2008 Yamaha Motorsports Majesty Owners Manual
2008 Yamaha Motorsports Majesty Manual
2008 Yamaha Motorsports Majesty manual content summary:
- 2008 Yamaha Motorsports Majesty | Owners Manual - Page 1
OWNER'S MANUAL YP400X LIT-11626-21-34 5RU-28199-13 - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 2
EAU10041 - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 3
degree of craftsmanship and reliability that have made Yamaha a leader in these fields. This manual will give you an understanding of the operation, inspection, and basic maintenance of this attention to the recommended maintenance schedules and operating instructions contained within this manual. - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 4
INFORMATION EAU35821 Particularly important information is distinguished in this manual by the following notations: The Safety Alert Symbol means ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED! WARNING CAUTION: NOTE: Failure to follow WARNING instructions could result in severe injury or death to - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 5
INFORMATION EAU10192 AFFIX DEALER LABEL HERE YP400X OWNER'S MANUAL ©2007 by Yamaha Motor Corporation, U.S.A. 1st edition, April 2007 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A. - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 6
TABLE OF CONTENTS SAFETY INFORMATION ...1-1 Further safe-riding points ...1-4 Location of important labels ...1-6 DESCRIPTION ...2-1 Left view ...2-1 Right view ...2-2 Controls and instruments...2-3 INSTRUMENT AND CONTROL FUNCTIONS ...3-1 Main switch/steering lock ...3-1 Indicator and warning lights - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 7
light bulb ...6-37 Replacing the license plate light bulb ...6-38 Troubleshooting ...6-39 Troubleshooting charts ...6-40 SCOOTER CARE AND STORAGE ...7-1 Matte color caution YAMAHA MOTOR CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...9-9 - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 8
SHOULD: G OBTAIN THOROUGH INSTRUCTIONS FROM A COMPETENT SOURCE ON ALL ASPECTS OF SCOOTER OPERATION. THE WARNINGS G OBSERVE AND MAINTENANCE REQUIREMENTS IN THE OWNER'S MANUAL. G OBTAIN QUALIFIED TRAINING IN SAFE AND PROPER RIDING TECHNIQUES. G OBTAIN PROFESSIONAL TECHNICAL SERVICE AS INDICATED BY THE - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 9
SAFETY INFORMATION G G G G G G G Always signal before turning or changing lanes. Make sure that other motorists can see you. The posture of the operator and passenger is important for proper control. The operator should keep both hands on the handlebar and both feet on the footboard during - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 10
SAFETY INFORMATION When loading within this weight limit, keep the following in mind: G Cargo and accessory weight should be kept as low and close to the scooter as possible. Make sure to distribute the weight as evenly as possible on both sides of the scooter to minimize imbalance or instability. G - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 11
SAFETY INFORMATION G G G G G G G Take care not to spill any gasoline on the engine or exhaust system when refueling. Never refuel while smoking or in the vicinity of an open flame. Never start the engine or let it run for any length of time in a closed area. The exhaust fumes are poisonous - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 12
SAFETY INFORMATION G 1 and ankle so they do not flap), and a bright colored jacket. Do not carry too much luggage on the scooter. An overloaded scooter is unstable. 1-5 - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 13
SAFETY INFORMATION EAU10381 Location of important labels Please read the following important labels carefully before operating this vehicle. 1 1 2 3 4 5 6 7 1-6 - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 14
, gasoline or solvent will damage windshield. Use neutral detergent. 3JJ-2835Y-A0 2 WARNING BEFORE YOU OPERATE THIS VEHICLE, READ THE OWNER'S MANUAL AND ALL LABELS. ALWAYS WEAR AN APPROVED MOTORCYCLE HELMET, eye protection, and protective clothing. 5GK-2118K-00 5RU-21668-00 5 WARNING Improper - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 15
SAFETY INFORMATION 7 1 5RU-21686-00 1-8 - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 16
DESCRIPTION EAU10410 Left view 1 1 2 3 4 5 6 7 8 9 2 3 4 5 6 7 11 1. Headlight (page 6-36) 2. Fuel tank cap (page 3-9) 3. Rear storage compartment (page 3-13) 4. V-belt case air filter element (page 6-20) 5. Owner's tool kit (page 6-2) 6. Fuses (page 6-34) 7. Battery (page 6-33) 8. Shock - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 17
DESCRIPTION EAU10420 Right view 1 2 3 4 2 3 4 5 6 7 8 7 6 5 1. Grab bar (page 5-2) 2. Passenger seat (page 3-11) 3. Rider seat (page 3-11) 4. Coolant reservoir (page 6-18) 5. Radiator 6. Centerstand (page 6-31) 7. Air filter element (right) (page 6-20) 8. Shock absorber assembly spring preload - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 18
DESCRIPTION EAU10430 Controls and instruments 1 1 2 3 4 5 6 7 8 9 2 3 4 5 6 7 8 12 1. Rear brake lever (page 3-8) 2. Left handlebar switches (page 3-7) 3. Rear brake lock lever (page 3-8) 4. Speedometer (page 3-2) 5. Multi-function display (page 3-3) 6. Tachometer (page 3-3) 7. Right - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 19
INSTRUMENT AND CONTROL FUNCTIONS EAU10460 Main switch/steering lock sidestand is moved down. EAU10660 OFF All electrical systems are off. The key can be removed. EAU10680 loss of control or an accident. Make sure that the vehicle is stopped before turning the key to "OFF" or "LOCK". 2 LOCK The - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 20
few seconds, then go off, have a Yamaha dealer check the electrical circuit. Speedometer 1 1. Speedometer 5 6 7 8 9 2. High beam indicator light " 3. Engine trouble warning light " Turn signal indicator lights " " and " " The corresponding indicator light flashes when the turn signal switch is - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 21
INSTRUMENT AND CONTROL FUNCTIONS EAU11872 EAU36105 Tachometer 1 Multi-function display EWA12311 1 2 3 4 2 WARNING Be sure to stop the vehicle before making any setting changes to the multi-function display. 2 3 1. V-belt replacement indicator "V-BELT" 2. Fuel level warning indicator " " 3. - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 22
between the various tripmeter and odometer modes in the following order: TRIP F → TRIP (top) → TRIP (bottom) → ODO → TRIP F the fuel reserve tripmeter manually, it will reset itself automatically and the display will return to the prior mode after refueling and traveling 5 km (3 mi). NOTE: The - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 23
INSTRUMENT AND CONTROL FUNCTIONS vehicle and let the engine cool. (See page 6-40.) been reached), the indicator must be reset after the oil change for the next periodic oil change to be indicated at the correct time. (See page 6-14.) The electrical circuit of the indicator can be checked according - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 24
INSTRUMENT AND CONTROL FUNCTIONS the minute digits will start flashing. 4. Push the "RESET" button to set the minutes. 5. Push the "SELECT" button and then release it to start the clock. Pushing the "SELECT" button for at least two seconds switches the clock display to the ambient temperature - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 25
center position. To cancel the turn signal lights, push the switch in after it has returned to the center position. 3-7 CAUTION: See page 5-1 for starting instructions prior to starting the engine. - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 26
INSTRUMENT AND CONTROL FUNCTIONS EAU12900 EAU12950 EAU12962 Front brake lever 1 2 3 4 5 6 7 8 9 Rear brake lever 1 Rear brake lock lever 1 1 1. Front brake lever 1. Rear brake lever 1. Rear brake lock lever The front brake lever is located on the right handlebar grip. To apply the front - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 27
INSTRUMENT AND CONTROL FUNCTIONS G rear brake lock lever is applied. To provide secure locking of the rear wheel, apply the rear brake lever first before moving the rear brake lock lever to the left. EWA12361 EAU13162 Fuel tank cap To open the fuel tank cap 1. Open the lid by sliding the lever - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 28
INSTRUMENT AND CONTROL FUNCTIONS move it. 3. Close the lid. EWA11120 EAU13211 Fuel fuel may deteriorate painted surfaces or plastic parts. EAU36080 1 2 3 4 5 6 7 WARNING Be sure that the fuel tank cap is properly installed and locked before riding the scooter. 1 Recommended fuel UNLEADED - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 29
10%. Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. EAU13431 EAU34140 Catalytic converter This model is equipped with a catalytic converter in the exhaust system. EWA10860 Seats 1 2 3 4 5 6 7 8 9 WARNING The - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 30
INSTRUMENT AND CONTROL FUNCTIONS 1 1 2 3 1. Open. To close the rider seat 1. Fold the rider seat down, and then push it down to lock it in place. 2. Remove the key from the main switch if the scooter will be left unattended. NOTE: Make sure that the rider seat is properly secured before riding. - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 31
INSTRUMENT AND CONTROL FUNCTIONS EAU34150 EAU14492 Adjusting the rider seat 1 Storage compartments Front storage compartment A To open the storage compartment when it is locked, insert the key in the lock, turn it counterclockwise, and then grasp the lock while pushing the button in. To open the - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 32
INSTRUMENT AND CONTROL FUNCTIONS and then remove it. 1 1 2 3 4 5 6 7 8 9 Rear storage compartment Two helmets can be stored in the storage compartment under the seats. (See page 3-11.) 1. Lock. 2. Lid 1 1 2 2 1. Storage compartment opening lever 2. Lid 1. Rider seat ECA10080 Front storage - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 33
INSTRUMENT AND CONTROL FUNCTIONS being washed, wrap any articles stored in the compartment in a plastic bag. Do not keep anything valuable or breakable in the storage compartment. ECA11100 EAU14890 Adjusting the shock absorber assemblies 1 2 5 4 3 2 1 handling and loss of stability may result. - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 34
INSTRUMENT AND CONTROL FUNCTIONS EAU15301 Sidestand 1 2 3 4 5 6 7 8 9 The sidestand is located on the left side of the frame. Raise the sidestand or lower it with your foot while holding the vehicle upright. NOTE: The built-in sidestand switch is part of the ignition circuit cut-off system, which - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 35
INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is turned on. 3. Turn the key on. 4. Keep the front or rear brake applied. 5. Push the start switch. Does the engine start? NOTE: This check is most reliable if - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 36
PRE-OPERATION CHECKS EAU15593 1 2 3 4 5 6 7 8 9 The condition of a vehicle is the owner's responsibility. Vital components can start to deteriorate quickly and unexpectedly, even if the vehicle remains unused (for example, as a result of exposure to the elements). Any damage, fluid leakage or loss - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 37
PRE-OPERATION CHECKS EAU15605 Pre-operation check list ITEM G CHECKS G G G PAGE 3-10 Fuel Engine oil Final transmission oil Coolant G G G G G G G G G Front brake G G G G G G G Rear brake G G G G G Throttle grip G G Check fuel level in fuel tank. Refuel if necessary. Check fuel line for - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 38
PRE-OPERATION CHECKS ITEM G G G G CHECKS Check for damage. Check tire condition and tread depth. Check air pressure. Correct if necessary. Make sure that operation is smooth. Lubricate lever pivoting points if necessary. Make sure that operation is smooth. Lubricate pivots if necessary. Make sure - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 39
sure that there is adequate ventilation. For safety, always start the engine with the centerstand down. CAUTION: See page 5-3 for engine break-in instructions prior to operating the vehicle for the first time. In order for the ignition circuit cut-off system to enable starting, the sidestand must - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 40
OPERATION AND IMPORTANT RIDING POINTS EAU16760 EAU16780 EAU16792 Starting off 1 2 3 4 5 6 7 1. Grab bar Acceleration and deceleration Braking 1. Close the throttle completely. 2. Apply both front and rear brakes simultaneously while gradually increasing the pressure. NOTE: Before starting off, - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 41
OPERATION AND IMPORTANT RIDING POINTS Rear cult. EAU16841 Engine break-in There is never a more important period in the life of your engine than the period between 0 and 1600 km (1000 mi). For this reason, you should read the following material carefully. Since the engine is brand new, do not put - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 42
the key from the main switch. EWA10310 1 2 3 4 5 6 7 8 9 CAUTION: G Keep the engine speed out of the tachometer red zone. G If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. G G WARNING Since the engine and exhaust system - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 43
intervals. EAU17301 PERIODIC MAINTENANCE PROPER PERIODIC MAINTENANCE OF YOUR VEHICLE IS IMPORTANT IN ORDER TO ENJOY LONG, PLEASURABLE SERVICE. ESPECIALLY IMPORTANT ARE THE MAINTENANCE SERVICES RELATED TO EMISSIONS CONTROL. THESE CONTROLS NOT ONLY FUNCTION TO ENSURE CLEANER AIR, BUT ARE ALSO VITAL - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 44
the rear storage compartment. (See page 3-13.) Pull up the storage compartment mat, and then remove the owner's tool kit. The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and minor - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 45
. Replace any damaged parts. 2 3 √ √ Replace. √ √ 4 5 Every 26600 mi (42000 km 6 7 8 √ * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 9 6-3 - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 46
PERIODIC MAINTENANCE AND MINOR REPAIR EAU32185 General maintenance and lubrication chart INITIAL ODOMETER READINGS 4000 mi (7000 km) or 6 months √ 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months Every 12000 mi (19000 - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 47
PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month √ 4000 mi (7000 km) or 6 months √ ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months G 10 * Steering - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 48
operation 25 * switches G Adjust headlight beam. * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. G G √ √ √ √ √ √ NOTE: From 24000 mi (37000 km) or 36 months, repeat the maintenance intervals starting from 8000 mi (13000 km) or - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 49
MAINTENANCE AND MINOR REPAIR EAU36370 NOTE: G The air filters and V-belt filter need more frequent service if you are riding in unusually wet or dusty areas. G Hydraulic brake service After disassembling the brake master cylinders and calipers, always change the fluid. Regularly check the brake - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 50
PERIODIC MAINTENANCE AND MINOR REPAIR EAU18712 Removing and installing cowlings and panels 1 2 3 4 The cowlings and panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a cowling or panel needs to be removed and installed - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 51
PERIODIC MAINTENANCE AND MINOR REPAIR Cowling B To remove the cowling 1. Remove the screws. To install the cowling Place the cowling in the original position, and then install the screws. Cowlings C and D 1 2 3 1. Screw access cover 1 To remove one of the cowlings 1. Remove cowlings A and B. 2. - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 52
PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 1 3 4 5 6 7 8 9 2. Install the screw access cover by placing it in its original position. 3. Install the grab bar by installing the collars and grab bar bolts. Tightening torque: Grab bar bolt: 23 Nm (2.3 m·kgf, 16.6 ft·lbf) 1. Left floorboard mat 1. - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 53
PERIODIC MAINTENANCE AND MINOR REPAIR EAU34290 Panel A To remove the panel 1. Remove the bolts. To install the panel Place the panel in the original position, and then install the bolts. 1 2 2 1. Panel B 2. Screw 2 3 4 5 6 1 1. Bolt 2. Panel A Panel B To remove the panel Remove the screws, - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 54
normally). NOTE: If the spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 2. Check the spark plug for electrode erosion and excessive carbon or other deposits - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 55
PERIODIC MAINTENANCE AND MINOR REPAIR necessary. Specified spark plug: NGK/CR7E 3. Install the spark plug with the spark plug wrench, and then tighten it to the specified torque. Tightening torque: Spark plug: 12.5 Nm (1.25 m·kgf, 9 ft·lbf) 1 To install the spark plug 1. Measure the spark plug - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 56
PERIODIC MAINTENANCE AND MINOR REPAIR EAU36110 EAU34182 Canister 1 2 3 4 5 6 7 8 9 This model is equipped with a canister to prevent the discharging of fuel vapor into the atmosphere. Before operating this vehicle, make sure to check the following: G Check each hose connection. G Check each hose - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 57
PERIODIC MAINTENANCE AND MINOR REPAIR To change the engine oil (with or without oil filter element replacement) 1. Start the engine, warm it up for several minutes, and then turn it off. 2. Place an oil pan under the engine to collect the used oil. 3. Remove the engine oil filler cap and the engine - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 58
PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 1 2 3 4 5 6 7 8 9 1. Oil filter element cover 2. O-ring 3. Compression spring 4. Oil filter element ECA12910 Tightening torque: Oil filter element cover bolt: 10 Nm (1.0 m·kgf, 7.2 ft·lbf) NOTE: Make sure that the O-rings are properly seated. 8. Install - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 59
PERIODIC MAINTENANCE AND MINOR REPAIR 11. Reset the oil change indicator according to the following procedure. To reset the oil change indicator 1. Turn the key to "ON". 2. Hold the "OIL CHANGE" button pushed for two to eight seconds. the correct time. To reset the oil change indicator before the - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 60
PERIODIC MAINTENANCE AND MINOR REPAIR EWA11310 EAU20070 1 G 1 2 3 4 5 6 7 8 9 2 G WARNING Make sure that no foreign material enters the final transmission case. Make sure that no oil gets on the tire or wheel. Coolant The coolant level should be checked before each ride. In addition, the - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 61
PERIODIC MAINTENANCE AND MINOR REPAIR 1 NOTE: The coolant should be between the minimum and maximum level marks. 5. If the coolant is at or below the minimum level mark, open the coolant reservoir cap, add coolant to the maximum level mark, and then close the coolant reservoir cap. 1. Right fl - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 62
radiator. G If the engine overheats, see page 6-40 for further instructions. Air filter elements and check hoses and V-belt case air filter element air filter element should be serviced at the intervals specified in the periodic maintenance and lubrication chart. Service all air filter elements more - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 63
PERIODIC MAINTENANCE AND MINOR REPAIR Left 6. Install the rubber cap. ECA12922 Left 1 1. Air filter element Right 1 CAUTION: G Make sure that each filter element is properly seated in its case. G Always replace both air filter elements at the same time, otherwise poor engine performance or - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 64
PERIODIC MAINTENANCE AND MINOR REPAIR Cleaning the V-belt case air filter element 1. Remove cowling E. (See page 6-8.) 2. Remove panel B. (See page 6-8.) 3. Remove the left air filter case cover. 4. Remove the V-belt air filter case cover by removing the screws. 1 1 2 3 4 5 6 1 2 1. Screw 2. V- - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 65
PERIODIC MAINTENANCE AND MINOR REPAIR EAU21382 EAU21401 EAU21861 Checking the throttle cable free play Valve clearance The valve clearance changes with use, resulting in improper air-fuel mixture and/or engine noise. To prevent this from occurring, the valve clearance must be adjusted by a Yamaha - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 66
to loss of control. Have excessively worn tires replaced by a Yamaha dealer immediately. Brakes, tires, and related wheel parts replacement should be left to a Yamaha Service Technician. - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 67
PERIODIC MAINTENANCE AND MINOR REPAIR EAU21992 Front tire: Size: 120/80-14M/C 58S Manufacturer/model: IRC/MB67 DUNLOP/D305FL Rear tire: Size: 150/70-13M/C 64S Manufacturer/model: IRC/MB67 DUNLOP/D305L EWA10580 Cast wheels To maximize the performance, durability, and safe operation of your vehicle, - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 68
PERIODIC MAINTENANCE AND MINOR REPAIR EAU22011 Accessories and replacement parts EWA10621 been approved by Yamaha. EAU33453 Front and rear brake lever free play Front 1 2 3 4 5 6 7 8 9 WARNING This vehicle is not designed to pull a trailer or to be attached to a sidecar. The accessories or - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 69
PERIODIC MAINTENANCE AND MINOR REPAIR brake system. EWA14211 EAU33473 WARNING A soft or spongy feeling in the brake lever can indicate the presence of air in the hydraulic system. If there is air in the hydraulic system, have a Yamaha dealer bleed the system before operating the vehicle. Air in the - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 70
PERIODIC MAINTENANCE AND MINOR REPAIR EAU22390 Checking the front and rear brake pads 1 2 3 4 5 6 The front and rear brake pads must be checked for wear at the intervals specified in the periodic maintenance and lubrication chart. EAU22420 indicator groove has almost disappeared, have a Yamaha - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 71
PERIODIC MAINTENANCE AND MINOR REPAIR enter the brake system, possibly causing it to become ineffective. Before riding, check that the brake fluid is above the minimum level mark and replenish if necessary. A low brake fluid level may indicate worn brake pads and/or brake system leakage. If the - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 72
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23091 EAU23111 EAU23172 Checking and lubricating the cables 1 2 3 4 5 6 7 8 9 The operation of all control cables and the condition of the cables should be checked before each ride, and the cables and cable ends should be lubricated if necessary. If a cable - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 73
must be checked as follows at the intervals specified in the periodic maintenance and lubrication chart. To check the condition EWA10750 2 3 4 5 6 7 8 9 WARNING Securely support the vehicle so that there is no danger of it falling over. Check the inner tubes for scratches, damage and excessive oil - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 74
specified in the periodic maintenance and lubrication chart. 1. Place a stand under the engine to raise the front wheel off the ground. EWA10750 WARNING Securely support the vehicle so that there is no danger of it falling over. 2. Hold the lower ends of the front fork legs and try to move - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 75
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23290 EAU34221 Checking the wheel bearings The front and rear wheel bearings must be checked at the intervals specified in the periodic maintenance and lubrication chart. If there is play in the wheel hub or if the wheel does not turn smoothly, have a Yamaha - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 76
PERIODIC MAINTENANCE AND MINOR REPAIR electrical accessories. To store the battery 1. If the vehicle will not be used for more than one month, remove the battery, fully charge it, and then place it in a cool, dry place. 2. If the battery will be stored for more than two months, check it at least - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 77
PERIODIC MAINTENANCE AND MINOR REPAIR 1 2 3 4 5 6 Specified fuses: Main fuse: 40.0 A Ignition fuse: 10.0 A Signaling system fuse: 10.0 A Headlight fuse: 20.0 A Taillight fuse: 10.0 A Radiator fan fuse: 10.0 A Fuel injection system fuse: 10.0 A Backup fuse: 10.0 A ECA10640 7 2 1 2 3 4 5 6 7 8 9 1. - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 78
PERIODIC MAINTENANCE AND MINOR REPAIR EAU34240 EAU24180 EAU36122 Replacing a headlight bulb 1 2 3 4 5 6 7 8 9 This model is equipped with quartz bulb headlights. If a headlight bulb burns out, have a Yamaha dealer replace it and, if necessary, adjust the headlight beam. Tail/brake light This model - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 79
PERIODIC MAINTENANCE AND MINOR REPAIR 1 clockwise. 7. Insert a new bulb into the socket, push it in, and then turn it clockwise until it stops. 8. Install the socket (together with the bulb) by turning it clockwise. 9. Place the turn signal light unit in the original position, and then install the - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 80
PERIODIC MAINTENANCE AND MINOR REPAIR push it in, and then turn it clockwise until it stops. 6. Install the socket (together with the bulb) by turning it clockwise. 7. Install the cowling removed. EAU34270 Replacing the license plate light bulb 1. Remove cowling B. (See page 6-8.) 2. Remove the - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 81
receive a thorough inspection before shipment from the factory, trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause poor starting and loss of power. The following troubleshooting charts represent quick and easy procedures for checking - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 82
PERIODIC MAINTENANCE AND MINOR REPAIR EAU42700 Troubleshooting charts Starting problems or poor engine performance 1 2 3 4 5 6 7 8 9 EWA10840 WARNING Keep away open flames and do not smoke while checking or working on the fuel system. 1. Fuel There is - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 83
PERIODIC MAINTENANCE AND MINOR REPAIR Engine overheating EWAT1040 G G WARNING Do not remove the radiator cap when the engine and radiator are hot. Scalding hot fluid and steam may be blown out under pressure, which could cause serious injury. Be sure to wait until the engine has cooled. Place a - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 84
on spoked wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. G Improper cleaning can damage plastic parts - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 85
SCOOTER CARE AND STORAGE cleaning products, solvent or thinner, fuel (gasoline), rust removers or inhibitors, brake fluid, antifreeze or electrolyte. Do not use high-pressure washers or steam-jet cleaners since they cause water seepage and deterioration in the following areas: seals (of wheel and - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 86
of the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your scooter for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 87
SCOOTER CARE AND STORAGE fuel from deteriorating. 3. Perform the following steps to protect the cylinder, piston rings, etc. from corrosion. a. Remove the spark plug cap and spark plug. b. Pour a teaspoonful of engine oil into the spark plug bore. c. Install the spark plug cap onto the spark plug, - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 88
4 (20W40) or SAE 20W40 -20° -10° 0° 10° 20° 30° 40° 50°C Fuel injection: Throttle body: Manufacturer: AISAN Recommended engine oil grade: API service SG type or higher, JASO standard MA Spark plug (s): Manufacturer/model: NGK/CR7E Spark plug gap: 0.7-0.8 mm (0.028-0.031 in) Weight: With oil and - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 89
SPECIFICATIONS Chassis: Frame type: Aluminum die-cast and steel tube backbone Caster angle: 27.00 ° Trail: 100.0 mm (3.94 in) Tire air pressure (measured on cold tires): Loading condition: 0-90 kg (0-198 lb) Front: 200 kPa (29 psi) (2.00 kgf/cm2) Rear: 250 kPa (36 psi) (2.50 kgf/cm2) Loading - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 90
License plate light: 12 V, 5.0 W × 1 Meter lighting: 12 V, 2.0 W × 3 High beam indicator light: 12 V, 1.4 W × 1 Turn signal indicator light: 12 V, 1.4 W × 2 Engine trouble warning light: 12 V, 1.4 W × 1 Fuses: Main fuse: 40.0 A Headlight fuse: 20.0 A Taillight fuse: 10.0 A Signaling system fuse: 10 - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 91
CONSUMER INFORMATION EAU26351 EAU26381 EAU26410 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 92
CONSUMER INFORMATION EAU26500 Model label 1 2 3 4 5 6 7 8 9 1 1. Model label The model label is affixed to the inside of the rear storage compartment. (See page 3-13.) Record the information on this label in the space provided. This information will be needed when ordering spare parts from a - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 93
that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327 - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 94
CONSUMER INFORMATION EAU26580 Scooter noise regulation 1 2 3 4 5 6 7 8 9 TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 95
24 months 20000 mi (31000 km) or 30 months 24000 mi (37000 km) or 36 months 28000 mi (43000 km) or 42 months Date of service Mileage Servicing dealer name and address Remarks 2 3 4 5 6 7 8 9 9-5 - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 96
CONSUMER INFORMATION Maintenance interval 32000 mi (49000 km) or 48 months 36000 mi (55000 km) or 54 months 40000 mi (61000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 1 2 3 4 5 6 7 8 9 9-6 - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 97
1. Operate and maintain the motorcycle as specified in the appropriate Owner's Manual, and 2. Give notice to an authorized Yamaha motorcycle dealer of any . An inspection and registration fee will be charged for this service. EMISSION CONTROL SYSTEM WARRANTY: Yamaha Motor Corporation, U.S.A. also - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 98
service, you must take it to any authorized Yamaha motorcycle dealer within the continental United States. Be sure to bring your warranty registration card or other valid proof of the original date of purchase. If a question or problem in the Owner's and Service Manual. We do recommend, however - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 99
no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 100
isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 9-10 - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 101
and lubricating ...6-30 Tires ...6-23 Tool kit...6-2 Troubleshooting ...6-39 Troubleshooting charts...6-40 Turn signal indicator lights ...3-2 Turn signal oil and oil filter element...6-14 Engine stop switch...3-7 Engine trouble warning light ...3-2 N Noise regulation ...9-4 P Parking ...5-4 - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 102
INDEX V Valve clearance ...6-23 Vehicle identification number ...9-1 W Warranty, extended...9-9 Warranty, limited ...9-7 Wheel bearings, checking...6-33 Wheels ...6-25 - 2008 Yamaha Motorsports Majesty | Owners Manual - Page 103
- 2008 Yamaha Motorsports Majesty | Owners Manual - Page 104
YAMAHA MOTOR CO., LTD. PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2007.6-0.4×1 ! (E)
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
-
104
 |
 |
LIT-11626-21-34
5RU-28199-13
YP400X
OWNER’S MANUAL