2007 Yamaha Motorsports Roadliner Owners Manual
2007 Yamaha Motorsports Roadliner Manual
2007 Yamaha Motorsports Roadliner manual content summary:
- 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 1
OWNER'S MANUAL XV19SW(C) XV19W(C) XV19MW(C) LIT-11626-20-40 1D7-28199-11 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 2
EAU10041 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 3
of craftsmanship and reliability that have made Yamaha a leader in these fields. This manual will give you an understanding of the operation, inspection, and basic maintenance of this close attention to the recommended maintenance schedules and operating instructions contained within this manual. - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 4
manual by the following notations: The Safety Alert Symbol means ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED! Failure to follow WARNING instructions procedures easier or clearer. WARNING CAUTION: NOTE: NOTE: G This manual should be considered a permanent part of this motorcycle and should - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 5
IMPORTANT MANUAL INFORMATION AND UNTIL YOU HAVE BEEN TRAINED IN SAFE AND PROPER RIDING TECHNIQUES. REGULAR INSPECTIONS AND CAREFUL MAINTENANCE, ALONG WITH GOOD RIDING SKILLS, WILL ENSURE - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 6
EAU10192 AFFIX DEALER LABEL HERE XV19SW(C)/XV19W(C)/XV19MW(C) OWNER'S MANUAL ©2006 by Yamaha Motor Corporation, U.S.A. 1st edition, June 2006 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A. - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 7
...6-25 Battery ...6-25 Replacing the fuses ...6-26 Replacing a headlight bulb ...6-28 Tail/brake light ...6-31 Replacing a turn signal light bulb ...6-31 License plate light ...6-31 Supporting the motorcycle ...6-32 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 8
TABLE OF CONTENTS Troubleshooting ...6-32 Troubleshooting chart ...6-33 MOTORCYCLE CARE AND STORAGE ...7-1 Matte color caution ...7-1 Care ...7-1 Maintenance record ...9-5 YAMAHA MOTOR CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...9-9 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 9
SHOULD: G OBTAIN THOROUGH INSTRUCTIONS FROM A COMPETENT SOURCE ON ALL ASPECTS OF MOTORCYCLE OPERATION. G OBSERVE THE WARNINGS AND MAINTENANCE REQUIREMENTS IN THE OWNER'S MANUAL. G OBTAIN QUALIFIED TRAINING IN SAFE AND PROPER RIDING TECHNIQUES. G OBTAIN PROFESSIONAL TECHNICAL SERVICE AS INDICATED BY - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 10
SAFETY INFORMATION due to EXCESSIVE SPEED or undercornering (insufficient lean angle for the speed). • Always obey the speed limit and never travel faster than warranted by road and traffic conditions. • Always signal before turning or changing lanes. Make sure that other motorists can see you. The - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 11
SAFETY INFORMATION Loading The total weight of the operator, passenger, accessories and cargo must not exceed the maximum load limit. Maximum load: 210 kg (463 lb) When loading within this weight limit, keep the following in mind: G Cargo and accessory weight should be kept as low and close to the - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 12
SAFETY INFORMATION tor and may limit control ability, therefore, such accessories are not recommended. Use caution when adding electrical accessories. If electrical accessories exceed the capacity of the motorcycle's electrical system, an electric failure could result, which could cause a dangerous - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 13
SAFETY INFORMATION EAU10381 Location of important labels Please read the following important labels carefully before operating this vehicle. 1 1-5 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 14
SAFETY INFORMATION 1 1 4 California only 2 PREMIUM UNLEADED GASOLINE ONLY 91 Min. Pump Octane (R+M) 2 5PW-2415E-11 3 5 1-6 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 15
DESCRIPTION EAU10410 Left view 2 1. 2. 3. 4. 5. 6. 7. 8. Headlight (page 6-28) Clutch fluid reservoir (page 6-18) Seat lock (page 3-12) Main fuse (page 6-26) Battery (page 6-25) Owner's tool kit (page 6-1) License plate light (page 6-31) Tail/brake light (page 6-31) 2-1 9. Engine oil drain bolt - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 16
DESCRIPTION EAU10420 Right view 2 1. 2. 3. 4. 5. 6. 7. 8. Helmet holder (page 3-13) Fuel injection system fuse (page 6-26) Rear brake fluid reservoir (page 6-18) Fuse box (page 6-26) Engine oil filler cap (page 6-9) Fuel tank cap (page 3-10) Front brake fluid reservoir (page 6-18) Brake pedal ( - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 17
DESCRIPTION EAU10430 Controls and instruments 2 1. 2. 3. 4. 5. 6. 7. Clutch lever (page 3-9) Left handlebar switches (page 3-7) Multi-function meter unit (page 3-3) Main switch/steering lock (page 3-1) Right handlebar switches (page 3-7) Throttle grip (page 6-13) Brake lever (page 3-9) 2-3 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 18
INSTRUMENT AND CONTROL FUNCTIONS EAU38390 EAU10540 Main switch/steering lock The main switch/steering lock is located under the main switch/steering lock cover. To access the main switch/steering lock, slide the cover forward. 3 ON All electrical circuits are supplied with power, and the meter - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 19
6. Neutral indicator light " " High beam indicator light " " Right turn signal indicator light " " Left turn signal indicator light " " Engine trouble warning light " " Fuel level warning light " " EAU11030 Turn signal indicator lights " " and " " The corresponding indicator light flashes when the - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 20
and then go off for 3.0 seconds. If this occurs, have a Yamaha dealer check the vehicle. EAU11530 EAU38422 Multi-function meter unit G G 3 Engine trouble warning light " " This warning light comes on or flashes when an electrical circuit monitoring the engine is defective. When this occurs, have - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 21
INSTRUMENT AND CONTROL FUNCTIONS Speedometer Tachometer 3 1. "SELECT" switch 1. Speedometer 1. Tachometer 2. Tachometer red zone The speedometer shows the riding speed. When the key is turned to "ON", the speedometer needle will sweep once across the speed range and then return to zero in order to - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 22
by pushing the "SELECT" switch, and then push the "RESET" switch for at least one second. If you do not reset the fuel reserve tripmeter manually, it will reset itself automatically, and the display will return to the prior mode after refueling and traveling 5 km (3 mi). Clock mode 1. Odometer - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 23
-diagnosis devices This model is equipped with a self-diagnosis device for various electrical circuits. If any of those circuits are defective, the engine trouble warning light will come on, and then the odometer/tripmeter/clock display will indicate a two-digit error code (e.g., 12, 13, 14). If the - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 24
INSTRUMENT AND CONTROL FUNCTIONS 4. Adjust the multi-function meter unit panel brightness level by pushing the "RESET" switch. 5. Push the "SELECT" switch to select the LCD. Item number "2" is displayed. Adjust the LCD brightness level by pushing the "RESET" switch. 1. 2. 3. 4. 5. Speedometer needle - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 25
the turn signal lights can also be canceled manually by pushing the switch in after it has EAU38331 CAUTION: See page 5-1 for starting instructions prior to starting the engine. 3 EAU41700 the right to turn them off. ECA15321 The engine trouble warning light will come on when the key is - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 26
INSTRUMENT AND CONTROL FUNCTIONS EAU12820 EAU12880 EAU12890 Clutch lever Shift pedal Brake lever 3 1. Clutch lever 1. Shift pedal 1. Brake lever The clutch lever is located at the left handlebar grip. To disengage the clutch, pull the lever toward the handlebar grip. To engage the clutch, - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 27
INSTRUMENT AND CONTROL FUNCTIONS EAU12941 EAU13120 Brake pedal Fuel tank cap 2. Turn the key counterclockwise to the original position, remove it, and then close the lock cover. NOTE: The fuel tank cap cannot be installed unless the key is in the lock. In addition, the key cannot be removed if - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 28
does not exceed 10%. Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. WARNING G G Do not overfill the fuel tank, otherwise it may overflow when the fuel warms up and expands. Avoid spilling fuel on the hot - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 29
INSTRUMENT AND CONTROL FUNCTIONS EAU13431 EAU34042 Catalytic converter This model is equipped with a catalytic converter in the exhaust system. EWA10860 Rider seat To remove the rider seat 1. Insert the key into the seat lock, and then turn it counterclockwise. WARNING The exhaust system is hot - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 30
INSTRUMENT AND CONTROL FUNCTIONS EAU38341 Helmet holder To release the helmet from the helmet holder Remove the rider seat, remove the helmet holding cable from the helmet holder and the helmet, and then install the seat. 3 1. Helmet holding cable 2. Helmet 1. Helmet holder 2. Helmet holding - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 31
INSTRUMENT AND CONTROL FUNCTIONS EAU38401 Adjusting the shock absorber assembly This shock absorber assembly is equipped with a spring preload adjusting nut. ECA10100 load and thereby soften the suspension, turn the adjusting nut in direction (b). With each complete turn of the adjusting nut, - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 32
tighten the locknut against the adjusting nut, and then tighten the locknut to the specified torque. EWA10220 G Always have a Yamaha dealer service the shock absorber. EAU15281 EXUP system This model is equipped with Yamaha's EXUP (EXhaust Ultimate Power valve) system. This system boosts engine - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 33
INSTRUMENT AND CONTROL FUNCTIONS EAU15301 Sidestand The sidestand is located on the left side of the frame. Raise the sidestand or lower it with your foot while holding the vehicle upright. NOTE: The built-in sidestand switch is part of the ignition circuit cut-off system, which cuts the ignition - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 34
INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is turned on. 3. Turn the key on. 4. Shift the transmission into the neutral position. 5. Push the start switch. Does the engine start? NOTE: This check is most reliable - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 35
INSTRUMENT AND CONTROL FUNCTIONS EAU38350 EWA12531 Auxiliary DC connector WARNING To prevent electrical shock or shortcircuiting, make sure that the cap is installed when the auxiliary DC connector is not being used. 3 1. Auxiliary DC connector A 12-V accessory connected to the auxiliary DC - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 36
PRE-OPERATION CHECKS EAU15591 The condition of a vehicle is the owner's responsibility. Vital components can start to deteriorate quickly and unexpectedly, even if the vehicle remains unused (for example, as a result of exposure to the elements). Any damage, fluid leakage or loss of tire air - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 37
PRE-OPERATION CHECKS EAU15605 Pre-operation check list ITEM Fuel • Check fuel level in fuel tank. • Refuel if necessary. • Check fuel line for leakage. • Check oil level in oil tank. • If necessary, add recommended oil to specified level. • Check vehicle for oil leakage. • Check vehicle for oil - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 38
PRE-OPERATION CHECKS ITEM Control cables CHECKS • Make sure that operation is smooth. • Lubricate if necessary Check for damage. Check tire condition and tread depth. Check air pressure. Correct if necessary. PAGE 6-21 Wheels and tires 6-14, 6-16 Brake and shift pedals Brake and clutch levers • - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 39
. 1. Turn the key to "ON" and make sure that the engine stop switch is set to " ". ECA11560 CAUTION: The fuel level warning light and engine trouble warning light should come on for a few seconds, then go 5-1 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 40
OPERATION AND IMPORTANT RIDING POINTS ECA11130 EAU16671 ECA10260 CAUTION: For maximum engine life, always warm the engine up before starting off. Never accelerate hard when the engine is cold! NOTE: The engine is warm when it quickly responds to the throttle. Shifting CAUTION: G 5 1. Shift - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 41
OPERATION AND IMPORTANT RIDING POINTS 4. At the recommended shift points shown in the following table, close the throttle, and at the same time, quickly pull the clutch lever in. 5. Shift the transmission into second gear. (Make sure not to shift the transmission into the neutral position.) 6. Open - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 42
the key from the main switch. EWA10310 WARNING G CAUTION: G 5 G Keep the engine speed out of the tachometer red zone. If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. G Since the engine and exhaust system can become very - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 43
. 1. Owner's tool kit The owner's tool kit is located under the rider seat. (See page 3-12.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and minor repairs. However, additional - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 44
PERIODIC MAINTENANCE AND MINOR REPAIR EWA10340 WARNING Modifications not approved by Yamaha may cause loss of performance, excessive emissions, and render the vehicle unsafe for use. Consult a Yamaha dealer before attempting any changes. 6 6-2 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 45
injection Exhaust system Evaporative emission control system (For California only) 7 * √ √ * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 6-3 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 46
PERIODIC MAINTENANCE AND MINOR REPAIR EAU32183 General maintenance and lubrication chart INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 47
PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months √ √ ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months √ √ Every 2500 mi (4000 km - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 48
* Throttle grip housing and cable √ √ √ √ √ 26 * Lights, signals and switches √ √ √ √ √ * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 6-6 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 49
PERIODIC MAINTENANCE AND MINOR REPAIR NOTE: From 24000 mi (37000 km) or 36 months, repeat the maintenance intervals starting from 8000 mi (13000 km) or 12 months. EAU38440 NOTE: G Air filter • This model's air filter is equipped with a disposable oil-coated paper element, which must not be cleaned - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 50
the same color. If any spark plug shows a distinctly different color, the engine could be operating improperly. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. If a spark plug shows signs of electrode erosion and excessive carbon or other deposits - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 51
PERIODIC MAINTENANCE AND MINOR REPAIR EAU19681 EAU38361 Canister (for California only) Engine oil and oil filter cartridge The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil filter cartridge replaced at the intervals specified in the periodic - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 52
PERIODIC MAINTENANCE AND MINOR REPAIR ECA10900 CAUTION: Make sure that the oil filler cap is securely tightened, otherwise oil may seep out when the engine is running. To change the engine oil (with or without oil filter cartridge replacement) 1. Remove the rider seat. (See page 3-12.) 2. Start the - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 53
PERIODIC MAINTENANCE AND MINOR REPAIR NOTE: Skip steps 7-9 if the oil filter cartridge is not being replaced. 7. Remove the oil filter cartridge with an oil filter wrench. 1. O-ring 1. Oil filter cartridge 2. Torque wrench NOTE: Make sure that the O-ring is properly seated. 1. Oil filter - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 54
PERIODIC MAINTENANCE AND MINOR REPAIR 11. Pour only 2.5 L (2.6 US qt) (2.2 Imp.qt) of the specified amount of recommended engine oil through the filler hole, insert the dipstick, and then tighten the oil filler cap. 12. Start the engine, rev it several times, and then turn it off. 13. Remove the - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 55
PERIODIC MAINTENANCE AND MINOR REPAIR EAU36762 EAU21381 EAU21401 Air filter element The air filter element must be replaced at the intervals specified in the periodic maintenance and lubrication chart. Have a Yamaha dealer replace the air filter element. Checking the throttle cable free play - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 56
PERIODIC MAINTENANCE AND MINOR REPAIR EAU21750 Tires To maximize the performance, durability, and safe operation of your motorcycle, note the following points regarding the specified tires. Tire air pressure The tire air pressure should be checked and, if necessary, adjusted before each ride. - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 57
PERIODIC MAINTENANCE AND MINOR REPAIR Always check the tires before operating the motorcycle. If a tire tread shows crosswise lines (minimum tread depth), if the tire has a nail or glass fragments in it, or if the sidewall is cracked, contact a Yamaha dealer immediately and have the tire replaced. - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 58
PERIODIC MAINTENANCE AND MINOR REPAIR EWA10600 EAU21960 EAU22011 WARNING This motorcycle is fitted with superhigh-speed tires. Note the following points in order to make the most efficient use of these tires. G Use only the specified replacement tires. Other tires may run the danger of bursting at - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 59
PERIODIC MAINTENANCE AND MINOR REPAIR any consequences caused by the use of items which have not been approved by Yamaha. EAU22072 EAU22270 Clutch lever Since this model is equipped with a hydraulic clutch, adjusting the clutch lever free play is not needed. However, it is necessary to check the - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 60
PERIODIC MAINTENANCE AND MINOR REPAIR EAU22390 Checking the front and rear brake pads The front and rear brake pads must be checked for wear at the intervals specified in the periodic maintenance and lubrication chart. EAU22430 indicator grooves have almost disappeared, have a Yamaha dealer - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 61
PERIODIC MAINTENANCE AND MINOR REPAIR Clutch Observe these precautions: G When checking the brake and clutch fluid levels, make sure that the top of each reservoir is level. G Use only the recommended quality brake fluid, otherwise the rubber seals may deteriorate, causing leakage and poor braking - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 62
PERIODIC MAINTENANCE AND MINOR REPAIR EAU22750 EAU23040 Changing the brake and clutch fluids Have a Yamaha dealer change the brake and clutch fluids at the intervals specified in the NOTE after the periodic maintenance and lubrication chart. In addition, have the oil seals of the brake and clutch - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 63
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23091 EAU23111 EAU23131 Checking and lubricating the cables The operation of all control cables and the condition of the cables should be checked before each ride, and the cables and cable ends should be lubricated if necessary. If a cable is damaged or does - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 64
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23140 Recommended lubricant: Lithium-soap-based grease (all-purpose grease) Checking and lubricating the brake and clutch levers Brake lever Recommended lubricant: Lithium-soap-based grease (all-purpose grease) Clutch lever 6 The operation of the brake - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 65
fork must be checked as follows at the intervals specified in the periodic maintenance and lubrication chart. To check the condition EWA10750 WARNING Securely support the vehicle so that there is no danger of it falling over. The operation of the sidestand should be checked before each ride, and - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 66
. EWA10750 ECA10590 CAUTION: If any damage is found or the front fork does not operate smoothly, have a Yamaha dealer check or repair it. WARNING Securely support the vehicle so that there is no danger of it falling over. 2. Hold the lower ends of the front fork legs and try to move - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 67
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23290 EAU33650 Checking the wheel bearings The front and rear wheel bearings must be checked at the intervals specified in the periodic maintenance and lubrication chart. If there is play in the wheel hub or if the wheel does not turn smoothly, have a Yamaha - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 68
PERIODIC MAINTENANCE AND MINOR REPAIR battery tends to discharge more quickly if the vehicle is equipped with optional electrical accessories. To store the battery 1. If the vehicle will not be used for more than one month, remove the battery, fully charge it, and then place it in a cool, dry place. - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 69
PERIODIC MAINTENANCE AND MINOR REPAIR Specified fuses: Main fuse: 50.0 A Headlight fuse: 20.0 A Signaling system fuse: 10.0 A Ignition fuse: 25.0 A Fuel injection system fuse: 15.0 A ECU fuse: 10.0 A Auxiliary DC connector fuse: 3.0 A Taillight fuse: 10.0 A Backup fuse: 10.0 A ECA10640 4. If the - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 70
PERIODIC MAINTENANCE AND MINOR REPAIR EAU38451 Replacing a headlight bulb 1. Bolt 2. Main switch/steering lock cover 1. Low beam headlight bulb 2. High beam headlight bulb 1. Screw 2. Disconnect the coupler shown. 6 This model features a headlight equipped with two quartz bulbs. If the high - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 71
PERIODIC MAINTENANCE AND MINOR REPAIR 2. Disconnect the headlight coupler, and then unhook the headlight bulb holder. ECA10650 CAUTION: Take care not to damage the following parts: G Headlight bulb Do not touch the glass part of the headlight bulb to keep it free from oil, otherwise the - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 72
PERIODIC MAINTENANCE AND MINOR REPAIR G 1. Headlight coupler 2. Headlight bulb EWA10790 G WARNING 6 Headlight bulbs get very hot. Therefore, keep flammable products away from a lit headlight bulb, and do not touch the bulb until it has cooled down. 2. Install the bulb by turning it clockwise. - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 73
PERIODIC MAINTENANCE AND MINOR REPAIR EAU24180 EAU38380 EAU24330 Tail/brake light This model is equipped with an LED type of tail/brake light. If the tail/brake light does not come on, have a Yamaha dealer check it. Replacing a turn signal light bulb 1. Remove the turn signal light lens by - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 74
Supporting the front wheel off the ground by using a motorcycle stand. To service the rear wheel Raise the rear wheel off the ground by using a Troubleshooting Although Yamaha motorcycles receive a thorough inspection before shipment from the factory, trouble may occur during operation. Any problem - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 75
PERIODIC MAINTENANCE AND MINOR REPAIR EAU42600 Troubleshooting chart EWA10840 WARNING Keep away open flames and do not smoke while checking or working on the fuel system. 1. Fuel There is enough fuel. Check - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 76
wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. Improper cleaning can damage windshields, cowlings - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 77
MOTORCYCLE CARE AND STORAGE cleaning products, solvent or thinner, fuel (gasoline), rust removers or inhibitors, brake fluid, antifreeze or electrolyte. Do not use high-pressure washers or steam-jet cleaners since they cause water seepage and deterioration in the following areas: seals (of wheel and - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 78
spray oil and wax sparingly and make sure to wipe off any excess. 7-3 Long-term Before storing your motorcycle for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 79
MOTORCYCLE CARE AND STORAGE 3. Perform the following steps to protect the cylinders, piston rings, etc. from corrosion. a. Remove the spark plug caps and spark plugs. b. Pour a teaspoonful of engine oil into each spark plug bore. c. Install the spark plug caps onto the spark plugs, and then place - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 80
: 155 mm (6.10 in) Minimum turning radius: 3480 mm (137.0 in) Engine oil: Type: YAMALUBE 4 (20W40) or SAE20W40 Recommended engine oil grade: API service SG type or higher, JASO standard MA Engine oil quantity: Without oil filter cartridge replacement: 4.10 L (4.33 US qt) (3.61 Imp.qt) With oil - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 81
SPECIFICATIONS Caster angle: 31.30 ° Trail: 152.0 mm (5.98 in) Rear: 280 kPa (41 psi) (2.80 kgf/cm²) Loading condition: 90-210 kg (198-463 lb) Front: 250 kPa (36 psi) (2.50 kgf/cm²) Rear: 280 kPa (41 psi) (2.80 kgf/cm²) High-speed riding: Front: 250 kPa (36 psi) (2.50 kgf/cm²) Rear: 280 kPa (41 psi) - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 82
lighting: LED Neutral indicator light: LED High beam indicator light: LED Turn signal indicator light: LED Fuel level warning light: LED Engine trouble warning light: LED ECU fuse: 10.0 A Fuel injection system fuse: 15.0 A Auxiliary DC connector fuse: 3.0 A Backup fuse: 10.0 A Fuses: 8 Main fuse - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 83
CONSUMER INFORMATION EAU26351 EAU26381 EAU26400 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 84
CONSUMER INFORMATION EAU26470 Model label 1. Model label The model label is affixed to the frame under the rider seat. (See page 3-12.) Record the information on this label in the space provided. This information will be needed when ordering spare parts from a Yamaha dealer. 9 9-2 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 85
that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1-800 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 86
CONSUMER INFORMATION EAU26560 Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 87
30 months 24000 mi (37000 km) or 36 months 28000 mi (43000 km) or 42 months 32000 mi (49000 km) or 48 months 9-5 Date of service Mileage Servicing dealer name and address Remarks 9 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 88
CONSUMER INFORMATION Maintenance interval 36000 mi (55000 km) or 54 months 40000 mi (61000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 9 9-6 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 89
1. Operate and maintain the motorcycle as specified in the appropriate Owner's Manual, and 2. Give notice to an authorized Yamaha motorcycle dealer of any . An inspection and registration fee will be charged for this service. EMISSION CONTROL SYSTEM WARRANTY: Yamaha Motor Corporation, U.S.A. also - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 90
in the Owner's and Service Manual. We do recommend, however service, you must take it to any authorized Yamaha motorcycle dealer within the continental United States. Be sure to bring your warranty registration card or other valid proof of the original date of purchase. If a question or problem - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 91
no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 92
isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 9 9-10 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 93
Troubleshooting chart ...6-33 Turn signal indicator lights ...3-2 Turn signal light bulb, replacing ...6-31 Turn signal switch ...3-8 D Dimmer switch ...3-8 Drive belt slack ...6-20 E Engine break-in ...5-3 Engine oil and oil filter cartridge ...6-9 Engine stop switch...3-8 Engine trouble warning - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 94
INDEX V Valve clearance ...6-13 Vehicle identification number ...9-1 W Warranty, extended...9-9 Warranty, limited ...9-7 Wheel bearings, checking...6-25 Wheels ...6-16 - 2007 Yamaha Motorsports Roadliner | Owners Manual - Page 95
YAMAHA MOTOR CO., LTD. PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2006.07-1.8×1 CR (E)
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
 |
 |
1D7-28199-11
XV19SW(C)
XV19W(C)
XV19MW(C)
OWNER’S MANUAL
LIT-11626-20-40