2006 Yamaha Motorsports V Star Classic Owners Manual
2006 Yamaha Motorsports V Star Classic Manual
2006 Yamaha Motorsports V Star Classic manual content summary:
- 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 1
OWNER'S MANUAL XVS65V(C) XVS65AV(C) XVS65ATV(C) LIT-11626-19-70 3B6-28199-1R - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 2
EAU10041 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 3
of craftsmanship and reliability that have made Yamaha a leader in these fields. This manual will give you an understanding of the operation, inspection, and basic maintenance of this close attention to the recommended maintenance schedules and operating instructions contained within this manual. - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 4
manual by the following notations: The Safety Alert Symbol means ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED! Failure to follow WARNING instructions procedures easier or clearer. WARNING CAUTION: NOTE: NOTE: G This manual should be considered a permanent part of this motorcycle and should - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 5
IMPORTANT MANUAL INFORMATION AND UNTIL YOU HAVE BEEN TRAINED IN SAFE AND PROPER RIDING TECHNIQUES. REGULAR INSPECTIONS AND CAREFUL MAINTENANCE, ALONG WITH GOOD RIDING SKILLS, WILL ENSURE THAT YOU SAFELY ENJOY THE CAPABILITIES AND THE RELIABILITY OF THIS MOTORCYCLE. - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 6
INFORMATION EAU10192 AFFIX DEALER LABEL HERE XVS65V(C)/XVS65AV(C)/XVS65ATV(C) OWNER'S MANUAL ©2005 by Yamaha Motor Corporation, U.S.A. 1st edition, June 2005 All rights reserved. Any reprinting or unauthorized use without the written permission of Yamaha Motor Corporation, U.S.A. - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 7
TABLE OF CONTENTS SAFETY INFORMATION ...1-1 Location of important labels ...1-5 DESCRIPTION ...2-1 Left view ...2-1 Right view ...2-3 Controls and instruments ...2-5 INSTRUMENT AND CONTROL FUNCTIONS ...3-1 Main switch/steering lock ...3-1 Indicator and warning lights ...3-2 Speedometer unit ...3-2 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 8
/brake light bulb ...6-33 Supporting the motorcycle ...6-34 Front wheel ...6-35 Rear wheel ...6-36 Troubleshooting ...6-38 Troubleshooting chart ...6-39 MOTORCYCLE CARE YAMAHA MOTOR CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY ...9-7 YAMAHA EXTENDED SERVICE (Y.E.S.) ...9-9 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 9
SHOULD: G OBTAIN THOROUGH INSTRUCTIONS FROM A COMPETENT SOURCE ON ALL ASPECTS OF MOTORCYCLE OPERATION. G OBSERVE THE WARNINGS AND MAINTENANCE REQUIREMENTS IN THE OWNER'S MANUAL. G OBTAIN QUALIFIED TRAINING IN SAFE AND PROPER RIDING TECHNIQUES. G OBTAIN PROFESSIONAL TECHNICAL SERVICE AS INDICATED BY - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 10
SAFETY INFORMATION wide on a turn due to EXCESSIVE SPEED or undercornering (insufficient lean angle for the speed). • Always obey the speed limit and never travel faster than warranted by road and traffic conditions. • Always signal before turning or changing lanes. Make sure that other motorists - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 11
SAFETY INFORMATION Loading The total weight of the operator, passenger, accessories and cargo must not exceed the maximum load limit. Maximum load: XVS65ATV 200 kg (441 lb) XVS65ATVC 198 kg (437 lb) XVS65AV 200 kg (441 lb) XVS65AVC 198 kg (437 lb) XVS65V 180 kg (397 lb) XVS65VC 178 kg (392 lb) When - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 12
another vehicle, make sure that it is kept upright and that the fuel cock is turned to "ON" or "RES" (for vacuum type) / "OFF" (for manual type). If it should lean over, gasoline may leak out of the carburetor or fuel tank. If you should swallow any gasoline, inhale a lot of - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 13
SAFETY INFORMATION EAU10381 Location of important labels Please read the following important labels carefully before operating this vehicle. 1 1-5 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 14
SAFETY INFORMATION 1 1 3 XVS65AV/ATV 2 4 3 XVS65V 5FB-21668-01 1-6 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 15
SAFETY INFORMATION 5 1 A1 6 California only 1-7 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 16
DESCRIPTION EAU32220 Left view XVS65V 2 1. 2. 3. 4. 5. 6. 7. Shift pedal (page 3-4) Fuel cock (page 3-7) Starter (choke) knob (page 3-8) Shock absorber assembly spring preload adjusting ring (page 3-12) Helmet holder (page 3-11) Owner's tool kit (page 6-1) Storage compartment (page 3-11) 2-1 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 17
DESCRIPTION XVS65AV/ATV 2 1. 2. 3. 4. 5. 6. 7. Shift pedal (page 3-4) Fuel cock (page 3-7) Starter (choke) knob (page 3-8) Shock absorber assembly spring preload adjusting ring (page 3-12) Helmet holder (page 3-11) Owner's tool kit (page 6-1) Storage compartment (page 3-11) 2-2 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 18
DESCRIPTION EAU32230 Right view XVS65V 2 1. 2. 3. 4. 5. 6. Engine oil filter element (page 6-11) Battery (page 6-30) Fuses (page 6-31) Main switch/steering lock (page 3-1) Air filter element (page 6-14) Brake pedal (page 3-5) 2-3 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 19
DESCRIPTION XVS65AV/ATV 2 1. 2. 3. 4. 5. 6. Engine oil filter element (page 6-11) Battery (page 6-30) Fuses (page 6-31) Main switch/steering lock (page 3-1) Air filter element (page 6-14) Brake pedal (page 3-5) 2-4 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 20
DESCRIPTION EAU10430 Controls and instruments 2 1. 2. 3. 4. 5. 6. 7. Clutch lever (page 3-4) Left handlebar switches (page 3-3) Speedometer unit (page 3-2) Fuel tank cap (page 3-5) Right handlebar switches (page 3-3) Throttle grip (page 6-16) Brake lever (page 3-5) 2-5 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 21
INSTRUMENT AND CONTROL FUNCTIONS EAU10460 EAU10660 Main switch/steering lock OFF All electrical systems are off. The key can be removed. EAU10680 To unlock the steering LOCK The steering is locked, and all electrical systems are off. The key can be removed. To lock the steering The main switch/ - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 22
" EAU11020 Turn signal indicator light " " This indicator light flashes when the turn signal switch is pushed to the left or right. EAU11060 Engine trouble warning light " " This warning light comes on or flashes when an electrical circuit monitoring the engine is defective. When this occurs, have - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 23
for approximately 15 seconds. However, the turn signal lights can also be canceled manually by pushing the switch in after it has returned to the center position. NOTE . ECA10050 CAUTION: See page 5-1 for starting instructions prior to starting the engine. 1. Engine stop switch " 2. Start switch " - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 24
INSTRUMENT AND CONTROL FUNCTIONS EAU12820 EAU12870 EAU12880 Clutch lever Shift pedal (XVS65V) Shift pedal (XVS65AV/ATV) 3 1. Clutch lever 1. Shift pedal 1. Shift pedal The clutch lever is located at the left handlebar grip. To disengage the clutch, pull the lever toward the handlebar grip. - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 25
INSTRUMENT AND CONTROL FUNCTIONS EAU12890 EAU12941 EAU13120 Brake lever Brake pedal XVS65V Fuel tank cap 3 1. Brake lever The brake lever is located at the right handlebar grip. To apply the front brake, pull the lever toward the handlebar grip. 1. Brake pedal XVS65AV/ATV To remove the fuel - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 26
INSTRUMENT AND CONTROL FUNCTIONS EAU13210 ECA10070 NOTE: The fuel tank cap cannot be installed unless the key is in the lock. In addition, the key cannot be removed if the cap is not properly installed and locked. EWA10130 Fuel CAUTION: Immediately wipe off spilled fuel with a clean, dry, soft - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 27
not exceed 10%. Gasohol containing methanol is not recommended by Yamaha because it can cause damage to the fuel system or vehicle performance problems. EAU13441 EAU13550 Catalytic converter This vehicle is equipped with catalytic converters in the exhaust system. EWA10860 Fuel cock The fuel cock - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 28
INSTRUMENT AND CONTROL FUNCTIONS ON This indicates reserve. With the fuel cock lever in this position, the fuel reserve is made available. Turn the fuel cock lever to this position if you run out of fuel while riding. When this occurs, refuel as soon as possible and be sure to turn the fuel cock - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 29
INSTRUMENT AND CONTROL FUNCTIONS EAU14184 Seats (XVS65V) Passenger seat To remove the passenger seat Remove the nut and washer, and then pull the passenger seat up. Tightening torque: Passenger seat nut: 13 Nm (1.3 m·kgf, 9.4 ft·lbf) To install the rider seat 1. Insert the projection on the front - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 30
INSTRUMENT AND CONTROL FUNCTIONS EAU14191 Seats (XVS65AV/ATV) Passenger seat To remove the passenger seat Remove the nut and washer, and then pull the passenger seat up. 3 Tightening torque: Passenger seat nut: 13 Nm (1.3 m·kgf, 9.4 ft·lbf) 1. Bolt 1. Seat holder 2. Projection Rider seat 1. Nut - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 31
INSTRUMENT AND CONTROL FUNCTIONS 2. Install the passenger seat. NOTE: Make sure that the seats are properly secured before riding. EAU14281 EAU14481 Helmet holder Storage compartment The storage compartment is located on the left side of the vehicle. To open the storage compartment 1. Slide the - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 32
INSTRUMENT AND CONTROL FUNCTIONS EAU14860 Adjusting the shock absorber assembly 2. To increase the spring preload and thereby harden the suspension, turn the adjusting ring in direction (a). To decrease the spring preload and thereby soften the suspension, turn the adjusting ring in direction (b). - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 33
pressure. G Do not deform or damage the gas cylinder in any way, as this will result in poor damping performance. G Always have a Yamaha dealer service the shock absorber. Luggage strap holders Sidestand The sidestand is located on the left side of the frame. Raise the sidestand or lower it with - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 34
INSTRUMENT AND CONTROL FUNCTIONS below and have a Yamaha dealer repair it if it does not function properly. EAU15311 Ignition circuit cut-off system The ignition circuit cut-off system (comprising the sidestand switch, clutch switch and neutral switch) has the following functions. G It prevents - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 35
INSTRUMENT AND CONTROL FUNCTIONS With the engine turned off: 1. Move the sidestand down. 2. Make sure that the engine stop switch is turned on. 3. Turn the key on. 4. Shift the transmission into the neutral position. 5. Push the start switch. Does the engine start? NOTE: This check is most reliable - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 36
PRE-OPERATION CHECKS EAU15591 The condition of a vehicle is the owner's responsibility. Vital components can start to deteriorate quickly and unexpectedly, even if the vehicle remains unused (for example, as a result of exposure to the elements). Any damage, fluid leakage or loss of tire air - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 37
PRE-OPERATION CHECKS EAU15603 Pre-operation check list ITEM Fuel • Check fuel level in fuel tank. • Refuel if necessary. • Check fuel line for leakage. • Check oil level in engine. • If necessary, add recommended oil to specified level. • Check vehicle for oil leakage. • Check vehicle for oil - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 38
PRE-OPERATION CHECKS ITEM CHECKS Check for damage. Check tire condition and tread depth. Check air pressure. Correct if necessary. PAGE Wheels and tires 6-17, 6-20 Brake and shift pedals Brake and clutch levers Sidestand • Make sure that operation is smooth. • Lubricate pedal pivoting points if - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 39
the key to "ON" and make sure that the engine stop switch is set to " ". 3. Shift the transmission into the neutral position. CAUTION: The engine trouble warning light should come on when the key is turned to "ON", and then go off after a few seconds. If the engine - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 40
OPERATION AND IMPORTANT RIDING POINTS after starting, immediately stop the engine, and have a Yamaha dealer check the self-diagnosis system. 6. After starting the engine, move the starter (choke) back halfway. ECA11130 (choke) turned on, then about 2.5 minutes with the starter (choke) in the - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 41
OPERATION AND IMPORTANT RIDING POINTS EAU16671 Shifting XVS65V Shifting gears lets you control the amount of engine power available for starting off, accelerating, climbing hills, etc. The gear positions are shown in the illustration. NOTE: To shift the transmission into the neutral position, - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 42
OPERATION AND IMPORTANT RIDING POINTS EAU16841 NOTE: Always shift gears at the recommended shift points. EAU16700 5 To decelerate 1. Apply both the front and the rear brakes to slow the motorcycle. 2. Shift the transmission into first gear when the motorcycle reaches 25 km/h (15.5 mi/h). If the - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 43
the engine, remove the key from the main switch, and then turn the fuel cock lever to "OFF". EWA10310 WARNING G CAUTION: If any engine trouble should occur during the engine break-in period, immediately have a Yamaha dealer check the vehicle. G Since the engine and exhaust system can become very - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 44
. 1. Owner's tool kit The owner's tool kit is located inside the storage compartment. (See page 3-11.) The service information included in this manual and the tools provided in the owner's tool kit are intended to assist you in the performance of preventive maintenance and minor repairs. However - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 45
PERIODIC MAINTENANCE AND MINOR REPAIR EWA10340 WARNING Modifications not approved by Yamaha may cause loss of performance, excessive emissions, and render the vehicle unsafe for use. Consult a Yamaha dealer before attempting any changes. 6 6-2 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 46
speed 5 * 6 * 7 * 8 * Exhaust system Evaporative emission control system (For California only) 9 * √ √ * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. 6-3 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 47
PERIODIC MAINTENANCE AND MINOR REPAIR EAU32183 General maintenance and lubrication chart INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 48
PERIODIC MAINTENANCE AND MINOR REPAIR INITIAL No. ITEM ROUTINE 600 mi (1000 km) or 1 month 4000 mi (7000 km) or 6 months ODOMETER READINGS 8000 mi 12000 mi 16000 mi 20000 mi (13000 km) (19000 km) (25000 km) (31000 km) or or or or 12 months 18 months 24 months 30 months 9 * Swingarm pivot bearings - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 49
√ √ √ 6 22 * Throttle grip housing and cable * Since these items require special tools, data and technical skills, have a Yamaha dealer perform the service. NOTE: From 24000 mi (37000 km) or 36 months, repeat the maintenance intervals starting from 8000 mi (13000 km) or 12 months. EAU17620 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 50
PERIODIC MAINTENANCE AND MINOR REPAIR G Hydraulic brake system • When disassembling the master cylinder or caliper cylinder, always replace the brake fluid. Check the brake fluid level regularly and fill as required. • Replace the oil seals on the inner parts of the master cylinder and caliper - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 51
PERIODIC MAINTENANCE AND MINOR REPAIR EAU18771 Removing and installing panels The panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a panel needs to be removed and installed. XVS65V XVS65AV/ATV XVS65V 1. Panel A 1. - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 52
the same color. NOTE: If any spark plug shows a distinctly different color, the engine could be defective. Do not attempt to diagnose such problems yourself. Instead, have a Yamaha dealer check the vehicle. 1. Spark plug cap 2. Remove the spark plug as shown, with the spark plug wrench included - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 53
PERIODIC MAINTENANCE AND MINOR REPAIR 3. Check each spark plug for electrode erosion and excessive carbon or other deposits, and replace it if necessary. Specified spark plug: NGK/DPR7EA-9 DENSO/X22EPR-U9 2. Clean the surface of the spark plug gasket and its mating surface, and then wipe off any - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 54
PERIODIC MAINTENANCE AND MINOR REPAIR EAU19742 Engine oil and oil filter element The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil filter element replaced at the intervals specified in the periodic maintenance and lubrication chart. To check - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 55
PERIODIC MAINTENANCE AND MINOR REPAIR Tightening torque: Engine oil drain bolt: 43 Nm (4.3 m·kgf, 31 ft·lbf) 9. Add the specified amount of the recommended oil, and then install and tighten the oil filler cap. Recommended engine oil: See page 8-1. Oil quantity: Without oil filter element - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 56
PERIODIC MAINTENANCE AND MINOR REPAIR G Make sure that no foreign material enters the crankcase. EAU20022 Final gear oil The final gear case must be checked for oil leakage before each ride. If any leakage is found, have a Yamaha dealer check and repair the vehicle. In addition, the final gear - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 57
PERIODIC MAINTENANCE AND MINOR REPAIR 2. Remove the oil filler bolt and drain bolt to drain the oil from the final gear case. 3. Install the final gear oil drain bolt, and then tighten it to the specified torque. Tightening torque: Final gear oil drain bolt: 23 Nm (2.3 m·kgf, 17 ft·lbf) 6. Check - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 58
PERIODIC MAINTENANCE AND MINOR REPAIR ECA10480 CAUTION: G G 1. Air filter element Make sure that the air filter element is properly seated in the air filter case. The engine should never be operated without the air filter element installed, otherwise the piston(s) and/or cylinder(s) may become - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 59
PERIODIC MAINTENANCE AND MINOR REPAIR EAU21271 EAU21381 EAU21401 Carburetors The carburetors are important parts of the engine and emission control system, which require very sophisticated adjustment. Therefore, all carburetor adjustments should be left to a Yamaha dealer, who has the necessary - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 60
PERIODIC MAINTENANCE AND MINOR REPAIR EAU32520 Tires To maximize the performance, durability, and safe operation of your motorcycle, note the following points regarding the specified tires. Tire air pressure The tire air pressure should be checked and, if necessary, adjusted before each ride. - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 61
PERIODIC MAINTENANCE AND MINOR REPAIR Maximum load*: XVS65ATV 200 kg (441 lb) XVS65ATVC 198 kg (437 lb) XVS65AV 200 kg (441 lb) XVS65AVC 198 kg (437 lb) XVS65V 180 kg (397 lb) XVS65VC 178 kg (392 lb) * Total weight of rider, passenger, cargo and accessories EWA10510 vehicle. Operation of an - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 62
PERIODIC MAINTENANCE AND MINOR REPAIR EWA10460 WARNING G G The front and rear tires should be of the same make and design, otherwise the handling characteristics of the vehicle cannot be guaranteed. After extensive tests, only the tires listed below have been approved for this model by Yamaha - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 63
PERIODIC MAINTENANCE AND MINOR REPAIR EAU21940 EAU22011 Spoke wheels To maximize the performance, durability, and safe operation of your motorcycle, note the following points regarding the specified wheels. G The wheel rims should be checked for cracks, bends or warpage, and the spokes for - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 64
PERIODIC MAINTENANCE AND MINOR REPAIR EAU22041 Adjusting the clutch lever free play 1. Loosen the locknut at the clutch lever. 2. To increase the clutch lever free play, turn the adjusting bolt in direction (a). To decrease the clutch lever free play, turn the adjusting bolt in direction (b). NOTE - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 65
PERIODIC MAINTENANCE AND MINOR REPAIR EAU22092 Adjusting the brake lever free play system. If there is air in the hydraulic system, have a Yamaha dealer bleed the system before operating the motorcycle. Air in the hydraulic system will diminish the braking performance, which may result in loss of - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 66
PERIODIC MAINTENANCE AND MINOR REPAIR EAU22231 EWA10670 Adjusting the brake pedal position and free play XVS65V WARNING It is advisable to have a Yamaha dealer make these adjustments. NOTE: The brake pedal position should be adjusted before adjusting the brake pedal free play. Brake pedal position - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 67
PERIODIC MAINTENANCE AND MINOR REPAIR To increase the brake pedal free play, turn the adjusting nut at the brake rod in direction (a). To decrease the brake pedal free play, turn the adjusting nut in direction (b). EAU22270 EAU22380 Adjusting the rear brake light switch Checking the front brake - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 68
PERIODIC MAINTENANCE AND MINOR REPAIR indicator grooves have almost disappeared, have a Yamaha dealer replace the brake pads as a set. EAU22540 EAU32343 Checking the front brake fluid level G Rear brake shoes G When checking the fluid level, make sure that the top of the master cylinder is - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 69
PERIODIC MAINTENANCE AND MINOR REPAIR brake fluid level goes down suddenly, have a Yamaha dealer check the cause. EAU22720 EAU23090 Changing the brake fluid Have a Yamaha dealer change the brake fluid at the intervals specified in the NOTE after the periodic maintenance and lubrication chart. In - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 70
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23111 EAU23131 EAU23140 Checking and lubricating the throttle grip and cable The operation of the throttle grip should be checked before each ride. In addition, the cable should be lubricated at the intervals specified in the periodic maintenance chart. - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 71
fork must be checked as follows at the intervals specified in the periodic maintenance and lubrication chart. To check the condition EWA10750 WARNING Securely support the vehicle so that there is no danger of it falling over. The operation of the sidestand should be checked before each ride, and - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 72
. If there is play in the wheel hub or if the wheel does not turn smoothly, have a Yamaha dealer check the wheel bearings. WARNING Securely support the vehicle so that there is no danger of it falling over. 6 2. Hold the lower ends of the front fork legs and try to move - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 73
PERIODIC MAINTENANCE AND MINOR REPAIR EAU23380 Battery The battery is located behind panel B. (See page 6-8.) This model is equipped with a sealedtype (MF) battery, which does not require any maintenance. There is no need to check the electrolyte or to add distilled water. ECA10620 G CAUTION: - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 74
PERIODIC MAINTENANCE AND MINOR REPAIR sealed-type (MF) battery charger, have a Yamaha dealer charge your battery. EAU23524 Replacing the fuses 1. Fuse box 2. Main fuse 3. Spare main fuse 6 The main fuse and the fuse box, which contains the fuses for the individual circuits, are located behind - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 75
PERIODIC MAINTENANCE AND MINOR REPAIR ECA10640 EAU23792 CAUTION: Do not use a fuse of a higher amperage rating than recommended to avoid causing extensive damage to the electrical system and possibly a fire. 3. Turn the key to "ON" and turn on the electrical circuit in question to check if the - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 76
PERIODIC MAINTENANCE AND MINOR REPAIR EWA10790 EAU24281 WARNING Headlight bulbs get very hot. Therefore, keep flammable products away from a lit headlight bulb, and do not touch the bulb until it has cooled down. 4. Place a new headlight bulb into position, and then secure it with the bulb holder. - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 77
MAINTENANCE AND MINOR REPAIR XVS65AV/ATV EAU24350 Supporting the motorcycle Since this model is not of the rear wheel. 2. Raise the front wheel off the ground by using a motorcycle stand. To service the rear wheel Raise the rear wheel off the ground by using a motorcycle stand or, if a motorcycle - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 78
Wheel axle 2. Front wheel axle pinch bolt To remove the front wheel EWA10820 WARNING G G It is advisable to have a Yamaha dealer service the wheel. Securely support the motorcycle so that there is no danger of it falling over. 1. Disconnect the speedometer cable from the front wheel. 6 3. Lift - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 79
to check if the front fork compresses and rebounds smoothly. 8. Connect the speedometer cable. It is advisable to have a Yamaha dealer service the wheel. Securely support the motorcycle so that there is no danger of it falling over. 1. Loosen the axle nut. 1. 2. 3. 4. 5. 6. Brake pedal free play - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 80
gear case, and drive shaft by pushing the wheel forward and guiding the drive shaft into the middle gear universal joint. 7. Tighten rear wheel off the ground according to the procedure on page 6-34. 8. While supporting the drive shaft, pull the rear wheel back to remove the following parts as an - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 81
a thorough inspection before shipment from the factory, trouble may occur during operation. Any problem in the fuel, compression, or ignition systems, for example, can cause poor starting and loss of power. The following troubleshooting chart represents a quick and easy procedure for checking - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 82
PERIODIC MAINTENANCE AND MINOR REPAIR EAU25891 Troubleshooting chart EWA10840 WARNING Keep away open flames and do not smoke while checking or working on the fuel system. 1. Fuel There is enough fuel. Check - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 83
wheels. If such products are used on hard-to-remove dirt, do not leave the cleaner on the affected area any longer than instructed. Also, thoroughly rinse the area off with water, immediately dry it, and then apply a corrosion protection spray. Improper cleaning can damage windshields, cowlings - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 84
MOTORCYCLE CARE AND STORAGE After normal use Remove dirt with warm water, a mild detergent, and a soft, clean sponge, and then rinse thoroughly with clean water. Use a toothbrush or bottlebrush for hard-to-reach areas. Stubborn dirt and insects will come off more easily if the area is covered with a - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 85
the presence of ammonia) and areas where strong chemicals are stored. Long-term Before storing your motorcycle for several months: 1. Follow all the instructions in the "Care" section of this chapter. 2. For motorcycles equipped with a fuel cock that has an "OFF" position: Turn the fuel cock lever - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 86
MOTORCYCLE CARE AND STORAGE EWA10950 WARNING To prevent damage or injury from sparking, make sure to ground the spark plug electrodes while turning the engine over. 6. Lubricate all control cables and the pivoting points of all levers and pedals as well as of the sidestand/centerstand. 7. Check and - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 87
39.60 cu.in) Bore × stroke: 81.0 × 63.0 mm (3.19 × 2.48 in) Compression ratio: 9.00 :1 Starting system: Electric starter Recommended engine oil grade: API service SE, SF, SG type or higher Engine oil quantity: Without oil filter element replacement: 2.60 L (2.75 US qt) (2.29 Imp.qt) With oil filter - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 88
SPECIFICATIONS Fuel: Recommended fuel: Unleaded gasoline only Fuel tank capacity: 16.0 L (4.23 US gal) (3.52 Imp.gal) Fuel reserve amount: 3.0 L (0.79 US gal) (0.66 Imp.gal) Operation: Left foot operation Gear ratio: 1st: 38/14 (2.714) 2nd: 38/20 (1.900) 3rd: 35/24 (1.458) 4th: 28/24 (1.167) 5th: 29 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 89
SPECIFICATIONS Rear tire: Type: With tube Size: 170/80-15M/C 77S Manufacturer/model: XVS65ATV BRIDGESTONE/EXEDRA G702 XVS65ATVC BRIDGESTONE/EXEDRA G702 XVS65AV BRIDGESTONE/EXEDRA G702 XVS65AVC BRIDGESTONE/EXEDRA G702 XVS65V BRIDGESTONE/EXEDRA G546 XVS65VC BRIDGESTONE/EXEDRA G546 Manufacturer/model: - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 90
lighting: 12 V, 1.7 W × 1 Neutral indicator light: 12 V, 1.7 W × 1 High beam indicator light: 12 V, 1.7 W × 1 Turn signal indicator light: 12 V, 1.7 W × 1 Engine trouble warning light: 12 V, 1.7 W × 1 Rear suspension: Type: Swingarm (monocross) Spring/shock absorber type: Coil spring/gas-oil damper - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 91
CONSUMER INFORMATION EAU26351 EAU26381 EAU26400 Identification numbers Record the key identification number, vehicle identification number and model label information in the spaces provided below for assistance when ordering spare parts from a Yamaha dealer or for reference in case the vehicle is - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 92
CONSUMER INFORMATION EAU26470 Model label 1. Model label The model label is affixed to the frame under the rider seat. (See page 3-9.) Record the information on this label in the space provided. This information will be needed when ordering spare parts from a Yamaha dealer. 9 9-2 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 93
that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or Yamaha Motor Corporation, U.S.A. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1-800 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 94
CONSUMER INFORMATION EAU26560 Motorcycle noise regulation TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED: Federal law prohibits the following acts or the causing thereof: (1) The removal or rendering inoperative by any person other than for purposes of maintenance, repair, or replacement of any - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 95
30 months 24000 mi (37000 km) or 36 months 28000 mi (43000 km) or 42 months 32000 mi (49000 km) or 48 months 9-5 Date of service Mileage Servicing dealer name and address Remarks 9 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 96
CONSUMER INFORMATION Maintenance interval 36000 mi (55000 km) or 54 months 40000 mi (61000 km) or 60 months Date of service Mileage Servicing dealer name and address Remarks 9 9-6 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 97
CONSUMER INFORMATION EAU26661 YAMAHA MOTOR CORPORATION, U.S.A. STREET AND ENDURO MOTORCYCLE LIMITED WARRANTY 9 9-7 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 98
CONSUMER INFORMATION 9 9-8 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 99
no extra cost. TRIP gives you up to $150 reimbursement per occurrence for any reasonable expenses you incur because your Yamaha needs covered service: replacement vehicle rental, emergency towing, phone calls, even food and lodging when you are away from home. This superb coverage goes into effect - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 100
isn't convenient, contact Yamaha with your Primary ID number (your frame number). We'll be happy to help you get the Y.E.S. coverage you need. Yamaha Service Marketing P.O. Box 6555 Cypress, CA 90630 1-(866)-YES-EXTD (1-866-937-3983) 9 9-10 - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 101
checking ...6-29 Storage ...7-3 Storage compartment ...3-11 Supporting the motorcycle ...6-34 H Handlebar switches ...3-3 trouble warning light ...3-2 T Throttle cable free play, checking ...6-16 Throttle grip and cable, checking and lubricating ...6-27 Tires...6-17 Tool kit ...6-1 Troubleshooting - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 102
INDEX Troubleshooting chart ...6-39 Turn signal indicator light ...3-2 Turn signal light bulb or tail/brake light bulb, replacing...6-33 Turn signal switch ...3-3 V Valve clearance ...6-16 Vehicle identification - 2006 Yamaha Motorsports V Star Classic | Owners Manual - Page 103
YAMAHA MOTOR CO., LTD. PRINTED ON RECYCLED PAPER PRINTED IN JAPAN 2005.06-2.7×1 CR (E)
-
1 -
2 -
3 -
4 -
5 -
6 -
7 -
8
-
9
-
10
-
11
-
12
-
13
-
14
-
15
-
16
-
17
-
18
-
19
-
20
-
21
-
22
-
23
-
24
-
25
-
26
-
27
-
28
-
29
-
30
-
31
-
32
-
33
-
34
-
35
-
36
-
37
-
38
-
39
-
40
-
41
-
42
-
43
-
44
-
45
-
46
-
47
-
48
-
49
-
50
-
51
-
52
-
53
-
54
-
55
-
56
-
57
-
58
-
59
-
60
-
61
-
62
-
63
-
64
-
65
-
66
-
67
-
68
-
69
-
70
-
71
-
72
-
73
-
74
-
75
-
76
-
77
-
78
-
79
-
80
-
81
-
82
-
83
-
84
-
85
-
86
-
87
-
88
-
89
-
90
-
91
-
92
-
93
-
94
-
95
-
96
-
97
-
98
-
99
-
100
-
101
-
102
-
103
 |
 |
3B6-28199-1R
XVS65V(C)
XVS65AV(C)
XVS65ATV(C)
OWNER’S MANUAL
LIT-11626-19-70