2008 Yamaha Motorsports Zuma Owners Manual
2008 Yamaha Motorsports Zuma Manual
2008 Yamaha Motorsports Zuma manual content summary:
- 2008 Yamaha Motorsports Zuma | Owners Manual - Page 1
OWNER'S MANUAL YW50X LIT-11626-21-15 5PJ-F8199-14 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 2
1 2 3 EAU10041 4 5 6 7 8 9 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 3
of craftsmanship and reliability that have made Yamaha a leader in these fields. 1 This manual will give you an understanding of the operation, inspection, and basic maintenance of this to the recommended maintenance schedules and operating instructions contained within this manual. 2 3 4 5 6 7 8 9 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 4
Particularly important information is distinguished in this manual by the following notations: EAU10122 EAU35821 Q 1 2 3 4 5 6 7 8 9 The Safety Alert Symbol means ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED! Failure to follow WARNING instructions could result in severe injury or death - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 5
INFORMATION EAU10122 1 2 AFFIX DEALER LABEL HERE 3 4 5 EAUT2190 6 7 8 9 YW50X OWNER'S MANUAL ©2007 by Yamaha Motor Corporation, U.S.A. 1st edition, July 2007 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A. - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 6
and lubricating the centerstand ...6-19 Checking the front fork ...6-19 Checking the steering ...6-20 Checking the wheel bearings ...6-20 Battery ...6-21 Replacing the fuse ...6-22 Troubleshooting ...6-23 Troubleshooting chart ...6-24 SCOOTER CARE AND STORAGE ...7-1 Care ...7-1 Storage ...7-3 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 7
...8-1 CONSUMER INFORMATION ...9-1 Identification numbers ...9-1 Reporting safety defects ...9-3 Scooter noise regulation ...9-4 Maintenance record ...9-5 YAMAHA MOTOR CORPORATION, U.S.A...9-7 RIVA LIMITED WARRANTY ...9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...9-9 EAU10210 1 2 3 4 5 6 7 8 9 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 8
SHOULD: ● OBTAIN THOROUGH INSTRUCTIONS FROM A COMPETENT SOURCE ON ALL ASPECTS OF SCOOTER OPERATION. ● OBSERVE THE WARNINGS AND MAINTENANCE REQUIREMENTS IN THE OWNER'S MANUAL. ● OBTAIN QUALIFIED TRAINING IN SAFE AND PROPER RIDING TECHNIQUES. ● OBTAIN PROFESSIONAL TECHNICAL SERVICE AS INDICATED BY THE - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 9
Q SAFETY INFORMATION ● ● ● changing lanes. Make sure that other motorists can see you. The posture of the operator and passenger is important for proper control. • The operator should keep both hands on the handlebar and both feet on the footboard during operation to maintain control of the - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 10
Q SAFETY INFORMATION keep the following in mind: ● Cargo and accessory weight should be kept as low and close to the scooter as possible. Make sure to distribute the weight as evenly as possible on both sides of the scooter to minimize imbalance or instability. ● Shifting weights can create a sudden - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 11
Safe-riding points Q SAFETY INFORMATION exhaust system when refueling. • Never refuel while smoking or in the vicinity of an open flame. Never start the engine or let it run for any length of time in a closed area. The exhaust fumes are poisonous and may cause loss of consciousness and death - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 12
Q SAFETY INFORMATION ● 1 2 3 4 5 6 7 8 9 ● ● ● ● ● ● Braking can be extremely difficult on a wet road. Avoid hard braking, because the scooter could slide. Apply the brakes slowly when stopping on a wet surface. Slow down as you approach a corner or turn. Once you have completed a turn, - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 13
Labels, location of Q SAFETY INFORMATION EAU10381 Location of important labels Please read the following important labels carefully before operating this vehicle. 1 2 4 5 6 1 2 3 3 4 5 6 7 8 9 1-6 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 14
Q SAFETY INFORMATION 1 5 1 2 3 4 5 4 6 7 8 9 3 2 6 1-7 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 15
Q SAFETY INFORMATION 1 2 3 4 5 6 7 8 9 1-8 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 16
Part locations DESCRIPTION EAU10410 EAU10400 Left view 1 1 2 3 4 5 6 7 8 9 1. Front wheel 2. Front brake caliper (page 6-15) 3. Front turn signal light 4. Helmet holder (page 3-8) 5. Storage compartment (page 3-9) 6. Rear turn signal light 7. Rear wheel 8. Adjusting nut (page 6-15) 9. - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 17
DESCRIPTION EAU10420 Right view 12 13 14, 15 16 17 1 2 3 4 5 6 7 20 12.Tail/brake light 13.Carrier (page 3-10) 14.Fuel tank cap 15.2-stroke engine oil tank cap 16.Seat (page 3-8) 17.Headlight 18.Spark plug (page 6-7) 19.Centerstand 20.Muffler 19 18 8 9 2-2 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 18
DESCRIPTION EAU10430 Controls and instruments 21 1 2 3 4 22 23 24 25 26 27 5 6 7 8 9 21.Rear brake lever (page 3-4) 22.Left handlebar switches (page 3-3) 23.Speedometer unit (page 3-2) 24.Fuel gauge (page 3-3) 25.Right handlebar switches (page 3-3) 26.Front brake lever (page 3-4) 27.Throttle - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 19
Main switch/steering lock INSTRUMENT AND CONTROL FUNCTIONS EAU10460 EAU10660 EAU1044D Main switch/steering lock OFF All electrical systems are off. The key can be removed. EAU10670 sition, and then turn it to "LOCK" while still pushing it. 3. Remove the key. To unlock the steering 1 2 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 20
Speedometer unit INSTRUMENT AND CONTROL FUNCTIONS EAU11003 EAU32441 EAUT1820 Indicator and warning lights 1 2 20 10 10 20 30 40 1 2 3 30 50 km/h 60 3 4 5 6 7 8 9 ZAUM00** 0 0 40 MPH 0000001 1. Turn signal indicator light "5" 2. High beam indicator light "&" 3. 2-stroke engine oil - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 21
Engine stop switch INSTRUMENT AND CONTROL FUNCTIONS EAU12140 EAU12347 EAU12400 Fuel gauge 1 Handlebar switches 1 Dimmer switch "%/&" Set this switch to "&" for the high beam and to "%" for the low beam. EAU12460 1 2 3 4 5 6 7 8 9 20 10 10 20 30 40 30 50 km/h 60 0 0 40 MPH 0000001 2 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 22
Push this switch to crank the engine with the starter. 1 2 3 4 5 6 7 8 9 ECA10050 Front brake lever Rear brake lever cC See page 5-1 for starting instructions prior to starting the engine. ZAUM00** ZAUM00** The front brake lever is located on the right handlebar grip. To apply the front brake - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 23
Fuel and 2-stroke engine oil tank caps INSTRUMENT AND CONTROL FUNCTIONS EAUT1030 Fuel and 2-stroke engine oil tank caps The fuel tank cap and the 2-stroke engine oil tank cap are located under the seat. (See page 3-8.) Fuel tank cap To remove the fuel tank cap To install the fuel tank cap - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 24
exceed 10%. Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. EAU40680 Recommended fuel: UNLEADED GASOLINE ONLY Fuel tank capacity: 5.7 L (1.5 US gal) (1.25 Imp.gal) 1. Fuel tank filler tube 2. Fuel level Make - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 25
Kickstarter INSTRUMENT AND CONTROL FUNCTIONS EAU13431 EAU13452 EAU13680 Catalytic converter This model is equipped with a catalytic converter in the exhaust system. EWA10860 2-stroke engine oil Make sure that there is sufficient 2stroke engine oil in the oil tank. Add the recommended 2- - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 26
Helmet holder INSTRUMENT AND CONTROL FUNCTIONS EAU13932 Seat 1 2 3 4 5 6 ZAUM00** 3. Fold the seat up. EAU14300 Helmet holder 1 To open the seat 1. Place the scooter on the centerstand. 2. Insert the key into the main switch, and then turn it counterclockwise to "OPEN". 1 OPEN ZAUM00** - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 27
Storage compartment INSTRUMENT AND CONTROL FUNCTIONS To release the helmet from the helmet holder Open the seat, remove the helmet from the helmet holder, and then close the seat. EAU14510 Storage compartment 1 ZAUM00** 1. Storage compartment There is a storage compartment under the seat. - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 28
Carrier INSTRUMENT AND CONTROL FUNCTIONS tended with the seat open. EAU14400 EAU15110 Front storage compartment Carrier 1 1 2 3 4 5 6 7 8 9 ZAUM00** 1 ZAUM00** 1. Front storage compartment EWA11190 1. Carrier EWA10170 w ● w ● ● ● Do not exceed the load limit of 3 kg (7 lb) for the - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 29
PRE-OPERATION CHECKS EAU15593 EAU15580 The condition of a vehicle is the owner's responsibility. Vital components can start to deteriorate quickly and unexpectedly, even if the vehicle remains unused (for example, as a result of exposure to the elements). Any damage, fluid leakage or loss of tire - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 30
Pre-operation check list PRE-OPERATION CHECKS EAU15605 Pre-operation check list ITEM CHECKS • Check fuel level in fuel tank. • Refuel if necessary. • Check fuel line for leakage. • Check oil level in oil tank. • If necessary, add recommended oil to specified level. • Check vehicle for oil - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 31
PRE-OPERATION CHECKS ITEM Centerstand Chassis fasteners Instruments, lights, signals and switches CHECKS • Make sure that operation is smooth. • Lubricate pivot if necessary. • Make sure that all nuts, bolts and screws are properly tightened. • Tighten if necessary. • Check operation. • Correct if - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 32
come on, have a Yamaha dealer check the electrical circuit. 3. Close the throttle completely. cC See page 5-4 for engine break-in instructions prior to operating the vehicle for the first time. ENGINE STOP START 1 ZAUM00** 1 ZAUM00** 1. Kickstarter lever 1. Engine stop switch "#/$" 1. Set - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 33
Starting off OPERATION AND IMPORTANT RIDING POINTS starting attempt should be as short as possible to preserve the battery. Do not crank the engine more than 5 seconds on any one attempt. If the engine does not start with the starter motor, try using the kickstarter. ECA11130 EAU16770 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 34
Braking OPERATION AND IMPORTANT RIDING POINTS EAU16780 EAU16792 EWA10300 Acceleration and deceleration 1 2 3 Braking 1. Close the throttle completely. 2. Apply both front and rear brakes simultaneously while gradually increasing the pressure. FRONT w ● (b) ● (a) 4 5 6 7 8 9 ZAUM00** The - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 35
changed. 1000 km (600 mi) and beyond Avoid prolonged full throttle operation. Vary speeds occasionally. ECA10270 4 5 ZAUM00** cC If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. 6 7 8 9 ZAUM00** 0 ~ 150 km (0 ~ 90 mi) Avoid - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 36
OPERATION AND IMPORTANT RIDING POINTS EWA10310 w ● 1 2 ● 3 4 Since the engine and exhaust system can become very hot, park in a place where pedestrians or children are not likely to touch them. Do not park on a slope or on soft ground, otherwise the vehicle may overturn. ECA10380 cC 5 6 7 8 9 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 37
rapid engine wear may result. Consult a 6-1 The owner's tool kit is located inside the rear storage compartment. (See page 3-9.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 38
PERIODIC MAINTENANCE AND MINOR REPAIR NOTE: If you do not have the tools or experience required for a particular job, have a Yamaha dealer perform it for you. EWA10340 EAU17226 1 2 3 4 5 6 7 8 9 w Modifications not approved by Yamaha may cause loss of performance, excessive emissions, and render - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 39
system valve, and hose for damage. • Replace any damaged parts. — — — — — * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 6-3 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 40
Maintenance and lubrication, periodic PERIODIC MAINTENANCE AND MINOR REPAIR General maintenance and lubrication chart INITIAL ODOMETER READING 2,000 mi (4,000 km) or 6 months — — — EAU17226 EAU32125 1 2 3 4 5 6 NO. ITEM ROUTINE 600 mi (1,000 km) or 1 month 10,000 mi 8,000 mi 6,000 mi - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 41
PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL NO. ITEM ROUTINE 600 mi (1,000 km) or 1 month 2,000 mi (4,000 km) or 6 months ODOMETER READING 10,000 mi 8,000 mi 6,000 mi 4,000 mi (7,000 km) (10,000 km) (13,000 km) (16,000 km) or or or or 30 24 18 12 months months months months EAU17226 1 2 3 4 5 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 42
months, repeat the maintenance intervals starting from 4000 mi (7000 km) or 12 months. EAU17620 7 8 9 NOTE: ● The air filter needs more frequent service if you are riding in unusually wet or dusty areas. ● Hydraulic brake system • When disassembling the master cylinder or caliper cylinder, always - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 43
Spark plug, checking PERIODIC MAINTENANCE AND MINOR REPAIR EAU18751 EAU19210 EAUT1831 EAU17226 Removing and installing the panel Panel A To remove the panel Remove the screws, and then take the panel off. Checking the spark plug The spark plug is an important engine component, which is - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 44
). NOTE: If the spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. NOTE: If a torque wrench is not available when installing a spark plug, a good estimate - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 45
Final transmission oil PERIODIC MAINTENANCE AND MINOR REPAIR EAU20061 EAU17226 Final transmission oil The final transmission case must be checked for oil leakage before each ride. If any leakage is found, have a Yamaha dealer check and repair the scooter. In addition, the final transmission - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 46
Air filter element, cleaning PERIODIC MAINTENANCE AND MINOR REPAIR EAUT0030 EAU17226 Cleaning the air filter element 1 2 1 2(✕2) 1 3 4 5 6 7 8 9 1. Remove panel A. (See page 6-7 for panel removal and installation procedures.) 2. Remove the air filter joint clamp. 3. Remove the air filter - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 47
Carburetor PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 10. Install the air filter case cover by installing the screws. 11. Install the air filter case by installing the screws, and then install the air filter joint clamp. 12. Install the panel. EC000082 EAU21251 EAU17226 Carburetor The - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 48
Tires PERIODIC MAINTENANCE AND MINOR REPAIR EAU21382 EAUT1701 EAU17226 Checking the throttle cable free play 1 2 3 4 ZAUM00** Tires To maximize the performance, durability, and safe operation of your scooter, note the following points regarding the specified tires. Tire air pressure The - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 49
Have excessively worn tires replaced by a Yamaha dealer immediately. Brakes, tires, and related wheel parts replacement should be left to a Yamaha Service Technician. ● ZAUM00** 1. Tire tread depth 2. Tire sidewall 3. Tire wear indicator It is dangerous to ride with a worn-out tire. When a tire - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 50
Rear brake lever free play, adjusting PERIODIC MAINTENANCE AND MINOR REPAIR EAU21960 EAU37911 EAU17226 EAU22170 Cast wheels 1 2 3 4 5 6 7 8 9 To maximize the performance, durability, and safe operation of your motorcycle, note the following points regarding the specified wheels. ● The wheel - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 51
Brake pads and shoes, checking PERIODIC MAINTENANCE AND MINOR REPAIR EAU22380 EAU17226 Checking the front brake pads and rear brake shoes (a) 1 ZAUM00** The front brake pads and the rear brake shoes must be checked for wear at the intervals specified in the periodic maintenance and - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 52
Brake fluid level, checking PERIODIC MAINTENANCE AND MINOR REPAIR limit line, have a Yamaha dealer replace the brake shoes as a set. 1 2 3 4 ZAUM00** EAU17226 EAU32343 Checking the front brake fluid level 1 make sure that the top of the master cylinder is level by turning the handlebars. - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 53
Throttle grip and cable, checking and lubricating PERIODIC MAINTENANCE AND MINOR REPAIR EAU22720 EAU23091 EAU23111 EAU17226 Changing the brake fluid Have a Yamaha dealer change the brake fluid at the intervals specified in the NOTE after the periodic maintenance and lubrication chart. In - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 54
Brake levers, lubricating PERIODIC MAINTENANCE AND MINOR REPAIR EAU23120 EAU43640 EAU17226 Adjusting the Autolube pump 1 2 3 4 5 6 7 8 9 The Autolube pump is a vital and sophisticated component of the engine, which must be adjusted by a Yamaha dealer at the intervals specified in the - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 55
fork must be checked as follows at the intervals specified in the periodic maintenance and lubrication chart. To check the condition EWA10750 1 2 w Securely support the motorcycle so that there is no danger of it falling over. Check the inner tubes for scratches, damage and excessive oil leakage - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 56
. If there is play in the wheel hub or if the wheel does not turn smoothly, have a Yamaha dealer check the wheel bearings. ZAUM00** w Securely support the motorcycle so that there is no danger of it falling over. 2. Hold the lower ends of the front fork legs and try to move - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 57
Battery PERIODIC MAINTENANCE AND MINOR REPAIR EAU23380 EWA10760 EAU17226 Battery w ● CHILDREN. To charge the battery Have a Yamaha dealer charge the battery as soon as possible if it seems to have discharged. Keep in mind that the battery tends to discharge more quickly if the vehicle is - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 58
Fuse, replacing PERIODIC MAINTENANCE AND MINOR REPAIR ● EAU17226 1 2 3 4 5 6 7 8 9 battery can cause permanent battery damage. To charge a sealed-type (MF) battery, a special (constant-voltage) battery charger is required. Using a conventional battery charger will damage the battery. If you - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 59
PERIODIC MAINTENANCE AND MINOR REPAIR EAU25860 EAU17226 Troubleshooting Although Yamaha scooters receive a thorough inspection before shipment from the factory, trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 60
chart PERIODIC MAINTENANCE AND MINOR REPAIR Troubleshooting chart w 1 2 Keep away open flames and do not smoke while checking or working on the fuel system. EAU17226 EAU25901 EWA10840 1. Fuel 3 4 5 6 7 8 9 There is enough fuel. - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 61
spoked wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. Improper cleaning can damage plastic parts such - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 62
SCOOTER CARE AND STORAGE After normal use Remove dirt with warm water, a mild detergent, and a soft, clean sponge, and then rinse thoroughly with clean water. Use a toothbrush or bottlebrush for hard-to-reach areas. Stubborn dirt and insects will come off more easily if the area is covered with a - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 63
of the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your scooter for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. Drain the carburetor float chamber by loosening the drain bolt; this will prevent fuel deposits - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 64
SCOOTER CARE AND STORAGE spark plug electrodes while turning the engine over. 1 2 3 4 5 6 7 8 9 5. Lubricate all control cables and the pivoting points of all levers and pedals as well as of the sidestand/ centerstand. 6. Check and, if necessary, correct the tire air pressure, and then lift the - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 65
Specifications SPECIFICATIONS Dimensions Overall length 1890 mm (74.4 in) Overall width 705 mm (27.8 in) Overall height 1110 mm (43.7 in) Seat height 765 mm (30.1 in) Wheelbase 1275 mm (50.2 in) Ground clearance 120 mm (4.72 in) Minimum turning radius 1800 mm (70.9 in) Type YAMALUBE 2 or 2- - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 66
SPECIFICATIONS Tire air pressure (measured on cold tires) Loading condition 90 kg (198 lb) Front 200 kPa (29 psi) (2.00 kgf/cm2) Rear 200 kPa (29 psi) (2.00 kgf/cm2) Loading condition 90 kg - maximum load Front 200 kPa (29 psi) (2.00 kgf/cm2) Rear 200 kPa (29 psi) (2.00 kgf/cm2) Drum brake Operation - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 67
Vehicle identification number CONSUMER INFORMATION EAU26351 EAU26381 EAU26410 EAU26342 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 68
Model label CONSUMER INFORMATION EAU26460 Model label 1 2 3 4 5 6 7 8 9 ZAUM00** 1 1. Model label The model label is affixed to the location shown. Record the information on this label in the space provided. This information will be needed when ordering spare parts from a Yamaha dealer. - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 69
that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 70
Noise regulation CONSUMER INFORMATION EAU26580 Scooter noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: 1 2 3 4 5 6 7 Intake system Exhaust system Muffler Exhaust pipe Silencer Air cleaner case Air cleaner element Intake duct Federal law prohibits the following acts or the - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 71
24 months 10000 mi (16000 km) or 30 months 12000 mi (19000 km) or 36 months 14000 mi (22000 km) or 42 months Date of service Mileage Servicing dealer name and address Remarks 1 2 3 4 5 6 7 8 9 9-5 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 72
CONSUMER INFORMATION Maintenance interval 16000 mi (25000 km) or 48 months 18000 mi (28000 km) or 54 months 20000 mi (31000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 1 2 3 4 5 6 7 8 9 9-6 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 73
Warranty, limited CONSUMER INFORMATION EAU26681 YAMAHA MOTOR CORPORATION, U.S.A. RIVA LIMITED WARRANTY 1 2 3 4 5 6 7 8 9 9-7 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 74
CONSUMER INFORMATION 1 2 3 4 5 6 7 8 9 9-8 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 75
no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 76
isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 9-10 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 77
free play, checking ...6-12 Throttle grip and cable, checking and lubricating ...6-17 Tires ...6-12 Tool kit ...6-1 Troubleshooting ...6-23 Troubleshooting chart ...6-24 Turn signal indicator light ...3-2 Turn signal switch ...3-3 L Labels, location of ...1-6 C Cables, checking and lubricating - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 78
INDEX - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 79
1 2 3 4 5 6 7 8 9 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 80
1 2 3 4 5 6 7 8 9 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 81
1 2 3 4 5 6 7 8 9 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 82
1 2 3 4 5 6 7 8 9 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 83
1 2 3 4 5 6 7 8 9 - 2008 Yamaha Motorsports Zuma | Owners Manual - Page 84
YAMAHA MOTOR TAIWAN CO., LTD PRINTED IN TAIWAN 2007.06-1.3×1! (E)
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
 |
 |
OWNER’S MANUAL
5PJ-F8199-14
YW50X
LIT-11626-21-15