2011 Yamaha Motorsports Vino Classic Owners Manual
2011 Yamaha Motorsports Vino Classic Manual
2011 Yamaha Motorsports Vino Classic manual content summary:
- 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 1
Read this manual carefully before operating this vehicle. OWNER'S MANUAL XC50A LIT-11626-24-56 3D1-F8199-15 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 2
EAU10042 Q Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold. - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 3
Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. Yamaha continually seeks advancements in product design and quality. Therefore, while this manual contains the most current product information available at the time of - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 4
INFORMATION EAU10132 Particularly important information is distinguished in this manual by the following notations: Q This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 5
INFORMATION EAUT2191 XC50A OWNER'S MANUAL ©2010 by Yamaha Motor Corporation, U.S.A. 1st edition, July 2010 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A. - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 6
...6-21 Replacing the fuse ...6-23 Replacing the headlight bulb...6-23 Replacing the tail/brake light bulb .. 6-24 Replacing a turn signal light bulb ...6-25 Troubleshooting ...6-25 Troubleshooting charts...6-27 SCOOTER CARE AND STORAGE ...7-1 Matte color caution...7-1 Care ...7-1 Storage...7-3 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 7
INFORMATION ...9-1 Identification numbers ...9-1 Vehicle Emission Control Information label ...9-2 Reporting safety defects ...9-3 Scooter noise regulation ...9-4 Maintenance record ...9-5 YAMAHA MOTOR CORPORATION, U.S.A. RIVA LIMITED WARRANTY ...9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...9-9 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 8
EAU45762 Q LOCATION OF IMPORTANT SAFETY INFORMATION LABELS EAU10384 Read and understand all of the labels on your vehicle. They contain important information for safe and proper operation of your vehicle. Never remove any labels from your vehicle. If a label becomes difficult to read or comes off, - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 9
EAU45762 Q SAFETY INFORMATION LOCATION OF IMPORTANT LABELS 1 4 1 2 2 5 3 4 5 3 6 6 7 8 9 1-2 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 10
should: ● Obtain thorough instructions from a competent source on all aspects of scooter operation. ● Observe the warnings and maintenance requirements in this Owner's Manual. ● Obtain qualifi ed training in safe and proper riding techniques. ● Obtain professional technical service as indicated in - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 11
Q undercornering (insufficient lean angle for the speed). • Always obey the speed limit and never travel faster than warranted by road and traffi c conditions. • Always signal before turning or changing lanes. Make sure that other motorists can see you. The posture of the operator is important for - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 12
Q SAFETY INFORMATION as close to the center of the vehicle as possible and make sure to distribute the weight as evenly as possible on both sides of the scooter to minimize imbalance or instability. Shifting weights can create a sudden imbalance. Make sure that accessories and cargo are securely - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 13
. Refer to page 6-14 for tire specifications and more information on replacing your tires. Transporting the Scooter Be sure to observe following instructions before transporting the scooter in another vehicle. ● Remove all loose items from the scooter. ● Point the front wheel straight ahead on the - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 14
Q SAFETY INFORMATION that could break). Choose the location for the straps carefully so the straps will not rub against painted surfaces during transport. The suspension should be compressed somewhat by the tiedowns, if possible, so that the scooter will not bounce excessively during transport. - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 15
Q SAFETY INFORMATION 1 2 3 4 5 6 7 8 9 1-8 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 16
EAU10401 DESCRIPTION EAU10410 Left view 1 2 2 3 4 3 4 5 6 1 10 5 6 7 8 9 1. 2. 3. 4. 5. 6. 7. Front turn signal light (page 6-25) Luggage hook (page 3-11) Helmet holder (page 3-9) Storage compartment (page 3-10) Fuel tank cap (page 3-6) Rear turn signal light (page 6-25) Kickstarter (page - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 17
EAU10401 DESCRIPTION EAU10420 Right view 1 1 2 3 4 5 2 3 4 5 6 8 7 6 7 8 9 1. 2. 3. 4. 5. 6. 7. Tail/brake light (page 6-24) Carrier (page 3-11) Seat (page 3-9) Coolant reservoir (page 6-12) Headlight (page 6-23) Spark plug (page 6-7) Centerstand (page 6-19) 8. Muffler (page 3-8) 2-2 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 18
EAU10401 DESCRIPTION EAU10430 Controls and instruments 1 2 3 4 5 1 2 3 4 5 9 6 7 8 9 1. 2. 3. 4. 5. 6. 7. Rear brake lever (page 3-5) Left handlebar switches (page 3-3) Speedometer unit (page 3-3) Right handlebar switches (page 3-3) Front brake lever (page 3-4) Throttle grip (page 5-2) Rear - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 19
EAU1044E INSTRUMENT AND CONTROL FUNCTIONS EAU10460 EAU10661 Main switch/steering lock OFF All electrical systems are off. The key can be removed. EWA10061 ZAUM00** WARNING Never turn the key to "OFF" or "LOCK" while the vehicle is moving. Otherwise the electrical systems will be switched off, - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 20
, the radiator fan(s) automatically switch on or off according to the coolant temperature in the radiator. If the engine overheats, see page 6-28 for further instructions. ZAUM00** 9 1. Coolant temperature warning light" " - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 21
EAU1044E INSTRUMENT AND CONTROL FUNCTIONS EAUT1821 EAU12150 EAU12348 Speedometer unit 2 1 Fuel gauge Handlebar switches Left 1 2 1 1 3 ZAUM00** ZAUM00** 1. Speedometer 2. Odometer 1. Fuel gauge ZAUM00** 2 3 4 5 6 7 8 9 The speedometer unit is equipped with a speedometer and an odometer. - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 22
Start switch "," Push this switch while applying the front or rear brake to crank the engine with the starter. See page 5-1 for starting instructions prior to starting the engine. EAUM1132 EAU12900 Front brake lever 1 ZAUM00** 1. Front brake lever EAU12500 The front brake lever is located on - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 23
EAU1044E INSTRUMENT AND CONTROL FUNCTIONS EAU12950 EAUT1551 Rear brake lever 1 Rear wheel lock When the rear wheel lock lever is pulled down to lock the rear wheel, a cover will close over the main switch keyhole to help prevent theft. TIP ered. If the rear wheel lock lever is not easy to pull - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 24
WARNING Gasoline and gasoline vapors are extremely flammable. To avoid fires and explosions and to reduce the risk of injury when refueling, follow these instructions. 1. Before refueling, turn off the engine and be sure that no one is sitting on the vehicle. Never refuel while smoking, or while in - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 25
10% (E10). Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. 1 2 3 4 5 6 7 8 9 WARNING Gasoline is poisonous and can cause injury or death. Handle gasoline with care. Never siphon gasoline by mouth. If you - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 26
EAU1044E INSTRUMENT AND CONTROL FUNCTIONS EAU13433 ECA10701 EAU13680 Catalytic converter This model is equipped with a catalytic converter in the exhaust system. 1 2 3 4 5 6 7 8 9 EWA10862 WARNING The exhaust system is hot after operation. To prevent a fire hazard or burns: ● Do not park the - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 27
EAU1044E INSTRUMENT AND CONTROL FUNCTIONS EAUT1503 Seat 3. Fold the seat up. To close the seat 1. Fold the seat down, and then push it down to lock it in place. 2. Remove the key from the main switch if the scooter will be left unattended. TIP EAU14301 Helmet holder 1 1 2 3 ZAUM00** ZAUM00 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 28
EAU1044E INSTRUMENT AND CONTROL FUNCTIONS To release the helmet from the helmet holder Open the seat, remove the helmet from the helmet holder, and then close the seat. EAUT1712 Storage compartments 1 1 1 2 3 ZAUM00** 1. Storage compartment ZAUM00** 4 5 6 7 8 9 1. Front storage compartment - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 29
EAU1044E INSTRUMENT AND CONTROL FUNCTIONS ● ● in a plastic bag before storing them in the compartment. Since the rear storage compartment may get wet while the scooter is being washed, wrap any articles stored in the rear compartment in a plastic bag. Do not keep anything valuable or breakable in - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 30
Always follow the inspection and maintenance procedures and schedules described in the Owner's Manual. EWA11151 1 2 3 4 5 6 7 8 9 WARNING Failure to the vehicle if you find any problem. If a problem cannot be corrected by the procedures provided in this manual, have the vehicle inspected by a Yamaha - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 31
EAU15582 FOR YOUR SAFETY - PRE-OPERATION CHECKS Before using this vehicle, check the following points: ITEM Fuel • Check fuel level in fuel tank. • Refuel if necessary. • Check fuel line for leakage. • Check oil level in engine. • If necessary, add recommended oil to specified level. • Check vehicle - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 32
EAU15582 FOR YOUR SAFETY - PRE-OPERATION CHECKS ITEM Brake levers CHECKS • Make sure that operation is smooth. • Lubricate lever pivoting points if necessary. • Make sure that operation is smooth. • Lubricate pivots if necessary. • Make sure that all nuts, bolts and screws are properly tightened. • - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 33
IMPORTANT RIDING POINTS EAU15951 EAUT1512 EAU16770 Read the Owner's Manual carefully to become familiar with all controls. If , which could cause an accident or injury. NOTICE See page 5-3 for engine break-in instructions prior to operating the vehicle for the first time. 1. Turn the key to "ON - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 34
EAU15943 OPERATION AND IMPORTANT RIDING POINTS EAU16780 EAU16793 EAU16820 Acceleration and decelera- Braking tion 1 2 3 4 5 6 7 ● EWA10300 (a) ● (b) (b) ● (a) ZAUM00** The speed can be adjusted by opening and closing the throttle. To increase the speed, turn the throttle grip in direction - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 35
ten minutes. Vary the engine speed from time to time. Do not operate the engine at one set throttle position. NOTICE If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. EWA10311 9 ● WARNING Since the engine and exhaust system - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 36
EAU15943 OPERATION AND IMPORTANT RIDING POINTS ● 1 2 3 4 5 6 7 8 9 ● ans or children are not likely to touch them and be burned. Do not park on a slope or on soft ground, otherwise the vehicle may overturn, increasing the risk of a fuel leak and fire. Do not park near grass or other fl ammable - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 37
periodic maintenance charts should be simply considered as a general guide under normal riding conditions. However, depending on the weather, and electrical parts that can cause shocks or fires. ● Running the engine while servicing can lead to eye injury, burns, fi re, or carbon monoxide poisoning - - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 38
mi (7000 km) or 12 months. Items marked with an asterisk require special tools, data and technical skills, have a Yamaha dealer perform the service. EAU17561 Periodic maintenance chart for the emission control system 3 4 5 1 * Fuel line NO. ITEM ROUTINE INITIAL 600 mi (1000 km) or 1 month 2000 mi - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 39
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL NO. ITEM ROUTINE 600 mi (1000 km) or 1 month 2000 mi (4000 km) or 6 months √ ODOMETER READING 4000 mi (7000 km) or 12 months √ 6000 mi (10000 km) or 18 months √ 8000 mi (13000 km) or 24 months √ 10000 mi (16000 km) or 30 months √ 1 2 3 4 5 6 7 8 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 40
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU32126 General maintenance and lubrication chart INITIAL ODOMETER READING 2000 mi (4000 km) or 6 months 4000 mi (7000 km) or 12 months 6000 mi (10000 km) or 18 months 8000 mi (13000 km) or 24 months 10000 mi (16000 km) or 30 months 1 2 3 4 5 6 NO. - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 41
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL NO. ITEM ROUTINE 600 mi (1000 km) or 1 month 2000 mi (4000 km) or 6 months ODOMETER READING 4000 mi (7000 km) or 12 months 6000 mi (10000 km) or 18 months 8000 mi (13000 km) or 24 months 10000 mi (16000 km) or 30 months √ 1 2 9 10 11 12 * - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 42
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL NO. ITEM ROUTINE 600 mi (1000 km) or 1 month √ 2000 mi (4000 km) or 6 months √ ODOMETER READING 4000 mi (7000 km) or 12 months √ 6000 mi (10000 km) or 18 months √ 8000 mi (13000 km) or 24 months √ 10000 mi (16000 km) or 30 months √ 1 20 * 2 3 4 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 43
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU18751 EAU19272 EAUT1483 Removing and installing the Panel A To remove the panel panel Checking the spark plug 1 1 2 3 ZAUM00** Remove the screw, and then pull outward on the areas shown. 1 1 ZAUM00** 1. Partition ZAUM00** 4 5 6 7 8 9 1. Panel A - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 44
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT ing it up. 3. Remove the spark plug cap. to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 2. Check the spark plug for electrode erosion and excessive carbon or other deposits, and replace it if - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 45
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAUT1461 Engine oil and oil strainer The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil strainer cleaned at the intervals specified in the periodic maintenance and lubrication chart. To check the - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 46
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT 4 3 2 1 then tighten both drain bolts to their specified torques. Tightening torque: Engine oil drain bolt A: 23 Nm (2.3 m·kgf, 16.6 ft·lbf) Engine oil drain bolt B: 32 Nm (3.2 m·kgf, 23.1 ft·lbf) ECA11670 1 2 3 4 5 6 7 8 9 ZAUM00** 1 1. 2. 3. 4. - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 47
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAUT1561 Final transmission oil The fi nal transmission case must be checked for oil leakage before each ride. If any leakage is found, have a Yamaha dealer check and repair the scooter. In addition, the final transmission oil must be changed as follows - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 48
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU20070 Coolant 1 2 3 4 5 6 7 8 9 ● reading. The coolant level should be checked before each ride. In addition, the coolant must be changed at the intervals specified in the periodic maintenance and lubrication chart. EAUT1523 1 2. Check the coolant - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 49
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT water has been used instead of coolant, replace it with coolant as soon as possible, otherwise the cooling system will not be protected against frost and corrosion. If water has been added to the coolant, have a Yamaha dealer check the antifreeze content - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 50
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU21251 EAU44734 EAU21384 Carburetor 1 2 3 4 5 6 7 8 9 Checking the engine idling The carburetor is an important part of speed the engine and its emission control system, which requires very sophisticated adjustment. Therefore, carburetor adjustments - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 51
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU21401 EAU21912 Valve clearance The valve clearance changes with use, resulting in improper air-fuel mixture and/or engine noise. To prevent this from occurring, the valve clearance must be adjusted by a Yamaha dealer at the intervals specified in the - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 52
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT worn-out tire. When a tire tread begins to show crosswise lines, have a Yamaha dealer replace the tire immediately. The replacement of all wheeland brake-related parts, including the tires, should be left to a Yamaha dealer, who has the necessary - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 53
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU22170 Adjusting the rear brake lever free play 1 1 (b) ZAUM00** (b) 1 2 ZAUM00** (a) 1 EWA10650 (a) 3 EWA10650 1. Adjusting nut 1. Adjusting nut ZAUM00** WARNING If proper adjustment cannot be obtained as described, have a Yamaha dealer make - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 54
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU22361 Checking the front and rear be checked for wear at the intervals Checking and lubricating the brake shoes specified in the periodic maintenance cables 1 2 3 4 ZAUM00** The front and rear brake shoes must EAU23093 Front 1 2 5 6 7 1. Wear - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 55
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU23113 EAU43631 EAU23192 Checking and lubricating the Lubricating the front and rear Checking and lubricating the throttle grip and cable brake levers centerstand The operation of the throttle grip should be checked before each ride. In addition, the - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 56
as follows at the intervals specified in the periodic maintenance and lubrication chart. 1. Place the vehicle on the centerstand. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over.[EWA10751] 2. Hold the lower ends of the front fork legs and try to move - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 57
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAU23291 EAUT1233 Checking the wheel bearings The front and rear wheel bearings must be checked at the intervals specified in the periodic maintenance and lubrication chart. If there is play in the wheel hub or if the wheel does not turn smoothly, have a - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 58
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT dangerous since it contains sulfuric acid, which causes severe burns. Avoid any contact with skin, eyes or clothing and always shield your eyes when working near batteries. In case of contact, administer the following FIRST AID. • EXTERNAL: Flush with - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 59
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAUT1241 EAU23783 Replacing the fuse Specified fuse: 7.5 A Replacing the headlight bulb This model is equipped with a quartz bulb headlight. If the headlight bulb burns out, replace it as follows. ECA10650 1 ZAUM00** 3. Turn the key to "ON" and turn - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 60
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT 1. Remove the headlight unit by removing the screws. and then remove the burnt-out bulb. EAU24133 1 1 2 3 ZAUM00** ZAUM00** Replacing the tail/brake light bulb 1. Remove the tail/brake light lens by removing the screws. 1 1 2 4 5 6 7 8 9 1. - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 61
Troubleshooting Although Yamaha scooters receive a thorough inspection before shipment from the factory, trouble may occur during operation. Any problem may look like Yamaha parts, but they are often inferior, have a shorter service life and can lead to expensive repair bills. EWA15141 1 2 3 4 5 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 62
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT the area, including pilot lights from water heaters or furnaces. Gasoline or gasoline vapors can ignite or explode, causing severe injury or property damage. 1 2 3 4 5 6 7 8 9 6-26 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 63
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT EAUT1581 Troubleshooting charts Starting problems or poor engine performance 1. Fuel There is enough fuel. Check the fuel level in the fuel tank. There is no fuel. Supply fuel. Check the - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 64
EAU1722A PERIODIC MAINTENANCE AND ADJUSTMENT Engine overheating EWAT1040 1 2 3 4 5 6 7 ● ● WARNING Do not remove the radiator cap when the engine and radiator are hot. Scalding hot fluid and steam may be blown out under pressure, which could cause serious injury. Be sure to wait until the engine - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 65
on spoked wheels. If such products are used on hard-toremove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. ● Improper cleaning can damage plastic parts - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 66
EAU25991 SCOOTER CARE AND STORAGE with water, diluted mild detergent with water may be used. Be sure to rinse off any detergent residue using plenty of water, as it is harmful to plastic parts. Do not use any harsh chemical products on plastic parts. Be sure to avoid using cloths or sponges which - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 67
(because of the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your scooter for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. Drain the carburetor float cham- 7-3 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 68
EAU25991 SCOOTER CARE AND STORAGE ber by loosening the drain bolt; this will prevent fuel deposits from building up. Pour the drained fuel into the fuel tank. 3. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from rusting and the fuel from deteriorating. 4. - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 69
(1.50 x 1.71 in) Compression ratio 12.00 :1 Starting system Electric starter and kickstarter Lubrication system Wet sump Recommended engine oil grade API service SG type or higher, JASO standard MA Periodic oil change 0.78 L (0.82 US qt, 0.69 Imp.qt) Clutch Clutch type Dry, centrifugal automatic - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 70
SPECIFICATIONS Caster angle 24.00 degree Trail 70.0 mm (2.76 in) Rear wheel Wheel type Cast wheel Rim size J10 xMT 2.15 Battery Model GTX5L-BS Voltage, capacity 12 V, 4.0 Ah 1 2 3 4 5 6 7 8 9 Front tire Type Tubeless Size 90/90-10 41J Manufacturer/model MAXXIS / C-922 Front brake Type Drum - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 71
SPECIFICATIONS 1 2 3 4 5 6 7 8 9 8-3 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 72
EAU26343 CONSUMER INFORMATION EAU26352 EAU26390 EAU26410 Identification numbers 1 2 3 4 5 6 7 8 Key identification number Vehicle identification number Record the key identifi cation number, vehicle identification number and model label information in the spaces provided below for assistance when - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 73
EAU26343 CONSUMER INFORMATION EAU26460 EAU48270 Model label 1 Vehicle Emission Control Information label 1 1 2 3 ZAUM00** 1. Model label 4 1. Vehicle Emission Control Information label The model label is affixed to the location shown. Record the information on this label in the space provided - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 74
that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 75
EAU26343 CONSUMER INFORMATION EAU26580 Scooter noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 76
18 months 8000 mi (13000 km) or 24 months 10000 mi (16000 km) or 30 months 12000 mi (19000 km) or 36 months Date of service Mileage Servicing dealer name and address Remarks 9-5 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 77
EAU26343 CONSUMER INFORMATION Maintenance interval 14000 mi (22000 km) or 42 months 16000 mi (25000 km) or 48 months 18000 mi (28000 km) or 54 months 20000 mi (31000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 1 2 3 4 5 6 7 8 9 9-6 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 78
EAU26343 CONSUMER INFORMATION EAU26681 YAMAHA MOTOR CORPORATION, U.S.A. RIVA LIMITED WARRANTY 1 2 3 4 5 6 7 8 9 9-7 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 79
EAU26343 CONSUMER INFORMATION 1 2 3 4 5 6 7 8 9 9-8 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 80
no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 81
isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 1 2 3 4 5 6 7 8 9 9-10 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 82
24 Throttle grip and cable, checking and lubricating ...6-19 Throttle grip free play, checking...6-14 Tires ...6-15 Troubleshooting ...6-25 Troubleshooting charts ...6-27 Turn signal indicator lights ...3-2 Turn signal light bulb, replacing ...6-25 Turn signal switch ...3-4 M Maintenance, emission - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 83
INDEX Wheel bearings, checking...6-21 - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 84
INDEX - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 85
INDEX - 2011 Yamaha Motorsports Vino Classic | Owners Manual - Page 86
YAMAHA MOTOR TAIWAN CO., LTD PRINTED IN TAIWAN 2010.07-0.8 × 1 ! (E)
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
 |
 |
3D1-F8199-15
XC50A
OWNER’S MANUAL
Read this manual carefully before operating this vehicle.
LIT-11626-24-56