2010 Yamaha Motorsports Vino Classic Owners Manual

2010 Yamaha Motorsports Vino Classic Manual

Get 2010 Yamaha Motorsports Vino Classic PDF manuals and user guides View all 2010 Yamaha Motorsports Vino Classic manuals

2010 Yamaha Motorsports Vino Classic manual content summary:

  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 1
    Read this manual carefully before operating this vehicle. OWNER'S MANUAL XC50Z LIT-11626-23-63 3D1-F8199-14
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 2
    1 2 3 EAU10042 4 5 6 7 8 9 Q Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold.
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 3
    Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. Yamaha continually seeks advancements in product design and quality. Therefore, while this manual contains the most current product information available at the time of
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 4
    INFORMATION Particularly important information is distinguished in this manual by the following notations: 1 2 WARNING 3 4 5 6 7 8 9 EAU10122 EAU10132 Q This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 5
    INFORMATION EAU10122 1 2 3 4 5 EAUT2191 6 7 8 9 XC50Z OWNER'S MANUAL ©2009 by Yamaha Motor Corporation, U.S.A. 1st edition, July 2009 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A.
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 6
    ...6-20 Replacing the fuse ...6-21 Replacing the headlight bulb ...6-22 Replacing the tail/brake light bulb 6-23 Replacing a turn signal light bulb . 6-23 Troubleshooting ...6-24 Troubleshooting charts ...6-25 SCOOTER CARE AND STORAGE ...7-1 Matte color caution ...7-1 Care ...7-1 Storage ...7-3
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 7
    ...8-1 CONSUMER INFORMATION ...9-1 Identification numbers ...9-1 Reporting safety defects ...9-3 Motorcycle noise regulation ...9-4 Maintenance record ...9-5 YAMAHA MOTOR CORPORATION, U.S.A. RIVA LIMITED WARRANTY ...9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...9-9 EAU10210 1 2 3 4 5 6 7 8 9
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 8
    Labels, location LOCATION OF IMPORTANT LABELS EAU45762 EAU10383 1 2 3 4 5 6 7 8 9 Read and understand all of the labels on your vehicle. They contain important information for safe and proper operation of your vehicle. Never remove any labels from your vehicle. If a label becomes difficult
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 9
    LOCATION OF IMPORTANT LABELS 1 4 EAU45762 1 2 2 5 3 4 5 3 6 6 7 8 9 1-9 1-2
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 10
    should: ● Obtain thorough instructions from a competent source on all aspects of scooter operation. ● Observe the warnings and maintenance requirements in this Owner's Manual. ● Obtain qualified training in safe and proper riding techniques. ● Obtain professional technical service as indicated in
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 11
    Q SAFETY INFORMATION typical error made by the operator is veering wide on a turn due to excessive speed or undercornering (insufficient lean angle for the speed). • Always obey the speed limit and never travel faster than warranted by road and traffic conditions. • Always signal before turning or
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 12
    Q SAFETY INFORMATION ● EAU10221 1 2 3 4 5 6 7 8 9 ports. Do not run engine outdoors where engine exhaust can be drawn into a building through openings such as windows and doors. Maximum load: 77 kg (170 lb) Loading Adding accessories or cargo to your scooter can adversely affect stability and
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 13
    Q SAFETY INFORMATION even if sold and installed by a Yamaha dealer. Aftermarket Parts, Accessories, and Modifications While you may find aftermarket products similar in design and quality to genuine Yamaha accessories, recognize that some aftermarket accessories or modifications are not suitable
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 14
    Safe-riding points Q SAFETY INFORMATION EAU10350 EAU10221 Further safe-riding points ● ● 1 2 3 ● ● 4 ● 5 6 7 8 9 ● ● Make sure to signal clearly when making turns. Braking can be extremely difficult on a wet road. Avoid hard braking, because the scooter could slide. Apply the brakes
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 15
    Q SAFETY INFORMATION EAU10221 1 2 3 4 5 6 7 8 9 1-15 1-8
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 16
    Part locations DESCRIPTION Left view 1 2 EAU10401 EAU10410 2 3 4 5 6 1 3 4 5 6 7 8 9 1. Front turn signal light (page 6-23) 2. Luggage hook (page 3-11) 3. Helmet holder (page 3-9) 4. Storage compartment (page 3-10) 5. Fuel tank cap (page 3-6) 6. Rear turn signal light (page 6-23) 7.
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 17
    DESCRIPTION EAU10420 EAU10401 Right view 1 2 3 4 5 1 2 3 4 5 8 7 6 6 7 8 9 1. 2. 3. 4. 5. 6. 7. 8. Tail/brake light (page 6-23) Carrier (page 3-11) Seat (page 3-9) Coolant reservoir (page 6-11) Headlight (page 6-22) Spark plug (page 6-6) Centerstand (page 6-18) Muffler (page 3-8) 2-17 2-2
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 18
    DESCRIPTION Controls and instruments 1 2 3 4 5 EAU10401 EAU10430 1 2 3 4 5 9 6 7 8 9 1. 2. 3. 4. 5. 6. 7. 8. 9. Rear brake lever (page 3-5) Left handlebar switches (page 3-3) Speedometer unit (page 3-3) Right handlebar switches (page 3-3) Front brake lever (page 3-4) Throttle grip (page 5-2)
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 19
    Main switch/steering lock INSTRUMENT AND CONTROL FUNCTIONS EAU10460 EAU10661 EAU1044D Main switch/steering lock OFF All electrical systems are off. The key can be removed. EWA10061 WARNING Never turn the key to "OFF" or "LOCK" while the vehicle is moving. Otherwise the electrical systems
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 20
    , the radiator fan(s) automatically switch on or off according to the coolant temperature in the radiator. If the engine overheats, see page 6-26 for further instructions. 3-20 3-2
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 21
    Handlebar switches INSTRUMENT AND CONTROL FUNCTIONS EAUT1821 EAU12150 EAU12348 EAU1044D Speedometer unit 2 1 Fuel gauge Handlebar switches Left 1 1 1 ZAUM00** ZAUM00** 2 3 4 1. Speedometer 2. Odometer 1. Fuel gauge ZAUM00** 2 3 The speedometer unit is equipped with a speedometer and
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 22
    EAU12460 Start switch "," Push this switch while applying the front or rear brake to crank the engine with the starter. See page 5-1 for starting instructions prior to starting the engine. 1. Front brake lever The front brake lever is located on the right handlebar grip. To apply the front brake
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 23
    Rear wheel lock INSTRUMENT AND CONTROL FUNCTIONS EAU12950 EAUT1551 EAU1044D Rear brake lever 1 Rear wheel lock When the rear wheel lock lever is pulled down to lock the rear wheel, a cover will close over the main switch keyhole to help prevent theft. keyhole will be covered. TIP If the
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 24
    . EWA10881 WARNING Gasoline and gasoline vapors are extremely flammable. To avoid fires and explosions and to reduce the risk of injury when refueling, follow these instructions. 1. Before refueling, turn off the engine and be sure that no one is sitting on the vehicle. Never refuel while
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 25
    (E10). Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. 2 3 4 5 6 7 8 9 Recommended fuel UNLEADED GASOLINE ONLY Fuel tank capacity: 4.5 L (1.19 US gal) (0.98 Imp.gal) ECA11400 NOTICE Use only unleaded gasoline
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 26
    Kickstarter INSTRUMENT AND CONTROL FUNCTIONS EAU13433 ECA10701 EAU1044D EAU13680 Catalytic converter 1 2 3 4 5 6 7 8 9 This model is equipped with a catalytic converter in the exhaust system. EWA10862 NOTICE Use only unleaded gasoline. The use of leaded gasoline will cause unrepairable
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 27
    Helmet holder INSTRUMENT AND CONTROL FUNCTIONS EAUT1502 EAU1044D Seat To close the seat 1. Fold the seat down, and then push it down to lock it in place. 2. Remove the key from the main switch if the scooter will be left unattended. TIP Make sure that the seat is properly secured before
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 28
    Storage compartments INSTRUMENT AND CONTROL FUNCTIONS To release the helmet from the helmet holder Open the seat, remove the helmet from the helmet holder, and then close the seat. EAUT1712 EAU1044D Storage compartments 1 1 1 2 3 4 5 6 7 8 9 ZAUM00** 1. Storage compartment ZAUM00** 1.
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 29
    Luggage hook INSTRUMENT AND CONTROL FUNCTIONS ● EAU1044D ● plastic bag before storing them in the compartment. Since the rear storage compartment may get wet while the scooter is being washed, wrap any articles stored in the rear compartment in a plastic bag. Do not keep anything valuable
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 30
    the possibility of an accident or equipment damage. Do not operate the vehicle if you find any problem. If a problem cannot be corrected by the procedures provided in this manual, have the vehicle inspected by a Yamaha dealer. Before using this vehicle, check the following points: 4 5 6 7 8 9 4-30
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 31
    Pre-operation check list FOR YOUR SAFETY - PRE-OPERATION CHECKS Pre-operation check list ITEM Fuel • Check fuel level in fuel tank. • Refuel if necessary. • Check fuel line for leakage. • Check oil level in engine. • If necessary, add recommended oil to specified level. • Check vehicle for oil
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 32
    FOR YOUR SAFETY - PRE-OPERATION CHECKS ITEM Centerstand CHECKS • Make sure that operation is smooth. • Lubricate pivots if necessary. • Make sure that all nuts, bolts and screws are properly tightened. • Tighten if necessary. • Check operation. • Correct if necessary. • Check operation. PAGE 6-18
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 33
    Read the Owner's Manual carefully to become familiar with all controls. If there is a control or function you do not understand, ask your Yamaha dealer. EWA10271 Starting a cold engine ECA10250 the throttle open 1/8 turn. NOTICE See page 5-3 for engine break-in instructions prior to operating
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 34
    Braking OPERATION AND IMPORTANT RIDING POINTS EAU16770 EAU16780 EAU15943 EAU16793 Starting off 1 2 3 4 TIP Before starting off, allow the engine to warm up. 1. While pulling the rear brake lever with your left hand and holding the carrier with your right hand, push the scooter off the
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 35
    operation above 1/3 throttle. After every hour of operation, stop the engine, and then let it cool for five to ten minutes. NOTICE If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. 5-35 5-3
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 36
    Parking OPERATION AND IMPORTANT RIDING POINTS EAU17213 EWA10311 EAU15943 Parking 1 2 3 4 ● ● When parking, stop the engine, and then remove the key from the main switch. WARNING ● 5 6 7 8 9 ZAUM00** Since the engine and exhaust system can become very hot, park in a place where
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 37
    The most important points of vehicle inspection, adjustment, and lubrication are explained on the following pages. EWA10321 ● Running the engine while servicing can lead to eye injury, burns, fire, or carbon monoxide poisoning possibly leading to death. See page 1-3 for more information about
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 38
    mi (10000 km 6 4 7 5 * Idle speed * Exhaust system * Air induction system 8 6 9 7 — — — — — * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 6-38 6-2
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 39
    Maintenance and lubrication, periodic PERIODIC MAINTENANCE AND ADJUSTMENT EAU32125 EAU1722A General maintenance and lubrication chart INITIAL NO. ITEM ROUTINE 600 mi (1,000 km) or 1 month 2,000 mi (4,000 km) or 6 months ODOMETER READING 10,000 mi 8,000 mi 6,000 mi 4,000 mi (7,000 km) (10,
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 40
    PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL NO. ITEM ROUTINE 600 mi (1,000 km) or 1 month 2,000 mi (4,000 km) or 6 months ODOMETER READING EAU1722A 1 2 3 4 12 9 10 11 Front brake lever pivot shaft Rear brake lever pivot shaft Centerstand • Apply lithium-soap-based grease lightly. • Apply lithium-
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 41
    operation. • Adjust headlight beam. √ √ √ √ √ √ 22 * √ √ √ √ √ 5 * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. TIP From 12000 mi (19000 km) or 36 months, repeat the maintenance intervals starting from 4000 mi (7000 km) or
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 42
    Spark plug, checking PERIODIC MAINTENANCE AND ADJUSTMENT EAU18751 EAU1722A EAUT1483 Removing and installing the panel 1 2 3 ZAUM00** Checking the spark plug 1 1 1 4 ZAUM00** 1. Panel A 5 6 7 8 1. Panel A To install the panel Place the panel in the original position, and then install
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 43
    plug by pulling it up. 3. Remove the spark plug cap. ferent color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 2. Check the spark plug for electrode erosion and excessive carbon or other deposits, and
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 44
    Engine oil PERIODIC MAINTENANCE AND ADJUSTMENT EAUT1461 EAU1722A Engine oil and oil strainer 1 2 3 4 5 6 7 8 9 ZAUM00** The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil strainer cleaned at the intervals specified in the periodic
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 45
    PERIODIC MAINTENANCE AND ADJUSTMENT 4 3 2 1 seated. 7. Install engine oil drain bolt A, and then tighten both drain bolts to their specified torques. Tightening torque: Engine oil drain bolt A: 23 Nm (2.3 m • kgf, 16.6 ft • lbf) Engine oil drain bolt B: 32 Nm (3.2 m • kgf, 23.1 ft • lbf) EAU1722A
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 46
    Final transmission oil PERIODIC MAINTENANCE AND ADJUSTMENT EAUT1561 EAU1722A Final transmission oil 1 2 3 4 5 6 7 8 9 The final transmission case must be checked for oil leakage before each ride. If any leakage is found, have a Yamaha dealer check and repair the scooter. In addition, the
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 47
    Coolant PERIODIC MAINTENANCE AND ADJUSTMENT EAU20070 EAU1722A Coolant The coolant level should be checked before each ride. In addition, the coolant must be changed at the intervals specified in the periodic maintenance and lubrication chart. EAUT1523 TIP The coolant should be between the
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 48
    Air filter element and check hose, replacing and cleaning PERIODIC MAINTENANCE AND ADJUSTMENT ness of the coolant will be reduced.[ECA10472] 1 2 3 4 5 6 7 8 9 Coolant reservoir capacity: 0.25 L (0.26 US qt, 0.22 Imp.qt) EAU33031 EAUT1491 EAU1722A Replacing the air filter element and cleaning
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 49
    Throttle cable free play, checking PERIODIC MAINTENANCE AND ADJUSTMENT EAU21251 EAU44734 EAU21382 EAU1722A Carburetor The carburetor is an important part of the engine and its emission control system, which requires very sophisticated adjustment. Therefore, carburetor adjustments should be
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 50
    Tires PERIODIC MAINTENANCE AND ADJUSTMENT EAU21401 EAU21912 EAU1722A Valve clearance 1 2 3 4 5 6 7 8 9 The valve clearance changes with use, resulting in improper air-fuel mixture and/ or engine noise. To prevent this from occurring, the valve clearance must be adjusted by a Yamaha dealer at
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 51
    Front brake lever free play, checking PERIODIC MAINTENANCE AND ADJUSTMENT EWA10580 EAU21960 EAU22130 EAU1722A WARNING 8 It is dangerous to ride with a worn-out tire. When a tire tread begins to show crosswise lines, have a Yamaha dealer replace the tire immediately. 8 The replacement of all
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 52
    Rear brake lever free play, adjusting PERIODIC MAINTENANCE AND ADJUSTMENT EAU22170 EAU1722A Adjusting the rear brake lever free play 1 2 3 4 WARNING 5 6 7 8 9 If proper adjustment cannot be obtained as described, have a Yamaha dealer make this adjustment. ZAUM00** 1 (b) (a) 1 ZAUM00** (b)
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 53
    Throttle grip and cable, checking and lubricating PERIODIC MAINTENANCE AND ADJUSTMENT EAU22361 EAU1722A Checking the front and rear brake shoes Front Rear EAU23111 Checking and lubricating the throttle grip and cable 1 The operation of the throttle grip should be checked before each ride.
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 54
    oil leakage. To check the operation 1. Place the vehicle on a level surface and hold it in an upright position. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over. [EWA10751] 2. While applying the front brake, push down hard on the handlebars several
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 55
    as follows at the intervals specified in the periodic maintenance and lubrication chart. 1. Place the vehicle on the centerstand. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over.[EWA10751] 2. Hold the lower ends of the front fork legs and try to move
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 56
    Battery PERIODIC MAINTENANCE AND ADJUSTMENT EAU23290 EAUT1233 EAU1722A EWA10760 Checking the wheel bearings 1 2 3 4 5 6 7 8 9 The front and rear wheel bearings must be checked at the intervals specified in the periodic maintenance and lubrication chart. If there is play in the wheel hub or
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 57
    Fuse, replacing PERIODIC MAINTENANCE AND ADJUSTMENT The battery is located under the footboard. Remove panel A to access the battery. (See page 6-6.) To charge the battery Have a Yamaha dealer charge the battery as soon as possible if it seems to have discharged. Keep in mind that the battery
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 58
    Headlight bulb, replacing PERIODIC MAINTENANCE AND ADJUSTMENT electrical system and possibly a fire.[EWA15131] 1 2 3 4 5 6 7 8 9 Specified fuse: 7.5 A EAU23783 EAU1722A Replacing the headlight bulb This model is equipped with a quartz bulb headlight. If the headlight bulb burns out, replace
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 59
    Turn signal light bulb, replacing PERIODIC MAINTENANCE AND ADJUSTMENT 3. Remove the headlight bulb holder by turning it counterclockwise, and then remove the burnt-out bulb. EAU24133 EAU24204 EAU1722A Replacing the tail/brake light bulb 1. Remove the tail/brake light lens by removing the
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 60
    trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause poor starting and loss of power. The following troubleshooting parts, but they are often inferior, have a shorter service life and can lead to expensive repair bills. WARNING When
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 61
    charts PERIODIC MAINTENANCE AND ADJUSTMENT EAUT1581 EAU1722A Troubleshooting charts Starting problems or poor engine performance 1 1. Fuel There is enough fuel. Check the fuel level in the fuel tank. There is no fuel. Supply fuel. Check the
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 62
    PERIODIC MAINTENANCE AND ADJUSTMENT Engine overheating WARNING 1 2 3 4 5 6 7 8 9 Wait until the engine has cooled. Check the coolant level in the reservoir and radiator. The coolant level is OK. The coolant level is low. Check the cooling system for leakage. EAU1722A EWAT1040 ● ● Do not remove
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 63
    spoked wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. Improper cleaning can damage plastic parts (such
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 64
    SCOOTER CARE AND STORAGE luted mild detergent with water may be used. Be sure to rinse off any detergent residue using plenty of water, as it is harmful to plastic parts. Do not use any harsh chemical products on plastic parts. Be sure to avoid using cloths or sponges which have been in contact with
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 65
    of the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your scooter for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. Drain the carburetor float chamber by loosening the drain bolt; this will prevent fuel deposits
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 66
    SCOOTER CARE AND STORAGE up. Pour the drained fuel into the fuel tank. 3. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from rusting and the fuel from deteriorating. 4. Perform the following steps to protect the cylinder, piston rings, etc. from corrosion. a.
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 67
    mm (1.50 x 1.71 in) Compression ratio 12.00 :1 Starting system Electric starter and kickstarter Lubrication system Wet sump Recommended engine oil grade API service SG type or higher JASO standard MA Periodic oil change 0.78 L (0.82 US qt, 0.69 Imp.qt) Clutch Clutch type Dry, centrifugal automatic
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 68
    SPECIFICATIONS Caster angle 24.00 degree Trail 70.0 mm (2.76 in) EAU26320 Rear wheel Wheel type Cast wheel Rim size J10 xMT 2.15 Battery Model GTX5L-BS Voltage, capacity 12 V, 4.0 Ah 1 2 3 4 5 6 7 8 9 Front tire Type Tubeless Size 90/90-10 41J Manufacturer/model MAXXIS / C-922 Front brake Type
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 69
    Vehicle identification number CONSUMER INFORMATION EAU26352 EAU26390 EAU26343 EAU26410 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 70
    Vehicle Emission Control Information label CONSUMER INFORMATION EAU26460 EAU48060 EAU26343 Model label 1 2 3 4 5 6 7 8 9 ZAUM00** Vehicle Emission Control Information label 1 1 1. Model label The model label is affixed to the location shown. Record the information on this label in the
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 71
    that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 72
    Noise regulation CONSUMER INFORMATION Motorcycle noise regulation 1 2 3 4 5 6 7 Intake system Exhaust system Muffler Exhaust pipe Silencer Air cleaner case Air cleaner element Intake duct EAU26343 EAU26560 TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 73
    24 months 10000 mi (16000 km) or 30 months 12000 mi (19000 km) or 36 months 14000 mi (22000 km) or 42 months Date of service Mileage Servicing dealer name and address Remarks 1 2 3 4 5 6 7 8 9 9-73 9-5
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 74
    CONSUMER INFORMATION Maintenance interval 16000 mi (25000 km) or 48 months 18000 mi (28000 km) or 54 months 20000 mi (31000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks EAU26343 1 2 3 4 5 6 7 8 9 9-74 9-6
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 75
    Warranty, limited CONSUMER INFORMATION YAMAHA MOTOR CORPORATION, U.S.A. RIVA LIMITED WARRANTY EAU26343 EAU26681 1 2 3 4 5 6 7 8 9 9-75 9-7
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 76
    CONSUMER INFORMATION EAU26343 1 2 3 4 5 6 7 8 9 9-76 9-8
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 77
    no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 78
    isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) EAU26343 1 2 3 4 5 6 7 8 9 9-78 9-10
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 79
    ...6-23 Throttle cable free play, checking ...6-13 Throttle grip and cable, checking and lubricating ...6-17 Tires ...6-14 Troubleshooting ...6-24 Troubleshooting charts ...6-25 Turn signal indicator lights ...3-2 Turn signal light bulb, replacing ...6-23 Turn signal switch ...3-4 M Main switch
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 80
    INDEX W Warranty, extended ...9-9 Warranty, limited ...9-7 Wheel bearings, checking ...6-20 Wheels ...6-15 1 2 3 4 5 6 7 8 9
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 81
    1 2 3 4 5 6 7 8 9
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 82
    1 2 3 4 5 6 7 8 9
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 83
    1 2 3 4 5 6 7 8 9
  • 2010 Yamaha Motorsports Vino Classic | Owners Manual - Page 84
    YAMAHA MOTOR TAIWAN CO., LTD PRINTED IN TAIWAN 2009.07-0.8× 1! (E)
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
Read this manual carefully before operating this vehicle.
XC50Z
OWNER’S MANUAL
3D1-F8199-14
LIT-11626-23-63