accessories are not recommended. Use caution when adding electrical accessories. If electrical accessories exceed the capacity of the motorcycle's electrical system, an electric failure could result, which could cause a dangerous - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 13
SAFETY INFORMATION EAU10381 Location of important labels Please read the following important labels carefully before operating this vehicle. 1 1-5 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 14
SAFETY INFORMATION 1 1 2 California only 3 4 California only 5 1-6 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 15
DESCRIPTION EAU10410 Left view 2 1. 2. 3. 4. 5. 6. Engine oil drain bolt (crankcase) (page 6-9) Shift pedal (page 3-6) Fuel tank cap (page 3-7) Helmet holder (page 3-10) Fuses (page 6-32) Owner's tool kit (page 6-1) 2-1 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 16
DESCRIPTION EAU10420 Right view 2 1. 2. 3. 4. 5. 6. 7. 8. Rear brake fluid reservoir (page 6-23) Battery (page 6-31) Engine oil filler cap (page 6-9) Air filter element (page 6-13) Front fork spring preload adjusting bolt (page 3-10) Engine oil filter cartridge (page 6-9) Brake pedal (page 3-7) - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 17
DESCRIPTION EAU10430 Controls and instruments 2 1. 2. 3. 4. 5. 6. 7. 8. Clutch lever (page 3-6) Left handlebar switches (page 3-5) Speedometer (page 3-3) Tachometer unit (page 3-3) Main switch/steering lock (page 3-1) Right handlebar switches (page 3-5) Throttle grip (page 6-16) Brake lever ( - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 18
INSTRUMENT AND CONTROL FUNCTIONS EAU10460 EAU10660 Main switch/steering lock OFF All electrical systems are off. The key can be removed. EAU10680 To unlock the steering 3 LOCK The steering is locked, and all electrical systems are off. The key can be removed. To lock the steering The main - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 19
level detection circuit is defective, the following cycle will be repeated until the malfunction is corrected: The fuel level warning light Engine trouble warning light " " This warning light comes on when an electrical circuit monitoring the engine is defective. When this occurs, have a Yamaha - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 20
INSTRUMENT AND CONTROL FUNCTIONS EAU11601 EAU34031 Speedometer Tachometer unit G G 3 G G G 1. Speedometer 1. 2. 3. 4. 5. Tachometer Clock Odometer/tripmeter/fuel reserve tripmeter "RESET" button "SELECT" button two tripmeters (which show the distance traveled since they were last set to zero) - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 21
by pushing the "SELECT" button, and then push the "RESET" button for at least one second. If you do not reset the fuel reserve tripmeter manually, it will reset itself automatically and the display will return to the prior mode after refueling and 90 seconds have passed. Meter lighting control mode - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 22
FUNCTIONS If any of those circuits are defective, the engine trouble warning light will come on and the clock display will ) and for approximately 15 seconds. However, the turn signal lights can also be canceled manually by pushing the switch in after it has returned to the center position. NOTE: The - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 23
this switch to crank the engine with the starter. ECA10050 1. Clutch lever 1. Shift pedal CAUTION: See page 5-1 for starting instructions prior to starting the engine. EAU41700 The engine trouble warning light will come on when the key is turned to "ON" and the start switch is pushed, but this - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 24
INSTRUMENT AND CONTROL FUNCTIONS EAU12890 EAU12941 EAU13070 Brake lever Brake pedal Fuel tank cap 3 1. Brake lever 1. Brake pedal The brake lever is located at the right handlebar grip. To apply the front brake, pull the lever toward the handlebar grip. The brake pedal is on the right side - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 25
INSTRUMENT AND CONTROL FUNCTIONS EAU13211 ECA10070 NOTE: The fuel tank cap cannot be closed unless the key is in the lock. In addition, the key cannot be removed if the cap is not properly closed and locked. EWA11090 Fuel CAUTION: Immediately wipe off spilled fuel with a clean, dry, soft cloth, - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 26
not exceed 10%. Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. EAU34042 Rider seat To remove the rider seat 1. Insert the key into the seat lock, and then turn it counterclockwise. 3 1. Projection 2. Seat - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 27
INSTRUMENT AND CONTROL FUNCTIONS EAU14320 Helmet holder To release the helmet from the helmet holder Remove the rider seat, remove the helmet from the helmet holder, and then install the seat. EAU14720 Adjusting the front fork This front fork is equipped with spring preload adjusting bolts. - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 28
INSTRUMENT AND CONTROL FUNCTIONS EAU34062 NOTE: Align the appropriate groove on the adjusting mechanism with the top of the front fork cap bolt. Adjusting the shock absorber assembly This shock absorber assembly is equipped with a spring preload adjusting nut and a rebound damping force adjusting - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 29
INSTRUMENT AND CONTROL FUNCTIONS preload. With each complete turn of the adjusting nut, distance A is changed by 1.5 mm (0.06 in). ECA11240 CAUTION: Always tighten the locknut against the adjusting nut, and then tighten the locknut to the specified torque. Rebound damping force Rebound damping - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 30
gas pressure. G Do not deform or damage the gas cylinder in any way, as this will result in poor damping performance. G Always have a Yamaha dealer service the shock absorber. EAU15301 Sidestand The sidestand is located on the left side of the frame. Raise the sidestand or lower it with your foot - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 31
INSTRUMENT AND CONTROL FUNCTIONS EAU15311 Ignition circuit cut-off system The ignition circuit cut-off system (comprising the sidestand switch, clutch switch and neutral switch) has the following functions. G It prevents starting when the transmission is in gear and the sidestand is up, but the - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 32
INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is turned on. 3. Turn the key on. 4. Shift the transmission into the neutral position. 5. Push the start switch. Does the engine start? NOTE: This check is most reliable - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 33
PRE-OPERATION CHECKS EAU15591 The condition of a vehicle is the owner's responsibility. Vital components can start to deteriorate quickly and unexpectedly, even if the vehicle remains unused (for example, as a result of exposure to the elements). Any damage, fluid leakage or loss of tire air - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 34
PRE-OPERATION CHECKS EAU15605 Pre-operation check list ITEM Fuel • Check fuel level in fuel tank. • Refuel if necessary. • Check fuel line for leakage. • Check oil level in oil tank. • If necessary, add recommended oil to specified level. • Check vehicle for oil leakage. • Check vehicle for oil - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 35
PRE-OPERATION CHECKS ITEM CHECKS • Make sure that operation is smooth. • Check cable free play. • If necessary, have Yamaha dealer adjust cable free play and lubricate cable and grip housing. • Make sure that operation is smooth. • Lubricate if necessary Check for damage. Check tire condition and - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 36
. 1. Turn the key to "ON" and make sure that the engine stop switch is set to " ". ECA11560 CAUTION: The fuel level warning light and engine trouble warning light should come on for a few seconds, then go 5-1 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 37
OPERATION AND IMPORTANT RIDING POINTS ECA11130 EAU16671 ECA10260 CAUTION: For maximum engine life, always warm the engine up before starting off. Never accelerate hard when the engine is cold! NOTE: The engine is warm when it quickly responds to the throttle. Shifting CAUTION: G 1. Shift pedal - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 38
OPERATION AND IMPORTANT RIDING POINTS 4. At the recommended shift points shown in the following table, close the throttle, and at the same time, quickly pull the clutch lever in. 5. Shift the transmission into second gear. (Make sure not to shift the transmission into the neutral position.) 6. Open - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 39
remove the key from the main switch. EWA10310 WARNING G CAUTION: G G Keep the engine speed out of the tachometer red zone. If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. G Since the engine and exhaust system can become - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 40
. 1. Owner's tool kit The owner's tool kit is located under the rider seat. (See page 3-9.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and minor repairs. However, additional - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 41
PERIODIC MAINTENANCE AND MINOR REPAIR EWA10340 WARNING Modifications not approved by Yamaha may cause loss of performance, excessive emissions, and render the vehicle unsafe for use. Consult a Yamaha dealer before attempting any changes. 6 6-2 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 42
injection √ √ √ √ √ √ √ √ √ √ √ √ √ √ √ 5 * 6 * Exhaust system Evaporative emission control system (For California only) 7 * √ √ * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 6-3 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 43
PERIODIC MAINTENANCE AND MINOR REPAIR EAU32183 General maintenance and lubrication chart INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 44
PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 9 * Swingarm pivot bearings - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 45
* Throttle grip housing and cable √ √ √ √ √ 26 * Lights, signals and switches √ √ √ √ √ * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 6-6 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 46
damaging them. • The air filter elements need to be replaced more frequently when riding in unusually wet or dusty areas. G Hydraulic brake service • After disassembling the brake master cylinders and calipers, always change the fluid. Regularly check the brake fluid levels and fill the reservoirs - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 47
the same color. If any spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. If a spark plug shows signs of electrode erosion and excessive carbon or other deposits - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 48
PERIODIC MAINTENANCE AND MINOR REPAIR EAU19681 EAU34082 Canister (for California only) Engine oil and oil filter cartridge The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil filter cartridge replaced at the intervals specified in the periodic - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 49
PERIODIC MAINTENANCE AND MINOR REPAIR ECA10900 CAUTION: Make sure that the oil filler cap is securely tightened, otherwise oil may seep out when the engine is running. To change the engine oil (with or without oil filter cartridge replacement) 1. Remove the rider seat. (See page 3-9.) 2. Start the - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 50
PERIODIC MAINTENANCE AND MINOR REPAIR NOTE: Skip steps 7-9 if the oil filter cartridge is not being replaced. 7. Remove the oil filter cartridge with an oil filter wrench. 1. O-ring 1. Oil filter cartridge 2. Torque wrench NOTE: Make sure that the O-ring is properly seated. 6 1. Oil filter - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 51
PERIODIC MAINTENANCE AND MINOR REPAIR 11. Pour only 2.5 L (2.6 US qt) (2.2 Imp.qt) of the specified amount of recommended engine oil through the filler hole, insert the dipstick, and then tighten the oil filler cap. 12. Start the engine, rev it several times, and then turn it off. 13. Remove the - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 52
PERIODIC MAINTENANCE AND MINOR REPAIR EAU34103 Replacing the air filter elements This model is equipped with two air filter elements, one of which is located in the air filter case, the other is located in the silencer case. The air filter elements should be replaced at the intervals specified in - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 53
PERIODIC MAINTENANCE AND MINOR REPAIR ECA11530 CAUTION: G G Place a towel or cloth under the fuel hose joints when disconnecting hoses A and B to prevent fuel from spilling onto the vehicle. Make sure that no foreign material enters the fuel hose joints when the hoses are disconnected. d. Remove - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 54
PERIODIC MAINTENANCE AND MINOR REPAIR 10. Remove the clamp from the check hose, and then remove the plug to drain any accumulated water. b. Place the fuel tank in the original position, and then connect fuel hose B and the hoses shown. 1. Air filter element 2. Screw 8. Install a new air filter - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 55
PERIODIC MAINTENANCE AND MINOR REPAIR d. Connect fuel hose A. 17. Install the air induction system cover by installing the bolts. 18. Install the rider seat. Silencer case air filter element To replace the air filter element 1. Remove the fuel tank. (See steps 1-3 under "Air filter case element".) - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 56
PERIODIC MAINTENANCE AND MINOR REPAIR EAU21401 EAU21750 Valve clearance The valve clearance changes with use, resulting in improper air-fuel mixture and/or engine noise. To prevent this from occurring, the valve clearance must be adjusted by a Yamaha dealer at the intervals specified in the - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 57
PERIODIC MAINTENANCE AND MINOR REPAIR evenly from side to side. Properly adjust the suspension for your load, and check the condition and pressure of your tires. NEVER OVERLOAD YOUR VEHICLE. Make sure that the total weight of the cargo, rider, passenger, and accessories (cowling, saddlebags, etc. if - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 58
PERIODIC MAINTENANCE AND MINOR REPAIR G G Always make sure that the valve caps are securely installed to prevent air pressure leakage. Use only the tire valves and valve cores listed below to avoid tire deflation during a high-speed ride. EWA10600 EAU21960 WARNING This motorcycle is fitted with - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 59
PERIODIC MAINTENANCE AND MINOR REPAIR EAU22011 Accessories and replacement parts EWA10621 any consequences caused by the use of items which have not been approved by Yamaha. EAU22041 Adjusting the clutch lever free play WARNING This vehicle is not designed to pull a trailer or to be attached to - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 60
PERIODIC MAINTENANCE AND MINOR REPAIR NOTE: If the specified clutch lever free play could be obtained as described above, tighten the locknut and skip the rest of the procedure, otherwise proceed as follows. 3. Fully turn the adjusting bolt at the clutch lever in direction (a) to loosen the clutch - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 61
PERIODIC MAINTENANCE AND MINOR REPAIR EWA10630 EAU22270 EAU22390 WARNING G G After adjusting the brake lever free play, check the free play and make sure that the brake is working properly. A soft or spongy feeling in the brake lever can indicate the presence of air in the hydraulic system. If - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 62
PERIODIC MAINTENANCE AND MINOR REPAIR the point that a wear indicator almost touches the brake disc, have a Yamaha dealer replace the brake pads as a set. EAU34090 EAU22580 Checking the brake fluid level Front brake Rear brake pads 1. Remove the brake caliper bolt, and then tilt the caliper - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 63
PERIODIC MAINTENANCE AND MINOR REPAIR Before riding, check that the brake fluid is above the minimum level mark and replenish if necessary. A low brake fluid level may indicate worn brake pads and/or brake system leakage. If the brake fluid level is low, be sure to check the brake pads for wear and - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 64
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23040 Drive belt slack The drive belt slack should be checked and adjusted at the intervals specified in the periodic maintenance and lubrication chart. EAU23062 3. Note the position of the drive belt with a force of 45 N (4.6 kgf, 10 lbf) applied to the - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 65
PERIODIC MAINTENANCE AND MINOR REPAIR 3. To tighten the drive belt, turn the adjusting bolt on each side of the swingarm in direction (a). To loosen the drive belt, turn the adjusting bolt on each side of the swingarm in direction (b), and then push the rear wheel forward. NOTE: Using the alignment - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 66
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23111 EAU23131 Checking and lubricating the throttle grip and cable The operation of the throttle grip should be checked before each ride. In addition, the cable should be lubricated at the intervals specified in the periodic maintenance chart. Checking and - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 67
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23140 EAU23200 Checking and lubricating the brake and clutch levers Brake lever Recommended lubricant: Lithium-soap-based grease (all-purpose grease) Checking and lubricating the sidestand Clutch lever The operation of the sidestand should be checked - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 68
fork must be checked as follows at the intervals specified in the periodic maintenance and lubrication chart. To check the condition EWA10750 WARNING Securely support the vehicle so that there is no danger of it falling over. The swingarm pivots must be lubricated at the intervals specified in the - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 69
. EWA10750 ECA10590 CAUTION: If any damage is found or the front fork does not operate smoothly, have a Yamaha dealer check or repair it. WARNING Securely support the vehicle so that there is no danger of it falling over. 2. Hold the lower ends of the front fork legs and try to move - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 70
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23290 EAU33650 Checking the wheel bearings The front and rear wheel bearings must be checked at the intervals specified in the periodic maintenance and lubrication chart. If there is play in the wheel hub or if the wheel does not turn smoothly, have a Yamaha - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 71
PERIODIC MAINTENANCE AND MINOR REPAIR battery tends to discharge more quickly if the vehicle is equipped with optional electrical accessories. To store the battery 1. If the vehicle will not be used for more than one month, remove the battery, fully charge it, and then place it in a cool, dry place. - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 72
PERIODIC MAINTENANCE AND MINOR REPAIR Specified fuses: Main fuse: 30.0 A Headlight fuse: 15.0 A Signaling system fuse: 10.0 A Ignition fuse: 10.0 A Fuel injection system fuse: 15.0 A ECU fuse: 10.0 A Auto-decompression fuse: 15.0 A Backup fuse: 7.5 A ECA10640 6. Install the battery cover, and then - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 73
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23792 EWA10790 Replacing the headlight bulb This model is equipped with a quartz bulb headlight. If the headlight bulb burns out, replace it as follows. 1. Remove the headlight unit by removing the screws. WARNING Headlight bulbs get very hot. Therefore, - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 74
PERIODIC MAINTENANCE AND MINOR REPAIR EAU24180 EAU24210 Tail/brake light This model is equipped with an LED type of tail/brake light. If the tail/brake light does not come on, have a Yamaha dealer check it. Replacing a turn signal light bulb 1. Remove the turn signal lens by removing the screws. - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 75
PERIODIC MAINTENANCE AND MINOR REPAIR EAU24321 Replacing a license plate light bulb 1. Remove the license plate light unit by removing the nuts, washers and rubber dampers. 1. Turn signal light bulb 3. Insert a new bulb into the socket, push it in, and then turn it clockwise until it stops. 4. - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 76
Supporting the front wheel off the ground by using a motorcycle stand. To service the rear wheel Raise the rear wheel off the ground by using a Troubleshooting Although Yamaha motorcycles receive a thorough inspection before shipment from the factory, trouble may occur during operation. Any problem - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 77
PERIODIC MAINTENANCE AND MINOR REPAIR EAU25891 Troubleshooting chart EWA10840 WARNING Keep away open flames and do not smoke while checking or working on the fuel system. 1. Fuel There is enough fuel. Check - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 78
wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. Improper cleaning can damage windshields, cowlings - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 79
MOTORCYCLE CARE AND STORAGE After normal use Remove dirt with warm water, a mild detergent, and a soft, clean sponge, and then rinse thoroughly with clean water. Use a toothbrush or bottlebrush for hard-to-reach areas. Stubborn dirt and insects will come off more easily if the area is covered with a - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 80
plugs, and then install the spark plugs and the spark plug caps. EWA10950 Long-term Before storing your motorcycle for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 81
MOTORCYCLE CARE AND STORAGE 4. Lubricate all control cables and the pivoting points of all levers and pedals as well as of the sidestand/centerstand. 5. Check and, if necessary, correct the tire air pressure, and then lift the motorcycle so that both of its wheels are off the ground. Alternatively, - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 82
: 155 mm (6.10 in) Minimum turning radius: 3400 mm (133.9 in) Engine oil: Type: YAMALUBE 4 (20W40) or SAE20W40 Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter cartridge replacement: 3.70 L (3.91 US qt) (3.26 Imp.qt) With oil - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 83
SPECIFICATIONS Caster angle: 29.25 ° Trail: 130.0 mm (5.12 in) Rear: 250 kPa (36 psi) (2.50 kgf/cm²) Loading condition: 90-185 kg (198-408 lb) Front: 250 kPa (36 psi) (2.50 kgf/cm²) Rear: 290 kPa (42 psi) (2.90 kgf/cm²) High-speed riding: Front: 250 kPa (36 psi) (2.50 kgf/cm²) Rear: 250 kPa (36 psi) - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 84
LED Neutral indicator light: LED High beam indicator light: LED Turn signal indicator light: LED Fuel level warning light: LED Engine trouble warning light: LED Backup fuse: 7.5 A Auto-decompression fuse: 15.0 A Fuses: Main fuse: 30.0 A Headlight fuse: 15.0 A Signaling system fuse: 10.0 A Ignition - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 85
CONSUMER INFORMATION EAU26351 EAU26381 EAU26400 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 86
CONSUMER INFORMATION EAU26470 Model label 1. Model label The model label is affixed to the frame under the rider seat. (See page 3-9.) Record the information on this label in the space provided. This information will be needed when ordering spare parts from a Yamaha dealer. 9 9-2 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 87
that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1-800 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 88
CONSUMER INFORMATION EAU26560 Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 89
30 months 24000 mi (37000 km) or 36 months 28000 mi (43000 km) or 42 months 32000 mi (49000 km) or 48 months 9-5 Date of service Mileage Servicing dealer name and address Remarks 9 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 90
CONSUMER INFORMATION Maintenance interval 36000 mi (55000 km) or 54 months 40000 mi (61000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 9 9-6 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 91
CONSUMER INFORMATION EAU26662 YAMAHA MOTOR CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY 9 9-7 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 92
CONSUMER INFORMATION 9 9-8 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 93
no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 94
isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 9 9-10 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 95
Troubleshooting chart ...6-38 Turn signal indicator lights ...3-2 Turn signal light bulb, replacing ...6-35 Turn signal switch ...3-5 D Dimmer switch ...3-5 Drive belt slack ...6-25 E Engine break-in ...5-3 Engine oil and oil filter cartridge ...6-9 Engine stop switch...3-6 Engine trouble warning - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 96
INDEX V Valve clearance ...6-17 Vehicle identification number ...9-1 W Warranty, extended...9-9 Warranty, limited ...9-7 Wheel bearings, checking...6-31 Wheels ...6-19 - 2007 Yamaha Motorsports Midnight Warrior | Owners Manual - Page 97
YAMAHA MOTOR CO., LTD. PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2006.05-0.6×1 CR (E)
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
 |
 |
5PX-28199-15
XV17PCW(C)
XV17PCMW(C)
OWNER’S MANUAL
LIT-11626-20-22