2010 Yamaha Motorsports Majesty Owners Manual
2010 Yamaha Motorsports Majesty Manual
2010 Yamaha Motorsports Majesty manual content summary:
- 2010 Yamaha Motorsports Majesty | Owners Manual - Page 1
Read this manual carefully before operating this vehicle. OWNER'S MANUAL YP400Z LIT-11626-23-11 34B-28199-11 - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 2
EAU10042 Q Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold. - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 3
Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. Yamaha continually seeks advancements in product design and quality. Therefore, while this manual contains the most current product information available at the time of - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 4
INFORMATION EAU10132 Particularly important information is distinguished in this manual by the following notations: This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 5
INFORMATION EAU10193 YP400Z OWNER'S MANUAL ©2009 by Yamaha Motor Corporation, U.S.A. 1st edition, February 2009 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A. - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 6
TABLE OF CONTENTS LOCATION OF IMPORTANT LABELS ...1-1 SAFETY INFORMATION ...2-1 Further safe-riding points ...2-5 DESCRIPTION ...Left view ...Right view ...Controls and instruments...3-1 3-1 3-2 3-3 Ignition circuit cut-off system ...4-17 FOR YOUR SAFETY - PREOPERATION CHECKS ...5-1 OPERATION AND - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 7
rear turn signal light bulb ...Replacing the license plate light bulb ...Troubleshooting ...Troubleshooting charts ...7-36 7-36 7-37 7-38 8-1 8-1 8-1 8-3 SCOOTER CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...YAMAHA EXTENDED SERVICE (Y.E.S.) ...10-1 10-1 10-3 10-4 10-5 10-7 - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 8
LOCATION OF IMPORTANT LABELS EAU10383 1 Read and understand all of the labels on your vehicle. They contain important information for safe and proper operation of your vehicle. Never remove any labels from your vehicle. If a label becomes difficult to read or comes off, a replacement label is - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 9
, gasoline or solvent will damage windshield. Use neutral detergent. 8ET-2815K-00 WARNING BEFORE YOU OPERATE THIS VEHICLE, READ THE OWNER'S MANUAL AND ALL LABELS. ALWAYS WEAR AN APPROVED MOTORCYCLE HELMET, eye protection, and protective clothing. 5GK-2118K-00 1 2 3 4 5 3 4 5 LOAD LIMIT 2 kg - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 10
should: ● Obtain thorough instructions from a competent source on all aspects of scooter operation. ● Observe the warnings and maintenance requirements in this Owner's Manual. ● Obtain qualified training in safe and proper riding techniques. ● Obtain professional technical service as indicated in - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 11
SAFETY INFORMATION ● ● ● ● ● ● ● Always obey the speed limit and never travel faster than warranted by road and traffic conditions. Always signal before turning or changing lanes. Make sure that other motorists can see you. The posture of the operator and passenger is important for proper - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 12
SAFETY INFORMATION ● 1 2 3 4 5 6 7 8 9 ports. Do not run engine outdoors where engine exhaust can be drawn into a building through openings such as windows and doors. Loading Adding accessories or cargo to your scooter can adversely affect stability and handling if the weight distribution of the - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 13
SAFETY INFORMATION or modifications are not suitable because of potential safety hazards to you or others. Installing aftermarket products or having other modifications performed to your vehicle that change any of the vehicle's design or operation characteristics can put you and others at greater - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 14
SAFETY INFORMATION EAU10372 Further safe-riding points ● 1 2 3 4 5 ● ● ● ● 6 7 8 9 ● ● Be sure to signal clearly when making turns. Braking can be extremely difficult on a wet road. Avoid hard braking, because the scooter could slide. Apply the brakes slowly when stopping on a wet surface. - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 15
DESCRIPTION EAU10410 Left view 1 2 3 4 5 6 7 2 3 4 5 6 7 11 1. 2. 3. 4. 5. 6. 7. Headlight (page 7-34) Fuel tank cap (page 4-9) Rear storage compartment (page 4-14) V-belt case air filter element (page 7-19) Owner's tool kit (page 7-2) Fuses (page 7-33) Battery (page 7-31) 3-1 10 9 8 8 9 8. - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 16
DESCRIPTION EAU10420 Right view 1 1 2 3 4 5 6 7 8 9 1. 2. 3. 4. 5. 6. 7. Grab bar (page 6-2) Passenger seat (page 4-12) Rider seat (page 4-12) Coolant reservoir (page 7-18) Radiator Centerstand (page 7-29) Air filter element (right) (page 7-19) 3-2 2 3 4 8 7 6 5 8. Shock absorber assembly - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 17
DESCRIPTION EAU10430 Controls and instruments 1 2 3 4 5 6 7 8 2 3 4 5 6 7 12 1. 2. 3. 4. 5. 6. 7. Rear brake lever (page 4-8) Left handlebar switches (page 4-7) Rear brake lock lever (page 4-8) Speedometer (page 4-2) Multi-function display (page 4-3) Tachometer (page 4-3) Right handlebar switches - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 18
INSTRUMENT AND CONTROL FUNCTIONS EAU10460 Main switch/steering lock 1 2 3 4 5 6 7 8 9 The main switch/steering lock controls the ignition and lighting systems, and is used to lock the steering. The various positions are described below. EAU36070 sidestand is moved down. EAU10661 To unlock the - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 19
and warning lights 1 2 3 1. Turn signal indicator lights " " and " 2. High beam indicator light " " 3. Engine trouble warning light " " " Engine trouble warning light " " This warning light comes on if a problem is detected in the electrical circuit monitoring the engine. If this occurs, have - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 20
INSTRUMENT AND CONTROL FUNCTIONS EAU11872 EAU36109 Tachometer 1 1 2 3 4 5 6 7 8 9 Multi-function display EWA12312 1 2 3 4 2 WARNING Be sure to stop the vehicle before making any setting changes to the multi-function display. Changing settings while riding can distract the operator and - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 21
seconds). While "Trip" or "Trip F" is flashing, push the "RESET" button for at least one second. If you do not reset the fuel reserve tripmeter manually, it will reset it4-4 - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 22
Yamaha dealer check the electrical circuit. Self-diagnosis device This model is equipped with a self-diagnosis device for various electrical circuits. If a problem is detected in any of those circuits, the multi-function display will indicate an error code. If the multi-function display indicates an - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 23
INSTRUMENT AND CONTROL FUNCTIONS 3. Push the "SELECT" button, and the minute digits will start flashing. 4. Push the "RESET" button to set the minutes. 5. Push the "SELECT" button and then release it to start the clock. Pushing the "SELECT" button for at least two seconds switches the clock display - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 24
the sidestand up, push this switch while applying the front or rear brake to crank the engine with the starter. See page 6-1 for starting instructions prior to starting the engine. Turn signal switch " / " To signal a right-hand turn, push this switch to " ". To signal a left-hand turn, push this - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 25
INSTRUMENT AND CONTROL FUNCTIONS EAU12900 EAU12950 EAU12962 Front brake lever 1 Rear brake lever 1 Rear brake lock lever 1 2 3 4 5 6 7 8 9 1. Front brake lever 1. Rear brake lever 1. Rear brake lock lever The front brake lever is located on the right handlebar grip. To apply the front brake, - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 26
INSTRUMENT AND CONTROL FUNCTIONS ● 1 2 3 4 5 6 7 8 9 rear brake lock lever is applied. To provide secure locking of the rear wheel, apply the rear brake lever first before moving the rear brake lock lever to the left. EWA12361 EAU13163 Fuel tank cap To open the fuel tank cap 1. Open the lid by - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 27
WARNING Gasoline and gasoline vapors are extremely flammable. To avoid fires and explosions and to reduce the risk of injury when refueling, follow these instructions. 1. Before refueling, turn off the engine and be sure that no one is sitting on the vehicle. Never refuel while smoking, or while in - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 28
containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. EAU13433 Catalytic converter This model is equipped with a catalytic converter in the exhaust system. EWA10862 1 2 3 4 5 6 7 8 9 Recommended fuel UNLEADED GASOLINE - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 29
INSTRUMENT AND CONTROL FUNCTIONS pairable damage to the catalytic converter. EAU34140 Seats 1 1 2 2 3 1. Open. 1. Rider seat 2. Passenger seat TIP Do not push inward when turning the key. 3. Fold the rider seat up. 4 5 6 7 8 9 Rider seat To open the rider seat 1. Place the scooter on the - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 30
INSTRUMENT AND CONTROL FUNCTIONS To close the rider seat 1. Fold the rider seat down, and then push it down to lock it in place. 2. Remove the key from the main switch if the scooter will be left unattended. TIP Make sure that the rider seat is properly secured before riding. Passenger seat To - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 31
INSTRUMENT AND CONTROL FUNCTIONS EAU14494 Storage compartments Front storage compartment A To open the storage compartment when it is locked, insert the key in the lock, turn it counterclockwise, and then grasp the lock while pushing the button in. To open the storage compartment when it is - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 32
INSTRUMENT AND CONTROL FUNCTIONS 1 ● 1 2 3 4 5 6 7 8 9 1 being washed, wrap any articles stored in the compartment in a plastic bag. Do not keep anything valuable or breakable in the storage compartment. ECA11100 2 1. Storage compartment opening lever 2. Lid 1. Rider seat ECA10080 To close the - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 33
INSTRUMENT AND CONTROL FUNCTIONS EAU14891 Adjusting the shock absorber assemblies 1 2 5 4 3 2 1 handling and loss of stability may result. Adjust the spring preload as follows. To increase the spring preload and thereby harden the suspension, turn the adjusting ring on each shock absorber assembly - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 34
INSTRUMENT AND CONTROL FUNCTIONS pair it if it does not function properly. EAU45051 Ignition circuit cut-off system The ignition circuit cut-off system (comprising the sidestand switch and brake light switches) has the following functions. ● It prevents starting when the sidestand is up, but - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 35
INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is turned on. 3. Turn the key on. 4. Keep the front or rear brake applied. 5. Push the start switch. Does the engine start? WARNING If a malfunction is noted, have a - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 36
the possibility of an accident or equipment damage. Do not operate the vehicle if you find any problem. If a problem cannot be corrected by the procedures provided in this manual, have the vehicle inspected by a Yamaha dealer. Before using this vehicle, check the following points: ITEM CHECKS - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 37
FOR YOUR SAFETY - PRE-OPERATION CHECKS ITEM ● ● ● CHECKS Check operation. If soft or spongy, have Yamaha dealer bleed hydraulic system. Check brake pads for wear. Replace if necessary. Check fluid level in reservoir. If necessary, add recommended brake fluid to specified level. Check hydraulic system - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 38
5 6 7 8 9 Read the Owner's Manual carefully to become familiar with all controls. If NOTICE See page 6-3 for engine break-in instructions prior to operating the vehicle for the first for a few seconds, then go off. ● Engine trouble warning light ● V-belt replacement indicator ● Oil change - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 39
OPERATION AND IMPORTANT RIDING POINTS 2. Close the throttle completely. 3. Start the engine by pushing the start switch while applying the front or rear brake. NOTICE: For maximum engine life, never accelerate hard when the engine is cold![ECA11041] If the engine does not start, release the start - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 40
OPERATION AND IMPORTANT RIDING POINTS EAU16793 Braking EWA10300 Front EAU16841 Engine break-in There is never a more important period in the life of your engine than the period between 0 and 1600 km (1000 mi). For this reason, you should read the following material carefully. Since the engine is - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 41
and then remove the key from the main switch. EWA10311 NOTICE ● Keep the engine speed out of the tachometer red zone. ● If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. ● ● ● WARNING Since the engine and exhaust system can - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 42
inspection, adjustment, and lubrication are explained on the following pages. EWA10321 ● parts that can cause shocks or fires. Running the engine while servicing can lead to eye injury, burns, fire, or carbon monoxide poisoning - possibly leading to death. See page 2-1 for more information about - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 43
the rear storage compartment. (See page 4-14.) Pull up the storage compartment mat, and then remove the owner's tool kit. The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and minor - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 44
. Replace any damaged parts. √ √ Replace. √ √ Every 26600 mi (42000 km * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 7-3 - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 45
PERIODIC MAINTENANCE AND ADJUSTMENT EAU32185 General maintenance and lubrication chart INITIAL 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi (13000 km) or 12 months √ √ 12000 mi (19000 km) or 18 months √ √ 16000 mi (25000 km) or 24 months √ √ 20000 mi (31000 km - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 46
PERIODIC MAINTENANCE AND ADJUSTMENT INITIAL 600 mi (1000 km) or 1 month √ 4000 mi (7000 km) or 6 months √ ODOMETER READINGS 8000 mi (13000 km) or 12 months √ 12000 mi (19000 km) or 18 months √ 16000 mi (25000 km) or 24 months √ 20000 mi (31000 km) or 30 months √ No. ITEM ROUTINE 1 2 10 * - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 47
operation. 25 switches ● Adjust headlight beam. * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. ● √ √ √ √ √ √ TIP From 24000 mi (37000 km) or 36 months, repeat the maintenance intervals starting from 8000 mi (13000 km) or 12 - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 48
engine air filter elements need to be replaced and the V-belt air filter element needs to be serviced more frequently when riding in unusually wet or dusty areas. Hydraulic brake service After disassembling the brake master cylinders and calipers, always change the fluid. Regularly check the brake - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 49
PERIODIC MAINTENANCE AND ADJUSTMENT EAU18712 Removing and installing cowlings and panels The cowlings and panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a cowling or panel needs to be removed and installed. 1 1 2 - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 50
PERIODIC MAINTENANCE AND ADJUSTMENT Cowling B To remove the cowling 1. Remove the screws. 1 2 3 4 5 6 7 8 9 1. Grab bar bolt 2. Collar 3. Grab bar 1. Screw To install the cowling Place the cowling in the original position, and then install the screws. Cowlings C and D 1 1 To remove one of the - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 51
PERIODIC MAINTENANCE AND ADJUSTMENT 2 1 2. Install the screw access cover by placing it in its original position. 3. Install the grab bar by installing the collars and grab bar bolts. Tightening torque: Grab bar bolt: 23 Nm (2.3 m·kgf, 16.6 ft·lbf) 1. Left floorboard mat 1. Cowling E 1 3 4 To - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 52
PERIODIC MAINTENANCE AND ADJUSTMENT EAU34290 1 Panel A 1 2 3 4 5 To install the panel Place the panel in the original position, and then install the bolts. 1. Panel B 2. Screw To remove the panel 1. Remove the bolts. 2 2 1 6 7 8 9 1. Bolt 2. Panel A To install the panel Place the panel in the - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 53
normally). TIP If the spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 2. Check the spark plug for electrode erosion and excessive carbon or other deposits, and - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 54
PERIODIC MAINTENANCE AND ADJUSTMENT it if necessary. Specified spark plug: NGK/CR7E 3. Install the spark plug with the spark plug wrench, and then tighten it to the specified torque. Tightening torque: Spark plug: 12.5 Nm (1.25 m·kgf, 9 ft·lbf) 1 1 2 3 4 5 6 7 1. Spark plug gap To install the - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 55
PERIODIC MAINTENANCE AND ADJUSTMENT EAU36110 EAU34184 Canister Engine oil and oil filter element The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil filter element replaced at the intervals specified in the periodic maintenance and lubrication - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 56
PERIODIC MAINTENANCE AND ADJUSTMENT to collect the used oil. 3. Remove the engine oil filler cap and the engine oil drain bolt to drain the oil from the crankcase. 1 2 1 1 1 2 2 3 4 5 6 7 8 9 1. Engine oil drain bolt 2. Washer 1. Bolt 2. Oil filter element cover 1. Engine oil drain bolt 4. - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 57
PERIODIC MAINTENANCE AND ADJUSTMENT 7. Install the compression spring and oil filter element cover by installing the bolts, then tightening them to the specified torque. Tightening torque: Oil filter element cover bolt: 10 Nm (1.0 m·kgf, 7.2 ft·lbf) Recommended engine oil: See page 9-1. Oil quantity - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 58
PERIODIC MAINTENANCE AND ADJUSTMENT the correct time. To reset the oil change indicator before the periodic oil change interval has been reached, follow the above procedure, but note that the indicator will come on for 1.4 seconds after releasing the "OIL CHANGE" button, otherwise repeat the - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 59
PERIODIC MAINTENANCE AND ADJUSTMENT EAU20070 Recommended final transmission oil: See page 9-1. Oil quantity: 0.25 L (0.26 US qt, 0.22 Imp.qt) Coolant The coolant level should be checked before each ride. In addition, the coolant must be changed at the intervals specified in the periodic - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 60
case air filter element The air filter elements and the V-belt case air filter element should be serviced at the intervals specified in the periodic maintenance and lubrication chart. Service all air filter elements more frequently if you are riding in unusually wet or dusty areas. Replacing the - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 61
PERIODIC MAINTENANCE AND ADJUSTMENT Left 3. Pull the air filter element out. 1 2 1 3 3 1. Screw 2. Air filter case cover 3. Rubber cap Left 1 1 1. Air filter element Right Right stalling the screws. NOTICE: Make sure that each filter element is properly seated in its case. Always replace both - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 62
PERIODIC MAINTENANCE AND ADJUSTMENT Left Cleaning the V-belt case air filter element 1. Remove cowling E. (See page 7-8.) 2. Remove panel B. (See page 7-8.) 3. Remove the left air filter case cover. 4. Remove the V-belt air filter case cover by removing the screws. 1 1 2 3 4 5 6 1. Air filter check - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 63
PERIODIC MAINTENANCE AND ADJUSTMENT necessary. 8. Install the V-belt case air filter element by installing the screws. NOTICE: Make sure that the V-belt filter element is properly seated in its case.[ECA12941] 9. Install the V-belt air filter case cover by installing the screws. 10. Install the left - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 64
PERIODIC MAINTENANCE AND ADJUSTMENT EAU21863 Tires 1 2 3 4 5 6 7 8 9 To maximize the performance, durability, and safe operation of your scooter, note the following points regarding the specified tires. Tire air pressure The tire air pressure should be checked and, if necessary, adjusted before - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 65
control. Have excessively worn tires replaced by a Yamaha dealer immediately. Brakes, tires, and related wheel parts replacement should be left to a Yamaha Service Technician. After extensive tests, only the tires listed below have been approved for this model by Yamaha Motor Co., Ltd. Front tire - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 66
PERIODIC MAINTENANCE AND ADJUSTMENT EAU33453 Front and rear brake lever free play 1 2 3 4 5 6 7 8 9 1. Valve stem nut 2. Valve stem locknut brake lever ends. If there is free play, have a Yamaha dealer inspect the brake system. EWA14211 Front 1 1 2 Tightening torques: Valve stem nut: 2.0 Nm - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 67
PERIODIC MAINTENANCE AND ADJUSTMENT EAU33473 Adjusting the rear brake lock lever cable 1 (a) (b) 2 To decrease the rear brake lock lever cable length, turn the adjusting nut in direction (b). EWA10650 EAU22390 Checking the front and rear brake pads The front and rear brake pads must be checked - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 68
PERIODIC MAINTENANCE AND ADJUSTMENT indicator groove has almost disappeared, have a Yamaha dealer replace the brake pads as a set. 1 2 3 4 5 6 7 8 ● 1. Minimum level mark EAU34210 EAU22580 Checking the brake fluid level Front brake Rear brake pads Have a Yamaha dealer check each rear brake pad for - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 69
PERIODIC MAINTENANCE AND ADJUSTMENT ● ● lower the boiling point of the fluid and may result in vapor lock. Brake fluid may deteriorate painted surfaces or plastic parts. Always clean up spilled fluid immediately. As the brake pads wear, it is normal for the brake fluid level to gradually go down. - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 70
PERIODIC MAINTENANCE AND ADJUSTMENT EAU23111 EAU23172 EAU23213 Checking and lubricating the throttle grip and cable 1 2 3 4 5 6 7 8 9 The operation of the throttle grip should be checked before each ride. In addition, the cable should be lubricated at the intervals specified in the periodic - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 71
it. 4 5 6 7 8 9 To check the operation 1. Place the vehicle on a level surface and hold it in an upright position. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over.[EWA10751] 2. While applying the front brake, push down hard on the handlebars several - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 72
as follows at the intervals specified in the periodic maintenance and lubrication chart. 1. Place the vehicle on the centerstand. WARNING! To avoid injury, securely support the vehicle so there is no danger of it falling over.[EWA10751] 2. Hold the lower ends of the front fork legs and try to move - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 73
PERIODIC MAINTENANCE AND ADJUSTMENT ways shield your eyes when working near batteries. In case of contact, administer the following FIRST AID. EXTERNAL: Flush with plenty of water. INTERNAL: Drink large quantities of water or milk and immediately call a physician. EYES: Flush with water for 15 - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 74
PERIODIC MAINTENANCE AND ADJUSTMENT EAU34233 Replacing the fuses 1 2 3 4 5 6 7 8 9 The main fuse and the fuse box, which contains the fuses for the individual circuits, are located behind cowling A. (See page 7-8.) If a fuse is blown, replace it as follows. 1. Turn the key to "OFF" and turn off the - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 75
PERIODIC MAINTENANCE AND ADJUSTMENT EAU34240 EAU24181 Specified fuses: Main fuse: 40.0 A Ignition fuse: 10.0 A Signaling system fuse: 10.0 A Headlight fuse: 20.0 A Taillight fuse: 10.0 A Radiator fan fuse: 10.0 A Fuel injection system fuse: 10.0 A Backup fuse: 10.0 A Replacing a headlight bulb - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 76
PERIODIC MAINTENANCE AND ADJUSTMENT EAU36124 Replacing a front turn signal light bulb 1 2 3 4 5 6 1. Place the scooter on the centerstand. 2. Remove panel A. (See page 7-8.) 3. Remove the windshield by removing the screws. 1 2 1. Screw 2. Front turn signal light unit 2 1 clockwise. 7. Insert a - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 77
PERIODIC MAINTENANCE AND ADJUSTMENT EAU34263 Replacing a rear turn signal light bulb 1. Place the scooter on the centerstand. 2. Remove cowling C for replacing the left turn signal light bulb or cowling D for replacing the right turn signal light bulb. (See page 7-8.) 3. Remove the socket (together - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 78
trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause poor starting and loss of power. The following troubleshooting parts, but they are often inferior, have a shorter service life and can lead to expensive repair bills. EWA15141 - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 79
PERIODIC MAINTENANCE AND ADJUSTMENT EAU42701 Troubleshooting charts Starting problems or poor engine performance 1. Fuel There is enough fuel. Check the fuel level in the fuel tank. There is no fuel. Supply fuel. Check the - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 80
PERIODIC MAINTENANCE AND ADJUSTMENT Engine overheating EWAT1040 ● 1 ● 2 3 4 5 6 7 8 9 WARNING Do not remove the radiator cap when the engine and radiator are hot. Scalding hot fluid and steam may be blown out under pressure, which could cause serious injury. Be sure to wait until the engine has - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 81
on spoked wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. ● Improper cleaning can damage plastic parts - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 82
SCOOTER CARE AND STORAGE ● 1 2 3 4 5 6 7 8 9 ● ● plenty of water, as it is harmful to plastic parts. Do not use any harsh chemical products on plastic parts. Be sure to avoid using cloths or sponges which have been in contact with strong or abrasive cleaning products, solvent or thinner, fuel ( - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 83
of the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your scooter for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 84
SCOOTER CARE AND STORAGE fuel from deteriorating. 3. Perform the following steps to protect the cylinder, piston rings, etc. from corrosion. a. Remove the spark plug cap and spark plug. b. Pour a teaspoonful of engine oil into the spark plug bore. c. Install the spark plug cap onto the spark plug, - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 85
/model: NGK/CR7E Spark plug gap: 0.7-0.8 mm (0.028-0.031 in) Weight: With oil and fuel: 212.0 kg (467 lb) Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter element replacement: 1.50 L (1.59 US qt, 1.32 Imp.qt) With oil filter - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 86
SPECIFICATIONS Chassis: Frame type: Aluminum die-cast and steel tube backbone Caster angle: 27.00 ° Trail: 100.0 mm (3.94 in) Tire air pressure (measured on cold tires): Loading condition: 0-90 kg (0-198 lb) Front: 200 kPa (2.00 kgf/cm2, 29 psi) Rear: 250 kPa (2.50 kgf/cm2, 36 psi) Loading - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 87
light: 12 V, 5.0 W × 1 Meter lighting: 12 V, 2.0 W × 3 High beam indicator light: 12 V, 1.4 W × 1 Turn signal indicator light: 12 V, 1.4 W × 2 Engine trouble warning light: 12 V, 1.4 W × 1 2 3 4 5 6 7 8 9 Fuses: Main fuse: 40.0 A Headlight fuse: 20.0 A Taillight fuse: 10.0 A Signaling system fuse - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 88
CONSUMER INFORMATION EAU26352 EAU26381 EAU26410 Identification numbers 1 2 3 4 5 6 7 8 9 10 MODEL LABEL INFORMATION: VEHICLE IDENTIFICATION NUMBER: Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 89
CONSUMER INFORMATION EAU26500 EAU48060 Model label Vehicle Emission Control Information label 1 1 2 3 4 1. Vehicle Emission Control Information label 1. Model label The model label is affixed to the inside of the rear storage compartment. (See page 4-14.) Record the information on this label - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 90
that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327 - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 91
CONSUMER INFORMATION EAU26580 Scooter noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any device - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 92
months 24000 mi (37000 km) or 36 months 28000 mi (43000 km) or 42 months 32000 mi (49000 km) or 48 months 10-5 Date of service Mileage Servicing dealer name and address Remarks - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 93
CONSUMER INFORMATION Maintenance interval 36000 mi (55000 km) or 54 months 40000 mi (61000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 2 3 4 5 6 7 8 9 10 10-6 - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 94
1. Operate and maintain the motorcycle as specified in the appropriate Owner's Manual, and 2. Give notice to an authorized Yamaha motorcycle dealer of any . An inspection and registration fee will be charged for this service. EMISSION CONTROL SYSTEM WARRANTY: Yamaha Motor Corporation, U.S.A. also - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 95
in the Owner's and Service Manual. We do recommend, however service, you must take it to any authorized Yamaha motorcycle dealer within the continental United States. Be sure to bring your warranty registration card or other valid proof of the original date of purchase. If a question or problem - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 96
no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 97
isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 2 3 4 5 6 7 8 9 10 10-10 - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 98
checking and lubricating...7-29 Tires ...7-23 Tool kit...7-2 Troubleshooting ...7-37 Troubleshooting charts...7-38 Turn signal indicator lights ...4-2 Turn and oil filter element ...7-14 Engine stop switch ...4-7 Engine trouble warning light...4-2 N Noise regulation...10-4 P Parking ...6-4 Part - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 99
INDEX Vehicle Emission Control Information label...10-2 Vehicle identification number...10-1 W Warranty, extended ...10-9 Warranty, limited...10-7 Wheel bearings, checking ...7-31 Wheels...7-24 - 2010 Yamaha Motorsports Majesty | Owners Manual - Page 100
- 2010 Yamaha Motorsports Majesty | Owners Manual - Page 101
- 2010 Yamaha Motorsports Majesty | Owners Manual - Page 102
YAMAHA MOTOR CO., LTD. PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2009.05-0.6×1 ! (E)
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
 |
 |
34B-28199-11
YP400Z
OWNER’S MANUAL
Read this manual carefully before operating this vehicle.
LIT-11626-23-11