2008 Yamaha Motorsports Royal Star Venture S Owners Manual
2008 Yamaha Motorsports Royal Star Venture S Manual
2008 Yamaha Motorsports Royal Star Venture S manual content summary:
- 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 1
OWNER'S MANUAL XVZ13TFX(C) XVZ13TFSX(C) LIT-11626-21-42 2C9-28199-12 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 2
EAU10041 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 3
of craftsmanship and reliability that have made Yamaha a leader in these fields. This manual will give you an understanding of the operation, inspection, and basic maintenance of this close attention to the recommended maintenance schedules and operating instructions contained within this manual. - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 4
manual by the following notations: The Safety Alert Symbol means ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED! Failure to follow WARNING instructions procedures easier or clearer. WARNING CAUTION: NOTE: NOTE: G This manual should be considered a permanent part of this motorcycle and should - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 5
IMPORTANT MANUAL INFORMATION AND UNTIL YOU HAVE BEEN TRAINED IN SAFE AND PROPER RIDING TECHNIQUES. REGULAR INSPECTIONS AND CAREFUL MAINTENANCE, ALONG WITH GOOD RIDING SKILLS, WILL ENSURE - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 6
INFORMATION EAU10192 AFFIX DEALER LABEL HERE XVZ13TFX(C)/XVZ13TFSX(C) OWNER'S MANUAL ©2007 by Yamaha Motor Corporation, U.S.A. 1st edition, May 2007 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A. - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 7
TABLE OF CONTENTS SAFETY INFORMATION ...1-1 Location of important labels ...1-5 DESCRIPTION ...2-1 Left view ...2-1 Right view ...2-2 Controls and instruments ...2-3 INSTRUMENT AND CONTROL FUNCTIONS ...3-1 Main switch/steering lock ...3-1 Indicator and warning lights ...3-2 Speedometer unit ...3-4 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 8
bulb ...7-35 Replacing a turn signal light bulb or the tail/brake light bulb ...7-36 Supporting the motorcycle ...7-37 Troubleshooting ...7-37 Troubleshooting charts ...7-38 MOTORCYCLE CARE AND STORAGE ...8-1 Matte color caution ...8-1 Cleaning ...8-1 Storage ...8-2 SPECIFICATIONS ...9-1 CONSUMER - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 9
SHOULD: G OBTAIN THOROUGH INSTRUCTIONS FROM A COMPETENT SOURCE ON ALL ASPECTS OF MOTORCYCLE OPERATION. G OBSERVE THE WARNINGS AND MAINTENANCE REQUIREMENTS IN THE OWNER'S MANUAL. G OBTAIN QUALIFIED TRAINING IN SAFE AND PROPER RIDING TECHNIQUES. G OBTAIN PROFESSIONAL TECHNICAL SERVICE AS INDICATED BY - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 10
SAFETY INFORMATION wide on a turn due to EXCESSIVE SPEED or undercornering (insufficient lean angle for the speed). • Always obey the speed limit and never travel faster than warranted by road and traffic conditions. • Always signal before turning or changing lanes. Make sure that other motorists - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 11
SAFETY INFORMATION Loading The total weight of the operator, passenger, accessories and cargo must not exceed the maximum load limit. Maximum load: 190 kg (419 lb) When loading within this weight limit, keep the following in mind: G Cargo and accessory weight should be kept as low and close to the - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 12
another vehicle, make sure that it is kept upright and that the fuel cock is turned to "ON" or "RES" (for vacuum type) / "OFF" (for manual type). If it should lean over, gasoline may leak out of the carburetor or fuel tank. If you should swallow any gasoline, inhale a lot of - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 13
SAFETY INFORMATION EAU10381 Location of important labels Please read the following important labels carefully before operating this vehicle. 1 1-5 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 14
SAFETY INFORMATION 1 1 2 CAUTION Cleaning with alkaline or acid cleaner, gasoline or solvent will damage windshield. Use neutral detergent. 5JW-00 (5JW-2835Y-00) 3 4 CALIFORNIA ONLY 5 1-6 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 15
DESCRIPTION EAU10410 Left view 2 1. 2. 3. 4. 5. 6. 7. 8. Shift pedal (page 3-9) Starter (choke) knob (page 3-12) Fuel tank cap (page 3-10) Fuel cock (page 3-11) Battery (page 7-32) Coolant reservoir (page 7-16) Fuse box 2 (page 7-33) Sidecase (page 3-14) 2-1 9. Helmet holder (page 3-14) 10.Tail - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 16
DESCRIPTION EAU10420 Right view 2 1. 2. 3. 4. 5. 6. 7. 8. Muffler Owner's tool kit (page 7-1) Helmet holder (page 3-14) Travel trunk (page 3-14) Passenger seat Shock absorber assembly air valve (page 3-17) Rider seat (page 3-13) Fuel tank (page 3-10) 2-2 9. Front fork air valve (page 3-16) 10. - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 17
DESCRIPTION EAU10430 Controls and instruments 2 1. 2. 3. 4. 5. 6. 7. 8. Clutch lever (page 3-8) Audio system/CB radio control unit (page 4-3) Left handlebar switches (page 3-7) Rider headset jack (page 4-2) Speedometer unit (page 3-4) Main switch/steering lock (page 3-1) Right handlebar switches - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 18
INSTRUMENT AND CONTROL FUNCTIONS EAU10460 EAU10680 Main switch/steering lock LOCK The steering is locked, and all electrical systems are off. The key can be removed. To lock the steering To unlock the steering 3 1. Push. 2. Turn. The main switch/steering lock controls the ignition and lighting - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 19
3. 4. 5. 6. Left turn signal indicator light " High beam indicator light " " Oil level warning light " " Overdrive indicator light "O/D" Engine trouble warning light " Fuel level warning light " " " " EAU11030 " Turn signal indicator lights " " and " " The corresponding indicator light flashes - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 20
or pull the clutch lever. Overdrive indicator light "O/D" This indicator light comes on when the transmission is in overdrive (5th gear). EAU11500 Engine trouble warning light " " This warning light comes on or flashes when an electrical circuit monitoring the engine is defective. When this occurs - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 21
a tripmeter, select it by pushing the "SELECT" button, and then push the "RESET" button. If you do not reset the fuel reserve tripmeter manually, it will reset itself automatically and the display will return to "TRIP 1" after refueling and traveling 5 km (3 mi). 3-4 NOTE: After resetting the fuel - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 22
INSTRUMENT AND CONTROL FUNCTIONS EAU11840 NOTE: After setting the clock, be sure to push the "SELECT" button before turning the key to "OFF", otherwise the clock will not be set. Fuel meter The fuel meter indicates the amount of fuel in the fuel tank. The display segments of the fuel meter - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 23
the front or rear brake or disengaging the clutch will automatically deactivate the cruise control system. Push the "CANCEL" switch to manually deactivate cruise control. NOTE: G When the cruise control system is deactivated, the "RES" (resume) indicator light will come on. G Traveling speed - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 24
after the vehicle has traveled both about 150 m (490 ft) and for approximately 15 seconds. However, the turn signal lights can also be canceled manually by pushing the switch in after it has returned to the center position. NOTE: The self-canceling system only operates when the vehicle is moving, - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 25
EAU12780 Start switch " " Push this switch to crank the engine with the starter. ECA10050 3 1. Clutch lever CAUTION: See page 6-1 for starting instructions prior to starting the engine. EAU42390 Cruise control switches See page 3-5 for an explanation of the cruise control system. The oil level - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 26
INSTRUMENT AND CONTROL FUNCTIONS EAU12880 EAU12890 EAU12941 Shift pedal Brake lever Brake pedal 3 1. Shift pedal 1. Brake lever 1. Brake pedal The shift pedal is located on the left side of the engine and is used in combination with the clutch lever when shifting the gears of the 5-speed - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 27
INSTRUMENT AND CONTROL FUNCTIONS EAU13120 EAU13211 Fuel tank cap NOTE: The fuel tank cap cannot be installed unless the key is in the lock. In addition, the key cannot be removed if the cap is not properly installed and locked. EWA10130 Fuel WARNING Make sure that the fuel tank cap is properly - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 28
does not exceed 10%. Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. EAU13550 Fuel cock The fuel cock supplies fuel from the tank to the carburetors while also filtering it. The fuel cock lever positions are - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 29
INSTRUMENT AND CONTROL FUNCTIONS ON This indicates reserve. With the fuel cock lever in this position, the fuel reserve is made available. Turn the fuel cock lever to this position if you run out of fuel while riding. When this occurs, refuel as soon as possible and be sure to turn the fuel cock - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 30
INSTRUMENT AND CONTROL FUNCTIONS EAU13780 EAU14240 Locking the steering with a padlock Rider seat To remove the rider seat Remove the nuts, and then pull the rider seat up. 3 1. Projection 2. Seat holder In addition to the main switch/steering lock, there are brackets on the right side of the - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 31
INSTRUMENT AND CONTROL FUNCTIONS EAU14360 Helmet holders To close a helmet holder Place the helmet holder in the original position, and then remove the key. EWA11040 EAU14631 Sidecases and travel trunk EWA11081 WARNING Improper loading or overloading can cause loss of control and possibly an - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 32
INSTRUMENT AND CONTROL FUNCTIONS er conditions may make it necessary to further reduce the riding speed. Sidecases To open a sidecase 1. Insert the key into the lock, turn it counterclockwise, and then push it in. 3 1. Storage compartment 2. Storage pouch 1. Travel trunk lock 2. Unlock. To close - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 33
INSTRUMENT AND CONTROL FUNCTIONS ECA10910 EAU14651 CAUTION: Do not apply excessive pressure on the travel trunk lid when it is open. To close the travel trunk 1. Fold the travel trunk lid up completely, and then fold it down. 2. Turn the key clockwise, and then remove it. ECA10921 Adjusting the - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 34
INSTRUMENT AND CONTROL FUNCTIONS 3. Check the air pressure in each fork leg using a low-pressure air gauge. A low-pressure air gauge is available at a Yamaha dealer. 4. To increase the spring rate and thereby harden the suspension, increase the air pressure with an air pump. To decrease the spring - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 35
INSTRUMENT AND CONTROL FUNCTIONS EAU15301 Spring rate: Minimum (soft): Air pressure = 0 kPa (0 psi) (0 kgf/cm²) Standard: Air pressure = 0 kPa (0 psi) (0 kgf/cm²) Maximum (hard): Air pressure = 400 kPa (57 psi) (4.0 kgf/cm²) ECA11090 Sidestand The sidestand is located on the left side of the frame - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 36
INSTRUMENT AND CONTROL FUNCTIONS EAU15312 Ignition circuit cut-off system The ignition circuit cut-off system (comprising the sidestand switch, clutch switch and neutral switch) has the following functions. G It prevents starting when the transmission is in gear and the sidestand is up, but the - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 37
INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is turned on. 3. Turn the key on. 4. Shift the transmission into the neutral position. 5. Push the start switch. Does the engine start? NOTE: This check is most reliable - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 38
INSTRUMENT AND CONTROL FUNCTIONS EAU15412 Auxiliary DC jack and connector 12-V accessories connected to the auxiliary DC jack at the front and auxiliary DC connector under the rider seat can be used when the key is in the "ACC" or "ON" position. ECA11031 CAUTION: 3 The accessories connected to - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 39
AUDIO SYSTEM AND CB RADIO EAU15440 Location of parts 4 1. 2. 3. 4. 5. 6. Audio system/CB radio control unit Front speaker Rider headset jack Cassette deck lid Main switch/steering lock Eject (" ") button 7. Cassette deck compartment 8. Auxiliary audio input jack 9. Rear speaker 10.Passenger - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 40
AUDIO SYSTEM AND CB RADIO EWA11370 EAU15450 WARNING G Headsets (optional) G It is dangerous to operate the audio system controls while riding. Never take your hands off the handlebars while riding. Keep the volume at a low enough level to be aware of traffic conditions and ensure safety. - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 41
radio button "CB" Selecting a track on the optional CD changer G Selecting a CB channel G Adjusting the CB squelch level G Tuning in a radio station manually G Adjusting the intercom volume G Changing the settings in a mode Long push (one second or more) G Changing the cassette deck play direction - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 42
AUDIO SYSTEM AND CB RADIO Audio system SP/HS (Output) BASS TREB (Treble) FAD (Fade1) Long push (one second or more) G Turning off the CB radio EAU15480 Making basic settings Turning on/off the audio system Radio frequency 2 AV (Auto volume) IC (Intercom volume) 1 This mode does not appear in - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 43
AUDIO SYSTEM AND CB RADIO Adjusting the audio system volume Turning on/off the CB radio be set between "0" and "20". After the adjustment is made, the CB radio returns to normal operation and the CB channel appears in the display. Turn the volume control knob until the desired audio system volume - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 44
AUDIO SYSTEM AND CB RADIO EAU15502 Making mode settings General procedure The following setting procedure applies to the audio system, CB radio, and optional CD changer. NOTE: G In order to make settings in any of the audio system modes, make sure that the audio system is selected. If necessary, - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 45
AUDIO SYSTEM AND CB RADIO Adjusting the bass level Adjusting the treble level Adjusting the fade level (balance between front and rear speakers) 1. Repeatedly push the "SELECT" button for less than one second until "BASS" appears at the bottom of the display. 2. Repeatedly push either side of the - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 46
AUDIO SYSTEM AND CB RADIO NOTE: When the fade level is set to "0", the front and rear speaker levels are the same. Adjusting the intercom volume Adjusting the auto volume Turning on/off the CB roger beep 4 1. Repeatedly push the "SELECT" button for less than one second until the intercom volume - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 47
AUDIO SYSTEM AND CB RADIO EAU15520 EWA11380 Cassette deck operation G WARNING It is dangerous to operate the cassette deck while riding. Never take your hands off the handlebars while riding. Keep the volume at a low enough level to be aware of traffic conditions and ensure safety. ECA11760 G To - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 48
AUDIO SYSTEM AND CB RADIO Skipping songs NOTE: G The maximum number of songs that can be skipped in either direction is 9. G To stop skipping songs, push the up/down switch in the opposite direction that songs are being skipped. Skipping a blank Changing the tape play direction 4 While a cassette - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 49
AUDIO SYSTEM AND CB RADIO Turning on/off the Dolby noise reduction system Ejecting the cassette tape EAU15533 Radio operation 1. Eject (" ") button 1. Radio antenna 4 While the cassette tape is playing, push the eject (" ") button for more than two seconds to turn the Dolby B noise reduction - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 50
AUDIO SYSTEM AND CB RADIO EWA11390 Selecting a frequency band FM1 (Tape) AUX (Auxiliary audio source) (CD changer*) FM2 FM3 AM WARNING G G 4 G It is dangerous to operate the radio while riding. Never take your hands off the handlebars while riding. Keep the volume at a low enough level to be - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 51
4 Up to six stations can be programmed for each frequency band (FM1, FM2, FM3, and AM) using either manual or automatic tuning. Using manual tuning 1. Manually tune in a radio station that you wish to preset. (See the "Tuning in a preset radio station" section.) 2. Push the "SELECT" button once - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 52
AUDIO SYSTEM AND CB RADIO 3. Repeatedly push either side of the up/down switch for less than one second until the desired preset number ("1" through "6") is displayed. NOTE: Selecting "A" will automatically program the preset stations. See the following section. 4 4. Push the "SELECT" button once - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 53
AUDIO SYSTEM AND CB RADIO 4. Push the "SELECT" button once for less than one second to program preset radio stations automatically. EAU15540 Optional CD changer operation EWA11400 WARNING G G It is dangerous to operate the CD changer while riding. Never take your hands off the handlebars while - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 54
AUDIO SYSTEM AND CB RADIO Selecting a CD track Repeatedly push either side of the up/down switch for less than one second until the number for the desired CD track appears in the display. EAU15550 EWA11410 CB radio operation G WARNING It is dangerous to change CB radio channels or adjust the - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 55
of CB users. An operator of a CB radio station is still required to comply with the Communications Act and with the rules of CB Radio Service. CB radio functions The CB radio is capable of the following functions, which are further explained in the following sections: G Selecting a CB channel for - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 56
AUDIO SYSTEM AND CB RADIO Adjusting the squelch level returns to normal operation and the CB channel appears in the display. For maximum reception sensitivity, the squelch level should be set by turning the control knob fully counterclockwise, and then slowly turning it clockwise until the - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 57
27.365 27.375 27.385 27.395 27.405 4 NOTE: This radio has been designed for operation in the 11-meter Citizens Band Radio Service. It uses a frequency-synthesizing circuit with Phase-Locked Loop (PLL) technology to provide crystal-controlled transmit and receive operation on all 40 channels. The - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 58
AUDIO SYSTEM AND CB RADIO Transmitting and receiving Transmission EAU15570 Auxiliary audio source operation Auxiliary audio equipment can be connected to, and played through, the audio system. 1. Insert the output plug of the auxiliary equipment into the jack located at the right of the cassette - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 59
AUDIO SYSTEM AND CB RADIO 4 4-21 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 60
PRE-OPERATION CHECKS EAU15593 The condition of a vehicle is the owner's responsibility. Vital components can start to deteriorate quickly and unexpectedly, even if the vehicle remains unused (for example, as a result of exposure to the elements). Any damage, fluid leakage or loss of tire air - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 61
PRE-OPERATION CHECKS EAU15605 Pre-operation check list ITEM Fuel • Check fuel level in fuel tank. • Refuel if necessary. • Check fuel line for leakage. • Check oil level in engine. • If necessary, add recommended oil to specified level. • Check vehicle for oil leakage. • Check vehicle for oil - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 62
PRE-OPERATION CHECKS ITEM CHECKS Check operation. If soft or spongy, have Yamaha dealer bleed hydraulic system. Check fluid level in reservoir. If necessary, add recommended fluid to specified level. Check hydraulic system for leakage. PAGE Clutch 7-24, 7-26 Throttle grip • Make sure that - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 63
sidestand is not raised completely, it could contact the ground and distract the operator, resulting in a possible loss of control. G WARNING G The engine trouble warning light should come on for a few seconds, then go off. If a warning light does not go off, see page 3-2 for the corresponding - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 64
OPERATION AND IMPORTANT RIDING POINTS NOTE: If the engine fails to start, release the start switch, wait a few seconds, and then try again. Each starting attempt should be as short as possible to preserve the battery. Do not crank the engine more than 10 seconds on any one attempt. ECA11350 G - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 65
OPERATION AND IMPORTANT RIDING POINTS EAU16640 EAU16671 ECA10260 Starting a warm engine Follow the same procedure as for starting a cold engine with the exception that the starter (choke) is not required when the engine is warm. Shifting CAUTION: G 1. Shift pedal 2. Neutral position G Shifting - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 66
OPERATION AND IMPORTANT RIDING POINTS 4. At the recommended shift points shown in the following table, close the throttle, and at the same time, quickly pull the clutch lever in. 5. Shift the transmission into second gear. (Make sure not to shift the transmission into the neutral position.) 6. Open - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 67
the engine, remove the key from the main switch, and then turn the fuel cock lever to "OFF". EWA10310 WARNING G CAUTION: If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. G Since the engine and exhaust system can become very - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 68
. 1. Owner's tool kit The owner's tool kit is located inside the right sidecase. (See page 3-14.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and minor repairs. However - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 69
PERIODIC MAINTENANCE AND MINOR REPAIR EWA10340 WARNING Modifications not approved by Yamaha may cause loss of performance, excessive emissions, and render the vehicle unsafe for use. Consult a Yamaha dealer before attempting any changes. 7 7-2 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 70
km 7 5 * 6 * 7 * 8 * Exhaust system Evaporative emission control system (For California only) 9 * √ * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 7-3 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 71
PERIODIC MAINTENANCE AND MINOR REPAIR EAU32185 General maintenance and lubrication chart INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 72
PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 9 * Swingarm pivot bearings - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 73
PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months √ ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 18 * Front fork • Check - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 74
36 months, repeat the maintenance intervals starting from 8000 mi (13000 km) or 12 months. 7 EAU17660 NOTE: G The air filter needs more frequent service if you are riding in unusually wet or dusty areas. G Hydraulic brake and clutch systems • After disassembling the brake or clutch master cylinders - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 75
PERIODIC MAINTENANCE AND MINOR REPAIR EAU18712 Removing and installing cowlings and panels The cowlings and panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a cowling or panel needs to be removed and installed. 1. - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 76
PERIODIC MAINTENANCE AND MINOR REPAIR NOTE: Make sure that the projection fits into the grommet. 2. Install cowling A. EAU35860 Panels A and B To remove one of the panels Remove the bolt, and then pull the panel off as shown. 1. Grommet 2. Projection 3. Cowling A 1. Cowling B 2. Bolt NOTE: Make - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 77
PERIODIC MAINTENANCE AND MINOR REPAIR 1. Panel B 2. Bolt EAU19333 Panel C To remove the panel 1. Remove panel B. 2. Remove the left passenger footrest by removing the bolts. 3. Remove the screw, and then pull the panel off as shown. 1. Panel C 2. Screw 3. Bolt To install the panel Place the - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 78
same color. NOTE: If any spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. To install a spark plug 1. Measure the spark plug gap with a wire thickness gauge and - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 79
PERIODIC MAINTENANCE AND MINOR REPAIR 2. Clean the surface of the spark plug gasket and its mating surface, and then wipe off any grime from the spark plug threads. 3. Install the spark plug with the spark plug wrench, and then tighten it to the specified torque. Tightening torque: Spark plug: 17.5 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 80
PERIODIC MAINTENANCE AND MINOR REPAIR NOTE: The engine oil should be between the minimum and maximum level marks. 2. Place an oil pan under the engine to collect the used oil. 3. Remove the engine oil filler cap and drain bolt to drain the oil from the crankcase. NOTE: Skip steps 4-6 if the oil - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 81
PERIODIC MAINTENANCE AND MINOR REPAIR Recommended engine oil: See page 9-1. Oil quantity: Without oil filter cartridge replacement: 3.50 L (3.70 US qt) (3.08 Imp.qt) With oil filter cartridge replacement: 3.70 L (3.91 US qt) (3.26 Imp.qt) 1. O-ring 1. Torque wrench 2. Oil filter wrench NOTE: Make - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 82
PERIODIC MAINTENANCE AND MINOR REPAIR 9. Start the engine, and then let it idle for several minutes while checking it for oil leakage. If oil is leaking, immediately turn the engine off and check for the cause. NOTE: After the engine is started, the engine oil level warning light should go off if - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 83
PERIODIC MAINTENANCE AND MINOR REPAIR 2. Remove the oil filler bolt and drain bolt to drain the oil from the final gear case. 3. Install the final gear oil drain bolt, and then tighten it to the specified torque. Tightening torque: Final gear oil drain bolt: 23 Nm (2.3 m·kgf, 17 ft·lbf) 6. Check - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 84
fan is automatically switched on or off according to the coolant temperature in the radiator. G If the engine overheats, see page 7-38 for further instructions. EAU33030 7 4. If the coolant is at or below the minimum level mark, remove the rider seat (See page 3-13.), open the reservoir cap, add - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 85
PERIODIC MAINTENANCE AND MINOR REPAIR The coolant must be changed at the intervals specified in the periodic maintenance and lubrication chart. Have a Yamaha dealer change the coolant. EAU35193 Cleaning the air filter elements The air filter elements should be cleaned at the intervals specified in - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 86
PERIODIC MAINTENANCE AND MINOR REPAIR 7. Install the air filter element by fitting the projection on the air filter element into the holder in the air filter case, then tightening the screws. ECA10480 CAUTION: G 1. Air filter element 2. Screw G 7 6. Lightly tap the air filter element to remove - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 87
PERIODIC MAINTENANCE AND MINOR REPAIR EAU21271 EAU21311 EAU21382 Carburetors The carburetors are important parts of the engine and emission control system, which require very sophisticated adjustment. Therefore, all carburetor adjustments should be left to a Yamaha dealer, who has the necessary - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 88
PERIODIC MAINTENANCE AND MINOR REPAIR EAU21401 EAU32541 Valve clearance The valve clearance changes with use, resulting in improper air-fuel mixture and/or engine noise. To prevent this from occurring, the valve clearance must be adjusted by a Yamaha dealer at the intervals specified in the - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 89
PERIODIC MAINTENANCE AND MINOR REPAIR LOAD YOUR VEHICLE. Make sure that the total weight of the cargo, rider, passenger, and accessories (cowling, saddlebags, etc. if approved for this model) does not exceed the maximum load of the vehicle. Operation of an overloaded vehicle could cause tire damage, - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 90
PERIODIC MAINTENANCE AND MINOR REPAIR EAU21992 EAU22011 Cast wheels To maximize the performance, durability, and safe operation of your vehicle, note the following points regarding the specified wheels. G The wheel rims should be checked for cracks, bends, warpage or damage before each ride. If any - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 91
PERIODIC MAINTENANCE AND MINOR REPAIR any consequences caused by the use of items which have not been approved by Yamaha. EAU22072 EAU22092 Clutch lever Adjusting the brake lever free play 1. Clutch lever free play Since this model is equipped with a hydraulic clutch, adjusting the clutch lever - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 92
PERIODIC MAINTENANCE AND MINOR REPAIR EWA10630 EAU22280 EAU22390 WARNING G G After adjusting the brake lever free play, check the free play and make sure that the brake is working properly. A soft or spongy feeling in the brake lever can indicate the presence of air in the hydraulic system. If - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 93
PERIODIC MAINTENANCE AND MINOR REPAIR indicator grooves have almost disappeared, have a Yamaha dealer replace the brake pads as a set. EAU22470 EAU22660 Checking the brake and clutch fluid levels Front brake Clutch Rear brake pads 1. Minimum level mark 1. Minimum level mark 1. Brake pad wear - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 94
PERIODIC MAINTENANCE AND MINOR REPAIR G Use only the recommended quality brake fluid, otherwise the rubber seals may deteriorate, causing leakage and poor braking or clutch performance. brake fluid level goes down suddenly, have a Yamaha dealer check the cause. EAU22750 Changing the brake and - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 95
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23091 EAU23111 EAU44270 Checking and lubricating the cables The operation of all control cables and the condition of the cables should be checked before each ride, and the cables and cable ends should be lubricated if necessary. If a cable is damaged or does - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 96
PERIODIC MAINTENANCE AND MINOR REPAIR EAU43600 EAU23200 Recommended lubricant: Lithium-soap-based grease (all-purpose grease) Checking and lubricating the brake and clutch levers Checking and lubricating the sidestand The operation of the brake and clutch levers should be checked before each - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 97
fork must be checked as follows at the intervals specified in the periodic maintenance and lubrication chart. To check the condition EWA10750 WARNING Securely support the vehicle so that there is no danger of it falling over. Check the inner tubes for scratches, damage and excessive oil leakage. To - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 98
. EWA10750 ECA10590 CAUTION: If any damage is found or the front fork does not operate smoothly, have a Yamaha dealer check or repair it. 7 WARNING Securely support the vehicle so that there is no danger of it falling over. 2. Hold the lower ends of the front fork legs and try to move - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 99
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23290 EAU23370 EWA10760 Checking the wheel bearings The front and rear wheel bearings must be checked at the intervals specified in the periodic maintenance and lubrication chart. If there is play in the wheel hub or if the wheel does not turn smoothly, have - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 100
PERIODIC MAINTENANCE AND MINOR REPAIR G KEEP THIS AND ALL BATTERIES OUT OF THE REACH OF CHILDREN. ECA10630 EAU23663 CAUTION: G Replacing the fuses The main fuse is located behind panel C. (See page 7-8.) To charge the battery Have a Yamaha dealer charge the battery as soon as possible if it - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 101
PERIODIC MAINTENANCE AND MINOR REPAIR Fuse box 1 is located behind cowling A. (See page 7-8.) Fuse box 2 is located behind panel B. (See page 7-8.) Specified fuses: Main fuse: 30.0 A Cruise control fuse: 10.0 A Carburetor heater fuse: 10.0 A Auxiliary DC connector fuse: 5.0 A Auxiliary DC jack fuse: - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 102
PERIODIC MAINTENANCE AND MINOR REPAIR 3. Turn the key to "ON" and turn on the electrical circuit in question to check if the device operates. 4. If the fuse immediately blows again, have a Yamaha dealer check the electrical system. EAU23770 Replacing the headlight bulb This model is equipped with a - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 103
PERIODIC MAINTENANCE AND MINOR REPAIR and fingerprints on the headlight bulb using a cloth moistened with alcohol or thinner. EAU24281 Replacing a turn signal light bulb or the tail/brake light bulb 1. Remove the lens by removing the screws. 2. Remove the defective bulb by pushing it in and - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 104
Supporting the front wheel off the ground by using a motorcycle stand. To service the rear wheel Raise the rear wheel off the ground by using a Troubleshooting Although Yamaha motorcycles receive a thorough inspection before shipment from the factory, trouble may occur during operation. Any problem - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 105
PERIODIC MAINTENANCE AND MINOR REPAIR EAU42310 Troubleshooting charts Starting problems or poor engine performance EWA10840 WARNING Keep away open flames and do not smoke while checking or working on the fuel system. 1. Fuel There is - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 106
PERIODIC MAINTENANCE AND MINOR REPAIR Engine overheating EWAT1040 WARNING G G Do not remove the radiator cap when the engine and radiator are hot. Scalding hot fluid and steam may be blown out under pressure, which could cause serious injury. Be sure to wait until the engine has cooled. Place a - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 107
MOTORCYCLE CARE AND STORAGE EAU37833 EAU26121 Matte color caution ECA15192 Cleaning Frequent, thorough cleaning of your motorcycle not only enhances its appearance, but also improves its performance and extends its life. ECA10731 CAUTION: Some models are equipped with matte colored finished parts - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 108
the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your motorcycle for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. For motorcycles equipped with a fuel cock that has an "OFF" position: Turn the fuel cock lever - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 109
MOTORCYCLE CARE AND STORAGE 3. Drain the carburetor float chamber by loosening the drain bolt; this will prevent fuel deposits from building up. Pour the drained fuel into the fuel tank. 4. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from rusting and the - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 110
× 66.0 mm (3.11 × 2.60 in) Compression ratio: 10.00 :1 Starting system: Electric starter Lubrication system: Wet sump Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter cartridge replacement: 3.50 L (3.70 US qt) (3.08 Imp.qt) With - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 111
SPECIFICATIONS Transmission type: Constant mesh 5-speed Operation: Left foot operation Gear ratio: 1st: 43/17 (2.529) 2nd: 31/19 (1.632) 3rd: 30/25 (1.200) 4th: 24/25 (0.960) 5th: 22/28 (0.786) Size: 150/90B15M/C 74H Manufacturer/model: DUNLOP/D404 Manufacturer/model: BRIDGESTONE/G702G Rim size: 15M - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 112
: 12 V, 1.7 W × 1 Turn signal indicator light: 12 V, 1.7 W × 2 Fuel level warning light: 14 V, 3.0 W × 1 Coolant temperature warning light: 12 V, 1.7 W × 1 Engine trouble warning light: 12 V, 1.7 W × 1 Fuses: Main fuse: 30.0 A Headlight fuse: 15.0 A Signaling system fuse: 15.0 A Ignition fuse: 10 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 113
CONSUMER INFORMATION EAU26351 EAU26381 EAU26400 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 114
CONSUMER INFORMATION EAU26470 Model label 1. Model label The model label is affixed to the frame under the rider seat. (See page 3-13.) Record the information on this label in the space provided. This information will be needed when ordering spare parts from a Yamaha dealer. 10 10-2 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 115
that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 116
CONSUMER INFORMATION EAU26560 Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 117
months 24000 mi (37000 km) or 36 months 28000 mi (43000 km) or 42 months 32000 mi (49000 km) or 48 months 10-5 Date of service Mileage Servicing dealer name and address Remarks 10 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 118
CONSUMER INFORMATION Maintenance interval 36000 mi (55000 km) or 54 months 40000 mi (61000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 10 10-6 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 119
CONSUMER INFORMATION YAMAHA MOTOR CORPORATION, U.S.A. ROYAL STAR™ VENTURE® LIMITED WARRANTY EAU26703 10 10-7 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 120
CONSUMER INFORMATION 10 10-8 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 121
CONSUMER INFORMATION 10 10-9 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 122
, checking ...7-20 Engine oil and oil filter cartridge ...7-12 Engine, starting a warm...6-3 Engine stop switch...3-8 Engine trouble warning light ...3-3 M Main switch/steering lock ...3-1 Maintenance and lubrication, periodic...7-4 Maintenance, emission control system ...7-3 Maintenance, periodic - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 123
...8-2 Supporting the motorcycle ...7-37 Swingarm pivots, lubricating...7-30 Wheel bearings, checking ...7-32 Wheels ...7-23 T TALK switch...3-7 Throttle cable free play, checking...7-20 Throttle grip and cable, checking and lubricating ...7-28 Tires...7-21 Tool kit ...7-1 Troubleshooting...7-37 - 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 124
- 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 125
- 2008 Yamaha Motorsports Royal Star Venture S | Owners Manual - Page 126
YAMAHA MOTOR CO., LTD. PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2007.06-0.5×1 CR (E)
2C9-28199-12
XVZ13TFX(C)
XVZ13TFSX(C)
OWNER’S MANUAL
LIT-11626-21-42