2007 Yamaha Motorsports Morphous Owners Manual

2007 Yamaha Motorsports Morphous Manual

Get 2007 Yamaha Motorsports Morphous PDF manuals and user guides View all 2007 Yamaha Motorsports Morphous manuals

2007 Yamaha Motorsports Morphous manual content summary:

  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 1
    OWNER'S MANUAL CP250Wm LIT-11626-20-30 1B7-28199-11
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 2
    EAU10041 AWARNING The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. YAMAHA LIT-CALIF-65-01
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 3
    degree of craftsmanship and reliability that have made Yamaha a leader in these fields. This manual will give you an understanding of the operation, inspection, and basic maintenance of this attention to the recommended maintenance schedules and operating instructions contained within this manual.
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 4
    EAU35821 Particularly important information is distinguished in this manual by the following notations: & 1 A WARNING 1 CAUTION: NOTE: The Safety Alert Symbol means ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED! Failure to follow WARNING instructions could result in severe injury or death to
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 5
    INFORMATION EAU10192 AFFIX DEALER LABEL HERE CP250W OWNER'S MANUAL ©2006 by Yamaha Motor Corporation, U.S.A. 1st edition, April 2006 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A.
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 6
    Replacing a front turn signal light bulb 6-39 Replacing a rear turn signal light bulb 6-40 License plate light 6-41 Troubleshooting 6-41 3-1 3-1 3-2 3-3 3-6 3-7 3-7 3-7 3-8 3-9 3-10 3-10 3-11 3-12 3-12 3-14 3-15 3-16 4-1 4-2 PERIODIC MAINTENANCE AND MINOR REPAIR 6-1 PERIODIC MAINTENANCE 6-1 Owner
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 7
    TABLE OF CONTENTS Troubleshooting charts SCOOTER CARE AND STORAGE Care Storage SPECIFICATIONS 6-42 7-1 7-1 7-3 8-1 CONSUMER INFORMATION 9-1 9-4 Maintenance record 9-5 YAMAHA MOTOR CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY 9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) 9-9
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 8
    SHOULD: • OBTAIN THOROUGH INSTRUCTIONS FROM A COMPETENT SOURCE ON ALL ASPECTS OF SCOOTER OPERATION. • OBSERVE THE WARNINGS AND MAINTENANCE REQUIREMENTS IN THE OWNER'S MANUAL. • OBTAIN QUALIFIED TRAINING IN SAFE AND PROPER RIDING TECHNIQUES. • OBTAIN PROFESSIONAL TECHNICAL SERVICE AS INDICATED BY THE
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 9
    A SAFETY INFORMATION • Always signal before turning or changing lanes. Make sure that other motorists can see you. • The posture of the operator and passenger is important for proper control. • The operator should keep both hands on the handlebar and both feet on the footboard during operation to
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 10
    A SAFETY INFORMATION When loading within this weight limit, keep the following in mind: • Cargo and accessory weight should be kept as low and close to the scooter as possible. Make sure to distribute the weight as evenly as possible on both sides of the scooter to minimize imbalance or instability.
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 11
    A SAFETY INFORMATION • Take care not to spill any gasoline on the engine or exhaust system when refueling. • Never refuel while smoking or in the vicinity of an open flame. • Never start the engine or let it run for any length of time in a closed area. The exhaust fumes are poisonous and may cause
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 12
    A SAFETY INFORMATION and ankle so they do not flap), and a bright colored jacket. • Do not carry too much luggage on the scooter. An overloaded scooter is unstable. ^^ 1 1-5
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 13
    A SAFETY INFORMATION EAU10381 Location of important labels Please read the following important labels carefully before operating this vehicle. 1 1 2 3 4 5 6 7 8 9 10 1-6
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 14
    /cm 2 }, 36 psi 5FB-21668-01 2 LOAD LIMIT 2 kg {4 lbs} 5RU-24877-A0 3 A WARNING • BEFORE YOU OPERATE THIS VEHICLE, READ THE OWNER'S MANUAL AND ALL LABELS. • ALWAYS WEAR AN APPROVED MOTORCYCLE HELMET, eye protection, and protective clothing. 5GK-2118K-00 6 A WARNING Improper loading can cause loss
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 15
    A SAFETY INFORMATION 7 LOAD LIMIT 2 kg {4 lbs} 5RU-24877-A0, 10 A WARNING Improper loading can cause loss of control. Read owner's manual for proper loading. 3JJ-28446-A1 1 8 EMISSION HOSE ROUTING FUEL TANK THROTTLE BODY =--ATMOSPHERE CANISTER 5RU-21686-00 9 LOAD LIMIT 3 kg {7 lbs} 3TB-24877-A0
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 16
    DESCRIPTION EAU10410 Left view 2 1. Headlight (page 6-37) 2. Main fuse (page 6-35) 3. Fuse box (page 6-35) 4. Fuel tank cap (page 3-8) 5. Storage compartment C (page 3-12) 6. Storage compartment B (page 3-12) 7. Air filter element (page 6-21) 8. Owner's tool kit (page 6-2) 2-1 9. V-belt case air
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 17
    DESCRIPTION EAU10420 Right view 2 1. Trunk (page 3-14) 2. Helmet holder (page 3-12) 3. Grab bar (page 5-2) 4. Engine oil filler cap (page 6-15) 5. Battery (page 6-34) 6. Coolant reservoir (page 6-20) 7. Rider backrest (page 3-11) 2-2
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 18
    DESCRIPTION EAU10430 Controls and instruments 2 1. Rear brake lever (page 3-7) 2. Left handlebar switches (page 3-6) 3. Rear brake lock lever (page 3-7) 4. Multi-function display (page 3-3) 5. Right handlebar switches (page 3-6) 6. Front brake lever (page 3-7) 7. Throttle grip (page 6-24) 8. Main
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 19
    INSTRUMENT AND CONTROL FUNCTIONS EAU10460 Main switch/steering lock sidestand is moved down. EAU10660 OFF All electrical systems are off. The key can be removed. EAU10680 be switched off, which may result in loss of control or an accident. Make sure that the vehicle is stopped before turning the
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 20
    right. EAU11080 High beam indicator light " I D " This indicator light comes on when the high beam of the headlight is switched on. Engine trouble warning light " HS " This warning light comes on when an electrical circuit monitoring the engine is defective. When this occurs, have a Yamaha dealer
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 21
    INSTRUMENT AND CONTROL FUNCTIONS EAU38240 Multi-function display EWA12311 1 2 3 4 A WARNING Be sure to stop the vehicle before making any setting changes to the multi-function display. 1. Oil change indicator "OIL" 2. V-belt replacement indicator "V-BELT" 3. Fuel level warning indicator "JjS"
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 22
    seconds). While "TRIP" or "F TRIP" is flashing, push the "RESET" button for at least one second. If you do not reset the fuel reserve tripmeter manually, it will reset itself automatically and the display will return to the prior mode after refueling and traveling 5 km (3 mi). 3-4
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 23
    INSTRUMENT AND CONTROL FUNCTIONS segment near "E", fuel meter and the fuel level warning indicator will start flashing. Refuel as soon as possible. Oil change indicator "OIL" This indicator flashes at the initial 1000 km (625 mi), then at 5000 km (3125 mi) and every 5000 km (3125 mi) thereafter to
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 24
    center position. To cancel the turn signal lights, push the switch in after it has returned to the center position. CAUTION: See page 5-1 for starting instructions prior to starting the engine. 3-6
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 25
    INSTRUMENT AND CONTROL FUNCTIONS EAU12900 EAU12950 EAU12962 Front brake lever Rear brake lever Rear brake lock lever % ^ (f 1. Front brake lever 1. Rear brake lever ( E^ 1. Rear brake lock lever 3 This vehicle is equipped with a rear brake lock lever to prevent the rear wheel from moving
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 26
    INSTRUMENT AND CONTROL FUNCTIONS rear brake lock lever is applied. • To provide secure locking of the rear wheel, apply the rear brake lever first before moving the rear brake lock lever to the left. EWA12361 EAU13161 Fuel tank cap To open the fuel tank cap 1. Open the lid by sliding the lever
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 27
    INSTRUMENT AND CONTROL FUNCTIONS move it. 3. Close the lid. EWA11120 EAU13211 Fuel fuel may deteriorate painted surfaces or plastic parts. EAU36080 A WARNING Be sure that the fuel tank cap is properly installed and locked before riding the scooter. 2 Recommended fuel UNLEADED GASOLINE ONLY Fuel
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 28
    not exceed 10%. Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. EAU13441 EAU13932 Catalytic converter This vehicle is equipped with catalytic converters in the exhaust system. EWA10860 Seat To open the seat
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 29
    INSTRUMENT AND CONTROL FUNCTIONS EAU38120 Adjusting the rider backrest The rider backrest can be adjusted to the two different positions shown. To close the seat 1. Fold the seat down, and then push it down to lock it in place. 2. Remove the key from the main switch if the scooter will be left
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 30
    INSTRUMENT AND CONTROL FUNCTIONS EAU38140 Helmet holder The helmet holder is located on the bottom of the seat. A helmet holding cable is provided under the seat to secure a helmet to the helmet holder. To secure a helmet to the helmet holder 1. Open the seat. (See page 3-10.) 2. Pass one end of
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 31
    INSTRUMENT AND CONTROL FUNCTIONS Storage compartment C This storage compartment is also located under the seat. A helmet can be stored in this compartment. 1. Lock. 2. Lid 3 1. Storage compartment light switch 1. Storage compartment C NOTE:. Some helmets cannot be stored in this compartment
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 32
    INSTRUMENT AND CONTROL FUNCTIONS ECA15290 3 CAUTION: Keep the following points in mind when using the storage compartments. • Since the storage compartments accumulate heat when exposed to the sun, do not store anything susceptible to heat inside them. • To avoid humidity from spreading through
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 33
    INSTRUMENT AND CONTROL FUNCTIONS EAU15301 Sidestand 2 The sidestand is located on the left side of the frame. Raise the sidestand or lower it with your foot while holding the vehicle upright. NOTE:. The built-in sidestand switch is part of the ignition circuit cut-off system, which cuts the
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 34
    INSTRUMENT AND CONTROL FUNCTIONS EAU15371 Ignition circuit cut-off system The ignition circuit cut-off system (comprising the sidestand switch and brake light switches) has the following functions. • It prevents starting when the sidestand is up, but neither brake is ap^^ plied. 3| • It prevents
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 35
    INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is turned on. 3. Turn the key on. 4. Keep the front or rear brake applied. 5. Push the start switch. Does the engine start? NOTE: This check is most reliable if performed
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 36
    PRE-OPERATION CHECKS EAU15591 The condition of a vehicle is the owner's responsibility. Vital components can start to deteriorate quickly and unexpectedly, even if the vehicle remains unused (for example, as a result of exposure to the elements). Any damage, fluid leakage or loss of tire air
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 37
    PRE-OPERATION CHECKS EAU15605 Pre-operation check list ITEM Fuel ...CHECKS Check fuel level in fuel tank. Refuel if necessary. Check fuel line for leakage. Check oil level in engine. If necessary, add recommended oil to specified level. Check vehicle for oil leakage. Check vehicle for oil leakage.
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 38
    PRE-OPERATION CHECKS ITEM ...CHECKS Check for damage. Check tire condition and tread depth. Check air pressure. Correct if necessary. Make sure that operation is smooth. Lubricate lever pivoting points if necessary. Make sure that operation is smooth. Lubricate pivots if necessary. Make sure that
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 39
    sure that there is adequate ventilation. • For safety, always start the engine with the centerstand down. CAUTION: See page 5-3 for engine break-in instructions prior to operating the vehicle for the first time. In order for the ignition circuit cut-off system to enable starting, the sidestand must
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 40
    OPERATION AND IMPORTANT RIDING POINTS EAU16760 EAU16780 EAU16791 Starting off NOTE: _ Before starting off, allow the engine to warm up. 1. While pulling the rear brake lever with your left hand and holding the grab bar with your right hand, push the scooter off the centerstand. Acceleration and
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 41
    OPERATION AND IMPORTANT RIDING POINTS Rear cult. EAU16841 Engine break-in There is never a more important period in the life of your engine than the period between 0 and 1600 km (1000 mi). For this reason, you should read the following material carefully. Since the engine is brand new, do not put
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 42
    the engine, and then remove the key from the main switch. EWA10310 5 CAUTION: • Keep the engine speed below 9000 r/min. • If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. A WARNING • Since the engine and exhaust system can
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 43
    intervals. EAU17301 PERIODIC MAINTENANCE PROPER PERIODIC MAINTENANCE OF YOUR VEHICLE IS IMPORTANT IN ORDER TO ENJOY LONG, PLEASURABLE SERVICE. ESPECIALLY IMPORTANT ARE THE MAINTENANCE SERVICES RELATED TO EMISSIONS CONTROL. THESE CONTROLS NOT ONLY FUNCTION TO ENSURE CLEANER AIR, BUT ARE ALSO VITAL
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 44
    before attempting any changes. €S§^ 1. Owner's tool kit 6 The owner's tool kit is located inside the trunk. (See page 3-14.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 45
    . . Replace any damaged parts. Replace. Every 26600 mi (42000 km) 7 | 7 | 7 | V 7 | 7 V | 7 * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 6-3
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 46
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU32162 General maintenance and lubrication chart INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (6000 km) or 6 months V V ODOMETER READINGS 7000 mi 10000 mi 13000 mi 16000 mi (11000 km) (16000 km) (21000 km) (26000 km) or or or or 12 months 18
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 47
    PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (6000 km) or 6 months ODOMETER READINGS 7000 mi 10000 mi 13000 mi 16000 mi (11000 km) (16000 km) (21000 km) (26000 km) or or or or 12 months 18 months 24 months 30 months 9 * Wheel bearings 10 *
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 48
    . 24 * V V V switches • Adjust headlight beam. * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. V V V V V V NOTE: _ From 19000 mi (31000 km) or 36 months, repeat the maintenance intervals starting from 7000 mi (11000 km) or
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 49
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU38260 NOTE: • The air filter and V-belt filter need more frequent service if you are riding in unusually wet or dusty areas. • Hydraulic brake service • After disassembling the brake master cylinders and calipers, always change the fluid. Regularly check the
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 50
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU18781 EAU38191 Removing and installing cowlings The cowlings shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a cowling needs to be removed and installed. Cowling A To remove the
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 51
    PERIODIC MAINTENANCE AND MINOR REPAIR Cowling B To remove the cowling 1. Remove the windshield by removing the screws. To install the cowling Place the cowling in the original position, and then install the bolts. 1. Cowling B 1. Screw 2. Windshield 2. Pull the front of the cowling slightly
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 52
    PERIODIC MAINTENANCE AND MINOR REPAIR Left 1. Floorboard mat 1. Screw 2. Quick fastener 1. Cowling F Right 6 1. Cowling H 1. Floorboard mat 1. Screw 2. Quick fastener 2. Remove the screws and the quick fasteners. 3. Pull the cowling down slightly, and then pull it outward as shown. To
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 53
    PERIODIC MAINTENANCE AND MINOR REPAIR Cowling C To remove the cowling 1. Remove cowling F. 2. Remove the screws and bolts. 1. Tab To install the cowling 1. Place the cowling in the original position, and then install the screws and bolts. 2. Install cowling F. 1. Bolt 2. Screw 3. Cowling C
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 54
    PERIODIC MAINTENANCE AND MINOR REPAIR fasteners. 6. Pull the cowling slightly forward, and then pull it outward as shown. Left To install the cowling 1. Place the cowling in the original position, and then install the screws and the quick fasteners. 1. Quick fastener 2. Screw 6 To install the
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 55
    PERIODIC MAINTENANCE AND MINOR REPAIR 2. 3. 4. 5. Close the trunk. Install storage compartment B. Install cowling F or H. Install cowling E. EAU38250 Checking the spark plug The spark plug is an important engine component, which is easy to check. Since heat and deposits will cause any spark plug to
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 56
    ridden normally). NOTE: _ If the spark plug shows a distinctly different color, the engine could be defective. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 2. Check the spark plug for electrode erosion and excessive carbon or NOTE: If a torque
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 57
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU36110 EAU38211 Canister FUEL TANK THROTTLE BODY Engine oil and oil filter element The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil filter element replaced at the intervals specified in the periodic
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 58
    PERIODIC MAINTENANCE AND MINOR REPAIR cap with the spark plug wrench. 8. Install the engine oil filler cap cover by placing it in its original position. 9. Place the floorboard mat in the original position. To change the engine oil (with or without oil filter element replacement) 1. Start the engine
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 59
    PERIODIC MAINTENANCE AND MINOR REPAIR 4. Check the washer for damage and replace it if necessary. 1. Bolt 2. Oil filter element cover 1. Engine oil drain bolt 2. Washer 6. Remove and replace the oil filter element and O-rings. 1. Oil filter element cover 2. O-ring 3. Compression spring 4. Oil
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 60
    PERIODIC MAINTENANCE AND MINOR REPAIR Tightening torque: Oil filter element cover bolt: 10 Nm (1.0 m·kgf, 7.2 ft·lbf) Recommended engine oil: See page 8-1. Oil quantity: Without oil filter element replacement: 1.50 L (1.59 US qt) (1.32 Imp.qt) With oil filter element replacement: 1.70 L (1.80 US qt)
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 61
    PERIODIC MAINTENANCE AND MINOR REPAIR releasing the "OIL CHANGE" button, otherwise repeat the procedure. EAU20061 Final transmission oil The final transmission case must be checked for oil leakage before each ride. If any leakage is found, have a Yamaha dealer check and repair the scooter. In
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 62
    PERIODIC MAINTENANCE AND MINOR REPAIR EWA11310 EAU20070 A WARNING • Make sure that no foreign material enters the final transmission case. • Make sure that no oil gets on the tire or wheel. 7. Check the final transmission case for oil leakage. If oil is leaking, check for the cause. Coolant The
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 63
    element and the V-belt case air filter element should be serviced at the intervals specified in the periodic maintenance and lubrication chart. Service all air filter elements more frequently if you are riding in radiator. • If the engine overheats, see page 6-42 for further instructions. 6 6-21
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 64
    PERIODIC MAINTENANCE AND MINOR REPAIR ment installed, otherwise the piston(s) and/or cylinder(s) may become excessively worn. To clean the air filter check hoses 1. Remove cowling D. (See page 6-8.) 2. Check the hoses at the bottom of the air filter case for accumulated dirt or water. 1. Bolt 2.
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 65
    PERIODIC MAINTENANCE AND MINOR REPAIR Cleaning the V-belt case air filter element 1. Remove cowling D. (See page 6-8.) 2. Remove the V-belt air filter case cover by removing the screws. necessary. 6. Install the V-belt case air filter element by installing the screws. 7. Install the V-belt air
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 66
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU21381 EAU21401 EAU36131 Checking the throttle cable free play Valve clearance The valve clearance changes with use, resulting in improper air-fuel mixture and/or engine noise. To prevent this from occurring, the valve clearance must be adjusted by a Yamaha
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 67
    to loss of control. Have excessively worn tires replaced by a Yamaha dealer immediately. Brakes, tires, and related wheel parts replacement should be left to a Yamaha Service Technician. 6
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 68
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU21992 Front tire: Size: 120/70-13M/C 53P Manufacturer/model: DUNLOP/D305F Rear tire: Size: 130/70-13M/C 63P Manufacturer/model: DUNLOP/D305 EWA10580 Cast wheels To maximize the performance, durability, and safe operation of your vehicle, note the following
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 69
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU22011 Accessories and replacement parts EWA10621 been approved by Yamaha. EAU33453 Front and rear brake lever free play Front A WARNING This vehicle is not designed to pull a trailer or to be attached to a sidecar. The accessories or replacement parts
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 70
    PERIODIC MAINTENANCE AND MINOR REPAIR brake system. EWA14211 EAU38270 A WARNING A soft or spongy feeling in the brake lever can indicate the presence of air in the hydraulic system. If there is air in the hydraulic system, have a Yamaha dealer bleed the system before operating the vehicle. Air in
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 71
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU22390 Checking the front and rear brake pads The front and rear brake pads must be checked for wear at the intervals specified in the periodic maintenance and lubrication chart. EAU22430 indicator grooves have almost disappeared, have a Yamaha dealer
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 72
    PERIODIC MAINTENANCE AND MINOR REPAIR enter the brake system, possibly causing it to become ineffective. Before riding, check that the brake fluid is above the minimum level mark and replenish if necessary. A low brake fluid level may indicate worn brake pads and/or brake system leakage. If the
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 73
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU23091 EAU23111 EAU23170 Checking and lubricating the cables The operation of all control cables and the condition of the cables should be checked before each ride, and the cables and cable ends should be lubricated if necessary. If a cable is damaged or does
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 74
    fork must be checked as follows at the intervals specified in the periodic maintenance and lubrication chart. To check the condition EWA10750 A WARNING Securely support the vehicle so that there is no danger of it falling over. Check the inner tubes for scratches, damage and excessive oil leakage
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 75
    . EWA10750 ECA10590 CAUTION: If any damage is found or the front fork does not operate smoothly, have a Yamaha dealer check or repair it. _ A WARNING Securely support the vehicle so that there is no danger of it falling over r : 7 2. Hold the lower ends of the front fork legs and try to move
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 76
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU23290 Checking the wheel bearings The front and rear wheel bearings must be checked at the intervals specified in the periodic maintenance and lubrication chart. If there is play in the wheel hub or if the wheel does not turn smoothly, have a Yamaha dealer
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 77
    PERIODIC MAINTENANCE AND MINOR REPAIR electrical accessories. To store the battery 1. If the vehicle will not be used for more than one month, remove the battery, fully charge it, and then place it in a cool, dry place. 2. If the battery will be stored for more than two months, check it at least
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 78
    PERIODIC MAINTENANCE AND MINOR REPAIR Specified fuses: Main fuse: 30.0 A Headlight fuse: 15.0 A Signaling system fuse: 10.0 A Ignition fuse: 10.0 A Radiator fan fuse: 10.0 A Auxiliary DC connector fuse: 10.0 A Fuel injection system fuse: 10.0 A Backup fuse: 10.0 A Taillight fuse: 10.0 A ECA10640 1.
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 79
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU38231 Replacing a headlight bulb This model is equipped with quartz bulb headlights. If a headlight bulb burns out, replace it as follows. 1. Remove cowling C. (See page 6-8.) 2. Remove the headlight bulb cover by turning it counterclockwise. Wjk s ^ 1\
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 80
    PERIODIC MAINTENANCE AND MINOR REPAIR down. 5. Place a new headlight bulb into position, and then secure it with the bulb holder. ECA10660 CAUTION: Do not touch the glass part of the headlight bulb to keep it free from oil, otherwise the transparency of the glass, the luminosity of the bulb, and
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 81
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU38221 Replacing a front turn signal light bulb 1. Place the scooter on the centerstand. 2. Remove cowlings A and B. (See page 6-8.) 3. Remove the bolts, washers, and well nuts. 1. Rubber cover 1. Screw 2. Panel 5. Disconnect the coupler shown, and then
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 82
    PERIODIC MAINTENANCE AND MINOR REPAIR clockwise. 15. Place the multi-function display unit in the original position, and then install the washers, bolts and well nuts. 16. Install the cowlings. EAU34260 Replacing a rear turn signal light bulb 1. Place the scooter on the centerstand. 2. Remove
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 83
    on, have a Yamaha dealer check the electrical circuit or replace the bulb. Troubleshooting Although Yamaha scooters receive a thorough inspection before shipment from the factory, trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 84
    PERIODIC MAINTENANCE AND MINOR REPAIR EAU42130 Troubleshooting charts Starting problems or poor engine performance EWA10840 A WARNING Keep away open flames and do not smoke while checking or working on the fuel system. There is enough
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 85
    PERIODIC MAINTENANCE AND MINOR REPAIR Engine overheating EWA10400 A WARNING • Do not remove the radiator cap when the engine and radiator are hot. Scalding hot fluid and steam may be blown out under pressure, which could cause serious injury. Be sure to wait until the engine has cooled. • After
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 86
    wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. • Improper cleaning can damage windshields, cowlings
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 87
    SCOOTER CARE AND STORAGE After normal use Remove dirt with warm water, a mild detergent, and a soft, clean sponge, and then rinse thoroughly with clean water. Use a toothbrush or bottlebrush for hard-to-reach areas. Stubborn dirt and insects will come off more easily if the area is covered with a
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 88
    of the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your scooter for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. Fill up the fuel tank and add fuel stabilizer (if available) to prevent the fuel tank from
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 89
    SCOOTER CARE AND STORAGE pivoting points of all levers and pedals as well as of the sidestand/ centerstand. 5. Check and, if necessary, correct the tire air pressure, and then lift the scooter so that both of its wheels are off the ground. Alternatively, turn the wheels a little every month in order
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 90
    capacity: 14.0 L (3.70 US gal) (3.08 Imp.gal) Fuel injector: Manufacturer: AISAN Model/quantity: 1100-87C70-A/1 Recommended engine oil grade: API service SE, SF, SG type or higher Spark plug (s): Manufacturer/model: NGK/CPR7EA-9 Spark plug gap: 0.8-0.9 mm (0.031-0.035 in) Engine oil quantity
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 91
    SPECIFICATIONS Operation: Centrifugal automatic type Chassis: Frame type: Steel tube backbone Caster angle: 28.00 ° Trail: 103.0 mm (4.06 in) Front tire: Type: Tubeless Size: 120/70-13M/C 53P Manufacturer/model: DUNLOP/D305F Front: 200 kPa (29 psi) (2.00 kgf/cm2) Rear: 225 kPa (33 psi) (2.25 kgf/
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 92
    plate light: 12 V, 5.0 W x 1 Meter lighting: LED High beam indicator light: LED Turn signal indicator light: LED Coolant temperature warning light: LED Engine trouble warning light: LED Fuel injection system fuse: 10.0 A Auxiliary DC connector fuse: 10.0 A Backup fuse: 10.0 A Fuses: Main fuse: 30
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 93
    CONSUMER INFORMATION EAU26351 EAU26381 EAU26410 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 94
    CONSUMER INFORMATION EAU26540 Model label 1. Model label The model label is affixed to the frame under the seat. (See page 3-10.) Record the information on this label in the space provided. This information will be needed when ordering spare parts from a Yamaha dealer. 9 9-2
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 95
    that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may call the Vehicle Safety Hotline toll-free at 1-888-327
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 96
    CONSUMER INFORMATION EAU26580 Scooter noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any device
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 97
    24 months 16000 mi (26000 km) or 30 months 19000 mi (31000 km) or 36 months 22000 mi (36000 km) or 42 months Date of service Mileage Servicing dealer name and address Remarks 9 9-5
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 98
    CONSUMER INFORMATION Maintenance interval 25000 mi (41000 km) or 48 months 28000 mi (46000 km) or 54 months 31000 mi (51000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 9 9-6
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 99
    n and r e g i s t r a t i o n m u s t take place within ten (10) days after transfer. An inspection and r e g i s t r a t i o n fee w i l l be c h a r g e d for this service. EMISSIONS CON T ROL SYS T EM WARRAN T Y Yamaha M o t o r Corporation, U.S.A. also warrants to the ultimate purchaser and each
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 100
    any or all of the recommended maintenance s h o w n in the.Owner's Manual instead of having the dealer do them? A. Yes, if you are a qualified mechanic and follow the procedures specified in the Owner's and Service Manual. We do recommend, however, that items requiring special tools or
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 101
    no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 102
    't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the YE.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 9 9-10
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 103
    break-in Engine oil and oil filter element Engine stop switch Engine trouble warning light F Final transmission oil Front and rear brake lever free checking and lubricating 6-31 Tires 6-24 Tool kit 6-2 Troubleshooting 6-41 Troubleshooting charts 6-42 Trunk 3-14 Turn signal indicator lights 3-2
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 104
    INDEX Vehicle identification number 9-1 9-9 9-7 6-34 6-26 W Warranty, extended Warranty, limited Wheel bearings, checking Wheels
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 105
  • 2007 Yamaha Motorsports Morphous | Owners Manual - Page 106
    PROTECT YOUR INVESTMENT Use Genuine YAMAHA Parts And Accessories. See your Authorized YAMAHA Dealer for a Genuine YAMAHA Service Manual. YAMAHA YAMAHA MOTOR CO., LTD. PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2006.5-0.6x2 Q (E)
  • 1
  • 2
  • 3
  • 4
  • 5
  • 6
  • 7
  • 8
  • 9
  • 10
  • 11
  • 12
  • 13
  • 14
  • 15
  • 16
  • 17
  • 18
  • 19
  • 20
  • 21
  • 22
  • 23
  • 24
  • 25
  • 26
  • 27
  • 28
  • 29
  • 30
  • 31
  • 32
  • 33
  • 34
  • 35
  • 36
  • 37
  • 38
  • 39
  • 40
  • 41
  • 42
  • 43
  • 44
  • 45
  • 46
  • 47
  • 48
  • 49
  • 50
  • 51
  • 52
  • 53
  • 54
  • 55
  • 56
  • 57
  • 58
  • 59
  • 60
  • 61
  • 62
  • 63
  • 64
  • 65
  • 66
  • 67
  • 68
  • 69
  • 70
  • 71
  • 72
  • 73
  • 74
  • 75
  • 76
  • 77
  • 78
  • 79
  • 80
  • 81
  • 82
  • 83
  • 84
  • 85
  • 86
  • 87
  • 88
  • 89
  • 90
  • 91
  • 92
  • 93
  • 94
  • 95
  • 96
  • 97
  • 98
  • 99
  • 100
  • 101
  • 102
  • 103
  • 104
  • 105
  • 106
OWNER’S MANUAL
LIT-11626-20-30
CP250W
m
1B7-28199-11